Document ykwxgwMpg6k2YK2GKez71dwNn

ABDOti 172968 Attachment "B,r page 7 of 14 EMPLOYEE SAFETY TRAINING 1. What people must abide by the Conoco General Plant Safety Rules and Procedures in our plant? A. Visitors Contractors Employees All of the above 2. Who~must abide by department safety rules and regulations while in a given department area in the plant? A. Department employees only B. Visitors other than contractors C. Contractors D\ Everyone 3. Good housekeeping results in improvement in: A. Product output --------B. - Employee morale ... ---------- ---------------------------- C. Safety conditions and reduced injuries D.. Product quality (E3 All of the above 4. A person who has an injury must report the injury to: (A') - His Supervisor The security guard. C. His lead operator D. The first person he sees after the injury 5. What do you use to wash a respirator? A. Wash the respirator with cold water B. Wash the respirator with hot, soapy water (CJ. Wash the respirator with warm water, mixed with a mild detergent, according to the manufacturer's instructions D. Respirators do not need to be washed 6i What should an employee know in order to perform a job safely? A. How to produce more product than anyone else B.. How to try harder (c]) The correct operating procedures for the job D. How to keep on the move by checking on problems -- -------- -- . ------- ABD0O1-72969- Attachment "B" Page 8 of 14 -77--Whp must sign the VCM Regulated Area Log sheet when entering a regulated area? A. Hourly employees B, Salaried employees 6. gontraetors' d) iypryone ..... 8. The work permit system is followed in the following areas of the plant: A The vinyl reactor and vinyl dryer areas 1 gp'mppund, dry blend, and P-1 areas % V.. tank farm, and yard areas All ^reas 9. Where and how is electrically driven equipment locked-out for repair or entry? k% |he breaker box with a lock At the start/stop switch with a lock At the stop/start switch with a tag At the stop/start switch with a special pin only 10. Employee smoking is permited only in what areas? A. As specified in Department Safety Rules 1: All pfflce areals g. Maintenance Shops |), Designated breakroom area (gj Ail 3feas mentioned 11. Any person who recognizes an unsafe condition or unsafe act should immediately ` report it to his; . ;' At Friend, if a cprworker erWorker, if 3. friend ' .Immediate Supervisor Security Guard Twining Supervisor Hr A pefspn should always wash his hands after handling any chemicals before he: At Dpes the next job I, ppps reports or similar paperwork g, ifltprs the east warehouse |fs pr smokes 13, Wftp |s guthorized to operate a Fork Lift truck in the plant? AhyOTi Who has driven a fork truck before A Conoco licensed operator , An experienced driver who has operated lift trucks for two years D. Anyone whose supervisor asks him to do so. - ABD0Q172970- ----- - Attachment "B" Page q of 14 r. j ^ 14. What is the correct plant phone number for sounding the plant fire alarm? A. 81 B. 0 C. 62 D. 63 15. ! What is the correct plant phone number for sounding the VCM vapor release alarm? X 61 'B. 62 C. 81 D. 63 ~~ : 16. What is the correct plant phone number to give the all-clear signal after a VCM emergency or fire? C. 62 D. 61 17. Who is authorized to perform repair work on respirators? Instrument mechanics only Appointed, qualified persons only Shift mechanics Shift supervisors 18. Are all Conoco plant personnel required to participate in the VCM health training? Yes 'b. No 19. Before entering a vessel of any kind, is it absolutely necessary that all lines to the vessel be blanked off? 20. Which of the following equipment require a continuous flow fresh air mask for entry? A. Dryer Inlet -- B. Dryer Outlet - Day Collector 21. A manhole watch is required to enter the V-10 activator pit. A. *^fes B. No - - -ABBOtfl72974 Attachment MB" Page 10 of 14 22. A safety line and harness must be worn when entering: V-10 activator pit Dryer burner and inlet duct Day-Collector 23. jGloves must be worn when: A. B. C. f D.) Openihg'"bag' boxes" Cleaning dryers Bagging Resin All of the above 24. Ear protection must be worn on Bird deck when in this areas for more than 30 minutes. 25. The east end of V-ll Dryer room .is the primary evacuation area for the Vinyl Department. Yes > No 26. There are how many Scott Air Paks in the V-ll Dryer.area? 27. The following people are responsible for housekeeping in the Dryer Areas: A. Utilities B. Dryer "A" Operator C. Dryer Lead Operator All of the above 28, All Dryer Personnel are authorized to drive the fork truck assigned to the Dryer Department. A. Yes .. B. (no Qs<\X\> dU'd&uu UJ i 29. Dryer Personnel are permitted to use air hose without safe-to-blow nozzles for personal cleaning. A. Yes No