Document qa7r91aDGEgz5wzx13zwxL7ek
(IMPORTANT: Type or print; read instructions before completing form)
Form Approved OMB Number: 2070-0092 Approval Expires: 11/92
PAGE 1 OF 9
1 | EPA
United States 1 Environmental | Protection j Agency i
FORM R
TOXIC CHEMICAL RELEASE
i |
INVENTORY REPORTING FORM
|
1 Section 313 of the Emergency Planning and Community Right-to-Know Act of 1986,| also Jcnown as Title III of the Superfund Amendments and Reauthorization Act |
i
i
|TRI FACILITY ID NUMBER |
| 70765THDWCHIGHW
|
---------------------------------- -
|Chem., Cat., or Gen. Name |
I | BENZENE
i | WHERE TO SEND | COMPLETED FORMS:
1 1 1 1
1. EPCRA Reporting Center P 0. Box 3348 Mernfield, VA 22116-3348 ATTN: TOXIC CHEMICAL RELEASE INVENTORY
2. APPROPRIATE STATE OFFICE (See instructions in Appendix F)
| |
1 |
1 1 1
1 Enter "X" here if |
this is a revision|
i i
IMPORTANT:
See instructions to determine when "Not Applicable (NA)' boxes should be checked.
|For EPA use only
PART I. FACILITY IDENTIFICATION INFORMATION
SECTION 1.
*-------------------------------------- - - - --------------- --------------- - - | |Section 2. TRADE SECRET INFORMATION
REPORTING YEAR
1995
| | 2.11 Are you claiming the toxic chemical identified on page 3 trade secret?
|j | [ J Yes (Answer question 2.2;
[X] No (Do not answer 2.2;
Go to Section 3)
1 ----------------------------------------------------------------------------------
| | 2.2| If yes in 2.1, is this copy:
[ ] Sanitized
[ ] Unsanitized
- - + -------+----------------- --------------- ----------- - - -------------
1
1 1 1
1
| SECTION 3. CERTIFICATION (Important: Read and sign after completing all form sections.)
I
I hearby certify that I have reviewed the attached documents and that, to the best of my knowledge and belief, the submitted
I
information is true and complete and that the amounts and values in this report are accurate based on reasonable estimates using|
data available to the preparers of this report.
I
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
Df) .`-1 C'.C: ~ ^Nr' T OFT ' A'
EPA United States Environmental Protection Agency
EPA FORM R PART I. FACILITY IDENTIFICATION
INFORMATION (CONTINUED)
PAGE 2 OF 9
| | TRI FACILITY ID NUMBER
|
| +-------------------------- ----------------- **
| | 70765THDWCHIGHW
|
j 4-------------------------------------------------- --
j |Chem., Cat., or Gen. Name | | +-------------------------------------------- -*
| | BENZENE
|
|SECTION 4. 'FACILITY IDENTIFICATION {Continued)
|4.2
This report contains information for:|
(Important: check only one)
| a. [XI An entire facility
b. [ ) Part of a facility
c. [ 1 Federal Facility
|4.3
Technical! Name Contact | DOYLE A. HANEY
| Telephone Number (include area code) j (504)353-6128
4.4 Public | Name Contact | GERRY DAIGRE
Telephone Number (include area code) (504)353-1602
|4.S
SIC Code I (4-digit) | a. 2812
b. 2821
c. 2869
1 1 .6 1
1 1 1 Longitude
1
}
1 |
Degrees 030
Latitude
| Minutes
1 1 19
i
7 I Dun k Bradstreet Number(a) i i i
i
(9 digits)
.8 | EPA Identification Number(a) (RCRA I.D. No.)
i 1 1
1 1
Seconds 00
1 .9 |
1 i i
Facility NPDES Permit Number(a)
(9 characters)
.10|
1 i i
Underground
Injection Nell
Code (UIC) I.D. (12 digits)
I | d. NA
1 i Degrees
1 1 091
i 1 a. i 1 b.
