Document oDXdnp7YmjB1vygadeZgG235D

c g 'o * CODE K0-789-P PKG ( DATE ) F2H45 si75>w (To t 'T {/ <, EST WGT ) L.QCATN CG CODE PQ LOT 01 YC016B 93 ss?~ 01 YC016B 01 YC016B 93 ~jc/sifZ DRY* WEIGHT 1SP1 7ZIA1 PROCESSES ( ) K0-789-D (I) APPROVED 'EY FWP 03/25/32 CGMTYP JOB NAME TYPED BY: \ /v^/f DRY NO. PKG TOTAL ACTUAL CONT PKG WGT WEIGHT USE LBS **' ;nt ss zz yc 5:: ys XX.XX 50 XX. XX XX. XX XX. XX **** "* 50 50 777.771 XX .-XX XX. XX EQUIP NAME "KROLOR" ORANGE Y NON-BLEEDING I | ."BEFORE USING SV, MAKE SURE THAT N-28-D LINE | jX IF ANY IS BLANKED OFF.211 I 1 *f EH3N 60" <990 G) WATER IN V-211 . SET AGITATOR ON k I / h j ^f Ts p e e d . 208 I 2'L-WOGH IN DRUM AND f DUMP IN AND STIR^MDg? U3i w RECORD: START A.CDT LBS 32--D | 530 YC16B l 4200 ADJUST TO 75" (1275 G) NOTE: VOLUMES HIGHER MAY CAUSE DUSTING IN EXHAUST HOOD. WITH AGITATOR ON LOU SPEED PUMP V-211 THRU y i-IOMOG AT 2800-3200 PSI INTO V-208 | y\ WHEN V-211 MTY,WASH COLOR THRU HOMOG WITH MIN | X/ HOT WATER AT 2300-3200 PSI INTO V-208 I XXRECORD : V-208 VOL._______ - k ADJUST TO 54-(1890G-) i fir\ INSPECT HOMOG STRAINER k CLEAN IF NECESSARY 20~T"X| RUN~1 7~(51 4~&7~WATli7"'INTO~V"START k AGITATOR.& INSTALL TEMP CHART SV II . PUMP V-208 THRU HOMOG AT 48O0-520O PSI INTO SV. ] RECORD: TIME START J&&A TOTAL MINUTES \J4foTE: IF HOMOG PRESSURE FALLS BELOW 4800 PSI, 3-WAY VALVE WILL RECIRCULATE SLURRY TO V-208 I WHEN V-208 MT, RUN IN 5*(240 G) WATER k PUMP I THRU HOMOG AT 4800-5200 PSI INTO SV I 349 ~'"wHILE~HOMOG7-RUN~6"""72i4~ 'k RUN 10O03 WATER INTO V-384 k HEAT TO 110-120-xF 384 WEIGH INTO V-384 k PUMP TO V-349 m IJRUN 10,003 WATER INTO V-384 k PUMP TO V-349 |J^H>ADJ v -349 TO 22" (1040 G) k STIR 15 MIN \T \ RECORD DENSITY: ML (1.082-1 .086) | I 2545 I I I | | 32-D | I I .... j | 2545 | | !. JXiiir^HlFs-ii"H5MOG~COMPLiTi7''A5j'`iv"'TO`"45*{235i"G>JT' SV \`\yl RECORD: PH k ADJ TO 11.1-11.3 USING N-7-D | 4 AT 5% (10 PARTS WATER TO 1 PART N-7--D) f ASSUME 5OX i SIPHON N-7-D INTO SV k RECORD : PH f/Jz,, ! I HEAT TO 190-194WF IN 55-65 MIN k REC: HT JfJk.*? | i k RECORD: /*?_*? I | NOTE: STRIKE MUST BE STARTED IMMEDIATELY ON | v~. 4.< ft * r-T-r r*. 4 i *. r* it r **" *i* v i <" 7 | | I7-D I i I | MENU . I, COMTYP JOB NAME: 04K0789DMI LBS CODE LBS NILE HEATING SV, RUN 52* (1430 G) WATER INTO V-343 ETER IN FROM V-386 M____ ,Z:IL$/GAL, JM.GAL STIR 15 MIN OR LONGER RECORD: DENSITY ./dPif-C/ML <1 .018-1 .020) , NOTE: THIS PROCESS CALLS FOR N-27-D ON SURFACE BE SURE THAT HOSE IS NOT IN UNDERSURFACE STRIKE LIN 27-D 39 N S 2 HEATING COMPLETE, RECORD: PH/&/ V-343 ACID PUMP AT 65 SETTING (255 MIN) V-349 SILICATE PUMP AT 54 SETTING (210. MIN) MEDIATELY METER IN V-343 6 V-349* MAINTAIN SV AT 190-194#F DURING STRIKE RECORD: START MINUTES V-343 V-349 Ql OLQ TIME V-343 V-349 NORMAL INCHES INCHES PH AT 20 MIN kUti (49)___ (20)__ (9*3-10*0) 40 MIN UtL (45)___ (18)___. (9.3-10*0) 1 HR IMA (41) M3. (16>/_ ^(9* 3-10.0) 1/4 HR $* (25) (. 8)_^_ Vjy(9.3-10.0> 1/2 HR WA < 9) 13u ( 0>_Q_ -5SL(9*3-10*0) FINISH (Stjfyb ( 0) j L _1J3l ( 7.5-8*5) NOTE: IF PH DROPS BELOW 9*3 IN FIRST HOUR, STOP PUMPS & SEE SUPV* IF FINAL PH IS ABOVE 8-5, ADJ TO 7.5-8.5 & RECORD: ____ PH ASSUME 77% V 27-D p-`677~(5T4~G)~WAfgR~fo~V~305^~7J-'C^~T D 6 STIR 2 MIN . V^ 330 7-D 165 3 I wi-fiN V-349 MT, RINSE IN WITH MINIMUM WATER 6 jr spr p u mp a t z e r o s e t t in g 32r | WEN V-343 MT, RINSE IN WITH MINIMUM WATER 6 - N OFF PUMP MOTOR MIN AT 190-194KF, THEN TURN OFF STEAM RD: START IfiL-SttAW IN ALUM USING BADGER METER Lu s h a l m l in e w it h w a t e r s RECORD: PH*3L (3.4-3.8) 6 IF NECESSAFCr AD J (DOWN ONLY) TO 3.4-3*8 & RECORD: PH,,X,, E: USE LIQUID ALUM, N-115-A* ADD TO SV VIA BADGER METER* STIR 5 MIN AFTER EACH ADDITION* ASSUME 50% IN N-7-D FROM S31 IN 10-12 MIN t. STIR 5 MIN RECORD: PHjMr (S.2-6.4) IF NECESSARY ADJ TO 6.2-6.4* RECORD:-PHjb'V ASSUME 77% E N-7-D 10 TO 1 WITH WATER ASSUME 50% HON N-7-D INTO SV POUR IN STIR 15 MIN STOP AGITATOR I I START FINISH OPERATOR ZMZzlA 1060 50 115-A 530 115-A 27-D 7-D 97S-A vf 50 r \f ij t DUP050046975 DUP050046976