Document rO8ryQ32gy9Mnp71v7OeMDBE
CG' 03 ( DAT
CODE KY-907-D PKG
F2L36
'4780*'
( LOT )
( EST WGT )
, PROCESSES
APPROVED* rBl
t ) KY-907-D (H) FWP 06/15/82
f{ COMTYP JOB NAME: O3KY907DKH.
TYPED BY: .
'. 8.9
TIME _____M
EQUIP KENT
CG CODE . PQ
LOT
DRY* WEIGHT
14 X?S?7 ~jso'
14 YC-2 93 .14 YC-2 93 14 YC-2 93
'U /dii
DRY CONT.
/d>d
NAME "KROLOR* YELLOW-MEDIUM
NO. PKG-
>7
PKG WGT
TOTAL WEIGHT
3S-fo
ACTUAL USE LBS
__ NON-BLEEDING ACCT LBS
1I
BEFORE USING SV, MAKE SURE THAT N-28-D LINE
IF ANY IS BLANKED OFF."
I RUN 60"(990 G> WATER IN V-203. SET AGITATOR ON
HIGH SPEED.
WEIGH IN DRUM & POUR IN
355
, DUMP IN AND STIR 5 MIN
.LOT
I RECORD: START7>iL^___
i
FIN
_,
H"
I 32-D I 355 3550
TO 75` (1275 G) | T| WITH AACGITATOR ON LOW SPEED PUMP V-203 THRU
&10G AT 2400-2600 PSI INTO V-205 I if'i W^EN V-203 Mt, WASH COLOR THRU HOMOG WITH MIN I JxtfF HOT WATER AT . 2400,-2600 PSI INTO V-205
[ 1'M^RECORD: V-205 VOLrG._' 6 ADJ TO 60* (2100 G) 1 ST\ INSPECT HOMOG STRAINER & CLEAN IF NECESSARY
205 f \ RUN^IO" (514 G) WATER INTO V*Z^/& START i^?GITATOR'
SV Wl PUMP V-205 THRU HOMOG AD-4800-5200 PSI INJO I REPORT: TIME START VAST-- TOTAL MINUTES JZS___ |^N6t .E; IF HOMOG PRESSURE FALLS BELOW 4800 PSI,
Jf3-WAY VALVE WILL RECIRCULATE SLURRY TO V-205
^4 i WHEN V-205 MT. RUN IN 5" (240 G) WATER & PUMP
THRU HOMOG AT 4800-5200 PSI INTO SV
SP STEP 01 - SET FORMULA SELECTOR TO POSITION
243) OR POSITION 6 (V-244)
PRESS SV CAM RESET PB - SET 22 TC IN AUTO
MOTE (TEMP IS SET AT 190-194SF)
RECORD LEVELS & SET R/M.COUNTER 1 AS FOLLOWS:
A. 1U-G3&L-Z PRESET *3
45 GAL
SET STRIKE FLOW CONTROLLERS AS FOLLOWS: ;
3FC1 (N-27-D CONTROLLER) IN MANUAL 0.73
3FC20 (N-27-D WATER) IN MANUAL LOCAL 9.56
3FR10 (N-27-D/WATER) RATIO
1.31
SFC10 (N-32-D CONTROLLER) IN MANUAL .96
8FC20 (N-32-D WATER) IN MANUAL LOCAL 8.45
SFC20 (N-32-D WATER) IN REMOTE
SFR10 (N-32-D/WATER) RATIO
1.76
&PM GPM
GPM GPM
1 I { I 1 I I I
21383-
i I 115--D | 239 Ii iI ! 27-D 1 302 I. 1 1i 1 32-D I 2022
.OT*
EQUIP MENTI
CQMTYP JOB NAME =03KY907BMH PAGE 02
DATE PRINTED: 6/16/82
PAGE a CG S3 KY-907-D
USE 1 N- ACC-T LBS I CODE LBS
PER AT OR STEP PB
RECORD LEVEL 2LG
IF BELOW 35% FOLLOW SOL'NI
E-UP PROCEDURE FOR N-27-D
JUST SV ^d^jrs* (2470 G)
RECORD PH JjtJL* ADJ TO 11.1-If.3 WITH N-7~D AT
5L^'10 PARTS WATER TO > 1 PART fsL-7-B)
IPHON INTO SV. RECORD: PH
ASSUME 50%
OPERATOR STEP PB
'
7
7-B l I
STEP 06/39*- AFTER HEAT-UP RECORD: "p h "1
ITCH 3FC20, 8FC10, & 8FC20 TO AUTO
'PER A TOR STEP PB
SP STEP 10/43* WHEN 3FC20, 8FC10 & 8FC20 FLOWS
IN LIMITS, SWITCH 3FC10 TO AUTO 6 PB
SP STEP 11/44* WHEN 3FC10 & 3FC20 FLOWS ARE
LIMITS, SWITCH 3FC20 TO REMOTE
TOR STEP PB
DURING STRIKE RECORD:
SP STEP
V-243/V-244
. RANGE
13/46 (30 MIN)
9.0-TO.O
1 4/47 (60 MIN)
9.0-10.0
15/48 (2 HRS)
9*0-10.0
16/49 (3 HRS)
9,0-10.0
1 7/50 (FINAL)
7*5-8*5
NOTE; IF PH NOT IN RANGE, NOTIFY SUPV & NOTE
IN IF FINAL PH >8*5,- ADJ TO 7.5-8.5*
ECORD; PH___ *
ASSUME 77%
IN
J1
11 i .i
i -i
ii 11
1t 11
ii it
( [ . .i i
11 ____ L^7-D i 55f*H128--A i "5~
ADD 27' (208 G) WATER TO V-3S5 D it STIR FOR 2. MIN FOR S 57
ASSUME 50%
1l 90 | 7-D i 45
URING.STRIKE CHECK LEVEL IN V-387. IF LOW LEVEL LIGHT IS NOT LIT., GO TO S-35
F LOU LEVEL LIGHT IS LIT, VERIFY BY CHECKING THAT LOW LEVEL PEG IN VAT IS ABOVE SURFACE
IF^VISUAL CHECK CONFIRMS LOW LEVEL, FOLLOW
STEARATE MAKE-UP PROCEDURE*
1 IN 32* (317 GAL). DO HOT MAKE UP THIS SOLUTION MORE THAN 30 MINUTES IN ADVANCE* DELAY BETWEEN END OF STEP 41 HEAT-UP AND START OF. STEP 48 HOMOGENIZATION SHOULD BE LESS THAN 30 MINUTES* 1 TURN ON STEAM & AGITATOR ADJUST TO 42* (403 GAL)'AT 17S-132F SET BADGER METER FOR 550* PUMP IN FROM V-387 THRU UNDERSURFACE . DISTRIBUTORS AS FAST AS POSSIBLE
SHUT OFF PUMP STIR 30 MIN AT 178~182F FOR S 48 I DO NOT SHUT OFF AGITATOR
450 50 50
| 169-AI 450 i is: -Hi 50 I 160-Ai 50
DUPO 50046294
DUP050046295
DUP050046296
DUP050046297
ft**
Ka5'v
DUP050046298