Document RJ79QjkMD8ZR9BgExeEvy7VVk

0 Material Safety .Data Sheet I Emergency Medical Telephone (800) 441 -3637 (conoco) CRUDE OIL (SWEET) I. MATERIAL IDENTIFICATION Name Crude Oil (Sweet) CAS Registry Number Mixture; See Section XI Chemical Family Petroleum Hydrocarbons Transportation Emergency Phone l-{800) 424-9300 (Chemtrec) n. OSHA HAZARD DETERMINATION The material is hazardous as defined by OSHA's Hazard Communication Standard, 29 CFR 1910.1200. Refer to Section XI of this MSDS for federal and state regulatory information. Hazardous Ingredients CAS Registry Number Hydrocarbons (Aromatic A Paraffinic) Mixture Benzene 71-43-2 Cowcentnrthm > 95% < .01 - 2 wt % HifHwM Physical Properties Variable-Flammable or combustible depending on flash point Could be as hazardous as Class IA Flammable Liquid - NFPA 30-1987. HL PHYSICAL DATA Appearance and Odor Usually greenish-black liquid; Petroleum aromatic odor Specific Gravity (HsO I) 0.7 - 1.1 Bolling Point/Range 50* - >1100*F Evaporation Rata Variable Vapor Pressure (nuaHg) @ d(*F 100 - 800 (Variable) IV. REACTIVITY DATA Stable: X Unstable:____ Hazardous Din--pnslilnn Materials: Normal combustion forms carbon dioxide; incomplete combustion may produce carbon monoarirtr Conditions to Avoid: Oxidizing materials, heat, flame. MISC0011/August 1989 MCD 000023500 Conoco Inc., P.O. Box 2197, Houston, TX 77252 General Information No. (713) 293-5550 V. FIRE AND EXPLOSION HAZARD DATA led < 1 UED Flash Point: 1 than Ambient (Variable! Flash point Is variable; handle and store in accordance with NFPA procedures. Could be hazardous as a Class IA Flammable Liquid - NFPA 30-1987. Extinguishing Media: Use dry chemical, COj, foam. Spedal Fire Fighting Procedures: Water may be ineffective to extinguish, but water should be used to keep fire-exposed containers cool. If a leak or spill has not ignited, use water spray to disperse the vapors and to protect personnel attempting to stop a leak. Water spray may be used to flush spills away flora areas of potential ignition. Unusual Fire and Explosion Hazards: Products of combustion may contain carbon monoxide, carbon dioxide and other toxic materials. Do not enter enclosed or confined space without proper protective equipment including respiratoiy protection. National Fire Protection Association fNFPAl Classification Health 1 Fire 3 Reactivity 0 TRANSPORTATION AND STORAGE HAZARD RATING Least-0 Slight-1 Moderate-2 High-3 Extreme-4 Storage Conditions: Store in accordance with National Fire Protection Association regulations. Shipping Information: DOT: Flash Point < HOT Proper Shipping Name: Crude Oil, Petroleum Hazard Clasm Flammable Liquid UN/NA Noj UN 1267 DOT Labd(s): Flammable Liquid DOT Placard: Flammable IATA/IMO: Flash Point < 73*F Proper Shipping Name: Petroleum Crude Oil Hazard Class: 3 (3.2 IMO) UN N04 UN 1267 IMO/ICAO Label: Flammable Liquid Packaging Group: H Flash Point tHOT Crude Oil, Petroleum Combustible Liquid UN 1267 None Combustible Flash Point {73*7 Petroleum Crude Oil 3 (33 IMO) UN 1267 Flammable Liquid IH VH. HEALTH HAZARD INFORMATION Exflpsure Limits for Crude Oil (Sweet) PED TLV: None Established Exposure limit lor Petroleum Distillates PED 400 ppm: 1600 mate3 TWA Exposure Limits for Benzene PED \ ppm - g HD-IWA TLV: 10 ppm - ptg/tf 5 ppm - (Short-Term Exposure Limitl Du Pont AED 1 ppm - 8 A 12 Hr. TWA 03 ppm - Action Level 5 gPffl: \5 Mift-IWA MISC0011/August 1989 2 MCD 000023501 PHaai7 Routes of Exposurc/Entry: Skin, Inhalation. Signs and SynjMons of Exponn/Mcdkal Conditions Aggravated by Exposure: Studies with mice and rats have shown that some petroleum have caused either damage or tumors of the kidneys or tumors of the liver. However, kidney effects were not seen in similar