Document Z4QZm2DmV1GD2qjM8O14NmXEd
A
F&bok
NAME
VCM EXPOSURE TRAINING -TEST, 1980-
DEPART!
/-<r/ DATE
1. Evidence has been found that exposure to high-level concentrations of VCM over long periods of time could cause cancer of the liver.
True( prf
False( )
, . <
2. A finger bone disease, acraosteolyis ("AOL"), has been linked to the manual cleaning of PVC reactors.
True(^f
False ( )
3. Liquid VCM can cause severe frostbite.
True(*"^f
False( )
4. The exposure limits for VCM are
/ ppm average for any eight
hour period and
ppm for any 15 minute period.
5. The three VCM regulated areas in the plant are:
A. Dry blend basement, Q.C. Lab and the Plasticizer Tank Farm.
B. Plasticizer Building, Boiler House and the East Warehouse. (cTT) VCM Tank Farm and the two large reactor areas.
6. If you have no business in a VCM regulated area, you must stay out.
True(
False ( )
7. Respiratory equipment (gas mask, air-line respirators, Scott AirPack, etc.) is required above (but not below):
1.0 ppm
(B) 0. S'1 ppm
(C) 10.0 ppm
8. Our Honeywell continuous monitors alarm when
in an area.
%
/ ppm is detected
9. We monitor your VCM exposure to:
4
A. Minimize your exposure to VCM. B. Monitor progress in reducing VCM concentrations. <> Both A & B. D. To make sure we have a record.
10. Protective clothing is required for certain jobs.
True(
False ( )
VAB.0001076240
J
DEPARTMENT
Excessive amounts of lead in the body can cause serious harm, including death.
True iS
False _______
The lead materials we have in this plant are powders used as heat stabilizers and color pigments in PVC compounds.
X
True
False
~
The exposure limit for lead is 3"^______ micrograms of lead per cubic
meter of air for any eight-hour work period.
*
The exposure limit for lead is lowered if you work more than eight (S) hours during a work period.
True
False
Lead used in this plant can enter the body by:
A. Inhaling B. Swallowing C. Absorbing through the skin D. All of the above
A 1 B Onlv*
If you get lead material on your skin or clothing, you don't have to do anything about it because lead is not absorbed through your skin.
True
False
NOTE: If you think that was a ''trick" question, you should think about vour answer again.
lead tasks require breathing protection. Name one such task
tyijlL___rarb r- ___________
It is O.K. to take food, drinks, etc. into lead areas, provided you are careful to not let lead materials get into them.
T rue
False
Medica1 testing is used to make certain your lead exposure is not hurting you.
T rue
False
If the lead area ventilation systems are working and your medical tests a:'! d mo n i t o r i n g res u 11 s are a 1 1 "Good," you don't have to be concerned
NO TE :
T rue
False
If you're not sure about your answer, you need to think about it some more.
VAB.0001076241
.1
ABERDEEN FORKLIFT TRAINING PROGRAM SECTION I QUIZ
Good, competent, professional forklift operation is a safe operation and you can never be too experienced to learn more about safety.
.2 The first rule of safe forklift operation is to know the capacity of
your truck. 3. The load capacity of each of our forklift trucks is clearly marked on
the identification plate on the truck. If you are in doubt about your forklift's ability to pick up a certain load, use the trial and error approach. A pre-work check of your forklift should be made to be sure it's working right and will operate safely. The further the center of the load is away from the front of the carriage, the larger the load you can pick up. All of the forklift trucks in the Aberdeen Plant are equipped with a hand brake. You should try to repair any problems you find during the pre-work check of the forklift truck.
ft
*
r
ft
t
i
h Ii h I-
i
i, i i i
i i
i i
i i
i i
1:|
'I I
I
I I I I
.I
I II
I
/
/
!
i
i
j
i i i i i
i i l ! I i i
j I i i
VAB.0001076242
....................................................... ... ..........
mill FrNIIH. <+ HTiWiiTIWni'Trri'iMhilMHti'lt^llHTOIIII'Wii^'i-H'^rPrwHi.iTnii-..........i*Mt>r-nrn^l' .Til'ti n n rrqrr-11
FM ': 11 : 111H
. -11
1:1 Hill;,.. i-;.n-rroiiTHimiitHliriin:TwmMp*w>i>'mTTMfTHHHifrttH>'HT| n
i|i MW MTiWrM1- '
**q + i *| 11 M 11 ............11 M r-11!1 H 1 M M M 1 11 H I............ " f M | ............... fft* III M II ' "I'ruM-
, , I n-rr'-iHI 11 r 11 I hi-i 1111 KM H< M KKI' 111 Ki-KI l-H H
IX
r|i:i|iMI-tMlPkil'-:'ll
|r. i,iinl|.rTiiii|niiilltjl1|*MMl'l^',Mltmiil|l'|H|'i'^F1-t,tl,>l'lNJN,,,-l..........l-n|ii-|11H-Fnmimir||i'.
MM KM I I 111 KTi-l *ri 11* H+IH M?" " 11111111 W 111 " 1111! Hi1111 Mtfl IH 11111 : i i-hii-i 11.111 i-'i
m 11 rl |1 ................. |
....................' I -i1 11111
*
........ t+* mi n+*jrtVM-M H M -I I
ABERDEEN FORKLIFT TRAINING PROGRAM SECTION II QUIZ
A forklift truck steers with its rear wheels, not its front wheels like your car.
