Document qnDvbqaxR5QJaVmY6pbk6bk
Ct/fr fiaTlrt/Ats&e '/3c
September 9, 1981
/
Scientific Products Division American Hospital Supply Corporation 1430 Waukegan Hoad McGaw Park, IL 60085
REPLY TO: EAST WALPOLE. MA 02032 TEL: 617-068-2500
Dear Sir:
Would you please furnish us Material Safety Handling Sheets for the following chemicals- We need these to conform to the storage of these chemicals in accordance with the chemical manufacturer's recommendations.
N-^JEPTANE 5177-8 Very trutf yours.
Herbert W, Church Purchasing Analyst
HC/ns
CORPORATE HEADQUARTERSEAST WALPOLE. MA BRANCH OFFICES AND PLANTSMARTINEZ, CA SAN MATEO. CA WILMINGTON. CA CHICAGO. IL BARDSTOWN, KY * SHREVEPORT. LA NORWOOD. MA
PERTH AMBOY. NJ FRANKLIN. OH . PORTLAND. OR . CHARLESTON, SC
BIRD 013216
U.S. DEPARTMENT OF LABOR Occupational Safety and Health Administration
MATERIAL SAFETY DATA SHEET
Required under USDL Safety and Health Regulations for Ship Repairing, Shipbuilding, and Shipbreaking <29 CFR 1915, 1916, 1917)
MANUFACTURER'S NAME
MALLINCKROOT, INC.
CHEMICAL NAME ANQ SYNONYMS
CHeiOjOCrgAaL nfAicmiClyo--m----p---o---u---n--d7
SECTION 1
EMERGEN
P.0. Box K, Paris, Ky. 40361
TRADE NAME ANO SYNONYMS
Dlproovl mefchaae___________________ * CH,
SECTION 11 HAZARDOUS INGREDIENTS
PAINTS, PRESERVATIVES, & SOLVENTS
X TLV
(Units)
ALLOYS AND METALLIC COATINGS
PIGMENTS
BASE METAL
CATALYST VEHICLE SOLVENTS ADDITIVES
OTHERS
ALLOYS
` METALLIC COATINGS FILLER METAL PLUS COATING OR CORE FLUX OTHERS
HAZARDOUS MIXTURES OF OTHER LIQUIDS. SOLIDS, OR GASES
TLV X (Units)
TLV X {Units!
SECTION III - PHYSICAL DATA
SOILING POINT <*F.l vapor pressure (mm Ha.iat 22.3F
VAPOR DENSITY (AIR*1> SOLUBILITY IN WATER
208F
SPECIFIC GRAVITY (HjO-l)
40 mm.
PERCENT, VOLATILE BY VOLUME (%)
3.45
EVAPORATION RATE
Water ........u
insoluble
appearance ano poor Colorless Liquid
0.68 . 100
1
9
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
P1--ASM POINT (M.ttiod used)
25 "F
FLAMMA8UE LIMITS
U*f -erf-
^'^^AlcohoI^P'toam, carbon dioxide, dry chemical
SPECIAL EIRE FIGHTING PROCEDURES
------- Hn nob use uat-er. Heptane is lighter than water and will float. ..may. ..spread. the fire.
UNUSUAL FIRE ANO EXPLOSION HAZARDS
Vapors are heavier than air.
ignition and flash back.
They may travel a.long dlSar'C.g-L9..J>PinJt:..<?f
PAGE (1)
(Continued on reverie side)
Form 0SHA-20
Rev. May IX
SECTION V . HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE
500 ppm_________________
craters of overexposure
~___________________________ ______________________________
------ Remove froa-ecnosphara. AVaft- ar-t;14igial-iresp-l-cafciq[i--if~paTson- is--unconscious-
Get medical attention.
EMERGENCY ANO RIRST AIO PROCEDURES
______ATTqp jtH filial rpeji<raf^n -If porann 1Q nni>nn<r<ftn<.____Gfft mPfH Oa.1__Rf tfULtlfrin,
SECTION VI - REACTIVITY DATA
STABILITY
UNSTABLE
CONDITIONS TO AVOID
STABLE incompatability (Matenalt to anuuij
X
.
HAZAROOUS DECOMPOSITION PRODUCTS
HAZAROOUS POLYMERIZATION
MAY OCCUR WILL NOT OCCUR
conditions to avoio
X
SECTION VII - SPILL OR LEAK PROCEDURES
STEPS TO 3E TAKEN IN CASE MATERIALIS RELEASED OR SPILLED
Absorb on paper rowel. Let: eyaporate. in a hood, in., an iron..pan,___ Alias,fuses Co clear Che hood vent3 and burn Che paper.
WASTE OISPQSAL METHOD
Mix with lower flammable organic solvenc and spray Inco Che Ignition chamber
of an incinerator with afterburner.
SECTION VII! SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION 'SOKl/V tVpef
Gas mash with orranlc vanor canniscer.
ventilation
LOCAL EXHAUST
SPECIAL
...MECHANICAL /General)
OTHER
PROTECTIVE GLOVES
aTH62SBrt5craIVE; EQU,pMeNT
EVE PROTECTION
Solash proof eoeeles.
SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO 3E TAKEN IN 4ANOLING ANO STORING
'
flurg'trfe sfoT-agp ?< preferrpri. Tna-trfe srnra^p should ha in a standard room
for flammable solvent.
OTHER PRECAUTIONS
PAGE (21
OP<3 *33.340
Form OSHA-20
Xt, Miy 72
2c 34
BIRD 013218