Document XRJpjdxO1rGvjx3OOOnGOxeXd

Interoffice Communication To Distribution From Tom Grumbles Dm November 9, 1981 Subject MSDS FOR LIGHT AROMATIC DISTILLATE Enclosed is a draft MSDS for LAD. Please review the appropriate sections as Indicated by the distribution below, and return any comments or additions to me by December 1. Thomas G. Grumbles ajo Enclosure Distribution: Sid Pitts - Fire and Explosion Data Dr. Drumwright - Medical and First Aid Susan Litzau - Legal Aspects Michele Malloy - Legal Aspects Larry Hubbard - Transportation and Storage Bill Groves - Hazard Class Information, Handling and Storage Materials and Coatings Chuck Muth - Hazardous Ingredients, Physical Data VEU-274092 .5 i DRAFT MATERIAL SAFETY DATA SHEET (conoco) Conoco Chemicals S Greenway Plaza East P.O. Box 2197 Houston, Texas 77001 -W. ilnjl i IR00UC13DENTIEICATI0N MANUFACTURER'S NAME Conoco Chemicals Company REGULAR TELEPHONE NO. ' EMERGENCY TELEPHONE NO. JU4,!wWHsy -Tii 318/491-5403 318/491-5070 ADDRESS P.O.Box 727, Westlake, LA 70669 TRADENAME SYNONYMS Light Aromatic Distillate gapeeff^gj., i LIU DOUSTNGREDIENTS .uag>et!ww;a.1 yia" MATERIAL OR COMPONENT % HAZARO DATA , Benzene Dicycle Pentadienes 40-5C 20-3C ' m BOIUNG POINT (*F.) VAPOR PRESURE VAPOR DENSITY (AIR * 1) SOLUBILITY IN WATER APPEARANCE AND 000R 120-350 5.4 psi Negligible SPECIFIC GRAVITY (H:0 = 1) PERCENT VOLATILE BY VOLUME (%) EVAPORATION RATE D MELTING POINT Clean, yellowish liquid 0.86 100 EXTINGUISHING MEDIA c SPECIAL FIRE FIGHTING PROCEDURES UNUSUAL FIRE AHO EXPLOSION HAZARD Water spray; carbon dioxide; foam; dry chemical. VEV-274G? Shut off source of fuel. Cool exposed tanks with water spray. Self-contained breathing apparatus should be worn when fighting fires._____________________________________________________________________ .____________________________ When heated this material can release sufficient vapor to form explosive vapors. FIRST AID eycg. Flush with large amounts of water for at least 15 minutes. medical aid. Seek SUN: Wash skin thoroughly with non-abrasive soap and water, persists, seek medical aid. If Irrltaticn Remove victim to fresh air. If breathing has stopped administer MHALATKM: artificial respiration or oxygen and cardlo-pulmonary resuscitation if necessary. Seek medical aid. tHfiETnOH: Do Not Induce Vomiting. If possible administer gastric lavage. Avoid aspiration. Seek medical aid.______________________________________________ NATURE OF HAZARD EYES: Vapors or liquid are irritating to the eyes. SION: Repeated or prolonged skin contact may cause defatting and lead to dermatitis. Percutaneous absorption jnay occur. INHALATION: Irritation to nose and upper respiratory tract. May cause CNS depression and reversible effects on liver and kidneys. INGESTION: Systemic effects may occur. EFFECTS OF OVEREXPOSURE: ACUTE OVEREXPOSURE- Dizziness* nausea; vomiting; anesthesia leading to unconciousness and coma. CHRONIC OVEREXPOSURE: Unknown. Contains benzene which is a suspect leukemeden. THRESHOLD LIMIT VALUE (TLV) None established. Based on the benzene content a value of 10 ppm for an eight hour TWA is recommended. TOXICITY DATA SKIN CONTACT: No specific data available. EYE CONTACT: No specific data available INHALATION: No specific data available INGESTION: No specific data available SPECIAL PRECAUTIONS: avoid inhalation and repeated skin contact. VEV-274Q94 CONDITIONS CONTRIBUTING TO INSTABILITY High temperatures INCOMPATIBILITY Strong oxidizers HAZARDOUS DECOMPOSITION PRODUCTS CO! CO2 CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION Ji ,.^, i1-.' '-'-T liw. - , - -' ' " `r . .':. T'V : ; ---Jr, wenypwi'' ewiw..,11111wijji I'. ,, HU-..UU* ' STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED Evacuate the area and remove all sources of Ignition. Avoid Inhalation of vapor Increase ventilation if spilled In an enclosed areas. Vacuum large amounts. Smaller amounts may be absorbed and picked up mechanically. NEUTRALIZING CHEMICALS WASTE DISPOSAL METHOD Must be disposed in an approved landfill or incinerated In accordance with local state, or federal regulations. VENTILATION REQUIREMENTS m , ~ r - 'fMiUTi i Mechanical ventilation when in ues. Local exhaust wherever possible. SPECIFIC PERSONAL PROTECTIVE EQUIPMENT RESPIRATORY (SPECIFY IN DETAIL): EYE: Organic vapor air purifying cartridge respirator or air supplied equipment dependent on concentration. Chemical goggles and face shield. GLOVES: Butyl rubber or other impervious material when handling liquid. OTHER CLOTHING AND EQUIPMENT: Other impervious clothing as needed to avoid skin contact. ' iMCO HAZARD CUSS AND NUMBER 3.1 RECIfll*RECAUflONS JniU^SJQ*'---. 4--J HAZARD CLASSIFICATION INFORMATION US 00T CLASSIFICATION Flammable liquid UN NUMBER 1993 EEC OANGEROUS SUBSTANCE CUSSIFICARON ADR CUSS NUMBER EEC SPECIAL RISKS AND SAFETY ADVICE atiwiaMM CAS NUMBER 64742-83-2 USUAL SHIPPING CONTAINERS STORAGE TRANSPORT TEMPERATURE TRANSPORTATION AND STORAGE ELECTROSTATIC ACCUMULATION HAZARD STORAGE/TRANSPORT PRESSURE LOADING/UNLOADING TEMPERATURE % VISCOSITY AT LOAOING/UNLOAOING TEMPERATURE HANDLING AND STORAGE MATERIALS AND COATINGS SUITABLE UNSUITABLE Steel Tha above dam is based on mats and experience which Conoco beileves reliable and are supplied for informational purposes only. Conoco disclaims any liability lor damage or injury which results from the use of the above data and nothing contained therein shall constitute a guar antee, WARRANTY OF MERCHANTABILITY, or representation (including freedom from patent liability) by Conoco with respect to the data. Ihe product described, or their use for any specific purpose, even if that purpose is known to Conoco. Conoco assumes no responsibility for injury to Buyer or third persons proximately caused by the product if reasonable safety measures are not adhered to as stipulated in the data UEV-274096