Document pa51LBDdbaqdq5EEZm85E3oj

72-62-7820-01 MATERIAL SAFETY DATA SHEET ABDOO105643 Asktsnd Chernies/ Camasm* DIV'SION OF ASHLAND OIL. INC. P O BOX 2219. COLUMBUS. OHIO 43216 1614) SB9-3333 24-HOUR EMERGENCY TELEPHONE 1606) 324-1133 001641 EPON RESIN 828 THIS MSDS COMPLIES WITH 29 CFR 1910.1200 (THE HAZARD COMMUNICATION STANDARD) oipO Attend- Page A Product Name: EPON RESIN 828 CAS NUMBER: 25068-38-6 VISTA CHEMICAL COMPANY HIGHWAY 25 ABERDEEN MS 39730 05 50 086 9431550- PRODUCT: 3320655 INVOICE: 558813 INVOICE DATE: 09/09/89 TO: SAME Data Sheet No: 0004007-006 Prepared: 02/03/88 Supersedes: 03/04/86 ATTN: PLANT MGR./SAFETY DIR. ^ V7>* . v djsSECfTrON'4I--'PRODUCT CIBBNTJ'FillCATil'ON^^^ General or Generic ID: EPOXY RESIN DOT Hazard Classification: NOT APPLICABLE ^ E.Cffil 0 N M RO N BN T*S . IF PRESENT, IARC, NTP AND OSHA CARCINOGENS AND CHEMICALS SUBJECT TO THE REPORT ING REQUIREMENTS OF SARA TITLE III SECTION 313 ARE IDENTIFIED IN THIS SECTION. SEE DEFINITION PAGE FOR CLARIFICATION INGREDIENT X Ibv NT) PEL TLV Note BISPHENOL A/EPICHLOROHYDRIN EPOXY RESIN CAS 9: 25068-38-6 100 ( 1) Notes: ( 1) PEL/TLV NOT ESTABLISHED FOR THIS MATERIAL THIS PRODUCT IS AN EPOXY RESIN PRODUCED BY THE CONDENSATION REACTION OF EPICHLOROHYDRIN AND BISPHENOL-A, WHICH ARE CONSUMED IN THE PROCESS. RESIDUAL LEVELS OF EPICHLOROHYDRIN ARE CONTROLLED TO 1 PPM, MAX. BISPHENOL-A LEVELS ARE TYPICALLY <100 PPM. ^^SEefTitON ilsPIrSBHY*S:IDAL 4DATTA ^ Vr Boiling Point for PRODUCT > 500.00 Deg F ( 260.00 Oeg C a 760.00 ran Hg Vapor Pressure for PRODUCT 0.03 mm Hg 3 77.00 Deg F ( 25.00 Deg C) Specific Vapor Density AIR = 1 > 1.0 Specific Gravity 1.168 3 68.00 Deg F ( 20.00 Deg C) Percent Volatiles NOT APPLICABLE Evaporation Rate NOT APPLICABLE Appearance CLEAR, G COLOR 3 MAX, VISCOUS State Form - ' ' FLASH POINT! PMCC ) LIQUID HOMOG SOLN ZSS&m.ON'--4(IVr$FJI-.R-E*&#AN D*BXR120SXONM*NRORMAT4R0N ' ' V'-'./ -if-. 480.0 Deg F ( 248.9 Deg C) EXPLOSIVE LIMIT NOT APPLICABLE EXTINGUISHING MEDIA: WATER FOG OR CARBON DIOXIDE OR DRY CHEMICAL HAZARDOUS DECOMPOSITION PRODUCTS: MAY FORM TOXIC MATERIALS:, CARBON DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC. FIREFIGHTING PROCEDURES: WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT AND POSSIBLY ENDANGER THE LIFE OF THE FIREFIGHTER, ESPECIALLY IF SPRAYED INTO CONTAINERS OF HOT, BURNING LIQUID. HEAR SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WHEN FIGHTING FIRES. WATER MAY BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL UNTIL FIRE IS OUT. SPECIAL FIRE & EXPLOSION HAZARDS: NOT APPLICABLE NFPA CODES: HEALTH- 2 FLAMMABILITY- 1 REACTIVITY- 0 PERMISSIBLE EXPOSURE LEVEL: NOT ESTABLISHED FOR PRODUCT SEE SECTION II AND SECTION IX. COPYRIGHT 1988 CONTINUED ON PAGE: 2 72-62-7820-01 MATERIAL SAFETY DATA SHEET ABD00105644 Ashland Chemical Company DIVISION OF ASHLAND OIL. INC. P. 0. BOX 2219. COLUMBUS. OHIO 43216 (614) 889*3333 24-HOUR EMERGENCY TELEPHONE (606) 324-1133 001641 EPON RESIN 828 >-*S&CCra;ON*V^HBA mn *HA*ZA RD D AIfVA3*CiGo n*iin u:e d*) Page: 2 EFFECTS OF ACUTE OVEREXPOSURE: FOR PRODUCT EYES - CAN CAUSE IRRITATION. SKIN - CAN CAUSE REDDENING, IRRITATION, DERMATITIS, POSSIBLE