1 1 a.
1 1 b.
1 1 a. i
1 b.
1 1 a. i 1 b.
I *
Longitude
1 Minutes
1 1 16
|
|1 |
008187080
NA
LAD0081B7080
NA
LA0003301
LA0049638
NA
Seconds 20
SECTION 5. PARENT COMPANY INFORMATION
|5.1|Name of Parent Company
I *........................
II I |[ 1 NA
I
THE DON CHEMICAL COMPANY
|5.2|Parent Company's Dun k Bradatreet Number|
i
|[ ] NA
|
(9 Digita)
001381581
*---- ----------------- ---------------------------------------------------------------
EPA Form 9250-1 (Rev. 12/4/94) - Previous editiona are obaolete.
c \i
EPA
United States Environmental Protection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION
PAGE 3 OF 9
i | TRI FACILITY ID NUMBER i i j 70765THDWCHIGHW i i |Chem., Cat., or Gen. Name i i | BENZENE
SECTION 1. TOXIC CHEMICAL IDENTITY (Important: DO NOT complete this section if you complete Section 2 below.)
11.11 CAS Number (Important: Enter only one number exactly as it appears on the Section 313 list.
I *.............................
II ||
000071-43-2
...................................................................................................................................................................................................................
.....................
.................. .................. *
- - ................................. ... ......... ... *
*
----------------------------------------
|1.2| Toxic Chemical or Chemical Category Name (Important: Enter only one name exactly as it appears on the Section 313 list.)
I ...............................................................................................................................................................................................................................................................................................
II II
BENZENE
|1.3| Generic Chemical Name (Important: Complete only if Part I, Section 2.1 is checked 'yes. I
NA
|SECTION 2. MIXTURE COMPONENT IDENTITY (Important: DO NOT complete this | section if you complete Section 1 above.)
|2.1| Generic Chemical Name Provided by Supplier (Important: Max. of 70 chars., including numbers, letters, spaces, and punct.)
II II
NA
|
|SECTION 3. ACTIVITIES AND USES OF THE CHEMICAL AT THE FACILITY
1 |Manufacture |the toxic |chemical: j.l\ 1 i
i
i
| Process 3.2 j the toxic
| chemical i i i
1 1 1 1 1 1 1 1
1
1 1 1 1 1 1 1
i | Otherwise use 3.3j the toxic
| chemical:
1 1
1 1 1 1 1 1
a. [X] Produce b. [ ) Import
a. [ 1 As a reactant b. t ) As a formulation component
a. [ ] As a chemical processing aid b. [X] As a manufacturing aid
(Important: Check all that apply.) If produce or import:
c. [X] For on-site uae/processing d. m For sale/distribution e. [X] As a byproduct f. ( ] As an impurity
c. [X] As an article component d. [ ] Repackaging
c. [X] Ancillary or other use
1 l1 1 1 i i
l i
i
i
i i i i i i
i
i i i i i
Section 4. MAXIMUM AMOUNT OF THE TOXIC CHEMICAL ON-SITE AT ANY TIME DURING THE CALENDAR YEAR
1 4.1| 08 (Enter two- digit code from instruction package.)
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
i 1
i i
t 1
r))
()". t r h
r our ^ r-F^r,T i a.
EPA
United States Environmental Protection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 4 OP 9
1 |TRI FACILITY ID NUMBER 1 1 | 70765THDHCHIGHH 1 1 |Chem., Cat., or Gen. Name 1 1 | BENZENE
| SECTION 5. RELEASES OF THE TOXIC CHEMICAL TO THE ENVIRONMENT ON-SITE
i
1 j
1i
j 5.l |
1
|Fugitive or non-point air |emissions
1
ii
j 5.2 |Stack or point air emissions 11
|A 1 1 1
i
11 1 I 1HA| 11
ii
1 [ ]NA| 11
Total Release (pounds/year) |B.
