Document a4vq4LR0XwjxL1dqL16Jjn5k9
DATE March 19. 1976
JOB
IC/FF-54 Master Copy
l i W. D. Lubic
Monsanto (logo)
TECHNICAL DATA SHEET MCS-1238
CAPACITOR FLUID
No. IC/FF-54 (Date: Mo/Yr)
MCS-1238 is suggested as a capacitor impregnant dielectric fluid to directly replace presently used polychlorinated biphenyl (PCB) fluids. If was designed to provide the outstanding dielectric characteristics of PCB impregnant fluids such as Aroclor- 1016.
MCS-1238 fluid consists of a chlorine-free synthetic aromatic
hydrocarbon combined with a high dielectric constant aryl sulfone
and additives to give good dielectric properties. Because of its
relatively high dielectric constant and other characteristics, it
can be used in present capacitor types with minimum dielectric
redesign. MCS-1238 fluid is not as fire resistant* as the pre
sently used Aroclor 1016; however, no flammability standards for
capacitor impregnant fluids have been adopted and MCS-1238 appears
to be somewhat less flammable than equivalent viscosity petroleum
oils. Based upon initial test data, MCS-1238 is acceptable from
human and environmental health considerations; it does biodegrade
and does not bioaccumulate.
0205536
Registered Trademark of Monsanto Company.
': n ,|i v - I , 1 I,
I
TOWOLDMON0043803
WATER_PCB-00028272
In addition, MCS-1238 fluid compared to Aroclor 1016 has much better low temperature characteristics, can be used in metallized paper/film capacitors, is better in DC capacitors and has better high frequency characteristics.
Typical data for MCS-1238, determined on various samples of fluid, are given in the following sections. Material is available
for evaluation.
f' Standard Disclaimer Clause (boxed)
J *Fire Resistance Disclaimer (boxed) from p. 12, Legal Guidelines
` Monsanto logo ^ MIC Address Line
TYPICAL DATA* ELECTRICAL PROPERTIES Dielectric constant at 25C, 60 Hz (ASTM D924) Dielectric constant at 100C, 60Hz (ASTM D924) Dissipation factor, 100C, 60 Hz (ASTM D877) Resistivity, 100C, 10^ ohm cm (ASTM D1169) In MCS-1238 impregnated capacitors
(2 microfarad, 585 VAC, 2 layers .66 mil paper, 0.3% Unox added)
Capacitance at 25C Dissipation factor at 25C Capacitance at 90C Dissipation factor at 90C
6.0 5.1 0.046 1,000
1.97 0.0037 1.87 0.0039
TYPICAL DATA*
PHYSICAL AND CHEMICAL PROPERTIES
Specific gravity, 25/25C (ASTM D1810)
Viscosity, at 100F (37.8C) (ASTM D445)
Viscosity, at 210P (98.9C)
Pour Point (ASTM D97)
Flash Point (ASTM D92)
Fire Point (ASTM D92)
Autogenous Ignition Temperature (ASTM D2215)
Hydrolysis (NH after 168 hrs. at 210<>F with 0.5% H2O and aluminum and steel present)
Vapor Pressure
95C 150 C 220 C
1.018 9.1 cs. 1.98 cs. -60F (-51C ) 303F (150C ) 328F (165C ) 835F (4466C ) 0.00
1 torr 10 torr 100 torr
* This data is based upon samples tested in the laboratory and is not guaranteed for all samples.
SPECIFICATIONS*
CHARACTERISTICS
LIMITS
Appearance
Specific Gravity at 25V25C
A clear colorless to light straw liquid.
1.01 - 1.03
Viscosity @ 37.8C Flash Point
9-12 cs. 300F Minimum
Fire Point
320"? Minimum
Moisture
0.005% Maximum
Df 100C/60 Hz
0.05 Maximum
DK lOO'C
5.0 - 5.2
`
0205538
* These specifications are tentative and subject to confirmation or change as experience is developed.
TOWOLDMON0043805 WATER_PCB-00028274
MATERIALS COMPATIBILITY
MCS-1238 is compatible with all currently used dielectric materials; paper, polypropylene film, paper/filra combination, metallized paper and metallized film. It is also generally compatible with other capacitor materials of construction used with Aroclor 1016 chlorinated hydrocarbons. One exception is that two part epoxy sealants should not be used with MCS-1238.
It is recommended that compatibility tests be conducted with the fluid and samples of the specific materials to be used under conditions simulative of actual use. ASTM D3255, Method for Investigating the Compatibility of Transformer Insulation and Construction Materials in Askarels, has been found useful in compatibility testing.
HANDLING PRECAUTIONS
Since MCS-1238 may cause a moderate degree of skin irritation, care should be taken to avoid prolonged or repeated skin contact with this product. Should dermal contact occur, remove contaminant by washing with soap and water. In case of eye contact, flush eyes thoroughly with large amounts of water.
This product appears to possess no other acute toxicologic 0205539
TOWOLDMON0043806 WATER_PCB-00028275
properties which would require special handling other than the good hygiene practices employed with any industrial chemical.
s
RECOMMENDATIONS FOR USE
An antioxidant and an epoxide scavenger should be used with MCS-1238. lonol* (2,6-ditertiary butyl para cresol) anti oxidant is present in the new fluid and 0.01% should be added to the fluid during each purification cycle in the capacitor impreg nation process. A convenient method of handling the lonol is to dissolve the required amount in a small amount of MCS-1238 and add the resulting solution to the batch of fluid.
The suggested sequence of MCS-1238 fluid preparation is similar to that used to Aroclor 1016 chlorinated hydrocarbons; specifically, remove moisture (20 ppm maximum), add epoxide, clay treat, add antioxidant, degas and then use the fluid for impreg nation. Conditions for each step are determined by the specific equipment used; therefore, no operating details are listed.
SHIPPING INFORMATION
MCS-1238 is available in standard steel drums and cans. Shipping classification is Plastics Synthetic Liquid NOIBN.
* Trademark of Shell Chemical Company
0205540
TOWOLDMON0043807 WATER_PCB-00028276
MCS-1238 labels must contain the following statement: CAUTION - MAY CAUSE SKIN IRRITATION. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. FIRST AID: IN CASE OF CONTACT, WASH THOROUGHLY WITH WATER.
6-
Monsanto (logo)
^
TOWOLDMON0043808 WATER_PCB-00028277