Document r69DZzddxK8OkELvd7pYXvqLJ

BETZ PROCESS CHEMICALS, INC. (713) 367-2442 9669 GROGANS MILL ROAD THE WOODLANDS , TX 77380 MATERIAL SAFETY DATA SHEET 24 HOUR EMERGENCY TELEPHONE (HEALTH OR ACCIDENT) (800) 877-1940 DISTRIBUTED: MAY-22-1992 PRODUCT : PETROFLO 20Y14 (PAGE 1 OF 3) EFFECTIVE DATE 12-06-91 PRINTED: 6-Dec-1991 REVISIONS TO SECTIONS: 1 PRODUCT APPLICATION : OIL BASED CORROSION INHIBITOR. ........ SECTION 1......................HAZARDOUS INGREDIENTS............................. INFORMATION ON PHYSICAL HAZARDS, HEALTH HAZARDS, PEL'S AND TLV'S FOR SPECIFIC PRODUCT INGREDIENTS AS REQUIRED BY THE OSHA HAZARD COMMUNICATIONS STANDARD IS l ED. REFER TO SECTION 4 (PAGE 2) FOR OUR ASSESSMENT OF THE POTENTIAL ACUTE ANu CHRONIC HAZARDS OF THIS FORMULATION. HEAVY AROMATIC NAPHTHA;***CAS#64742-06-9;C0MBUSTIBLE LIQUID;IRRITANT(EYE); PEL/TLV:NONE; NOTE-MANUFACTURERS SUGGESTED EXPOSURE LIMIT:100PPM TRADE SECRET INGREDIENT(428);EYE IRRITANT;PEL/TLV:10MG/M3. TSRN 125438 5266P ^UTYLATED HYDR0XYANIS0L(BHA)***CAS#121-00-6;IRRITANT,POTENTIAL SENSITIZER; NIMAL CARCINOGEN (IARC- 2B);PEL/TLV:NONE. -SECTION 2..................... TYPICAL PHYSICAL DATA................................................. Pp 50% EXTRACT (APPROX.) F T.(DEG.F): 167 SETA(CC) VAPOR PRESSURE(iranHG): <10 VISC cps70F: 14 EVAP.RATE: <1 ETHER-1 PHYSICAL STATE: LIQUID 4.5 ODOR: HYDROCARBON SP.GR.(70F)0R DENSITY: 7.61 LBS/GAL VAPOR DENSITY(AIR-1): >1 %SOLUBILITY(WATER): 0 APPEARANCE: YELLOW FREEZE POINT(DEG.F): <-30 ........ SECTION 3..................... REACTIVITY DATA..................................................... STABLE.MAY REACT WITH STRONG OXIDIZERS.DO NOT CONTAMINATE.BETZ TANK CLEAN-OUT CATEGORY 'B' THERMAL DECOMPOSITION (DESTRUCTIVE FIRES) YIELDS ELEMENTAL OXIDES. SL 010631 C*o ^ MATERIAL SAFETY DATA SHEET (PAGE 2 OF 3) r *)UCT: PETROFLO 20Y14 ^-SECTION 4.....................HEALTH HAZARD EFFECTS............................................... AWE SKIN EFFECTS *** PRIMARY ROUTE OF EXPOSURE MODERATELY IRRITATING TO THE SKIN.POTENTIAL SKIN SENSITIZER ACUTE EYE EFFECTS *** SEVERE IRRITANT TO THE EYES ACUTE RESPIRATORY EFFECTS *** PRIMARY ROUTE OF EXPOSURE PROLONGED EXPOSURE MAY CAUSE DIZZINESS AND HEADACHE CHRONIC EFFECTS OF OVEREXPOSURE*** PROLONGED OR REPEATED OVEREXPOSURES MAY CAUSE SKIN SENSITIZATION;PRODUCT OR PRODUCT COMPONENT MAY INCREASE THE RISK OF CANCER BASED ON LIMITED ANIMAL DATA. MEDICAL CONDITIONS AGGRAVATED *** NOT KNOWN SYMPTOMS OF EXPOSURE *** .'XCESSIVE DERMAL EXPOSURE CAUSES DEFATTING AND DRYING OF SKIN;EXCESSIVE INHALATION OF VAPORS CAUSES DIZZINESS,HEADACHE AND NAUSEA. .........SECTION 5....................... FIRST AID INSTRUCTIONS............................................ SKIN CONTACT*** REMOVE CONTAMINATED CLOTHING.WASH EXPOSED AREA WITH A LARGE QUANTITY OF SOAP SOLUTION OR WATER FOR 15 MINUTES EYE CONTACT*** IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MINUTES.IMMEDIATELY CONTACT A PHYSICIAN FOR ADDITIONAL TREATMENT RATION EXPOSURE*** Remove victim from contaminated area to fresh air.apply appropriate FIRST AID TREATMENT AS NECESSARY INGESTION** DO NOT FEED ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSIVE VICTIM JO NOT INDUCE VOMITING.IMMEDIATELY CONTACT PHYSICIAN. DILUTE CONTENTS OF STOMACH USING 3-4 GLASSES MILK OR WATER .........SECTION 6..................... SPILL,DISPOSAL