(enter range code from
1
instructions or estimate) 1
1
2240
1 1 1 1
14270
I 1 1
Basis of Estimate (enter code)
E
0
1 C. % From 1 Stormwater 1 1
1 1 1 1
1 1 1
1 |5.3 |
)
| [Discharges to receiving [streams or water bodies
|(enter one name per box)
[5.3.1 Stream or Water Body Name
|MISSISSIPPI RIVER 1
|5.3.2 Stream or Hater Body Name |na 1
5.3.3 Stream or Hater Body Name
1
1 1 1 1 i
i4 i
i ! i
i i
i
i iM i
i i i i
i i i i
1 1 1 000.00 1
1 1 1 1
1 1 1 1
1 |5.4 j
i
1 [Underground injections jon-site
i
1 5.5
i
1 [Releases to land on-site
i
ii ii 1 [X] NA |
11
NA
1 1 1
i1 i1 i1 i1
*
11 |5.5.1| Landfill 11
1I [5.5.2( Land treatment/ | | application farming ii
1 [X] NA | NA 11
11 11 | [X] NA|
11
NA
i1 i1 i1
ii 1 i1 i1 i1
11 | 5.5.3 | Surface impoundment
ii
11 1 [X]NA| 11
NA
i i i
11 |5.5.4| Other disposal ii !
| [X]NA| NA 11
ii i i
| ( ] Check here only if additional Section 5.3 information is provided on page 5 of this form. 1
1 1 1
11 1 1
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes
A 1-10 pounds B - 11-499 pounds; C - 500 - 999 pounds.
on a non; : i-'M t r r nt i a
EPA
United States Environmental Protection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
| Section S.3 ADDITIONAL INFORMATION ON RELEASES OF THE TOXIC CHEMICAL TO THE ENVIRONMENT ON-SITE
|5.3 | |
|Discharges to receiving I streams or water bodies |(enter one name per box)
|A. Total Release (pounds/year) j (enter range code from j instructions or estimate)
15.3.4 Stream or Hater Body Name
PAGE 5 OF 9
| lTRI FACILITY ID NUMBER
| | 7076STHDWCHIGHW
------------------------- -------*-----------------------------------
j |Chem., Cat., or Gen. Name
| 4--..-----------------------------------------------------------------
| | BENZENE
Basis of Estimate (enter code)
% From Stormwater
15.3.S Stream or Water Body Name
|5.3.6 Stream or Hater Body Name
| SECTION 6. TRANSFERS OF THE TOXIC CHEMICAL IN WASTES TO OFF-SITE LOCATIONS
| 6.1 DISCHARGES TO PUBLICLY OWNED TREATMENT WORKS (POTW)
-----------------------------............---------------- .........--------- ...
|6.1.A Total Quantity Transferred to POTWs and Basis of Estimate
|6.1.A.1 Total Transfers (pounds/year) 1 (enter range code or estimate)
6.1.A.2 Basis of Estimate (enter code)
NA
6.1.B POTW Name and Location Information
|6.1.B.1| POTW Name II | Street Address
6.1.B.2 POTW Name Street Address
I I City
State
I |County
|Zip Coda
City State
j County | Zip Code
| If additional pages of Part II, Sections S.3 and/or 6.1 are attached, indicate the total number of | pages in this box [ ] and indicate which Part II, Sections 5.3/6.1 page this is, here. [1 ] | (example: 1,2,3,etc.)
EPA Form 92S0-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes: A - 1-10 pounds; B - 11-499 pounds; C - 500 - 999 pounds.
