Document jyoOa5VkoE6m4kb70oyxroBzp

FILE NAME: Kaiser Gypsum (KG) DATE: 1965 DOC#: KG 105 DOCUMENT DESCRIPTION: Report - IHF Discussional with Cover Gypsum Kaiser Memo & AP Article - Asbestos is Pointed Out as Cause of Lung Cancer j c o p ie s to KA3SS> GYPSUM COMPANY, 3. C. 1N7E&-OHFICS MEMORANDUM q w Q q q R.L. Allgood W.L. Traub C.E. Caprye J.H. Walton J.D. Cassidy R.J. Wiborn J.D. Chambers S.R. Witt N.D. Dicks D.K. Koman cc: P .J . Franklin J.F. Modaff G.B. Kirk P.D. Crleman J.C. Reilly __________________________ T? K _ Sf'n^r'PT' D ate F rom At S ubject March L.R. FI. XC 2432 Health Kaza The attached material has been received from the Gypsum Association and is presented for your in formation. In connection v/ith protection against asbestos dust, it is advised to use a respirator with a filter especially designed for asbestos dust. ! LRF:sb C 0 P Y REPORT ON C 0 P Y INDUSTRIAL HYGIENE FOUNDATION OF AMERICA, INC., DISCUSSIONAL, PITTSBURGH PENNSYLVANIA. JANUARY 12, 13 and 14. 1965 On the evening of January 12th, Mr. Kenneth M. Morse of the U.S. Steel Corp., spoke on major noise sources. Thera wasn't anything new or startling in the discussion. On Wednesday, January 13th in a talk by Mr. Thomas B. Bonney, Aluair.ua Company of America, entitled "Accuracy of Field Measurements of Noise" stressed somethings that were of interest. For one thing, he said that noise tests that were made without complete equipment including calibration equipment were of little value. That anyone using the equipment to do a good job would have to be familiar with the equipment and recognize the methods to be used in relation to the job that was to be done. Oddly enough in the discussion period afterwards he stated that they did not possess an impact noise meter and had done no work on impact noise. This was followed by a talk on "Typical Designs, Design Factors, Low Frequency Versus High Frequency Attenuation" by Vaughn H. Hill of the DuPont Company. He covered a lot of old ground but he came up with one method of absorbing sound by dampening, that was quite interesting, primarily because of the magnitude of the installation that was found necessary. He cited a particular case of the gear housing that was made of one half inch plate and to dampen the sound they put a one quarter inch layer of felt over the housing and then applied one quarter inch of steel plate by means of bolts spaced on ten inch centers stagered. Apparently it was effective but it must have been quite costly. In addition to the platas the base of the machine was filled with concrete, and a retaining box around the base was filled with sand. If such a piece of equipment were on the second floor of a plant I would begin to worry about the added weight that was being placed on this floor area. At 10:45 Paul E. Toth, Supervisor, Industrial Hygiene Unit, Ford Motor Company gave a report on "Speech Interference, Hearing Damage Risk and Attenuation with Ear Protectors", that was the best part of the whole program. He was not to enthused about the present risk damage criteria that uses the two wave bands 300 to 6C0 and 600 to 1200 at 85DB as a maximum safe exposure. He cited two cases chat were rather interesting. They had one man who spent 7 days cleaning buckets on a bucket elevator with a hammer he would struck the bucket to knock out material that was on the inside and the maximum time that he would spend actually doing this operation would not exceed 4 hours. He did this for 7 days and at the end of that time complained of ringi-.^: in his ears and inability to hear. A check on the actual noise created disclosed a noise energy of 120 D3 maximum with the high energy at about 1,000 of frequency. The man was 55 years old and the hearing loss established by the comp, court was 55DR. I I - 2 In tha second case it was 3 man 60 years old had only 5 hours exposure to a chipping gun used to cleen off scale on the inside of a metal tanic. The overall r.oise level was 120 D3 and as in the previous case the can con plained o -- in thiec ears and loss of hearing the day following the exposure. In this case t!he award by the Compensation Court was 65 D3 of loss. Aga in there was n,oo previous audicnetric examination to determine how ::,,ah hearing loss there was prior to this exposure. When questioned about the exposure Mr. Toth stated that in malting the tests no impact noise measurements ware made. That an overall noise reading was taken at the sight of the exposure, that a tape recording was made of the noise and this recording was analyzed ir. the laboratory. There was discussion from tha floor after this at which it was pointed out that a recent study disclosed that if a mar. were 50 years old and put into a noisey area thaz the maximum allowable exposure should be reduced by 12 D3, and at 60 by 20 D3. The finding apparently was that the oldar hearing mechanism could not stand or recover from the higher r.oise levels. If I remember correctly Glorig of