Document vbY8DeLYd5a3KOR7MqbmMnpw

AWUaWWKUMWPWHnWWI* MATERIAL SAFETY DATA SHEET Emergency Telephone (614) 431-6600 (OPERATION ALERT) QB9MAW. LOUWAHA 70794 THE OSHA HAZARD COMMUNICATION STANDARD 29 CFR 1910.1200 REQUIRES THAT HE INFORMATION CONTAINED ON THESE SHEETS BE MADE AVAILABLE TO YOUR WORKERS. INSTRUCT YOUR WORKERS TO HANDLE THIS PRODUCT PROPERLY. FOR INDUSTRIAL USE ONLY VISTA CHEMICAL COMPANY ATTN: DEBBIE LEMMONS NON-EMERGENCY TELEPHONE P O BOX 91 (504) 387-5101 ABERDEEN, MS 39730 DESCRIPTION VC 106PM PVC HOMOPOLYMER CAS#9002-86-2 PRODUCT TYPE PVC HOMOPOLYMER APPLICATION THERMOPLASTICS PAGE 1 CUR ISS 08-DEC-93 SIGNAL WORD CAUTIONl This material presents possible health hazards as determined when reviewed according to the requirements of the Occupational Safety and Health Administration 29 CFR Part 1910.1200 "Hazard Communication" Standard. CONTAINS VINYL CHLORIDE Vinyl chloride is a cancer-suspect agent. If polyvinyl chloride is subjected to further processing at temperatures, and for times, sufficient to cause mass melting of polyvinyl chloride resulting in release of vinyl chloride under circumstances where employee exposure is greater than 0.5 ppm averaged over an 8 hour work day, OSHA Standard 29 CFR 1910.1017 for the control of employee exposure to vinyl chloride is applicable and appropriate cautionary measures must be taken. CHEMICAL HAZARD RATING HEALTH-1(slight) FIRE-1(slight) REACTIVITY-0(least) CHRONIC-* 29CFR1910.1200 HAZARDOUS INGREDIENTS/REPORTED HEALTH EFFECTS CAS/REGISTRY NO. MATERIAL DESCRIPTION % RANGE The ingredients listed below have been associated with one or more of the listed immediate and/or delayed(*) health hazards. Risk of damage and effects depends upon duration and level of exposure. BEFORE USING OR HANDLING, READ AND UNDERSTAND THE MSDS. 75-01-4 *VINYL CHLORIDE CANCER HAZARD. Can cause cancer. This material has been listed by NTP, IARC or OSHA as a human carcinogen. < 0.001 READ NEXT PAGE DISCLAIMER-SEE REVERSE SIDE VAB.0001070657 MATERIAL SAFETY DATA SHEET :C8 FtfBCIKfW&flf? VC 106PM PVC HOMOPOLYMER CAS#9002 86-2 PRODUCT TYPE: PVC HOMOPOLYMER APPLICATION: THERMOPLASTICS Emergency Telephone (614)431-6600 (OPERATION ALERT) PAGE 2 CUR ISS 08-DEC-93 29CFR1910.1200 HAZARDOUS INGREDIENTS/REPORTED HEALTH EFFECTS CAS/REGISTRY NO. MATERIAL DESCRIPTION % RANGE ACGIH TLV: 5 ppm (13 mg/m3) TWA OSHA PEL: 1 ppm TWA, 5 ppm 15-minute STEL OTHER: OSHA PEL: CANCER-SUSPECT AGENT, 29CFR1910.1017 NIOSH DOCUMENT NUMBER: 79-102 PHYSICAL DATA APPEARANCE SPECIFIC GRAVITY @ 25/25 C BOILING POINT, DEGREES F VAPOR PRESSURE @ 20 C VAPOR DENSITY (AIR-1) EVAPORATION RATE (BUT. ACET.-l) FREEZING POINT ODOR PH DETERMINATION SOLUBILITY IN WATER WHITE POWDER 1.40 NOT APPLICABLE 0 NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE BLAND NOT APPLICABLE NOT SOLUBLE IMMEDIATE HEALTH HAZARD DATA SKIN ABSORPTION: No hazards known to Borden. INGESTION: No hazards known to Borden. INHALATION: Not expected to be harmful under normal conditions of use. However, if allowed to become airborne, may cause irritation of nose, throat and lungs. SKIN: No hazards known to Borden. EYES: May cause irritation on prolonged or repeated contact. HANDLING PRECAUTIONS INHALATION: Avoid prolonged or repeated breathing of dust or vapor. EYES: Avoid prolonged or repeated contact with eyes. Handle in accordance with good industrial hygiene and safety practices. These practices include avoiding unnecessary exposure and removal of the material from eyes, skin and clothing. Wash thoroughly after handling. EMERGENCY AND FIRST AID PROCEDURES INGESTION: If accidently swallowed, dilute by drinking