EPA
United States Environmental Protection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 6 OF 9
1 J tri facility id number
1 I 70765THDWCHIGHW 1 -------------- ----------------------------------j |Chem., Cat., or Gen. Name j -------------- *--------------------------------j | BENZENE
SECTION 6.2 TRANSFERS TO OTHER OFF-SITE LOCATIONS
|6.2.1 0ff-9ite EPA Identification Number (RCRA ID No.) j NA
| Off-Site Location Name
| Street Address
------------------ ---- ----------------- ----------- ----------- ------------------------------------------------ +---------
| City
| County
I
| State
|Zip Code
| Is location under control of reporting
[ ) YES
[ ] NO
|
|A. Total Transfers (pounds/year) | (enter range code or estimate)
|B. Basis of Estimate | (enter code)
|C. Type of Waste Treatment/Disposal/ | Recycling/Energy Recovery (enter code)
U- ii. i
1 12. |2-
1 3. 13.
i
4 . !
ii. i 12
1 |3.
|4-
SECTION 6 .2 TRANSFERS TO OTHER OFF-SITE LOCATIONS
,.*.2.2 Off-site EPA Identification Number (RCRA ID No.) I NA
I I
Off-Site Location Name
I
Street Address
City State
|Zip Code
| County 1
| Is location under control of reporting
[ ] YES
[ ] NO
A. Total Transfers (pounds/year) (enter range code or estimate)
|B. Basis of Estimate | (enter code)
i
|C. Type of Waste Treatment/Disposal/ 1 Recycling/Energy Recovery (enter code)
1
1 1. |1.
1 11.
1 2. |2.
1 12.
1 3. 1 3 *
1 |3.
1 4 . |4.
1 l-
If additional pages of Part II, Section 6.2 are attached, indicate the total number of pages in this box [ ] and indicate which Part II, Sections 6.2 page this is, here. [1 ]
(example: 1,2,3,etc.)
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes: A - 1-10 pounds; B - 11-499 pounds; C - 500 - 999 pounds.
I 1 I
p'O P rONrTnir,'n ' P'
EPA
United States Environmental Protection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 7 OF 9
| |TRI FACILITY ID NUMBER
j | 7076STHDWCHIGHW 1 ----------* - - --------* ' -----------------| |Chem., Cat., or Gen. Name j +-------------------------- ----------------- - | | BENZENE
Section 7A. ON-SITE WASTE TREATMENT METHODS AND EFFICIENCY
[ ] Not Applicable (NA) - Check here if no on-site treatment is applied to any waste stream containing the toxic chemical or chemical category.
a. General Waste Stream (enter code )
b. Waste Treatment Method(s) Sequence [enter 3-character code(sl)
c. Range of Influent Concentration
7A. la
7A. lb
1 | P21
| 2 | NA
+----- ---
------
+
---------------------------
------
I4 |
|5 |
7A.1C
d. Treatment Efficiency Estimate
7A. Id
098.00
%
e. Based on Operating Data?
7A.le
Yes ]
No tX
7A.2a 7A.3a 7A.4a 7A.Sa
7A.2b
3I ---- -----
SI
+ ------
7A. 3b
1 | A02 +-----
| 2 | NA
I I
I
------------
---------- --------- +
I7 |
I
5| 8|
| | |
1 A02
2| NA
|
------------------------ *
--- -----------------------------
*--------------- ----- ------------
I4 I
I5 |
|
+ 4.------------------+ 4.----------------- +
i7 I
|8 I
|
7A.4b
6I 7A.5b
1 I Pll ------
- -------
I 4|
2 NA SI I
II
1 | Bll | ---------------------------------
4I
I
------------------ 4>
----------------------------*
7I
I
2 | NA - ------+---------
5| ---------
+----------------
8|
7A.2C 7A.3c 7A.4C 7A.Sc
7A.2d
065.00
%
Yes (]
No [XI
7A. 3d
025.00
%
7A.3e
Yes [1
No [X
7A.4d
000.00
%
7A. 4e
Yes t]
No tX]
7A.Sd
095.00
%
7A.Se
Yes []
No 1X]
| If additional pages are attached, indicate the total number of pages in this box [3 ] and indicate which page this is, here [1].| EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
| EPA
I | United States
Environmental Protection i Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
| Section 7A. ON-SITE WASTE TREATMENT METHODS AND EFFICIENCY
[ ] Not Applicable (NA) - Check here if no on-site treatment is applied to any waste stream containing the toxic chemical or chemical category.
