Document mBvN4mjmeaQ93Bd5OgrgVjYNO

Attachment "B" Page 7 of 14 EMPLOYEE SAFETY TRAINING 1. What people must abide by the Conoco General Plant Safety Rules and Procedures in our plant? Visitors Contractors Employees All of the above 2. ( Who must abide by department safety rules and regulations while in a given department area in the plant? A. Department employees only B. Visitors other than contractors C. Contractors Everyone 3. Good housekeeping results in improvement in A. Product output B.- Employee morale - ----------- ------------- --- C. Safety conditions and reduced injuries D. Product quality eDi All of the above 4 A person who has an injury must report the injury to: His Supervisor The security guard. His lead operator The first person he sees after the injury 5. What do you use to wash a respirator? Wash the respirator with cold water Wash the respirator with hot, soapy water Wash the respirator with warm water, mixed with a mild detergent, according to the manufacturer's instructions D. Respirators do not need to be washed 6. What.should an employee know in order to perform a job safely? A. How to produce more product than anyone else B. How to try harder The correct operating procedures for the job D. How to keep on the move by checking on problems ABBO&lmi?- - Attachment MBM Page 8___ of 14 -7---Who must sign the VCM Regulated Area Log sheet when.entering a regulated area? A. B. C. (^D^i Hourly employees Salaried employees Contractors Everyone ..... 8. The work permit system is followed in the following areas of the plant; A. B. C. Qh) The vinyl reactor and vinyl dryer areas Compound,~dry blend, and P-1 areas V.C. tank farm, and yard areas All areas 9. Where and how is electrically driven equipment locked-out for repair or-entry? /kj Y. C. D. At the breaker box with a lock At the start/stop switch with a lock At the stop/start switch with a tag At the stop/start switch with a special pin only 10. Employee smoking is permited only in what areas? A. As specified in Department Safety Rules B. All office area's C. Maintenance Shops D. Designated breakroom area (Y\ All areas mentioned 11. Any person who recognizes an unsafe condition or unsafe act should immediately 'report it to his: >' A. Friend, if a co-worker B. Co-worker, if a friend (Q - Immediate Supervisor D. Security Guard E. Training Supervisor 12. A person should always wash his hands after handling any chemicals before he: A. Does the next job B. Does reports or similar paperwork C. Enters the east warehouse fT57). Eats or smokes 13. Who is authorized to operate a Fork Lift truck in the plant? & Anyone who has driven a fork truck before A Conoco licensed operator C. An experienced driver who has operated lift trucks -for two years D. Anyone whose supervisor asks him to do so. A&DOO472918 -------- Attachment MBM Page 9 of 14 14. What is the correct plant phone number for sounding the plant fire alarm? 15. | What is the correct plant phone number for sounding the VCM vapor release alarm? A: 61 62 C. 81 D. 63 ~~ ~~ "r 16. What is the correct plant phone number to give the all-clear signal after a VCM emergency or fire? B. 81 C. 62 D. 61 17. Who is authorized to perform repair work on respirators? A. Instrument mechanics only b.) Appointed, qualified persons only C. Shift mechanics D. Shift supervisors t 18: Are all Conoco plant personnel required to participate in the VCM health training? 19. Before entering a vessel of any kind, is it absolutely necessary that all lines to the vessel be blanked off? (A.)- Yes B. No 20. Which of the following equipment require a continuous flow fresh air mask for entry? -'A Dryer Inlet -- B. Dryer Outlet Day Collector . 21. A manhole watch is required to enter the V-10 activator pit. Yes B. No ABB001729W Attachment "B" Page 10 of 14 22. A safety line and harness must be worn when entering: > A.; V-10 activator pit ) Dryer burner and inlet duct C.' Day Collector 23. Gloves must be worn when: " ' 7A g. C. (D) Opening bag'boxes Cleaning dryers Bagging Resin All of the above 24. Ear^orotection must be worn on Bird deck when in this areas for more than.30 minutes. Yes B, No 25. The east end of V-ll Dryer room is the primary evacuation area for the Vinyl Department. (A\ Yes B. No 26. There are how many Scott Air Paks in the V-ll Dryer.area? @4 B. 1 C. 3 _| 27. The following people are responsible for housekeeping in the Dryer Areas: ' A> Utilities B. Dryer "A" Operator '<C\y' Dryer Lead Operator All of the above 28. All Dryer Personnel are authorized to drive the fork truck assigned to the Dryer Department. A. Yes (|) No 29. Dryer Personnel are permitted to use air hose without safe-to-blow nozzles for personal cleaning. A. Yes No