Document Z49Mm3Z3qw77pyJdG9kzbMjKV

* CG ' 01 YE-221-0 rn 11/iL/i?s$ < DATE > < LOT ) BL ENDED BAJXl CG 01 , PQ 4448* LBS* < EST WT ) PROCESSES < ) YE-721-D CM) APPROVED BY: FWP 11/08/82 COMTYP JOB NAME; 01YE721DMM RUN INTO V-i 1^*"" OPTR___ I^UPWMP FROM V-351 TO V-358 1>T FUiS>H"-V"351 J, PUMPING LINES WITH 1000G J^WATER INTO V-358 1-an ADJ TO 74* <353$ G> AT >Ij69*F F ""(7*2-7.4) NOTE IF G/ML OUT OF LIMITS FILL OUT CHECK LIST & ATTACH. TAKE 1 QT SAMPLE. SV RUN 20* <996 G) WATER INTO V- ,, 5 RE0RD N-41-D STORAGE TANK TO PUMP FROM. CIRCLE ONE; 402 410 411 420 424C425. CHECK WITH CU SUPV: *STORAGE TANK MUST CONTAIN AT LEAST 1900 GAL: 402=39'. 410=20* 411=38*, 420=20*, 424=20* j C42S2SO ^STORAGE TANK MUST HAVE STIRRED AT LEAST 20 MIN SINCE LAST ADDITION OR ADJUSTMENT i JWPTORAGE TANK MUST BE ISOLATED UNTIL ALL ^'''PUMPING FOR THIS BATCH IS COMPLETE an SET METER FOR 300 G & PUMP TO SV LOT: . EQUIP MENT | -' 5 CONT COMTYP JOB NAME: 01YE721DMM PAGE 02 AT APPROX 1O0 G WHILE CONTINUING TO PUHp T CHECK PH 6 DENSITY. RECORD BELOW. IF NOT IN RANGE.. STOP PUMPING & SEE SUPV. DATE PRINTED:11/08/82 USE N- ACCT I..BS CODE LBS -PH:(2.2-3.?) DENSITY: '*36QZ*rG/ML C1.270-1 .328) IF S~23 OK JHJEN S-22 COMPLETE, RECORD I I DENSIXT G/ML ON TRAPPED SAMPLE ! L^WJHEND OF S-22 PUMPING. \QSTJSING DENSITY FROM S-24, FIND METER SETTING FOR SECOND PUMPING IN TABLE BELOW. NOTE: TABLE ACCOUNTS FOR 300 G ALREADY PUMPED IN S-22. CIRCLE DENSITY 6 SETTING IN TABLE BELOW. #'#*# TABLE k **K 1 1 G/ML SETTING I G/ML SETTING 1 G/ML SETTING! 1 1 .270 1259 1 1 .291 1146 1 1.312 1049 1 1 1 1.271 I 1 1.272 1253 1248 ! 1.292 1 1.293 1141 1136 1 1 .313 I 1.314 1045 1 1040 1 1 1 1 .273 1242 1 1.294 1131 1 1.315 1 036 1 1 1 1.274 1 1 1 .275 1236 1231 1 1.295 1 1.296 1126 1121 K3.316" T032D 1 ~"W? 1 1 i 1.276 1225 1 1 .297 1116 I 1 .318 1023 1 1.277 1219 1 1.298 1112 1 1 .319 1019 1 1 i 1.278 1214 1 1.299 1107 1 1.320 1015 1 1 i 1.279 1208 1 1.300 1103 i 1 .321 1010 1 1 i 1.280 1203 t 1 .301 1098 1 1 .322 1O06 1 1 1 .281 1198 1 1.302 1094 1 .323 1003 1 i 1.232 1193 1 1 .303 1089 1 .324 999 1 1 1.283 1187 1 1 .304 1084 1 1.325 995 1 1 1.284 1182 1 1.305 1080 1.326 991 1 i 1.285 1177 1 1.306 1076 1 1.327 987 1 1.286 1171 1 1.307 1070 1 1.328 983 1 I 1.287 1166 1 1.308 1066 1 .329 979 1 1 1.288 1161 1 1 .309 1061 1 .330 975 i 1 i 1.289 1155 1 1 .310 1057 1 1 .331 971 1 1 1.290 1151 1 1.311 1053 1 .332 967 1 1 I ! I I I 1 1 1 ! ! i i i ! 