I a General Waste Stream
(enter code )
b. Waste Treatment Method(s) Sequence [enter 3-character code(s))
c. Range of Influent Concentration
7A. la
7A. lb
3I
6I
Fll
I 4|
-
I 3I
2 |NA
|
-------------- *
- - - ---------------
5I
I
7A.1C
d. Treatment Efficiency Estimate
7A. Id
099.99
%
7A.2b
1 | Fll | 2 | NA
|
7A.2C
7A. 2d
7A.3a
6I 7A.3b
6I
I 4|
I 7|
5I
1| AO 7
| 2 | NA
4---------------4
*-
4 4---------------------------4 4-
I 4|
|5 |
4
4.---------------------------4
4.
.4 4---------------------------4 4-
I 7|
|8 |
7A.3C
099.99
%
7A.3d
095.00
%
7A.4a
7A.4b
F99 2 I NA
7A.4C
7A.4d
I4
099.90
%
PAGE 7 OF 9
|TRI FACILITY ID NUMBER ---------- -------- -------I 70765THDWCHIGHW
IChem., Cat., or Gen. Name |
| BENZENE
e. Based on Operating Data?
7A.le
Yes [X ]
t]
7A.2e
[X)
No [)
7A.3e
[1
No [X]
7A.4e
Yes [X]
[]
7A.Sb
1 A01
I 4|
I 7|
2 | NA
|
SI I
7A.5C
7A.5d
099.99
t
7A.5e
IJ
[X
If additional pages are attached, indicate the total number of pages in this box [3 ] and indicate which page this is, here [2].| EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
' PF'
EPA
United States 'nvironmental rotection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 7 OP 9
|TRI FACILITY ID NUMBER
................................. *-------------------
I 70765THDWCHIGHW
|Chem., Cat., or Gen. Name --------------------------------------------- -| BENZENE
Section 7A. ON-SITE WASTE TREATMENT METHODS AND EFFICIENCY
[ ] Not Applicable (NA) - Check here if no on-site treatment is applied to any waste stream containing the toxic chemical or chemical category.
a. General Waste Stream (enter code )
b. Waste Treatment Method(s) Sequence [enter 3-character code(a)]
c. Range of Influent Concentration
7A. la
7A. lb
1 | F99
| 2 | A04 |
- - - -----------4
+--------------- +
4 - *---------------------4
4------------4---------------------------------------------------------4
3 | A03
| 4 | C99
| 5 | Cll |
4------------------ - 4
4--------------------------4
4-------------------------4
4---------------------------4
6 | NA
|7
4-- -------------*--4
||
4--------4
8| |
7A.1C
d. Treatment Efficiency Estimate 7A. Id
099.99
e. Based on Operating Data?
7A.le
Yes [X]
No []
7A.2a
7A.2b
1 | P42 | 2 | NA
|
7A.2c
7A.3a 7A. 4a 7A.5a
6I 7A.3b
3I
4-
6I 7A.4b
I
4- - -
7A.5b
1 | P49
4 ---------------- 4 4--------------------
I 4I
4 4------------------- 4 4------------------
I 1I
2 | NA
|
8I
1I
4*
4-
4I
I e|
7A.3c 7A.4C 7A.Sc
7A.2d 099.00
7A.3d 099.00
7A.4d
7A.5d
7A.2e
Yes tX
No [I
7A.3e
Yes [X]
[1
7A.4e
[]
t1
7A.5e
6I
I 4|
*4 4 4 4-
I 7I
5I
Yes [1
No I
4 44
If additional pages are attached, indicate the total number of pages in this box [3 ]1 and indicate which page this is, here [31.
