Document mm6x5pBQyRek3R1GrJkg2epXB

(conoco) Interoffice Communication to Distribution From Tom Grumbles oate November 9, 1981 Sub,ect MSDS FOR LIGHT AROMATIC DISTILLATE Enclosed is a draft MSDS for LAD. Please review the appropriate sections as indicated by the distribution below, and return any comments or additions to me by December 1. Thomas G. Grumbles Enelosure Distribution: Sid Pitts - Fire and Explosion Data Dr. Drumwright - Medical and First Aid Susan Litzau -Legal Aspects Michele Malloy - Legal Aspects Larry Hubbard - Transportation and Storage Bill Groves - Hazard Class Information, Handling and Storage Materials and Coatings Chuck Muth - Hazardous Ingredients, Physical Data CCR 000001728 DRAFT MATERIAL SAFETY DATA SHEET w Conoco Chemicals 5 Greenway Plaza East P.O. Box 2197 Houston, Texas 77001 v. MANUFACTURER'S NAME Conoco Chemicals Company ADDRESS P.O. Box 727, Westlake, LA REGULAR TELEPHONE NO. 318/491-5403 EMERGENCY TELEPHONE NO. 318/491-5070 70669 -- TRADE NAME Light Aromatic Distillate SYNONYMS life.. --.`.'-w; v.-.t.v MATERIAL OR COMPONENT % HAZARD DATA Benzene Dicycle Pentadienes 40-5C 20-3C 1 BOIUNG POINT (F.) VAPOR PRESURE VAPOR DENSITY {AIR = 1) SOLUBILITY IN WATER APPEARANCE AND ODOR ... -iSE J3 120-350 5.4 psi Negligible SPECIFIC GRAVITY (H.Q = 1) PERCENT VOLATILE BY VOLUME (%) EVAPORATION RATE < =D MELTING POINT Clean, yellowish liquid 0.86 100 FLASH POINT (TEST METHOD) less 'than 6O0F AUTOIGNITION TEMPERATURE FLAMMABLE LIMITS IN AIR. % BY VOL. LOWER UPPER EXTINGUISHING MEDIA SPECIAL FIRE FIGHTING PROCEDURES UNUSUAL RRE Water spray; carbon dioxide; roam; dry chemical CCR 000001729 Shut off source of fuel. Cool exposed tanks with water spray. Self-contained breathing apparatus should be worn when fighting fires._______________________________________________________________________ _________ - _________ Uhan heated this material can release sufficient vapor to form FIRST AID EYES: Flush with large amounts of water for at least 15 minutes. medical aid. Seek SKIN' Wash skin thoroughly with non-abrasive soap and water. persists, seek medical aid. If irritatiqn Remove victim to fresh air. If breathing has stopped administer INHALATION: artificial respiration or oxygen and cardio-pulmonary resuscitation if necessary. Seek medical aid. INGESTION: Not Induce Vomiting. If possible administer gastric lavage Avoid aspiration. Seek medical aid. NATURE OF HAZARD EYES: Vapors or liquid are irritating to the eyes. SKIN: Repeated or prolonged skin contact may cause defatting and lead to dermatitis. Percutaneous absorption jnay occur. INHALATION: Irritation to nose and upper respiratory tract. May cause ClJS depression and reversible effects on liver and kidneys. INGESTiON: Systemic effects may occur. EFFECTS OF OVEREXPOSURE: ACUTE OVEREXPOSURE: Dizziness, nausea; vomiting; anesthesia leading to unconciousness and coma. CHRONIC OVEREXPOSURE: Unknown. Contains benzene which is a suspect leukemeden. THRESHOLD LIMIT VALUE (TLV) None established.. Based on the benzene content a value of 10 ppm for an eight hour TWA is recommended. TOXICITY DATA SKIN CONTACT: No specific data available. EYE CONTACT: No specific data available INHALATION; No specific data available INGESTION: No specific data available 00 V30 tc* 00 -r .* * .. CONDITIONS CONTRIBUTING TO INSTABILITY High temperatures INCOMPATIBILITY Strong oxidizers HAZARDOUS DECOMPOSITION PRODUCTS CO, co2 CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED Evacuate the area and remove all sources of ignition. Avoid inhalation of vapor > Increase ventilation if spilled in an enclosed areas. Vacuum large amounts. Smaller amounts may be absorbed and picked up mechanically. NEUTRALIZING CHEMICALS WASTE DISPOSAL METHOO Must be disposed in an approved landfill or incinerated in accordance with local state, or federal regulations. 33fev . , VENTILATION REQUIREMENTS Mechanical ventilation when in ues. Local exhaust wherever possible. SPECIFIC PERSONAL PROTECTIVE EQUIPMENT RESPIRATORY (SPECIFY IN DETAIL); Organic vapor air purifying cartridge respirator or air supplied equipment dependent on concentration. EYE; Chemical goggles and face shield. GLOVES; Butyl rubber or other impervious material when handling liquid. OTHER CLOTHING AND EQUIPMENT; CCR 000001731 Other impervious clothing as needed to avoid skin contact. ijfjxJfjlo 1 ifc fl 1 IMCQ HAZARO CUSS AND NUMBER 3.1 UN NUMBER 1993 HAZARD CLASSIFICATION INFORMATION US DOT CUSSIFICATION Flammable liquid EEC DANGEROUS SUBSTANCE CUSSIFICATION ADR CUSS NUMBER EEC SPECIAL RISKS ANO SAFETY ADVICE CAS NUMBER 64742-83-2 USUAL SHIPPING CONTAINERS STORAGE TRANSPORT TEMPERATURE TRANSPORTATION AND STORAGE ELECTROSTATIC ACCUMULATION HAZARD STORAGE/TRANSPORT PRESSURE LOAOING/UNLOAOING TEMPERATURE VISCOSITY AT LOAOING/UNLOAOING TEMPERATURE HANDLING AND STORAGE MATERIALS AND COATINGS SUITABLE UNSUfTABLE Steel The above data is based on tests and experience which Conoco believes reliable and are suooiied for informational purposes only. Conoco disclaims any liability for damage or injury wmch results from the use of the above data and nothing contained therein shall constitute a guar* antee, WARRANTY OF MERCHANTABILITY, or reoresentation (including freedom from patent liability) by Conoco with resoecxto the oata. the product cescribed. or their use for any specific purpose, even if that purpose is known to Conoco. Conoco assumes no resoonsibiiity for injury to Buyer or third persons oroximately caused by the product if reasonable safety measures are not adhered to as stipulated in the data sheet. CCR 000001732