Document nmnreg8bJzwZDkD4zO0KxgmN1

L. A. Bennett G* F. Wilson MELO POINT OR AKRON DEPARTMENT m avDo, NO. Avon Lake Technical Center FTKU> PDINT OR AKRON DEPARTMENT k IUM, HO. Avon Lake Technical Center Bldg. 414 Area Monitoring Log 9/30/75 to 10/6/75 DATA VOUM HITTER DATS THIS LETTER 10/2V75 Date/Shift Comments 10-1 2-B Rupture disc on 15 gallon boly blew and some vTnyl leulr^t^nroffiltinajust above the ruoture disc*. This, along with the VCM that may be drawn back Into the building through holes in the roof and walls produced readings of 84 ppm on ti sensor by the filter corck and 32 ppm over the fire door. Area was checked with OVA and levels were back to normal within a few minutes. 10-4 5-C cc: R. M. Kreager C. Or ben-N.V/ee rs ch -J.A1ten F, Zieber D.Barnicki-P.DeChant-V.Cerson F.Krause-D. Popovich G. Wilson Bennett - 2 Trying to strip vapors from SA poly with very little wind. VCM coming back into the building where sensor over by D poly, registered 101 ppm, filter crock sensor was 21 ppm and the sensor by the fire doors showed 5 ppm. The readings quickly dropped below 2 ppm as soon as the vent was closed. This is the first time in about a month that any readings reached 100 ppm or more. A taller vent stack is being installed to reduce this situation. 10-5 6- B Venting D Poly - 5ppm 10-6 7- B & C A charge was going out of control so a portion of it was vented to the 3000 BDT. The vent line was ope during transfer and a large amount (27 ppm) of VCA/ ,was drawn back into the building. The alarms occurred right between B and C shifts. Because the log was terminated immediately after this excursion these reading resulted in very high shift averages, since the shift was only 26 minutes. Therefore, these averages should be discounted. General - Not a bad week, except for two large excursions when a 15 gallon poly rupture disc assembly leaked and when the venting of A poly came back into the building. No report from lab 13 since THA was out of service. I'WNM HKV. (/ MTHO. IN U..A. NGC 23707 'O -Jf- -ff- -is -? - W-i3--if--W--H.-K--W--W--W.-W -H- W -W- -W -W -W W -M- - -W -W -J-r -M- 44* it- -W- -W- K- it- -W- -U- -if- -W <M- }f- H- -M- -W -W -W -W -H- -W -S--M- ?+' W -W -W--W -W- +f- K* -W ** 4* -M- * -W-W- ****-------------iMf^GO X X--------------ALTC E3U-IDCS X *V AIR MONITORING SYSTEM-------------------. _______________________________ ______________________ ____________________ _______ _.................................. ................................................