Document pBJ60o0La8w8zz9E98EXmVX9X

H NATROCHEM, INC. Post Office Box 1205 Savannah, Georgia 31498-4201 (912) 236-4464 C1-25 DLC HCR - OCTOBER 1986 MATERIAL SAFETY DATA SHEET Date Revised: 07/22/86 TION I - PRODUCT IDENTIFICATION iONYMS ene on Calcium Silicate CHEMICAL FAMILY: Coumarone Indene Resin SECTION II - HAZARDOUS INGREDIENTS INGREDIENT CAS REGISTRY PERCENT TLV(Units) Manville's MicroCel E 1344-95-2 28 30 mppcf** Flexon 340 64742-11-6 27 5 mg/m3** ** See Section V for further information on Exposure Limits. TRANSPORTATION: N/D PEL'S N/D N/D SECTION III - PHYSICAL DATA BOILING POINT: N/DA VAPOR PRESSURE(mm Hg): N/DA VAPOR DENSITY(Air = 1): N/DA SOLUBILITY IN WATER: Negligible APPEARANCE AND ODOR: Tan, free fl SPECIFIC GRAVITY: 1.160 PERCENT VOLATILES: N/DA EVAPORATION RATE: N/DA CAS #: 63393-89-5* ing powder with mild naphthenic odor. SECTION IV - FIRE & EXPLOSION HAZARD DATA FLASH POINT(Method Used): 350'F COC FLAMMABLE LIMITS: Lower - N/DA Upper - N/DA AUTOIGNITION TEMPERATURE: N/DA EXTINGUISHING MEDIA: Carbon dioxide, foam, dry chemical, or water fog. SPECIAL FIRE FIGHTING PROCEDURES: Self-contained breathing apparatus with a full facepiece operated in pressure-demand or other positive pressure mode. UNUSUAL FIRE & EXPLOSION HAZARDS: Fumes, smoke, carbon monoxide, sulfur oxides, aldehydes and other decomposition products, in the case of incomplete combustion. SECTION V - PRECAUTIONARY DATA ** Microcel E: Dust from this material is considered a nuisance particulate with a TLV of 30 mppcf or 15mg/M3 Flexon 340: 5mg/m3 for oil mist in air. There is no toxicology information about this material, however, the components possess irritancy potential. The oil componet has been classified by IARC as a skin carcinogen in mice; however, the carcinogenic potential of resinous material containing this oil has not been extablished. Page 1 of 3 MARKETED BY HARWICK 60 S. Seiberling Street Akron, Ohio 44305 DO 08604? CONFTDFNTIAl. Cl-25 DLC SECTION VI - HEALTH HAZARD DATA EXPOSURE LIMITS: TLV - 30 mppcf or 15mg/M3 CHEMICAL LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN: NTP: No I.A.R.C. Monographs: Yes OSHA: No EFFECTS OF OVEREXPOSURE: - EYES: Product contacting the eyes may cause eye Irritation. SKIN: Prolonged or repeated skin contact with this product tends to remove skin oils possibly leading to irritation and dermatits In the absence of good personal hygiene; however, based on human experience and available toxicological data, this product is judged to be neither a "corrosive" nor an "irritant" by OSHA criteria. INHALATION: Excessive inhalation of vapors can cause nasal and respiratory irritation. SWALLOWING: Product has a low order of acute oral and dermal toxicity, but minute amounts aspirated into the lungs during ingestion may cause mild to severe pulmonary injury. SECTION VII - EMERGENCY & FIRST AID PROCEDURES EYE CONTACT: Flush with large amounts of water, lifting upper and lower lids occasionally, Get medical attention. SKIN CONTACT: Thoroughly wash exposed area with soap and water. Remove contaminated clothing. Launder contaminated clothing before re-use. INHALATION: Remove individual to fresh air and call a physician. INGESTION: If ingested, DO NOT induce vomiting; Get medical attention immediately. SECTION VIII - REACTIVITY DATA STABILITY: Stable CONDITIONS TO AVOID: Open flames, high temperatures, electric arc. INCOMPATIBILITY: Strong oxidizing agents. HAZARDOUS DECOMPOSITION PRODUCTS: May form toxic materials: Carbon dioxide, and carbon monoxide, sulfur oxides, and aldehydes. HAZARDOUS POLYMERIZATION: Will not occur. SECTION IX - SPILL OR LEAK PROCEDURES STEPS MATERIAL IS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: MINIMIZE SPILL AREA. Wear suitable protective equipment; avoid skin and eye contact. Collect for disposal. WASTE DISPOSAL METHOD: Use registered transporters. Dispose in accordance with local, state, and federal regulations. SECTION X - SPECIAL PROTECTION INFORMATION RESPIRATORY PROTECTION: OSHA or NIOSH approved dust mask. VENTILATION: Provide explosion proof ventilation as required to control aiborn dust levels. PROTECTIVE GLOVES; PVC or Neoprene EYE PROTECTION: Safety Goggles OTHER PROTECTIVE EQUIPMENT: Protective clothing, eye wash station, safety shower. DO 086043 confidential 1 CI-25 DLC SECTION XI - SPECIAL PRECAUTIONS PRECAUTIONS TO BE TAKEN IN HANDLING & STORAGE: Handling can create explosive dust clouds. Eliminate ignition sources, use explosion proof equipment. Conveying and processing equipment should be spark-proof, well bonded and grounded. Avoid dust accumulations. OTHER PRECAUTIONS: Wash with soap and water before eating, drinking, smoking, ro using toilet facilities. Launder contaminated clothing before reuse. N/A * Not Applicable N/D Not Determined N/DA = No Data Available The information given in this MSDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, use, storage, and disposal of the product are beyond our control and knowledge. For this reason, we do not assume responsibility and expressly disclaim liablility for loss, damage, or expense arising out of or in any way connected with the handling, use, storage, or disposal of the product. Page 3 of 3 DO COA/p 086044 TNT Tqi