California,-was in on this particular study. During the discussion period someone mentioned the California Law which has an exposure chart as follows: T .x -rsm ? , 20-7=5 75-150 i50-000 200-600 600-1200 O c> o 12C0 to 24C0 to 2300 4SC0 to 9600 5 Hours 110 102 2 1/2 Hours 113 105 1 1 / 4 Hours 116 103 97 95 100 93 103 101 95 95 95 95 98 93 93 S3 101 101 101 101 In theory at least any exposure beyond the hours indicated that would exceed the prescribed noise level in any of tha wave bands would constitute and injurious exposure. It was then pointed out by another member that in Michigan no award is made if tha claimant is gainfully employed even though not with the same employer, but at retirement or total disability for any reason an award for hearing loss could be made. Mr. Toth then went on to describe the work that has been cone at Ford Motor in all of their plants in the way of hearing loss conservation and presented the following statements of what they do: 1 . In determining noisey environment they use an overall noise level of SO DD with r.o analysis ror tia^uancy peaks. In other words if the overall noise level is greater than SO D3 the area is immediately designated as a compulsory ear protection area. y V - 3 - 2. After various experiments wit!-, ear plugs they found that th tiver.ess varied so much due to fit that they have completely tinued the use of them, and instead require ear muffs in any that is designated as an ear protection area. 3. That while the ear muffs with the liquid in the cushion was more effective it was found that the effectiveness was greatly reduced when used in an area where compulsory eye protection program was also enforce. That ear muffs with the sponge cushion were much nor* effective when eye glasses were worn and therefore they have gone to the sponge rubber entirely. 4. And when buying in quantity they have been able to get ear muffs down to $4.30 a pair. I believe this was a Wilson ear muff but I am not sure. 5. He suggested that if the ear protection program using ear muffs were tobe started it should always be started in the winter time-so that the men would get use to wearing them before the hot weather came. 6 That in some of their plants where they encounter heat, he has found that the men have rapped the ear muff in aluminum foil and apparently have found it a lot cooler. 7. That in all of the Ford Motor Plants yearly audiometrie examinations are made of all of their employees. That these audiometrie examinations are made in the plant, that the men are taken directly from their jobs to the medical department and immediately given the audiometrie examination and then returned to work. When asked from the floor hew the information obtained with the audiemetric examinations was used, Mr. Toth stated chat up to this point there hac been no attempt to correlate it but it was expected that it would be done. When questioned as to whether, particularly in New York State, consideration had bean given to the possibility that such audiometric examinations of current employees could establish hearing loss evidence for posthumous awards, Mr. Toth said that no consideration has been given to this possibility. Cn Wednesday afternoon, I found the material cn Air Pollution Codes and Prospects quite disappointing. They spoke of Fecera 1 control, State contr ol but admitted their biggest problem, and one for whic h they had no answers, was the village, city and township cooes which admit tedly were based on in sufficient knowledge of the subject. Another speaker from Midland, Michigan spoke on the "Broad Engineering Approaches to the Abatement of Air Pollution", and left me with the impression that the whole program was not so much the abatement of air pollution as it was the abatement of neighborhood ccmplair.es which the elaborate testing setup in and around the plant was designed to combat and alleviate. -4 - Zn r.~c -*li^3 w.'w r.gir.eering prabl. discussion of tha advantages of cart: and washers. of z ir pollution wound u? as a types of blowers, air filters Cr. Thursday morning the subject -was Met Environment, end the first pert of the session which governed the rassurrent and interpretation of date seemed to offer confusion rather then conclusions. Scree of the findings of earlier studies w h i c h wer e cuite eussesive were being reputed by scare of the people at the treating. I beliave this is understandable as there apparently hasn't beer, too much work cone cn it and the tall: and discussion mostly concerned th methods of measurement rather tha tatien of the results of such measurements. helpful ir.terore* After the ccffee break the second part of the program which daalt with the "Engineering Control of Hot Environment Problems" was a little bit more conclusive. The most startling was the presentation by 3. 