_ ARGO NUMBER 2805 ARGO REACTOR NUMBER 37 BUILDING NUMBER 414 LOO OUT TIME : 16 26 ------ 10 6 1975 ARGO CHANNEL STREAM NUMBER SENSOR POSITION ALARM CONNECTIONS SHIFT NUMBER 1 -B ELAPSED MINUTES 302. 1 -C 480. 2 -A 480. ? -B 479. 2 -C Q 3-A O .'3 B * 3-C K> OJ -J o oo 480. 480. 480. 430. 371 372 373 . 374 375 376 YELLOW LIGHTS - 5. PPM 1 23456 RED LIGHTS---------25. PPM 10 11 12 13 14 16 ALL HORNS----------- 99, PPM 25 25 36 14 14 14 COMMENTS------------- 3. PPM SENSOR 10 11 12 13 14 15 16 FLOOR 2 2 1 3 3 3 3 LOCATION BY FIRE-DOOR OVER BD TANK BY VCL TANK OVER D POLY FILTER CROCK 15 CAL POLYS BY FIREPOOR ALARM 1 ? 3 4 5 6 FLOOR 3 2_ 1 3 2 1 BLDG. EAST EAST EAST SOUTH SOUTH SOUTH BUILDING STREAM 1 STREAM 2 STREAM 3 STREAM 4 STREAM 5 STREAM 6 AVE/STD AVE/STD AVE/STD AVE/STD AVE/STD AVE/STD AVE/STD X OVER 5. PPM V. OVER 25. PPM y. OVER 99. PPM 0 33 0. 73 0. 35 1. 35 0. 70 2. 14 -0. 03 0. 17 0. 27 0. 53 0. 46 0. 51 0. 46 0. 53 1. 99 0. 00 0. 00 0. 66 0. 62 0. 38 0. 61 0. 34 0. 61 0. 32 0. 63 1. 20 1. 26 0. 92 0. 70 0. 77 0. 63 0. 00 0. 00 0. 00 0. 26 0. 20 0. 93 3. 73 0. 30 0. 17 0. 14 0. 39 0. 02 0. 11 -0. 06 0. 05 0. 03 0. 13 -O. 00 0. 06 0. 09 0. 17 0. 10 0. IS- 0. 44 0. 22 3. 81 16. 60 0. 64 1. 13 1. 41 6. 14 0. 63 1. 23 0. 00 1. 25 O. 00 O. 00 O. 39 0. 37 0. 27 0. 66 0. 16 0. 51 0. 18 0. 24 0. 68 0. 72 0. 69 0. 49 0. 39 0. 30 0. 00 0. 00 0. 00 0. 68 O. 74 0. 46 1. 28 0. 45 0. 92 0. 30 0. 33 0. 69 0. 62 1. 49 1. 64 0. 70 0. 90 1. 24 0. 00 0. 00 0. 16 0. 09 0. 03 0. 06 0, 00 0. 10 0. 14 0. 17 0. 17 0. 25 0, 49 0. 29 0. 15 0. 09 0. 00 0. 00 0. 00 0. 24 0. 16 0. 00 0. 13 -0. 00 0. 12 0. 09 0. 11 0. 20 . 0. 36 0. 54 0. 32 0. 53 0. 61 9. 00 0. 00 0. 00 <{*#***#**##*#*#*** CONTINUED ON NEXT PAGE ------ 2805 ARGO II **##***##***#<IHi-***'***`4HK**#**'**-#*## * 2305 ARGO XI BUILDING 414 AIR MONITORING SYSTEM 16 26 - 10 6 197S PAGE 2 * SHIFT NUMBER A"A ELAPSED MINUTES 430. BUILDING STREAM 1 STREAM 2 STREAM 3 STREAM 4 STREAM 5 STREAM 6 y. OVER V. OVER V. OVER AVE/STD .AVE/STD. _ . AVE/STD..._ AVE/STD..__AVE/STO __ .AVE/STD. AVE/STD _. ___5.. PPM__ _25, PPM. __99. .PPM . 0. 43 0. 27 0. 37 0. 34 0. 14 0. is 0. 21 0. 37 0. 43 0. 33 0. 96 1. 06 0. 71 0. 45 0. 63 0. 00 0. 00 4-B 4S0. 0. 12 0. 13 O. 03 0. 10 -0. 03 0. 06 0. 04 0 19 0. 1 0. 52 0. 37 o: 21 0. 