Document ZBV1r6Bwg1wmr54OQ5QXO3p98
dat e"
LOT A2KM-
in*
(EST^MATED WEIGHT: 3319* LBS*
< ) YE~735~D CM)
(>
<)
<) <)
CQMTYP JOB NAME:
FWP 10/08/31 SiYE735DMM
CQUIF RENT
NAME: MOLYBDATE ORANGE
1/^OBTAIN FOR S-34
i OBTAIN FDR S-23 |/3J/DBTAIN FOR S"38 i OBTAIN FDR S-40 1/5 i^OBTAIN FOR S-43 IA4/J DISSOLVE IN 30 G WATER AT 100-120*F IN
DRUM FOR S-47 DISSOLVE IN 30 G WATER AT 1O0-120*F IN
i . DRUM FOR S~51
~y~
I $ | WEIGH IN
OF'TR
MK 7JA.
OPTR ______ , MK ____
USE 1 N-.CODE t ACCT
LBS I .
i l :b s C
---- - j------------ --1. j---------
315 1 4-A 1 315
42 I 108-A I 42
105 -l .3-A i -105
58 1 32-D 1 58
47 j1
3-A 1 i
41
~1 7
1 76S-A !1 -f||it
1ii
17
60 IV-A 1 60
! 1424
| WEIGH IN. OPTR Sil~ , MK ///_,
ikfSjl\ JJ3L,,
OPTR ... , MK ___ , Ts.ssl-_,' -- ____ % i
FLUSH'DISTRIBUTOR LINES UNTIL WATER COMES
OUT ALL JETS - RECORD
OK)
IN 40 * (1992 G) WATER
1 RUN IN FROM V-354. OPTR _____
2.8"3.7) G/MLJj l ^2? 1 *270" i *328 > '
' ,.%-SZ.t y. ->SEE SUPVTT NOT IN RANGE.
j1J>T ADJ TO 3350 GAL AT 61^?*^^:
|
I b(67B IN V"240 & 246 j <69" IN VF24Ta 242, 245)
I WTJ ^S-TIR 5HIN * GRECORD: P H_A:JXTIb -T.6 )
j'ijIF NECESSARY, ADJ Tp PH-3-3-3.9 ASSUME 32% i
| ! & RECORD-:-*PH^X/Jl 03.8-3,9)
ASSUME 50% 1
i j NOTE: DILUTE N-7-P 10:1 WITH WATER BEFORE
I X ADDING
1 J\ i/1 RECORD : /.jJZ/G/ML (1.11 6--1 .118)
J*87E; IF G/ML OUT OF LIMITS, FILL OUT CHECK j
1ST & ATTACH
STIR AT 67-69-tfF FOR -28* TAKE 1 QT SAMPLE.|
N 2* (110 G) WATER INTO V-358
JN V-359 INTO V-351
ftp V-351 INTO V-358
URN ON AGITATOR
T IN N-108-A FROM :S~2
AD JUST TO 60* (32} 6 G> AT 67-69*P
j RECORD: Gtv #F
|2*rl' STIR 3~MIN. G~REc 6r D :
9.0-9.5)
!25rT IF NECESSARY, ADJ*TO PH 9*0-9.5 ASSUME 32%J
i|
it RECORDPH ,,rrr,,
ASSUME 50%!
i26-"T RECORD.; G/MLLL^ilz (1 *059/1 .060)
J 1 NOTE: G/HL OUT OF7LIMITS FILL OUT CHECK
! !,
LIST V ATTACH
|2>"f STIR AT 67-69*F FOR S--2B. TAKE 1 RTSAMPLE
ii
.-*
DUP050109522
EQUIP
PAGE 2 CG 01' YE-T35-D
OBTAIN i QT SAMPLES OF S-17 6 2-27
SOLUTIONS & TITRATE TWICE
RECORD: LOWEST PH Jjta&jft. ML N~10~D
/j l
LOWEST PH ,,2*t7 & ML M--10-D
NOTIFY SUPV IF ML N~10-D IS NOT IN RANGE
7*8-9.2 OR IF THE TWO TITRATIONS DIFFER
BY MORE THAN ,. 1 ML N-10-D <IF YES,
FLUSH ALL. EQUIPMENT & REPEAT TITRATIONS)
DO NOT PROCEED IF N-10-D. TITRATION IS OUT
OF RANGE
>''
USE -I LBS
CODE
USE LBS
WHH TITRATION IN S-28 OK, STRIKE V-358 THRU i
BOTH UNDERSURFACE DISTRIBUTORS INTO SV. IN
|
I 21-23 MIN.
,a
.
i
i I RECORD: STARTMi_lijfOTAL MIN._4l /_<67~71*)
j
I I NOTE:^STRIKE TIME UP WHEN 1/2 V-358 BOTTOM
i
i L SHOWS & BUBBLES APPEARS IN SIGHT GLASSES
!
i39^*MEDIATELY AT END OF STRIKE WASH IN V-35S
i
TIMER FOR 1 MIN.
|
|,3 | RUN IN-USING BADGER METER A.F.A.P.
_
;]
1 !I
OPTR___ _______ MK__Jl__._, ___**?_% OPTR__________ , MK_____ ;_____ , __________ %
\-Z i
28-D!
2.0'
i35 I DUMP IN N-4-A FROM S-i A.F.A.P.
|'
i 34^r,AFTER N-4-A IS ADDED, STIR 2 MIN. ,
!
a 02.s a mp l e & r e c o r d .: FPL,,^rsST2.4-2.5) i
i t7PPB-XS,,,,,Jrr^(MUST BE + )
!
i36*M$TIR 1 MIN AFTER ADDITION OF N-4-A
I
i 35^'D`JMP IN N-3-A FROM S~3
1
13&>KSTIR 3 MIN
\I
I POUR IN N-32--D FROM S-4
'
i
|4<f^STIR 2 MIN.
i
! 4rV|^RUN IN USING BADGER METER
! 336 !115--A
168
I 42^/1 STIR 3 MIN 6 FLUSH ALUM LINE WITH MINIMUM WATER!
I 4cCr DUMP IN N-3-A FROM S-5
I
144LT STIR 3 MIN. ry
,I
i 4^flREC0R; PH_Jl l JL< 5:8-6.05
1
|4j .IF NECESSARY, ADJUST TO PH 5.8-6.
I v, "H
! RECORD: PH____JrT" V
ASSUME 32% |
I 28-D-
! 4fVK,P0U.R IN N-765-^-SOLN FROM S-6
-!
i STIR 5 MIN _ a X, ____ si
Ii
!4<jXREC0RD: PH_4TM4.J5.8-6.5
I|
IF NECESSARY, ADJUST TO PH 5.8-6.0
I______ _ 1 3-A !.
I JK & RECORD:
ASSUME 32%!_______l! >p-D !
!5*f ] ^ POUR Jen N-994-A SOLN FROM S-7 <MUST BE DISSQL
i
I
2 MIN.
5URING S-52 DUMP IN
j 20 j 128-AI 2 <5
, FLOOD TO 153 <7619 G)
155l KSTOP AGITATOR
START FINISH OPTR HELPER
I JLZe.#
DUP050109523
DUP050109524