AND FIRE INSTRUCTIONS................. SPILL INSTRUCTIONS*** VENTILATE AREA,USE SPECIFIED PROTECTIVE EQUIPMENT.CONTAIN AND ABSORB ON ABSORBENT MATERIAL.PLACE IN WASTE DISPOSAL CONTAINER. THE WASTE CHARACTERISTICS OF THE ABSORBED MATERIAL,OR ANY CONTAMINATED SOIL, SHOULD BE DETERMINED IN ACCORDANCE WITH RCRA REGULATIONS. REMOVE IGNITION SOURCES.FLUSH AREA WITH WATER.SPREAD SAND/GRIT. DISPOSAL INSTRUCTIONS*** WATER CONTAMINATED WITH THIS PRODUCT MAY BE SENT TO A SANITARY SEWER TREATMENT FACILITY,IN ACCORDANCE WITH ANY LOCAL AGREEMENT,A PERMITTED WASTE TREATMENT FACILITY OR DISCHARGED UNDER A NPDES PERMIT PRODUCT(AS IS)- INCINERATE OR BURY IN APPROVED LANDFILL FIRE EXTINGUISHING INSTRUCTIONS*** FIREFIGHTERS SHOULD WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS(FULL FACE-PIECE TYPE).PROPER FIRE EXTINGUISHING MEDIA: "JY CHEMICAL/C02/FOAM OR WATER. SLIPPERY CONDITION. USE SAND/GRIT CO*1 5 to SL 010632 * pt 0< CP MATERIAL SAFETY DATA SHEET (PAGE 3 OF 3) 4UUCT: PETROFLO 20Y14 ^-SECTION 7...................... SPECIAL PROTECTIVE EQUIPMENT................................... USE PROTECTIVE EQUIPMENT IN ACCORDANCE WITH 29CFR SECTION 1910.132-134. USE RESPIRATORS WITHIN USE LIMITATIONS OR ELSE USE SUPPLIED AIR RESPIRATORS. VENTILATION PROTECTION*** ADEQUATE VENTILATION TO MAINTAIN AIR CONTAMINANTS BELOW EXPOSURE LIMITS RECOMMENDED RESPIRATORY PROTECTION*** IF VENTILATION IS INADEQUATE OR SIGNIFICANT PRODUCT EXPOSURE IS LIKELY, USE A RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES. RECOMMENDED SKIN PROTECTION*** NEOPRENE GLOVES WASH OFF AFTER EACH USE.REPLACE AS NECESSARY RECOMMENDED EYE PROTECTION*** SPLASH PROOF CHEMICAL GOGGLES -SECTION 8...................... STORAGE AND HANDLING PRECAUTIONS........................... SiuRAGE INSTRUCTIONS*** KEEP DRUMS & PAILS CLOSED WHEN NOT IN USE. STORE IN COOL VENTILATED LOCATION.STORE AWAY FROM OXIDIZERS HANDLING INSTRUCTIONS*** COMBUSTIBLE. DO NOT USE AROUND SPARKS OR FLAMES. BOND CONTAINERS DURING FILLING OR DISCHARGE WHEN PERFORMED AT TEMPERATURES AT OR ABOVE THE PRODUCT FLASH POINT. ************************************************************************** T'-'S MSDS WAS WRITTEN TO COMPLY WITH THE OSHA HAZARD COMMUNICATION STANDARD ^^********************************************************************** APPENDIX: REGULATORY INFORMATION THE CONTENT OF THIS APPENDIX REPRESENTS INFORMATION KNOWN TO BETZ ON THE EFFECTIVE DATE OF THIS MSDS. THIS INFORMATION IS BELIEVED TO BE ACCURATE. A>,u CHANGES IN REGULATIONS WILL RESULT IN UPDATED VERSIONS OF THIS DOCUMENT. ...TSCA: ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY ...REPORTABLE QUANTITY(RQ) FOR UNDILUTED PRODUCT: TREAT AS OIL SPILL ...RCRA: IF THIS PRODUCT IS DISCARDED AS A WASTE,THE RCRA HAZARDOUS WASTE IDENTIFICATION NUMBER IS: NOT APPLICABLE ...DOT HAZARD/UN#/ER GUIDE# IS: COMBUSTIBLE LIQUID NA1993/#27 ...CALIFORNIA SAFE DRINKING WATER ACT (PROPOSITION 65) MATERIALS: THIS PRODUCT CONTAINS THESE CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER OR REPRODUCTIVE TOXICITY: BUTYLATED HYDROXYANISOL(121-00-6) ...SARA SECTION 313 CHEMICALS: NONE ...SARA SECTION 312 HAZARD CLASS: IMMEDIATE(ACUTE),DELAYED(CHRONIC) AND FIRE ...MICHIGAN CRITICAL MATERIALS: NONE NFPA/HMIS : HEALTH - 2 ; FIRE - 2 ; REACTIVITY - 0 ; SPECIAL - NONE ; PE - B SL 010633 of protect* roli