SENSITIZATION. BREATHING - EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND RESPIRATORY IRRITATION. SHALLOWING - CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA. FIRST AID: IF ON SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER. IF IRRITATION OR RASH DEVELOPS, GET MEDICAL ATTENTION. REMOVE CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE RE-USE. IF IN EYES: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND LOWER LIDS OCCASIONALLY, GET MEDICAL ATTENTION. IF SWALLOWED: DO NOT INDUCE VOMITING. IMMEDIATELY DRINK TWO GLASSES OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL PHYSICIAN OR TRANSPORT TO AN EMERGENCY FACILITY. IF BREATHED: REMOVE INDIVIDUAL TO FRESH AIR. A PRIMARY ROUTE!S) OF ENTRY: INHALATION, SKIN CONTACT EFFECTS OF CHRONIC OVEREXPOSURE: FOR PRODUCT OVEREXPOSURE TO THIS MATERIAL (OR ITS COMPONENTS) HAS BEEN SUGGESTED AS A CAUSE OF THE FOLLOWING EFFECTS IN HUMANS:, SKIN SENSITIZATION 'xfJ^E(Cn>l'>ON'^V)I4aiR'BA'DTd(Vl>T^YJffDAn7A HAZARDOUS POLYMERIZATION: CANNOT OCCUR STABILITY: STABLE INCOMPATIBILITY: AVOID CONTACT WITH:, STRONG OXIDIZING AGENTS., STRONG MINERAL ACIDS., STRONG ALKALIES. ,, . ^j^BGTO<ON8V^^SPiEa^4<OR4^BAX^RRiO'GBaJU.KEIS^:>-.- -- AMINES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SMALL SPILL: ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER ABSORBENT MATERIAL. |LARGE SPILL: PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PREVENT SPREADING, PUMP LIQUID TO SALVAGE TANK. REMAINING LIQUID MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL AND SHOVELED INTO CONTAINERS. WASTE DISPOSAL METHOD: SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. LARGE SPILL: DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. w: ' -S EC03EO NmtWf&PrRDftWCWmf E*BQ U*P.M BNflWnOJBEi*U-SED RESPIRATORY PROTECTION: IF OVEREXPOSURE HAS BEEN DETERMINED OR DOCUMENTED, A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA RESPIRATORS UNDER SPECIFIED CONDITIONS. (SEE YOUR SAFETY EQUIPMENT SUPPLIER). ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE. VENTILATION: PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW LEVEL OF OVEREXPOSURE (FROM KNOWN, SUSPECTED OR APPARENT ADVERSE EFFECTS). PROTECTIVE GLOVES: WEAR RESISTANT GLOVES SUCH AS:, NATURAL RUBBER EYE PROTECTION: CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA REGULATIONS ARE ADVISEDi HOWEVER, OSHA REGULATIONS ALSO PERMIT OTHER TYPE SAFETY GLASSES. (CONSULT YOUR SAFETY EQUIPMENT SUPPLIER) OTHER PROTECTIVE EQUIPMENT: TO PREVENT REPEATED OR PROLONGED SKIN CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. ^SECT^ONillX^SREC^AL^PRiEDAUTOQNS jOR^OrTiHERJICOMMENTS r -- y CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID, AND/OR SOLIO), ALL HAZARD PRECAUTIONS GIVEN IN THIS DATASHEET MUST BE OBSERVED. THE INFORMATION ACCUMULATED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT WARRANTED TO BE WHETHER ORIGINATING WITH THE COMPANY OR NOT. RECIPIENTS ARE ADVISED TO CONFIRM IN ADVANCE OF NEED THAT THE INFORMATION IS CURRENT, APPLICABLE, AND SUITABLE TO THEIR CIRCUMSTANCES. COPYRIGHT 1988 LAST PAGE--SEE ATTACHMENT PAGE ENCLOSED--LAST PAGE