1 1 1 1 1 1 SET METER 6 PUMP/&2'3*Ls* (RECORD FROM TABLE) FLUSH^LINE WITH WATER INTO SV FOR APPROXIMATELY CONDS ADJ LEAD NITRATE TO 3244 G (68'-242/flWdMttfc* > AT 67^9*F RD: 1--*F 6 ICE CQJSUMED <330$/BLOCK> STIR 5 MIN 6 RECORD PH: (2.2-3.7) USE TITRIMETER TO ADJUST N-41-D PH **** I I 41-D I 330X__| 57-A I 4094 IF NECESSARY ADjL TO JgJ* 3.0-3.1 ASSUME 66% 33-D z. 4. RECORD PH ASSUME 50% DILUTE N-7-D 10:1 WITH WATER BEFORE ADDING ..1 7-D RECORD: A/jd/- G/ML (1.128-1.129) IF OUT OF SPEC ILL OUT CHECK LIST & ATTACH. I STIR AT 67-69KF FOR S-33. TAKE 1 GJT SAMPLE. DUP050059726 LOT'* EQUIP !-?ENT COMTYP JOB NAME: 01YE721DMM PAGE 03 DATE PRINTED:i 1/08/82 I USE | N- I USE I LBS I CODE I LBS OBTAIN 1 QT SAMPLES OF S-19 i, S-31 SOLUTIONS 6 TITRATE TWICE NOTIFY SUPV IF ML N-10-D IS NOT IN RANGE 9.5-9.9 OR IF THE TWO TITRATIONS DIFFER BY MORE THAN 0.10 ML N-IO-D (IF YES, FLUSH ALL EQUIPMENT & REPEAT TITRATIONS). DO NOT PROCEED IF N-IO-D TITRATION IS OUT OF RANGE ADJUST V-358 FOR A TITRATION PH OF 1.k&O TO iTftT FROM FINAL IN-LINE TITRATION, y[i_ 6 ML N-IO-D RE. C/ORDl'.SLO&W-EST/,. I 33-D 7-D -32 TITRATION OK, STRIKE V-358 THRU BOTH UNDERSURFACE MSIRIBUTORS INTO SV IN.44-44 MIN RECORD: START .Zt^Z^M^TOTAL MIN__jW.___ HP*E: STRIKE TIME UP WHEN 1/2 VAT BOTTOM SHOWS 6 BUBBLES APPEAR IN SIGHT GLASSES IMMEDIATELY DUMP IN N-4-A FROM S 2 & SET TIMER FOR 15 MINUTES ING S 34, WASH IN V-358 j STIR 2 MIN it RECORD PH__^&J_L(1.7-1 .8) ,_Jfe._(MUST BE + ) STIR TOTAL OF 15 MIN FROM S-34 i, RECORD: TEMP_3?__*F (67-73#F) -UMP N-3-A FROM S-3 jO^rflR 3 MIN MTL*PmR IN N-32-D FROM S-4 JHT\ 1 MIN IN LIQUID ALUM USING BADGER METER Ig 3 MIN & FLUSH ALUM LINE WITH WATER P IN N-3 FROM S-5 STIR 4 MIN FOR S-49 604 115-D| 302 I RUN IN HYDROCHLORIC ACID USING WEIGHT & FLOW CONTROL PANEL MK _JL_, MK ;______, JfT\ DURING S-45 SIFT N-711-B FROM S-6 INTO V-390""~ Jr WITH AGITATOR ON IN 1-2 MIN 4S i STIR 1-2 MIN TO MILKY SOLUTION I 28-D | 90 28-D |___ SV WHEN S-45 COMPLETE, IMMEDIATELY RUN IN N-711 B 8 SOLUTION GRADUALLY OVER 5 MIN PERIOD INTO SV ATCH FOAM!!! IF FOAMING IS EXCESSIVE, STOP IL FOAM SUBSIDES, IN BLANC FIXE N WHEN SCHEDULED, DUMP IN BLEND BACK LISTED ON 275 ^p-T28-A | 275 TOP OF PAGE 1 ___-- RECORD: CODE, LOT , IR 20 MIN . feORD: PH_^rj^_<5.8-4.0) IF j*ECESSARY, ADJ TO PH 5.8-6. ASSUME 50% it RECORD: PH-__&^?_____ ASSUME 66% FLOOD TO 153* (7298 G> & STOP AGITATOR Sj H. I I 7-D i___ : 33-D | OPTR DUP050059727