Document vwqLGJV5QJBddJzwJG2Dokjq

CO 4 CODE K0-789-D' PKG < DATE' ) _F?H44 517,, < LOT ) EST WGT ) PROCESSES ( ) KD-7.89-D (I) APPROVED `Bi FWP 03/25/82 \ LOCATW CG CODE PG) LOT DRY* DRY NO * PKG TOTAL ACTUAL WEIGHT /CONT PKG WGT WEIGHT USE LBS 01 Y.C016B 01 YC016B 01 YC016B 93 93 &U5JL gM. Bjsak Jtw TFBo 'XX.XX t/y xx.xx y xx.xx 'M+2PJP XX. XX ___ 50 50 50 _L__ XX.XX ____ ________ XX. XX NAME "KROLOR" ORANGE Y NON-BLEEDING USE LBS JSCC ' ACCT NCODE LBS "BEFORE USING SV, MAKE SURE THAT. N-28-D LINE IF ANY IS BLANKED OFF." RUN 60" <990 G> WATER IN V--211 . SET AGITATOR ON I ----------- I It I. 1 HIGH SPEED. WEIGH IN DRUM AND POUR IN DUMP IN AND STIR 5 MIN LOT RECORD : STAF<T___ILJl/Kl- fi $ * f in . 'mj JSJL- .*** J&jJkM-- TO 75" (1275 G) *NOTE: VOLUMES HIGHER 530 I 32-D I 530 84X50 IYC16B | 4200 75" MAY CAUSE DUSTING IN EXHAUST HOOD. WITH AGITATOR ON LOW SPEED PUMP V-211 THRU IMOG AT 2800-3200 PSI INTO V-208 :1EN V-211 MTY, WASH COLOR THRU HOMOG WITH MIN flUT WATER AT 2800-3200 PSI INTO V-208 ECORD: V-208 VOL. * & ADJUST TO 54*(i890G> INSPECT HOMOG STRAINER & CLEAN IF NECESSARY RUN 10* (514 G) WATER INTO V-&M START -I. AGITATOR.& INSTALL TEMP CHART PUMF V-208 THRU HOMOG^AI 4800-5200 PSI INT SV. RECORD; TIME START TOTAL MINUTES NOTE: IF HOMOG PRESSURE FALLS BELOW 4800 PSI, VALVE WILL RECIRCULATE SLURRY TO V-203 WHJStff V-208 MT, RUN IN 5" (240 G) WATER & PUMP HOMOG AT 4800-5200 PSI INTO SV MAY 381982 E HOMOG, RUN 6* (284 G) WATER INTO V-349 N^IOOO* WATER INTO V-384 4, HEAT TO 11O-120X-F INTO V-384 6 PUMP TO V-349 1 00$ WA'TSfi INTO V-384 & PUMP TO V-349 &DJ V-349 TOT (LO40 G) & STIR 15 MIN iiCORD DENS I `f y T V^LgG>/ML (1.082-1.086) 2545 | 32-D Y 2545 II II WHEN S-10 HOMOG COMPLETE, ADJ SV TO 45*(2300 G) RECORD: PH (OJS & ADJ TO 11.1-11.3 USING N-7-D T 5% (10 PARTS WATER TO 1 PART N-7-D) . , ASSUME 50% SIPHON N-7-D INTO SV 6 RECORD: F'H //'/_ . HEAT TO 190-194-x-F IN 55-65 MIN h REC: HT IlK>F 6 RECORD : NOTE: STRIKE MUST BE STARTED IMMEDIATELY ON r* rv x.< r i r- *7* r r> >. i /-* r* * ir a y t > r 7-D KENT | MTYP JOB NAME: 04KQ789DMI VJ-'i'tfy I LBS | CODE | LBS LE HEATING SV, RON 52' <143 G) WATER INTO I -343 ** I TER IN FROM V-386 MJCL. AD^ISIS/GAL ,$M_GAL I*_____ _l 27-D STIR IS MIN OR LONGER I RECORD: DENSITY !LMtLG/ML (1.018-1.020) , I T: THIS PROCESS CALLS FOR N-27-0 ON SURFACE. I I BE SURE THAT HOSE IS NOT IN UNDERSURFACE STRIKE LINE. 390 N S 20 HEATING COMPLETE, RECORD: PHJ T V-343 ACID PUMP AT 65 SETTING <255 MIN) 1 V-349 SILICATE PUMP AT 54 SETTING <210 MIN)} MEDIATELY METER IN V-343 & V-349. MAINTAIN SVI AT 190-194*F DURING STRIKE I RECORD: START v-349 FINIS MINUTEST ~MTi JflUI i TIME V-343 V-349 r\ INCHES S' INCHES AT 20 MlN^HteX^95-^ <20)^1 NORMAL | PH | .<9.3-10.0) | 40 M IN 3c4Ml.< 45) 1 HR S'e<41)_, 1 /4 HR 25) J~ir 1/2 HR StiS/H* 9) J_t f in is h .kar< 0) 3 8 ></ ______ 0 <9.3-10.0)1 [<9.3-10.0) I ____b<9.3-10.0)| ?9.3-10.0)I J22l 7.5-8.5)| NOTE: IF PH DROPS"BELOW 9.3 IN FIRST HOUR, STOP! PUMPS 6 SEE SUPV. IF FINAL PH IS ABOVE ! 8.5, ADJ TO 7.5-8.5 6 RECORD: _____PH | ASSUME 77% |. I 27-D 67* <514 G) WATER TO ADD & STlR 2 MIN . I 330 I 7-D \WLMEU V-349 MT, RINSE IN WITH MINIMUM WATER & yX SET PUMP AT 2ER0 SETTING 8 #3, I WHEN V-343 MT, RINSE IN WITH MINIMUM WATER 6 I RN OFF PUMP MOTOR STIR 30 MIN AT 199H& F, THEN TURN OFF STEAM RECORD: START jgStx ALUM USING BADGER METER I I 1060 1115-A "LUSH ALM LINE WITH WATER RECORD: FH_j EJ&8.4-3.8) & IF NECESSARY ADJ I I I I (DOWN ONLY) TO 3.4-3.8 6 RECORD: PH_____ II NOTE: USE LIGHJID ALUM, N-115-A. ADD TO SV VIA 1 I BADGER METER. STIR 5 MIN AFTER EACH ( I ADDITION. ASSUME 50%i,1115- ^ RUN IN N-7-D FROM S31 `IN 10-12 MIN 6 STIR 5 MINI xyr\I RECORD: PHM3 <6.2-6.4) &. IF .NECESSARY ADJ TO I II PH 6.2-6.4. RECORD: PH__4W ASSUME 77%U_Ji ! | 27-D uLj Du aILuUuTiicE. hN--7f-Dy T10 TO 1 WITH WATER yrsm^n n --77--Dd INTO SV Jmo >TQUR IN STIR 1!5 MIN 14*^1 STOP AGITATOR ASSUME 50% I _/JLr_l 7-D I 50 I978-A I `1 !I II START FINISH OPERATOR Ii ri I- l _3Lr-__ __i17 ' A II ri 165 530 DUP050046987 DUP050046988