Document v6mb48g2R6ENNVNjr9a83bXZ8
91-596
Occupational Health Act of ublic Low
' FOSECO, INC.
'
MATERIAL SAFETY f. HEALTH DATA SHEET
Definition of o Hoiouioui Moicnol
A ho.-ordouj nieiCMol ho one or more of the following chorocteristies: (I) hot o lloshpoint below
1-0 F., closed ei*p, or tubjeet to spentoneous hooting; (2) hot a threshold limit \ciue below 6C0 ppm for poses ond vopnrt, beiow 500 Mg/M^ief fumet, ond below 25 mppef for ousts; ij) o single dose orol
LD5Q below SCO mg Tig; (4) is subject to polymerization with the releose of lotge amounts of energy; (5) is o strong enduing or reducing egent; (6) couses first degree burns to skin in short time exposure or is systematically toxic by skin conlocr; or (7) in the Course of normal operation, m0y produce dusts. 90SCS, fumes, vapors, mists, or smokes which hove one or more of the above chorectentiics.
SECTION I
MA.sur,\ctua.:k's name ros:-:co. inc.
AOOKOS (Njr.it*f, 5ir*ei, Ciiv. ****. and ?IP Ct*r'.)
20200 Sheldon Hoed,
CHEVJCAL NAMC AND SYNONYMS
CHEMICAL FAMILY
EMERGENCY TELEPHONE NO.
216*236*3551
Brookpnrk, Ohio 441l2
TKAUl NA-jr. AND SYNONYMS
yr.0?AX>v 31 (Insulating Saard)
FORMULA
SECTION II HAZARDOUS INGREDIENTS
PAINTS, PRESERVATIVES. A SOLVENTS PIGMENTS
T.
TLV (Ua.tt)
ALLOYS AND METALLIC COATINCS
| BASE METAL
CATALYST VEHICLE
J ALLOYS
METALLIC COATINGS
SOLVENTS ADDITIVES
| KILLER METAL PLUS COATING OK CORE FLUX
| OTHERS
OTHERS
Crystalline Silica
HAZARDOUS MIXTURES OF OTHER LIQUIDS. SOLIOS. OR CASCS
Asbestos - This product is supplied AS 1 bonded hoard and doe, nor treat* n,h*cfot
dust durinr, nornai handling. No significant hazard should therefore
arise from the use of the product. However, as of July 7, 1972, the
$ hour time weighted average airborne concentration of asbestos fiber
to which ary employee nny be exposed shall not exceed five (longer than
5 micrometers) per cubic centimeter of air, regular air saonlcorinc Is
suggested.
SECTION III PHYSICAL DATA
BOILING POINT t*K.) VAPOR PRESSURE {mm H(.) vapor density ia:r = d
N /a n/a N/A
SPECIFIC GRAVITY lUO = II
Apparent
PERCENT VOLATILE
nv VOLUME iM
EVAPORATION KATE 1 5 1)
Density
fc/cc)
solloiuty in hater
vs?irtc
APPCAXANCi AND CSOR
larovn
j
!.^Fighy, J.
SECTION IV FIRE AND EXPLOSION HAZARD DATA
FLASH FOIST iMv.nee lxtlnc.l:.'r.:.\c media
SPcCval i ;s*E rjc.urtNc*. rwcci.OVKES
l.'/A
Non* Combust ib 1 c
FLAMMAULC LIMITS
tlv
(LAktf) || |
|1 1j
j;
70 . 30ir/
TLV - (t'Alll)
3.91 *
0.74 - 0.8* N/A N/A
LNLWAl MKC AND UXi'LCLU'N MaZAK;^
1193
TllKT.MIlM.n LIMIT VAl.lTf
^ SECTION V HEALTH HAZARD DATa '
t:i i c.n> .i nvriii.MMiM'v::
During scrip (without adequate ventilation) dost mav cmtsc dizziness and Irritation of
mucous membranes.
~I.Kc;i..\C\ AMI Hk~T All) fHOCtUUHKS
Eves - flush with s.v.tcr. Call physician.
Sldn - flush with tracer.
Inhalation - remove victim frem contaminated area to fresh air. Call physician.
STAMILITV
unstahle
SECTION VI REACTIVITY DATA
CONDITIONS TO AVOID
STAfll.E INCOMPATAUIMTV (Material* to
X
iia/ak^c-l's decomposition I'wuuucrs
(300 C - fmaII rmonnr.q of phenol,
HAZARDOUS rOLVMEKIZATIGN
MAY OCCUR
cresols
end
xvlenols) (450 C -
CONDITIONS TO AVOID
carbon
nonorcicc,
carbon
dlo>:
WILL NOT OCCUR
SECTION VII SPILL OR LEAK PROCEDURES
STEPS TO uc TAKEN in case material is released or spilled
Normal clcnn-uo.
WASTE disposal mcthoo
SECTION VIII SPECIAL PROTECTION INFORMATION
KESPJPATOPN >>M07 ECTlON (Specify type)
VENTILATION
LOCAL EXHAUST
U.S. Bureau of Mines v2170 or 2iB-114.
SPECIAL
PROTECTIVE CLOVES
---------------------------------- loch jtdMvnteI-
OTHER PROTECTIVE EQUIPMENT
OTHER
X
|CYE PROTECTION
_ _________________ Safety zljiszes^
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO JK TAKEN IN HANOUNC AND STOKING
________________________________________________Store at room temperature
OTHtK l'Hi:C ACTIONS
_____________ n/a
Cemolelc ond return promptly to:
rostco, i::c.
20200 Shelcon Hci. liroukt-crk., Ohio 44142
Data
1194