Document jgrpvMzqaLXRKm5368pwzmD8O
/ < 'DATfc
CODE KO-786-D PKG
5034* __LH33 < EST WGT
( LOT ) '
PROCESS
APPROVED'BY:
< ) K0-736-D (P > FWP 10/04/82
CQMTYP JOBNAME: 04KO786DMP
TIME: Lx:00/&,M# STANDARD HRS, 10.5
LOCATN QG CODE PQ
LOT
01 YC~1$ 941. J DS i4*
1 YC-10 93 JfSf?!
1 YC-10 93 2ZfSil
, 01 YC-10 93
_____
STANDARD B
BACK FOR
DRY*
<?<poo
DRY l
CONT ssrrisss-qs
100.00 100.00 100.00 100.00
NO. PKG
cZ
~W
'/o/o
PKG WGT
z=.zzr~ J2> ~s&
~JsL
EQUIP
MENT |
i NAME : VKRCLQR* ORANGE R
-------- I -- I-- --- -----
---------*---- ------------ -------
'BEFORE USING SV. MAKE SURE THAT N-28-D (HYDRO-
L/* CHLORIC ACID) LINE/ IF ANY IS BLANKED OFF".
211 >*' RUN 60 * < 990 G ) WATER IN V-211 6 ADD ASSUME 50%
& I... InfArAUU;STIC SODA SOLN) 6 SET AGITATOR ON HIGH SPEED
203 I ^J>RfEOIG( H IN DRUM AND POUR IN (SODIUM SILICATE>
J 3^! DUMP IN AND STIR' S_ J4L (MOLYBDATE ORANGE >
| | RECORD: START//.
1I i
FIN ill
TOTAL WEIGHT .rsss.jsrrrrsrn:
/&<>
JrOL
ACTUAL USE LBS
__/gO
--isfJPJsJiL.
ADJUST TO 75" i1275 G) *NOTE: VOLUMES HIGHER
I >KYHAN 75* MAY CAUSE DUSTING IN EXHAUST HOOD. I /] WITH AGITATOR ON LOW SPEED PUMP V-211 THRU
I "S H.OMOG AT 1 S00-2200 PSI INTO V-208 ! V-211 MT, WASH COLOR THRU HOMOG WITH MIN j HOT WATER AT 18^/2200 PSI INTO V-208 v i i .RECORD: V-208 VOL*5u6____ * 6 ADJUST TO $> <4l*40.&> | INSPECT HOMOG STRAINER & CLEAN IF NECESSARY'
RUN~75"
G J'WATER^INTo"^-mfc:'s t ar t ~
AGITATOR & INSTALL TEMP CHART
PUMP V-208 THRU HOMOG M 4800-5200 PSJ INTO Sj
RECORD: TIME START /J3J5A TOTAL. MINUTE^4.
TE. IF HOMOG PRESSURE FALLS BELOW 4800 PSI,
WAY VALVE WILL RECIRCULATE SLURRY TO V-208 WHEN V-208 MT, RUN IN 5`<.240 G) WATER & PUMP THRU HOMOG AT 4800-5200 PSI INTO SV
WHILE HOMOG, RUN 6" (284 G) WATER INTO V-349
]>SrVRUN 10004s WATER INTO V-384
W4<MJEIGH INTO V-384 % PUMP TO
& HEAT V-349
TO
1i-120*F
'*62400
|
32-D
|
240y
10004s WATER INTO V-384 & PUMP TO V-349
"ADJ V-349 TO 22" <104 G) & STIR 15 MIN
RECORD DENSITY : 4?2LG/ML (1 .078-1 > 81)
SV , WHEN S-11 HOMOG COMPLETE/ ADJ SV TO 66*<3400 G>
19 | RECORD: PH
6 ADJ TO 10,4-10.8 USING N-7-i)
J DILUTED' TO 5% (10 PARTS WATER TO < PART N-7-D)
ASSUME .50%
i >' IPHDN N--7-D INTO SV 6 RECORD: PH _____ . ..EAT TO i 90-194*r IN 55-65 MIN L REC :H1 fcfc.*K
i 6 RECORD 7
?--D
LQTEQUIP
HEHT
COHTTP JOB NAME * S4K0786DMP CG 04 K0-786-D
PAGE .02
DATE PRINTED:10/21/82
USE I
ACCT
LBS CODE LBS
ILE HEATING SV, RUN 51" Cl 400 G> WATER INTO
V-343
ER IN <SULFURIC ACID 60%) FROM V-386
, (h&W.*/GAL, SZ.,J_GAL
15 MIN OR LONGER
,
I RECORD: DENSITY
<1.018-1 *020)
| | | I I
|
-D 355
WHEN S 20 HEATING COMPLETE, RECORD:
SET V-343 ACID PUMP AT 72 SETTING <225 MIN)
SET V-349 SILICATE PUMP AT 66 SETTING <180 MIN)
IMMEDIATELY METER IN V-343 & V-349. MAINTAIN SV
AT 190-194wF DURING STRIKE
RECORD:
START
FINISH
MINUTES
V-343
-&S-
V-349
a J%si
TIME V-343
V-349
SV NORMAL
INCHES INCHES
PH
PH
AT MIN flit <47)_ <20)*0_ J&D_<9.3"10.0>
40 MIN tlm <43>*p_
1 HR t&ML <30>#
2 HR HM- (24)^
3 HR
< 16>
<17 )(*_ < 15)
< 7). C 0)
Zlt6L<9.3-10.0)
< 9.3-10.0) /i?..-J_< 9.3-10.0) 32^(9.3-10.0)
FINISHES. CO)
- _#_< 7.5-8.5)
NOTE: IF PH DROPS BELOW 9.3 IN FIRST HOUR, STOP
PUMPS & SEE SUPV. IF FINAL PH IS ABOVE
8.5, ADJ TO 7.5-8.5 & RECORD: _____PH
ASSUME 77%
________I
27-D
1___
67' <514 G) WATER TO V-385 & STIR 2 MIN
150 7-D I 75
SV 32"T WHEN V-349 MT, RINSE IN WITH MINIMUM WATER
JK SET PUMP AT ZERO SETTING
32'"| WHEN V-343 MT, RINSE IN WITH MINIMUM WATER i. JT. TURN OFF PUMP MOTOR
34P^TURN OFF STEAM
On IN LIQUID ALUM USING BADGER METER jftS'VFLUSH ALUM LINE WITH WATER.
600 1115-D
if
I RECORD:
C3.3-3.7) & IF NECESSARY ADJ
(DOWN ONLY) TO 3.3-3.7 , RECORD: PH____
NOTE: USE LIQUID ALUM, N-115-A. ADD TO SV VIA
BADGER METER. STIR 5 MIN AFTER EACH
_ ADDITION.
ASSUME 50% ____ 1115-D
3IN N-7-D FROM S 33 IN 4-6 MIN 6 STIR 5 MIN
\&T\ RECORD: PHj C& <4.0-4.2) & IF NECESSARY ADJ TO
I I PH 4.0-4.2. RECORD: PH tfe?
ASSUME 77%
I I 27-
! I DILUTE N-7-D 10' TO 1 WITH WATER
ASSUME 50%
,i 7-
I l^tPHON N-7-D INTO SV
(40^1 WHEN SCHEDULED ON TOP OF PAGE 1, DUMP IN
I | SUBSTANDARD TO BE BLENDED BACK.
I UflfCQRD: CODE
\Vr\ STOP AGITATOR
LOT _____,
!I
-sTm
OPERATOR
II
1 *1
"i f I
.-'tel#-
I
300
DUP050060077
DUP050060078
DUP050060079