15 0. 17 0. 00 0. 00 0. 00 4"C 480. 0. 37 0. 34 0. 09 0. 22 0. 13 0. 29 0. 01 0. 09 0. 77 i. 07 0. 75 0. 33 0. 45 0. 56 0. 00 0. 00 0. OO 5-A 4S0. 0. 43 0. 41 0. 24 0. 11 0. 09 0. 07 0. 25 0. 09 0. 40 0. 17 1. 01 0. 24 0. 36 2. 29 0. 63 0. 00 0. OO 5 ** B 430. 0. 53 0. 40 0. 42 0. 44 0. 16 0. 37 0. 53 0. 43 0. 54 0. 62 0. 97 0. 47 0. 54 0. 37 0. 00 0. 00 0. 00 5-C 430. 1. 32 3. S3 0. 28 0. 30 0. 16 0. 30 0. 50 0- 66 4. 65 19. 07 1, 59 3. SO 0. 71 0. 95 1. 83 0. 63 0. 63 6 - A. 480. 0. 57 O. 81 0. 32 0. 25 0. 15 0. 32 0. 39 0. 34 1. 03 2. 95 0. 97 1. 42 0. 60 0. 63 1. 25 0. 00 0. 00 6--B 430. 0. 70 0. 57 0. 33 0. 52 0. 53 1. 34 0. 36 0. 46 0. 99 0. 63 1. 05 1. 12 0. 87 O. S3 1. 25 0. 00 0. 00 6-C 430. 0. 26 0. 20 0. 21 O. 17 0. 04 0. 11 0. 00 0. 19 0. 19 0. 31 0. 52 0. 30 0. 49 0. 43 0. 00 0. 00 0. 00 7-A 7 --B 7-C 430. 430. y Qj O D 26. >4 O 0. 26 0. 40 O. 95 2. 18 2. 93 1. 67 0. 05 0. 07 -O. 01 0. 05 0. 02 0. 07 0. 03 0. 32 -0. 04 O. 18 0. 07 0. 18 -0. 02 0. 05 -0. 03 0. 07 0. 10 0. 05 0. 33 1. 26 1. 27 2. 61 0. 40 0. 37 0. 30 1. 16 3. 06 3. 09 2. 23 0. 43 O. 39 0. 29 1. 56 4. 63 13. 09 6. 26 1. 25 3. 01 14. 74 0. 00 1. 73 3. 23 0. 00 0. 00 0. 00 TOTAL 8967. 0. 52 0. S7 0. 23 0. 24 0. 15 0. 13 0. IS O. 23 0. 76 1. 18 1. 11 1. 29 0. 69 0. 97 0. 81 O. 20 0. 03 WORST SHIFT 2. 9 7C 0. 46 3A O. 70 1B 0. 53 5B 4. 65 5C 3. 81 2B 13. 09 7C 14. 74 _. 7.C. . . 3. 23 7 C. _ 0. 63 5C ffr**#**!frV******4rtf ^^^^fr^V*#********************************#***^**********#*****#**#*#***#*********^******-******* :*& K****-{i-*jHi-lr-H>-->HHMHtiHHHHH-lHHy>HH BCG IN COMMENTS ***************************************************** i*************** *************** + ********#**#*****#**********'***^**************************###*****#*#********#***#* STARTING UP AIR MONITOR LOG S 10:SO TUE. SEPTEMBER 30. 1975 DROPPING WASH H20 PROM SA, PUT A HOSE ON IT. 1310. SM SNITZ STREAM 4 17 MINUTES 2 PPM MAX 13 15 FINAL 9 30 1975 **fe*tt**4Mfr**V*4Ht*****te#*#*#***1H****.****#*#^##4He****#********#*4Hfr #*****-*****##** #**#***>#*##***#### e-e-tHUiti'+r****-************************-** CONTINUES ON NEXT PAGE -----3 2805 ARGO XX *4H#*****4Ht*#****#**#**ff********** W*Tr****^^**^:***^>*******^:+;**+** *****************#****#***#*****##*#***#***#***#**##*'****#**'#*#************ * 2305 ARGO II BUILDING 414 AIR MONITORING SYSTEM 16 26 - 10 ' 6 1975- PAGE 3 * >!< *"****#'****.'-t**#*#*******#***-*-!