large quantities of water. Immediately contact poison control center or hospital emergency room for any other additional treatment directions. INHALATION: Remove to fresh air. READ NEXT PAGE DISCLAIMER-SEE REVERSE SIDE l VAB.0001070658 MATERIAL SAFETY DATA SHEET WSCfHPTOSflT VC 106PM PVC HOMOPOLYMER CAS#9002-86-2 PRODUCT TYPE: PVC HOMOPOLYMER APPLICATION: THERMOPLASTICS Emergency Telephone (614)431-6600 (OPERATION ALERT) PAGE 3 CUR ISS 08-DEC-93 EMERGENCY AND FIRST AID PROCEDURES EYE CONTACT: Immediately flush eyes with plenty water. Call a physician if irritation pe rsists. FIRE AND EXPLOSION HAZARD DATA Will burn. Refer to NFPA Pamphlet No. 654, "Prevention of Fire and Dust Explosions in the Chemical, Dye, Pharmaceutical, and Plastic Industries," if this material is to be reduced to or collected as a powder. In case of fire, use water spray, dry chemical, foam or C02. Use water to keep fire-exposed containers cool. REACTIVITY DATA Normally stable as defined in NFPA 704-12(4-3.1). In common with most organic materials, this product should be treated as a combustible dust in the finely divided and suspended state. Hazardous polymerization: Will not occur. Decomposition products may include: Hydrogen chloride, CO, C02 and small amounts of aromatic and aliphatic hydrocarbons. CONTROL MEASURES If airborne contaminants are generated when the material is heated or handled, sufficient ventilation in volume and air flow patterns should be provided to keep air contaminant concentration levels below acceptable criteria. PERSONAL PROTECTION INFORMATION Where air contaminants can exceed acceptable criteria, use NIOSH/MSHA approved respiratory protection equipment. Respirators should be selected based on the form and concentration of contaminants in air in accordance with OSHA 29 CFR 1910.134 or other applicable standards or guidelines. SPILL OR LEAK PROCEDURES Sweep (scoop) up and remove to a chemical disposal area. Prevent entry into natural bodies of water. WASTE DISPOSAL Dispose of according to local federal requirements. state/provincial and READ NEXT PAGE DISCLAIMER-SEE REVERSE SIDE VAB.0001070659 MATERIAL SAFETY DATA SHEET CMRATM LttfflD PMTNCMHP MP HmapMMi In*. Oanml Pm*m FlfSCflPlfVC 106PM PVC HOMOPOLYMER PRODUCT TYPE: PVC HOMOPOLYMER APPLICATION: THERMOPLASTICS CAS#9002-86-2 A Emergency Telephone (614)431-6600 (OPERATION ALERT) PAGE 4 CUR ISS 08-DEC-93 STORAGE PRECAUTIONS Keep container closed. Store in a cool, dry place. TRANSPORT INFORMATION Not Regulated. 610 304 PREVIOUS ISSUE:06-OCT-93 PRINT DATE: 27-May-94 11:29 AM CURRENT ISSUE:08-DEC-93 THIS IS THE LAST PAGE DISCLAIMER-SEE REVERSE SIDE VAB.0001070660  BOX 417. QUMOH, LOUWAWA 70734 MATERIAL SAFETY DATA SHEET SARA TITLE III SECTION 313 AND 40 CFR Part 372 TOXIC CHEMICAL NOTIFICATION SHEET A Emergency Telephone (614)431-6600 (OPERATION ALERT) VC 106PM PVC HOMOPOLYMER CAS#9002-86-2 This product contains the following toxic chemical(s) subject to the reporting requirements of Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986, and Subpart C-Supplier Notification Requirement of 40 CFR Part 372. CAS Registry Number Chemical Name Pet. By Weight None required per SARA TITLE III SECTION 313 This Toxic Chemical Notification Sheet must not be detached from the Material Safety Data Sheet (MSDS). Any copying and redistribution of the MSDS shall include copying and redistribution of this notification sheet attached to copies of the MSDS subsequently redistributed. 610 304 PRINT DATE: 27-May-94 11:29 AM DISCLAIMER-SEE REVERSE SIDE VAB.0001070661 T. i H 1 t; I i .* r 1h f' * * if 4 A J< V. 1 . ". * '* * k r r. r ^ * i VAB.0001070662