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
PO P OF VIA C ONFTDFNT 1 Pi
| EPA
1 1 United States
Environmental Protection | Agency
1
EPA FORM R PART II. CHEMICAL-SPECIFIC
INFORMATION (CONTINUED)
PAGE 8 OF 9
1 | TRI FACILITY ID NUMBER 1 1 | 70765THDWCHIGHW 1 1 |Chem., Cat., or Gan. Name 1 1 | BENZENE
|Section 7B. ON-SITE ENERGY RECOVERY PROCESSES
( ] Not Applicable (NA) - Check here if no on-site energy recovery is applied to any waste stream containing the toxic chemical or chemical category.
Energy Recovery Methods [enter 3-character code(s)]
1 U03
2 NA
3
|Section 7C. ON-SITE RECYCLING PROCESSES
- - ------------------------------------------------------- ------------- ........------ * -- ----------------
[X] Not Applicable (NA) - Check here if no on-site recycling is applied to any waste stream containing the toxic chemical or chemical category.
Recycling Methods tenter 3-character code(s)]
6 I 10
EPA Form 9350-1 (Rev. 12/4/94) - Previous editions are obsolete.
ONF
EPA
United States Environmental -'rotection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 9 OF 9
|TRI FACILITY ID NUMBER
|
-- ----------------------------*----------------------------------------------------*
| 70765THDWCHIGHW
|
*----------- ----------------------------- --------------------------------------*
|Chem., Cat., or Gen. Name I +---------------*------------------- -- * *-------*
| BENZENE
|
Section B. SOURCE REDUCTION AND RECYCLING ACTIVITIES
All estimates can be reported using up to two significant figures.
1 8.1 |Quantity released *
i
[Quantity used for energy 8.2 [recovery on-site
i
[Quantity used for energy 8.3 [recovery off-site
i
8.4 (Quantity recycled on-site 1
i i i
i i i
i i
i i i
i i
Column A 1994
(pounds/year) 49000
o
0
o
| Column B
i Column C
j Column D
j 1995
i 1996
| 1997
j (pounds/year) I (pounds/year) j (pounds/year)
1 11
|
16500
i
16500
|
16500
1I i
ii i
1
661000
i
661000
|
661000
1l 1
ii l
1
0I
01
0
1i1
iii
1
0i
o]
0
1I1
1 8.5 |Quantity recycled off-site
i i
i i i i
! 01
1 1
0I I I
1 01
1 1
0
1 8.6 |Quantity treated on-site
i i
i i i i
29000
1 |
I i
699000
I I i
699000
1 |
1 1
699000
1 8.7 |Quantity treated off-site
i i
i i i i
1 o1
1 1
0
8.8 |Quantity released to the environment as a result of remedial actions, (catastrophic events, or one-time events not associated with (production processes (pounds/year)
i i I I
0
| ( (
i |
1 1
0 0
8 9 |Production Ratio or Activity Index -------4
8.10
|Did your facility engage in any source reduction activities for this chemical during
|the reporting year? If not, enter "NA* In Section 8.10.1 and answer Section 8.11.
0001.09
| Source Reduction Activities | ( [enter code(s)] |
8.10.1 |
NA
!*
8.10.2 |
i-
8.10.3 |
i.
8.10.4 |
i-
Methods to Identify Activity (enter codes)
|b. |c. !b.
|cic. |b. ib. ic.
8.ll| Is additional optional information on source reduction, recycling, or ( pollution control activities included with this report? (Check one box)
| YES 1 t1
NO [X]
| t |
* Report releases pursuant to EPRCA Section 329(8) including `any spilling, leaking, pumping, pouring, emitting, emptying, discharging, injecting, escaping. leaching, dumping, or disposing into the environment.* Do not include any quantity treated on-site or off-site.
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
r' O A 0 c E>
rONFTDFNT