*********'**-*********###*****'*-ft-*-#*** *##*************#*##**#***#**#****+** t1************* STREAM 6 / STREAM 1 STREAM 2 STREAM 3 STREAM 4 17 MINUTES 17 MINUTES 17 MINUTES 17 MINUTES 17 MINUTES 2 PPM MAX 6 PPM MAX 9 PPM MAX 2 PPM MAX 2 PPM MAX 13 21 FINAL 13 24 FINAL 13 27 FINAL 13 36 FINAL 19 34.FINAL 9 30 1975 y 30 1975 /]---------------- 9 30 1975 9 30 1975 n 9 30 1975 STREAM 3 STREAM 4 17 MINUTES 33 MINUTES 2 PPM MAX 20 31 FINAL 9 30 1975 PPM MAX 20 46 FINAL 9 30 1975 STREAM 2 STRFAM 6 16 MINUTES 17 MINUTES 2 PPM MAX 20 57 FINAL 9 30 1975 2 PPM MAX 21 10 FINAL 9 30 1975 STREAM 5 17 MINUTES 2 PPM MAX 21 43 FINAL 9 30 1975 STREAM 6 17 MINUTES 2 PPM MAX 21 46 FINAL. 9 30 1975 STREAM 4 53 MINUTES 3 PPM MAX 21 50 FINAL 9 30 1975 STRPAMS 2,4, 5,6. TIMF 2031. 2150 2T05 PPM VENTING D-POLY N0 AIR MOVEMENT __ ; _ ....................... 'STREAM 6 17 MINUTES 6 PPM MAX 5 34 FINAL 10 1 1975 STREAM 6 TIME 5.34 6 PPM CHGING VCL TO PREMIX SMALL LEAK RED ALARM 34 PPMfc AT 1453. FILTER CROCK. SNTTZ . .. ............... BLEW RD ON F POLY AT 1450 HR. , STREAM 5 , S3 PPM. CHECK WITH OVA AT 1435 HR. SHOWED ALL CLEAR S. M. .STREAM 5 17 MINUTES 84 PPM MAX 15 6 FINAL. 10. 1 1973 STREAM 6 17 MINUTES 32 PPM MAX 15 9 FINAL 10 1 1975 M ----N----------- -if------- CTTr--" STREAM 5 17 MINUTES 2 PPM MAX 20 30 1 1973 STREAM 1 17 MINUTES 4 PPM MAX 21 30 FINAL 10_ 1 1975 _ STREAM 2 17 MINUTES 3 PPM MAX 21 33 1 1975 STREAM 4 17 MINUTES 2 PPM MAX 21 39 1 1975 STREAM 4 17 MINUTES 2 PPM MAX 23 9 FINAL. 10 _ 1 1973 ,, STREAM 3 17 MINUTE'S 3 PPM MAX O 42 2 1975 STREAM 4 STREAM 3 35 MINUTES 17 MINUTES 3 PPM MAX 2 PPM MAX 1 51 FINAL 10 2 1975 2 30 FINAL 10 .2. 1975 STREAM 2 STREAM 5 STREAM 6 17 MINUTES 17 MINUTE'S 17 MINUTES 3 PPM MAX 9 PPM MAXV 5 PPM MAX 4 45 5 30 5 33 L 10 2 197755 -----------------i---------- L 10 2 1975 4 ------- L 10 . 2 1975 _..u_______.#-------4?----------------- STREAM 1 17 MINUTES 7 PPM MAX 5 36 L 10 2 1973 STREAM 2 17 MINUTES 4 PPM MAX 5 39 L 10 2 1975 STREAM 5 TIME 0 4 3PPM_VENT1NG SMALL VCL BOTTLE ... _ ................. .. STREAMS 4 3 TIME 1 51 2 30 3. 2. PPM ABORTED CHG TO 3000 VENTI o STREAMS 1,2,5.6, TIME 5 30 5 39 4T09 PPM VENTING AND STRIPPING SA POLY D-POLY 3000 WAGH'TK. WIND DIED DOWN NORTHE AST WIND STRFAM 5 17 MINUTES 2 PPM MAX 6 6 FINAL 10 2 1975 JL STREAM 5 __ 17 MINUTES____ 6 PPM MAX 7 0 FINAL 10 .3. 