3. Small of the Aluminum Company of America on seme of the ventilating systems that have been installed in their plants. Cr.e of these was unique in that the monitors cn the roof of the building were net used as enhaust but for tha intake of the air which was driven dawn into the work areas through ducts ar.c than distributed about 12 feet above whs floor through directional veins, and which produced a much cooler air than could be obtained iron talcing the air iron ground level. This combined with water evaporation could apparently produce ter.pere teres belcw 35 when the outside terper* cture was between 25 and 100. In conclusion I would say that this being the fir?t of the so called "Engineering Discussicnals", I would think that future meetings of this type would be very instructive and helpful. The nan who were there were top men in their field who have actually dene a great deal of work in the different areas of endeavour that were covered and w e r e willing ts> speak openly about their errors as well as their acccuplishnants. I would point cut that one of the instructions given to people invited to this nearer, g is that no rcan will be quoted cn any statement that he stakes, that no publicity is given to these nestings nor to the people w h o attend V* ^ * W m *V C* . * Y ou will fir.a aitachec the list of those poodle who w e r e registered, though not all cf them actually attended. Roughly 40 people were represented. I believe it would be to our advantage ao have seme cr.e of our people C* to ***^ * Vy <U -- i ' ^ M ^ a of this type that the Foundation puts on. A 3 A/ sn s/A. 3. Ecftiaser A.. 3. Hofcianar Vice President c 0 p Y ASBESTOS IS POTOTED OUT AS CAUSE OF LUNG CANCER by Alton Blakeslee AP Science Writer c 0 p Y NEW YORK (AP) -- Medical specialists pointed a strong finger of suspicion today at asbestos as a cause not only of lung cancer but also of another extremely rare form of fatal human cancer. This cancer, known as mesothelioma, involves the lining of the abdominal and chest cavities. Much of the specialists' evidence comes from autopsy studies of men working with asbestos as an insulation material. They said it also is possible that dust from products contain ing asbestos might be exposing people generally to some risk of cancers. How much risk there might be, they said, they could not tell Release Dust Asbestos is used not only for insulation but as a flooring material, in automobile brake shoes, and in many other applications. Ordinary wear and tear, they said, might release dust into the atmosphere. The report was presented to the American Public Health Association by Drs. Irving J. Selikoff and Jacob Ghurg of the Mount Sinai Hospital, New York, and E. Cuyler Hammond, Sc.D., director of statistical research for the American Cancer Society. Dr. Hammond is known for his studies of cigarette smoking in relationship to lung cancer. Asbestos is a mineral, magnesium silicate, and about 3 1/2 million tons of it are used worldwide each year, they said. In 1935, worldwide usage amounted to about 500 tons, the researchers said. Tiny, hard particles of asbestos can lodge in the lungs during mining, processing and application of asbestos-containing materials, or possibly from dust raised through normal wear, they said. 'Tie had previously found that lung cancer and possibly gastro intestinal cancer were markedly increased in incidence among asbestos insulation workera,n they said. 2 Increase Noted Now they also find a markedly high increase among such workers of mesothelioma, a cancer so rare it is not classed separately as a cause of death in the international classification of diseases. As a prise example, they reported finding 10 deaths due to this form of cancer in a study of 307 deaths among New York and New Jersey building trades union members engaged in using asbestos at least occasionally as an insulation material. By contrast, this form of cancer was found to be the cause of death among only three out of more than 30,000 autopsies in a study of the general population sponsored by the American Cancer Society. Other Studies Other studies showed a high incidence not only of lung cancer but mesotheliomas among persons vrho had asbestos particles in their lungs at the time of their deaths, they said. "It would appear that mesothelioma must be added to the neoplastic (cancer) risks of asbestos inhalation and joins lung cancer (53 out of 307 deaths) and probably cancer of the stomach and colon (34 of 307 deaths) as a significant complication of such industrial exposure in the United States," their report said. The cancers may not appear until 20 to 30 years after asbestos dust is inhaled or swallowed, they said. Since the particles do not dissolve, they may remain in body tissue as a continuous source that might incite ultimate cancer. Dr. Hammond said one worry is whether a few or even a single past exposure might set the stage for cancer. He said this is a matter calling for more research. Taking precautions to avoid breathing in asbestos dust is a main protection for industrial workers, he and Dr. Selikoff said.