Document a45VawLy31gBMk5Dw4jLv73GN

CODE K0-789-D P2 L3J55 < DATE 7 < LOT ) WAREHOUSE REQUEST NO. __ LOCATN ` CG CODE PQ F'KG 5179* DRY* 9 LOT WEIGHT PROCESSES APPROVE! < ) K0-789-D (I) FWP 11/04/82 COMTYP JOB NAME: 04KO789DMI DRY NO. PKG TOTAL ACTUAL nCONT . PKG WGT WEIGHT USE LBS 01 YC016B 93 01 YC016B 93 01 YC016B 93 nnn 01 YC016B 93 01 YC016B 93 _______ ~Is s s L Mio o .00 A.ffsL :::::: ______ _ _______ loo. 100.00 100.00 100.00 50 50 ~3jbo SO 50 50 ^e>e>c^ EQUIP NAME : "KROLOR* ORANGE Y NON-BLEEDING * BEFORE USING SV MAKE SURE N-28-D LINE (HYDRO CHLORIC ACID) IF ANY IS BLANKED OFF.' RUN 8* <990 G) WATER IN V-211. SET AGITATOR ON GH SPEED. IGH IN DRUM AND POUR IN (SODIUM SILICATE) DUMP IN AND STIR 5 MIN (MOLYBDATE ORANGE) 1I RECORD: f in *L ADJUST TO 75* (1275 G) *NOTE: VOLUMES HIGHER THAN 75* MAY CAUSE DUSTING IN EXHAUST HOOD. ORD PH: fak.-- (9.0-10.5) WI T^UAGITATOR ON LOW SPEED PUMP V-211 THRU OMOG AT 2800-3200 PSI INTO V-208 WHgN V-211 MTY,WASH COLOR THRU HOMOG WITH MIN ""ATER AT 2800-2200 PSI INTO V-208 CORD: V-208 VOL * 6 ADJUST TO 54*<1890G> 8* INSPECT HOMOG STRAINER & CLEAN IF NECESSARY RUN 10* (514 G) ^AfER'lNfo'v^j^START 2| AGITATOR 6 INSTALL TEMP CHART PUMP V-208 THRU HOMOG AT 4800^5200 PSI INTO. SV. RECORD: TIME START ^iJl^frOTAL MINUTES NOT>"TF HOMOG PRESSURE FALLS BELOW 4800 PSI, JAY VALVE WILL RECIRCULATE SLURRY TO V-208 WHEN V-208 MT, RUN IN 5*(240 G> WATER & PUMP THRU HOMOG AT 48OO-520O PSI INTO SV [LE HOMOG, RUN 6* <284 G) WATER INTO V-349 1000* WATER INTO V-384 6 HEAT TO 110-120*F | [GH INTO V-384 6 PUMP TO V-349 | 100O$ WATER INTO V-384 6 PUMP TO V-349 | J/'&JkJ V-349 TO 22* (lO^ft- G) & STIR 15 MIN | { ''RECORD DENSITY: A&^i_G/ML < 1.082-1 .086) I 2545 IYSr jJWHEN S-10 HOMOG COMPLETE, ADJ SV TO 45*(2300 G) |15W*T RECORD: PH/A.tZ * ADJ TO 11.1-11.3 USING N-7-D I | (CAUSTIC SODA SOLN) AT 5% (10 PARTS WATER TO I | ^TPART N-7-D > . ASSUME 50% l^n^HON N-7-D INTO SV 6 RECORD: PH 20 I/MTC0-T TO 190-194*F IN 55-65 MIN & REC?HT /3C-*F i^CRECORD: /22r_*F. STRIKE MUST START IMMEDIATELY AQ ACCT LBS 530 4200 32-D 1 2545 I 7-D 4Z- LOT: EQUIP MINT! i. COMTYF* JOB NAME: 4K0789DMI I | PAGE 2 CG 4 K0-789-D PAGE 2 Dftlt PK1NI tJJ: l o/wo/a. | USE I N~ IACCT | LBS I CODE I LBS 21 .KjHILE^HEATING SV, RUN 52* <1430 G) WATER INTO | 343 & 122 j/yTER^IN (SULFURIC ACID 607.) FROM V-386 I2 386 ( g a l ,35^g a l i 5 123 R 15 MIN OR LONGER ^ j 124 ORD: