Document g6m7wQDeXk7o7KM2RYz7adpL
V' Monsanto
U
MONOISOPROPYLBIPHEJI, DECEIVED
DIISOPROP YLBIPHENYL MAY 1 1 ''
Technical Data Sheet June 1, 1957
MONSANTO COMPANY
INFOHMA ic>' ( ' *UJ ST. LOUIS
DEVELOPMENT DEPAR1 MEN!
ORGANIC CHEMICALS DlVISi *
MONSANTO CHEMICAL COMPANY, 800 NORTH 12TH 81 VO.. ST. LOUIS I, MlSSO"R'
TO ASSIST YOU IN THE EVALUATION OF THE ABOVE PRODUCT, WE HAVE OBTAINED THE INFORMATION CON TAINED IN THIS BULLETIN FROM LITERATURE SOURCES AND PRELIMINARY INVESTIGAlION IN OUR WN LABORATORIES. WHILE WE BELIEVE THE INFORMATION IS ACCURATE, WE ASSUME NO RESPONSIBILITY AND DISCLAIM ANY LIABILITY INCURRED IN USING THESE DATA OR SUGGESTIONS, ONLY QIJAUFIFD TfCHNCM PERSONNEL SHOULD WORK WITH THIS PRODUCT UNTIL SUBSEQUENT STUDIES JUSTIFY US USE IN YOUR I'ROfi UCTS OR PROCESSES. OBVIOUSLY NOTHING IN THIS BULLETIN SHOULD BE CONSTRUED AS A fOCUMMiNDATION TO USE ANY PRODUCT IN CONFLICT WITH EXISTING PATENTS COVERING ANY MATERIA! OR ns USK
F ormula:
MIPB (CH.) CH
DIPB [ch3)2ch\
Mol. Wt. Appearance and Color
Approximate Assay '
196. 3
Water white liquid
62% meta isomer 38% para isomer
233 (Approx)
Clear, slightly amber liquid
Mixed isomers
PHYSICAL PROPERTIES
25 Refractive Index . N p
MIPB 1.5308
Soecific Gravitv
. MIPB
at 25 C. (77*F. ) at 100'C. (212F. ) at 200C. ( 392 *F. ) at 300'C. (572'F )
0. 979 0. 925 0. 857 0. 775
DIPB
1.563
DIPB
0.953 0. 902 0. 840 0. 756
TOWOLDMONOQ43832
MIPB
DIPB
Specific Heat, ICal/gm. *C. or BTU/lb. *F. )
at 100*C. (212*F. ) at 200*C. (392*F. ) at 300*C. (572*F. )
0. 470 0. 555 0. 637
0.482 0. 564 0. 646
Specific Heat. (BTU/#)
MIPB
DIPB
Cp = 0. 37 + 0. 00048t (t = *F. )
Cp * 0. 386 + 0. 0004 (t = *F. )
Viacoaitv ICentiatokea)
MIPB
DIPB
at 38*C. (100*F. ) at 99'C. (210*F. ) at 200*C. (392*F. ) at 300*C. (572*F. )
4. 655 1.402 0. 56 0. 31
12.527 2. 3<t0 0. 77 0. 36
Boiling Ranee (at 760 mm Ha)
295-300'C.
321-333C
Vapor Preaaure (mm Hg)
at 100*C. (212*F. ) at 150*C. (302*F.) at 200*c. (392T. ) at 250*C. (482*F. ) at 300*C. (572*F. ) at 350*C. (662*F. >
,
MIPB
_
10 63 290 950 3. 5 atm
DIPB
.
4 28 132 450 1.7 atm
Flash Point
139'C. (282*F.)
171*C. (340*
Fire Point
152*C. (306*F.)
185*C. (365
Pour Point
r
-54*C.
Thermal Conductivity (over temperature range of 100*C. - 220*G. )
-3l*C.
Cal/(cm2)(*C. /cm)(aec) BTU/(ftz)(*F/ft)(hr)
MIPB
28. 8 x 10"5 0.070
DIPB
28.1 x 10*5 0. 068
-2-
0614306
TOWOLDMONOQ43833
N,,( atoms of Hydrogen/cc)
__ ti
_____________
at 100*C. (212*F. ) at 200*C- (392F. ) at 300*C. (572*F. )
MIPB
4.56 x 10" 4.21 x 10 3.84 x 1022
DIPB
5. 00 x 10 4.63 x 1022 4. 25 x 1022
ELECTRICAL PROPERTIES MIPB
DIPB
Resistivity (ohm-cm)
1 x 1012 or greater 1 x 10*2 or greater 1 x 10^ or greater* 1 x 10*^ or greater*
* Treated with activated alumina
Dielectric Strenizth (60 cycles. 0. 1 inch eap)
Dielectric Constant
at 25*0. & 60 cycles at 25BC. & 1000 cycles
at 100'C. & 60 cycles at 100*C. & 1000 cycles
Power Factor
at 25C. & 60 cycles at 25C. & 1000 cycles
ait 100#C. & 60 cycles at 100C. & 1000 cycles
MIPB
40KV or greater
MIPB
2.66 2. 64
2. 50 2. 50
MIPB
0. 09% 0. 07%
0. 39% 0. 16%
DIPB
40 KV or greater
DIPB
2. 57 2. 57
2. 45 2. 45
DIPB
0. 3% 0. 08%
1.7% 0. 16%
-3G61<i3C?
TOWOLDMONOQ43834
Toxcitv Both MIPB and DIPB are of a low order of toxicity and, therefore, require no special handling. Available toxicity data may be summarized as follows:
Oral Toxicity (rats) The Oral Lethal Dose in rats of 3. 38 grams per kilogram classifies the material as "slightly toxic" from the standpoint of ingestion of single oral doses. Skin Absorption (rabbits) The material is not readily absorbed through the unbroken skin. Skin and Eve Irritation (rabbital The sample produced no measurable irritation when applied to the skin for a period of 24 hours, nor did it cause any damage to eye tissues when instilled in the conjunctival sac. Vapor Inhalation (ratal Exposure to a high concentration of vapors for six hours failed to kill the rats.
Suggested Uses Chemical Intermediate; Heat Exchanger Fluid where a pure hydrocarbon with excellent radiation resistance, thermal stability, and/or electric characteristics are required; Plasticizer and High Temperature Dielectric.
MM:sj 6/1 /57-1000 Printed in U. S. A. -4-
061430b
TOWOLDMONOQ43835