1973 , STREAM 5 6PPM, 0700 PINAL 10-3-751 OPENED 30 GALLON POLY, A CAR WHEEL WAS FOUND. THIS CAUSED THE EXCURSION. STREAM 4 17 MINUTES 4 PPM MAX 21 21 FINAL 10 3 1975 STREAM 4 17 MINUTES 4 PPM MAX 21 57 FINAL 10 3 1975 0442 TRANS. SA 377 TO :3000 .VENTING :3000. SMXTZ ANWAY ON 3000 LFIAKING :SLIGHTLY. PLACED HOOD AND HOSE ON IT. STREAM 6 STREAM 4 17 MINUTES 17 MINUTES 12 PPM MAX 4 57 FINAL 10 4 1975 101 PPM MAX 23 9 FINAL 10 4 1975 STREAM 5 17 MINUTES 21 PPM MAX 23 12 FINAL 10 4 1975 STREAM 6 17 MINUTES 5 PPM MAX 23 15 FINAL 10 4 1975 STREAMS 4,5,Vb 2300 STRIPPING SA. ***r^+******#*Fd-<Ht+****^*#***************************+***#****** ****************#*Hf***##****##***##******^tt***-****-***+'* fc^#*#***##******************* CONTINUED ON NEXT PACE ------ 2S03 ARGO II #*********<H*-tHHH***##*<H************ ******* iHI'*#*HH***4HHHH#**-Ht#***#***#******#****#*'*#********##******* *#**#****##**##*******HHHHMH****##*## **************** *#******* .. *^********>******^***********#******#***********-b--tt** ,**********************#*********************#*** 2805 ARGO XI BUILDING 414 AIR MONITORING SYSTEM 16 26 - 10 6 1973 PAGE 4 * STOPPED STRIPPING i ;a and re-evacuated at 0040 hr. Stream 4, 15. SPPM, STREAM*! 5, 3PPM, STRIPPING SA POLY, NOT MUCH WIN'D, CGMMiilNO BACK INTO BLDG. , SHUT OFF STEAM ANDOPENED VACUUM. S. M. STREAM 4 IV MINUTES 16 PPM MAX 0 57 FINAL 10 STREAM 5 17 MINUTES S PPM MAX 1 0 f-TNAL 10 STREAM 6 17 MINUTES 4 PPM MAX 1 3 FINAL 10 STEAM BACK ON TO SA POLY AT 0105 HR. , STREAMS CLEAR. AT 0805 HR. , STREAM 7, SHOWS 9. 6PPM, COULONT RECORD ANYTHING WITH OVA, BUT AEGUT A HALF PINT OF HEOH WAS ACCIDENTLY SPILLED AT THAT TINE S. M. STREAM 2 17 MINUTES 10 PPM MAX S 21 FINAL 10 5 1975 STREAM 5 17 MINUTES 6 PPM MAX 10 36 FINAL 10 5 1975 STREAM 6 17 MINUTES 5 PPM MAX 13 3 FINAL 10. _5._ 1973 STREAM 6 1300 VENTING U POLY 1300 EMISSION DID NOT TURN ON ANY LIGHTS 0232 PITTING ON VCM LINE TO PREMIX PQTUS CAL RXI LEAKING.. SNJ TJOHTEND FITTING AND PLACED VENT HOSE NEARBY. STREAM 4 17 MINUTES 7 PPM MAX 2 45 FINAL 10 6 1975 STREAM 5 17 MINUTES STREAM 4 1250 1UNKNOWN 6 PPM MAX 2 48 FINAL 10 6 1975 STREAM 5 1310 1LVD Of X POLY STREAM 4 36 MINUTES 6 PPM MAX 13 15 PINA!. 10 6 1975 STREAM 5 STREAM 4 STREAM 5 IS MINUTES 17 MINUTES 17 MINUTES 34 PPM MAX 12 PPM MAX 27 PPM MAX 13 18 FINAL 10 15 57 FINAL 10 16 0 FINAL 10 6 1975 6 1975 6 1975 S1REAMMS 4,5.66 1600 VENTING OF 3000 AFTER BURPINO SA 330. CHG OUT OF CONTROL STREAM 6 39' MINUTES 27 PPM MAX 16 25 FINAL 10 6 1975 ARGO II _ AIR MONITORING SYSTEM !aea=uuss==suBuaiik=si ea*<sa6SSi*j:^Rtfss&:ssL^su:&i^asiAsaa^&ij:&a ARCO II -- AIR MONITORING SYSTEM BS======8==S*=a=8X==MS=S.8.