When you are planning to make a turn while traveling forward, you should steer your forklift to the opposite side of the road or isle...in the direction you are going to turn.
I 3. When traveling backward, the rear wheels should pass the comer and
the front wheels should reach the corner before you start turning the steering wheel to make a turn.
A forklift truck operator must always watch the rear swing of the truck as well as the front swing of the load.
A forklift truck is much harder to steer when the forks are loaded.
A forklift truck operator should always travel with the forks four to six inches above the ground.
An operator should always inspect a load before he attempts to make a lift.
When picking up a load with a forklift truck, always approach the load squarely.
The forks should be spaced as widely as possible according to the load width and equally spaced form the sides of the carrigae.
10.
r n.
/_ 12.
'f' 13.
At times, it might become necessary to make a lift with only one fork.
*
At times, it might also become necessary to "pick up short", that is pick up a load with only part of your forks.
An operator should never put his head, hands or feet out of the truck cage.
Only the small Hyster forklift should ever be carried in the plant's elevators.
14. It is better to drive forward up a ramp when your truck is empty.
Lr 15. You should drive forward up a ramp and backwards down a ramp when your forks are loaded.
/
%
VAB.0001076243
9f
*fW h*n ii r*m i Ti i hN ri i Wm'+NI-I it'm !1 ri+i*THn*Jrpi fi-p-m Pt*i-iTri *Th " rn ii ill i m t*N,N n N'ti p n i m i 'iiiim-m^,<'ii-i--pi--iiiiiiiiinM- V|iHMi *
i! hi i rlTi btyiHtp
I p-' P= I I I I I I H~ II >1 II I I I -PI
i'MPI'll
III i M i i :^+|.| h I
| Wl | -1111
SECTION II QUIZ
Always cross railroad tracks at a 45 degree angle. Passengers should never be carried on a forklift truck as it is designed for only one person...the operator. Before depositing a load, the operator should take the time to inspect the place where he is going to unload. You should never use full back tilt when high stacking. The safest condition is when the top of the mast is only a foot to 18 inches back from vertical. If you have to leave the fork truck unattended for even a short time,
*
you should lower the forks and turn off the engine.
*
t
J
i i i
1
j
n i i
!
i *
i
r ii l
I
i
j
ii
4i
t j
i i
1r
-j i
1
H
i
i
\
;i
f
i * 7
I
I l
1.
r
i; i
*i
i i
s
d*
T
VAB.0001076244
hAlll(UM4WK4+MHl n J MIM4J 1111 u 11 .......................................
t
-i.
......................I
1 li
11 M I Uitl 11 hhiJ II111
I Itl 11 111 ' I' i-l 11 I i-l"
.......I'
...... ........... .
i II l'
I II: llJ: II Ml I
Mir;
pwi*Hii*+iTthMti-iiPrtP|nfii
iti Ifrl1 Ml' 1111
i ii hrii-ii ii^nr+i M*t'imi*MiiimiiiiH-rrtM*H+H,'iJ-HP'i'i'+i-;i'atii*ttiiiiHiii>i>ili-ii
H11^'||l-1IIIIIPll1H*ni,||l,lilhrilIIIIIIMM'lllhr-frtl'l|l||riH'Plf(|HirH'HIITHIII|r"l!IH'hP-llltH l-M MU PM 111111 1 M |-I11 hi 11111-: I tH H | .+H |-l 11 M I p II1111 |i ii i 111 r|
i m 111 r| i+rl it|i 1111
ii i :>i IH P11 I I " 111" I * 1111111
J-
I-.......... cliiJ| ii IMMM1IIII Ii . - III
ABERDEEN FORKLIFT TRAINING PROGRAM
SECTION III QUIZ
I
i If the tractor is attached to the trailer, you should be sure to notify i the driver that you are about to begin loading the trailer.
r
i>
It is not necessary to chock the wheels of a trailer to be loaded if the tractor is attached.
*
In addition to the dolly wheels, special jacks must be placed under the
front of a trailer, when the tractor is not attached, before loading
begins.
*.
4. Trailer floors should be checked for damage before loading begins.
5. The proper way to load a trailer is to load all of one side then all of the other side.
J-- 6.
L-- 7*
If double stacking is required when loading a trailer, it should be done m the front and back so the extra weight will be on the axles.
^ employee should neyer be lifted with a forklift truck unless a caged worklift is used.
_/-- 8.
When using a worklift, you must be sure that the safety pin is placed
through the worklift mount and the forklift forks to prevent the worklift from sliding off the forks.
V----- 9. It is O.K. for an employee to ride to a work site if he is riding in a
worklift.
6
J-- 10. Unloading a trash dumpster should be done with forklift mast straight up, not tilted forward or backward.
4 I
*
i i i
i >
i i i i 'i i i i
h i i
k l I l I i I l
1 1 i 1 i j i \ i
I i i 1
f k
i I i i
i ) i
i j
V
i i i
*
T
i
i i I
r
j
j i
I
i i i i i
I I I I
! j
VAB.0001076245
*-
i