Document p4872gzEzed55My5zVK77x0k

TITLI: ASBESTOS HANDLING PROCEDURES #65 DATE - Rev;>-sed: 2/3/87 PAGE 1 OF 5 I. PERMISSIBLE EXPOSURE LIMIT (PEL) A. No employee shall be exposed to an airborne concentration of asbestos, tremolite, anthophyllite, actinolite or a combination of these minerals in excess of 0.2 fiber per cubic centimeter of air as an 8-hour time-weighted average (TWA). B. The Safety Office will be notified prior to the removal of asbestos. Exposure shall be determined from breathing zone air samples that are representative of an 8-hour TWA of each employee. C. Employees will be notified in writing of the results of the monitoring as soon as possible. II. ENGINEERING CONTROL AND WORK PRACTICES Any of the following control methods shall be used to achieve compliance with the PEL A. Vacuum cleaner equipped with HEPA filters B. Enclosure or isolation C. Use of wet methods, wetting agents or removal encapsulants D. Use of glove bags E. Prompt disposal of wastes in leak tight containers III. RESPIRATORY PROTECTION AND PROTECTIVE CLOTHING Half face airpurifying respirators with high efficiency filters shall be worn at all times when airborne concen trations of asbestos are not in excess of.2 f/cc. For expo sures exceeding.2 f/cc, respirators shall be selected in accordance with Table D4 of 1926.58. SWRf/Asbestos 10D38 SAFE WORK PROCEDURES SOUTHWESTERN REFINING CO. TITLE: ASBESTOS HANDLING PROCEDURES #65 DATE:Revised 2/3/87 PAGE 2 OF 5 III. RESPIRATORY PROTECTION AND PROTECTIVE CLOTHING: cont. B. An employee shall be evaluated by a physician to determine that an employee will be able to function normally wearing a respirator. C. Qualitative fit tests -.?ill be performed every six months. 2A. Disposable coveralls, head coverings, gloves, and foot coverings shall be worn at all times. B. Contaminated clothing and respirator cartridges shall be placed in impermeable bags and properly labeled for disposal. IV. HYGIENE FACILITIES AND PRACTICE A. Protective clothing and respirators must be put on before entering the asbestos work area. B. Before removing protective equipment, all tools shall be decontaminated, and all asbestos materials placed in disposable bags. C. Protective clothing shall be cleaned with a HEPA vacuum before removing. D. Wash face and respirator before removing the respirator. E. All employees must shower after each asbestos exposure job. V. WARNING SIGNS A. Warning signs shall mark the asbestos work area. B. Asbestos shall be disposed of in properly labeled bags and should include the following: Danger Contains asbestos fibers Avoid creating dust Cancer and lung disease hazard SWRf/Asbestos 10039 SAFE WORK PROCEDURES SOUTHWESTERN REFINING CO. TITLE: ASBESTOS HANDLING PROCEDURES #65 DATE:Revised: 2/3/87 PAGE 3 OF 5 VI. EMPLOYEE TRAINING All employees exposed to asbestos shall be trained annually. The training shall include the following: A. Methods of recognition B. Health effects C. Relationship between smoking and asbestos exposure D. The nature of operations that could result in exposure E. The purpose, proper use, fitting instructions, and limi tations of respirators F. Appropriate work practices G. Medical surveillance requirements F. Location and access to training material and information. VII. MEDICAL SURVEILLANCE A. Medical examination prior to initial assignment and annually thereafter shall be made available. B. Medical examinations shall include: 1. Medical and work history directed to pulmonary, car diovascular, and gastrointestinal systems 2. A standardized questionnaire shall be filled out, and on annual examination, the abbreviated question naire will be used. 3. The physical examination shall include a chest roegtqenogram and a pulmonary function test. Interpreta tion of chest roentgenogram shall be performed by a B Reader, a board eligible/certified radiologist, or an experienced physician in pneumoconioses. SWRflAsbestos 10040 SAFE WORK PROCEDURES SOUTHWESTERN REFINING CO. TITLE: ASBESTOS HANDLING PROCEDURES#65 ________ DATE: Revised 2/3/87 PAGE 4 OF 5 VIII. THE FOLLOWING INFORMATION SHALL BE PROVIDED TO THE PHYSICIAN A. A copy of 1926.58 and Appendices D, E, and I B. A description of the affected employee's duties as they relate to exposure C. The employee's representative exposure level D. Description of personal protective equipment and respi rator used. IX. THE EXAMINING PHYSICIAN SHALL FORWARD TO THE SAFETY MANAGER A WRITTEN OPINION INCLUDING THE FOLLOWING: A. Whether the employee has detected medical conditions that would place the employee at an increased risk of health impairment from asbestos exposure B. Any recommended limitations on the employee or use of personal protective equipment C. A statement that the employee has been informed by the physician of the results of the medical examination D. The written opinion shall not reveal specific findings or diagnoses unrelated to occupational exposure to asbestos E. A copy of the physician's written opinion shall be given to the affected employee within 30 days of receipt. X. RECORDKEEPING A. Employee exposure records shall be maintained for at least 30 years B. A copy of information provided to the physician and a copy of the physician's written opinion shall be kept in the employee's file C. A copy of the employee's medical examination results including medical history questionnaire responses and result of any tests shall be kept in the medical files SWRf/Asbestos 10041 SAFE WORK PROCEDURES SOUTHWESTERN REFINING CO. TITLE: ASBESTOS HANDLING PROCEDURES #65 DATE: Revised: 2/3/8 7 PAGE 5 OF 5 X. RECORDKEEPING cont. D. All medical records shall be maintained for the duration of employment plus thirty years E. Training records shall be maintained one year beyond the last date of employment. XI. MISCELLANEOUS A. All employees will receive asbestos training in order to become familiar with methods of recognition and appro priate work practices. APPROVED: V. W. Litton - Manager of Safety/Hygiene T. w. sanas -- vice7President & General Manager SWRflAsbestos 10042