-===SS====1B=====t W1tS8S&SC:!3LilSJ3BWSUfcSBVSZft.'&,c;&SU3=SSSa ARCO IIIJ -- AIR MONITORING SYSTEM aBs==aE==s=UB=iBsai=iauE=E33s===3BsaAs; .'S&anft&^8S5SUSis:u*S.&Uss,S!il&l`i:SBBS8&S%6631S3S ARGO 11 -- AIR MONITORING CJYSTEM BsBP8BSssi(aaBaasssaiseB3=se=s'C=aBsi ARGO II -- AIR MONITORING SYSTEM ;S&SSb8BBBssuuaaasBSBBSuBssBasBBaB3ass==BBSB=: ARCO 11 -- AIR MONITORING SYSTEM SSBBSaiiSBBSiSBSBesaSliaUBBBS =B==UBUtiBUaBESI ARGO ri -- AIR MONITORING gygyEM UB8UBUBSsaaaaas3SaaSBBaasBBSSB3sssB3 3BBBBi ARGO ii -- AIR MONITORING gy;TM acaaBiU9n.-UBaBaSBBBasauBBBBBsa;BsuasaBsBSSBBBai ARCO ii -- AIR MONITORING SYSTEM B>===B====ai.asBBaBBas9suBsaseB==ss =uaBittB<ssas:=-as=Ba ARGO ii -- AIR MONITORING SYSTEM 8UaBEiSBS,S=BBBUSaBS>B8BBB8SS3BS>t=aliaBBBBBBBBII ssus^svussticsnuusdLU^sssussaas&sss ARGO 11 -- AIR MONITORING SYSTEM aHBBBSBav==BS='4aa==>/-aBUBBB3==7j=r.b!is&=asBsu: ===== Q ,=== o zzir. no c u> S88tfWr*as9lS&BS=.filiStB CSftlSSlUftSUKsa&MSSSBUlStfS ks&fiv isiiisaas. &2b!Afe!&S8Sa8S88888SaB3ft :B'4S.St ARCO ii -- AIR MONITORING SYSTEM Bsssssse8BtiBaaa9iiaBii!Baai:sasaa=8SBBasaaBBBi ARGO ii -- AIR MONITORING SYSTEM aua8SE-BsaseBaaa3auaiiBBS33B8eaaBBaseasBBi ARGO ii -- AIR MONITORING SYSTEM asusBBBasSBSBasBBBBBiiaBsaasaaaBaBBSSBaBBasa ARGO ii -- AIR MONITORING SYSTEM BSBSBBBSSaSBU8aBCaBBiC3BBBB8=siBBilBaBaBSBKI ARGO ii AIR MONITORING SYSTEM BBBBBBBBaBBUBBBinBBBBaaBflBBBIilaBaBBaaCBUafltl ARGO ii -- AIR MONITORING SYSTEM BtaBBaBaBBBBaaBb>iaaiixuBBBBBVc*aaMaaaHaaii ARCO zr -- AIR MONITORING SYSTEM BBBBSBsBBSBBaauBBBgiBMBBBaaassaaiBBaBaBBBiiaai ARGO ii -- AIR MONITORING SYSTEM =====.======3 kBB88BBaaB8BI ARGO ii -- AIR MONITORING SYSTEM iaBBBae.-=BBsaaaasu:iBBs;i aauaBaaaaaaai ^UlS8BSS%S8:;ttr.&SBUSLl8&t:SBa8S33eSESdC6 ARCO 1iiI -- AIR MONITORING SYSTEM IBBSzn K|B XBd Sbac^ UfiAC ARGO ii -- AIR MONITORING SYSTEM aaiiBBavssyaaui ****************************************************************************************************+************ IK#*#*#*#****#********* END LOG OF BUILDING 414 AIR MONITORING SYSTEM -- 2805 ARCO II *************************** *************HH>*****************^**************************************.**jHH*****************.*jH**^