Document jBwmrZmxQJj1EjJpJ27wjEGO9
STANDARD HRS'* 10*8 TIME
//&#/
CG CODE
P LOT
01 YC016B 93
01 YC016B 93
01 YC016B 93S^y&p'
LBS > S&bgE'
PROCESSES
APPROVED BY
( > K0789D <I) FWP 4/28/80
( > <>
( ) (>
() ( >'
TYPED BY: FWP 4/28/80
M M 'ogrjioo '
o
TOTAL EST'D. WGT 523:2
REQ. NO-<
l v/ *i.J'U: '
NON-BLEEDING
1 USE
EQUIP, | NAME : "KRGLOR"ORANGE Y
| LBS
211 \l/\ RUN 60" (990 G> WATER IN V-211* SET AGITATOR ON I
NCODE
ACC1 LBS
| / | HIGH SPEED. 1 %L-P WEIGH IN DRUM AND POUR IN
*3 I DUMP IN AND,STIR 5 MINS. RECORD; S TART_T^vf_^... rffn
-DJUST TO 75* (1275 G)
' ""
WITH AGITATOR ON LOW SPEED PUMP V-211 THRU
LJrllMOG AT 2800-3200 RSI INTO V-208
WHEN V--211 MTY,WASH COLOR THRU HOMOG WITH MIN
HOT WATER AT 2800-3200 PSI INTO V-208
: V-208 . VOL * J$jL__" & ADJUST TO ,54" < 1 890G) T HOMOG STRAINER 4, CLEAN IF NECESSARY "
530
t^o Zz*
I 32-D | IYC16B I
I I___ _ I I--I
530 4200
^5?4^G)~WAflR"lNT0"\SS!rCf's:f^f'
TATOR & INSTALL TEMP CHART PUMP V-208 THRU HOMOG AT-4800-5200 PSI ItyTJ
r e c o r d : juair St a r t MMl h l t o t a l min u t e s
NOT^^f HOMOG PRESSURE FALLS BELOW 4800 PSI, AY VALVE WILL RECIRCULATE SLURRY TO- V-208
WHEN V-208 NT,RUN IN 5" (240 G) WATER 4, PUMP THRU HOMOG- AT 4800-5200 PSI INTO SV
i ;
E HOMOG, RUN~6" (ii4 i)~W.ATii"'lNT0~V-i49
1000* WATER INTO V-384 4. HEAT TO 110-120*F TO V-384 4. PUMP TO V-349
iOOO* WATER INTO V-384 ,4, PUMP TO V-349 -349 TO 22" (104O G> h STIR 15 MIN
RECORD- DENSITY :/0_G/ML (1.082-1 .086)
32--D 1 2545
^N~5-irHOM^c5PLETErADj"irT6"45M2300-'G)
. RECORD; PH/`K G ADJ TO 11*1-11*3 USING N-7-D I DILUTED TO 5% (10 PARTS WATER TO 1 PART N-7-D)
SSUME 50% I .MN N-7-B INTO SV 4. RECORD: PH //'
, .* 1 ,/y. i vii
I i.
I HEAT TO 19C 94*F IN, 55-65 MIR 4. EEC : Ht *____ #F ' I 4i U#F , ' ' - I .NOTE SlRIKE MUST B[ -., r\U FED IMMEDIATELY ON I * COMPLETION OF-Hr/STING.
ililii
DUP050104595
CG 04 K0-789-D EST WGT 5232*
*\ USE
N- | us
I
I LBS
CODE | LB,
SV, RUN 52* < i'430 G> WATER INTO !
" T'
' ' MJS.;fe&.1t/GAL^^GAL I Atff FROM V-3B6
15 MIN OR LX ...
RECORD: DENSITY
GM/ML <1*018-1-020)
II .vl: 27--D | 39'
S 2 HEATING' COMPLETE-p/ii*f*i-lCORD: Ph J/' I
V-343 ACID PUMP AT 65 Sffiifm. <255 MIN)
I
V-349 SILICATE PUMP AT 54 SETTING <210 MIN)I
DIATELY METER IN V-343 & V-349. MAINTAIN SV|
190-194P DURING STRIKE* '
I
RECORD:
START
MINUTES
I
2.L&
V-343
V-349
SV NORMAL
^ INCHES INCHES
PH
PH
20 MI
(49)__ (20)__ ^L?(9.3-10 0) I
40 - MIN 9. (45.)
< 18)__ ^.(9*3-10 0) I
1 HR tUL <41 )
< 16)
1/4 HR /X < 25)..2.0- ( 8)_
* 3- 10 0)| *-(9 .3- 10 0) I
1/2 HR JJ4, < 9>V&- ( 0>...,,
1M<9 , 3" 10 0) |
FINISH,
0>^X'
( 7 * 5 8*5) t
NOTE: IF PH DROPS BELOW 9*3 IN FIRST HOUR, STOP |
PUMPS & SEE SUPV. IF FINAL. PH IS ABOVE I
8*5, ADJ TO 7*5-1 5 & RECORD:
._PH
3>/sas* (238 G) WATER INTO 1 35--140*F
ASSUME 77Z "HiAT~f0 :~"
27-D
DUMP IN 6 STIR TO DISSOLVE
| 530 l 15-A | 53
2" (514 G) WATER TO V-302 ADD & STIR 2 MIN
i" T T "
| 330 1 7-D j ,165
SV ,JiS<TwHEN V-349 MT, RINSE IN WITH MINIMUM WATER &
I I SET PUMP AT ZERO SETTING*
9'4**T WHEN V-343 MT, RINSE 'IN WITH MINIMUM WATER i
N OFF PUMP MOTOR.
STIR 30 HIN AT 190-194*F, THEN* TURN OFF STEAM
RECORD : START 7L9J~.^ t-**
N V-3M FROM S 31 & STIR 5 MIN
RECORD: PHJSj.ir3*4-3*8) 6 IF NECESSARY AD.L
(DOWN ONLY) TO 3-4-3.8 G RECORD: PH_
NOTE: DISSOLVE EXTRA N-15-A IN WATER"a T 135-14
*F IN DRUM , USE 30 GAL WATER TO SO*
N-15-A. STIR SV 5 MIN AFTER EACH ADDITION
RUN IN N-7-D FROM S 33 IN 10-12 MIN * STIR 5'
i14^-T\Rj'mREECCtCORD: PH&zH (6.2-6*4)* & j IF NECESSARY ADJ TO |
-T 1 PH 6.2-6.4,6 RECORD: PH&fV
ASSUME 11%
i | DILUTE N-7/D 10 TO 1 WITH WATER
ASSUME 50%
1 SIPHON N-7-D INTO SV
JEOUR IN STIR 15 MIN
I
^p-^TSTOP AGITATOR
|
50
i :za
SO
j
:7J,s
F"IN> ISH -XZStE
OPERATOR
i
DUP050104596
DUP050104597
DUP050104598
DUP050104599