DENSITY/^iAG/ML<1.018-1 .020) | I TE: THIS PROCESS CALLS FOR N-27-D ON SURFACE,| I E SURE HOSE IS NOT IN UNDERSURFACE STRIKE LINE I |^5e N S 20 HEATING COMPLETE, RECORD: PHJ&uQ V-343 ACID PUMP AT 65 SETTING <255 MIN) T V-349 SILICATE PUMP AT 54 SETTING <210 MIN) MMEDIATELY METER IN V-343 & V-349. MAINTAIN SV SV AT 190-194*F DURING STRIKE 6 RECORD: START FINISH MINUTES V-343 V-349 TIME V-343 V-349 SV NORMAL INCHES INCHES PH PH 20 MIN <49)=r_ <20)_trr <9.3-10.0) 40 MIN 4/*? <45)rrr_ <18)--rr L'JZ-. <9.3-10.0) 1 HR X^<41)jrr <i8)^^r iC7L~ < 9.3--10.0) 1/4 HR/4/S <25) jr-n < 8)j=r <9.3-10.0) 1/2 HR //_3.4^< 9)_~r_ < o)_n 3LijjL<9.3-10.0> f in is h A3_ZJT < > ~_ 3j 5T< 7.5-8.5) NOTE: IF PH DROPS BELOW 9.3 IN FIRST HOUR, STOP PUMPS 6 SEE SUF'V. IF FINAL PH IS ABOVE 8.5, ADJ TO 7.5-8.5 6 RECORD: _____PH ASSUME 77% II 27-D | Ii || || |I || 390 I ! I 27-D _____ 67* <514 G) WATER TO V-385 6 STIR 2 MIN 2- 0 330 7-D 165 SV |32 KpEN V-349 MT, RINSE IN WITH MINIMUM WATER 6 j I Y SET PUMP AT ZERO SETTING I 8 133 HSfjEN V-343 MT, RINSE IN WITH MINIMUM WATER & I TURN OFF PUMP MOTOR I 134 I STIR 30 MIN AT 190-194*F, THEN TURN OFF STEAM | I I ^RECORD: START 135 yitm IN LIQUID ALUM USING BADGER METER I 1060 1i5-D | 530 136 J^FLUSH ALM LINE WITH WATER 37 i RECORD: PHJSiJZ. <3.4-3.8) 6 IF NECESSARY ADJ I I (DOWN ONLY) TO 3.4-3.8 & RECORD: PH_-,, I I NOTE: USE LIQUID ALUM, Nr-115-A. ADD TO SV VIA J I BADGER METER. STIR 5 MIN AFTER EACH I ADDITION. ASSUME 50%|__,,_ 115-0 |______ SUN IN N-7-D FROM, S31 IN 10-12 MIN & STIR 5 MINI RECORD: PHiaST <6.2-6.4>* IF NECESSARY ADJ TO I I 1 EW^.2-6.4. RECORD: PH^V ASSUME 77% 1_______ 27-D I-- N-7-D 10 TO 1 WITH WATER N N--7-D INTO SV ASSUME 50%|_J&___ I r IN (PLASTOLEIN 9746A) & STIR 15 MIN i^so 978-A | 5 AGITATOR J START OPERATOR JUSm~ *zmjA .~3tr DUP050060170 DELIVER TO WAREHOUSE REQUEST FORM BY __^?LAM/flH REQUEST m//&<''/ 11/04/82 FOR : CG 04 ? CODE K07/&D LOT L2J55 SCHEDULED 11/09/82 WHSE DRY DRY NO. PKG TOTAL ACTUAL LOCATN CG CODE PQ LOT WEIGHT CONT PKG WGT WEIGHT WEIGHT BAY 3 01 YC016B 93 K2J83 1000 20 50 1000 _____ BAY2 01 YC016B 93 K2H26 3200 64 50 3200 PICK UP AND RETURN TO STORAGE; DRY DRY NO. PKG TOTAL LOCATN CG CODE PQ LOT WEIGHT CONT PKG WGT WEIGHT EXPLANATION FDR SHORTAGE/OVERAGE: SIGNED_________________ ___________ DATE _/_/__ COPY-1 PROD. CONTROL COPY-2 MANUFACTURING COPY-3 WAREHOUSE COPY-4 RAW MATERIAL DUP050060171