studies involving guinea pigs, dogs or monkeys. Also, the significance of the liver tumors in rodents is highly speculative. Mouse sldn painting studies have shown that some crude oils caused a low incidence of tumors. However, these studies involved repeated exposure of shaved skin which was never washed free of test material. The product contains petroleum hydrocarbons which may cause irritation to the eyes, skin and lungs after prolonged or repeated exposure. Extreme overexposure may cause weakness, headache, nausea, confusion, blurred vision, drowsiness and other nervous system effects; greater exposure may cause dizziness, slurred speech, flushed face, unconsciousness or convulsions. A few studies have indicated that workers exposed many years to high concentrations of benzene have a slightly higher incidence of leukemia. Benzene can also be toxic to the blood and blood-forming tissues. Carcinogenicity: The following components are listed by NTP, IARC, or OSHA as carcinogens: Vm. IX. Benzene NTP Yes IARC Category 1 OSHA Yea EMERGENCY AND FIRST AID INFORMATION Eyes: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Calk a physician. Sldm In case of contact, immediately wash skin with soap and plenty of water. If irritation develops, consult s physician. Inhalation: If Inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Call a physician. Ingestion: If swallowed, do not induce vomiting. Give large quantities of water. Never give anything by mouth to an unconscious person. Call a physician. Notes to Physician: Gastric lavage by qualified medical personnel may be considered, depending on quantity of material ingested. SPILL, LEAK AND DISPOSAL INFORMATION In Case of Spill or Leaks Contain spill immediately in smallest possible area. Recover as much of the product as possible by mechanical means, followed by recovering residual fluids by using absorbent materials. Nonrecoverable product, contaminated soil, debris and other materials should be placed in proper containers for ultigatAvoid washing, draining or directing material to storm or sanitary sewers. NOTE: Review FIRE AND EXPLOSION HAZARDS before proceeding with dean up. Use appropriate PERSONAL PROTECTIVE EQUIPMENT during dean up. Waste Disposal MhM Recycle as much of the recoverable product as possible. Treatment, storage, transportation and disposal must be in accordance with applicable Federal, State/Provindsl, and Local regulations. MISC0011/August 1989 3 MCD 000023502 X. PRECAUTIONARY MEASURES Resplratoty Protection: Select appropriate NIOSH-approved respiratory protection where necessary to maintain exposures below acceptable limits. Ventilation Mechanical ventilation required only in emergency or extreme conditions, such as confined spaces. Protective Gloves: Neoprene or NBR gloves should be worn to protect against chronic skin contact Eye Protection: Safety glasses with side shields and/or Caoe shield where splashing is present Other Protective Equipment: Coveralls if splashing is present XL REGULATORY INFORMATION FEDERAL REGULATIONS CERCLA, 44 CFR 302 Not Applicable SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1984, TITLE III SECTIONS 302, 304, 311, 312, 313 SECTION 302/304 - Extremely Hazardous Substances (40 CFR 355) The material does not contain extremely hazardous substances at greater than 1.0% concentration; however, it is possible that this material may contain extremely hazardous substances at a lower concentration so that a large enough spill could warrant an Emergency Release Report under Section 304. SECTION 311/312 - MSDS and Chemical Inventory Reporting Requirements (40 CFR 370) The material should be reported under the following EPA hazard categories: x Immediate (Acute) Health Hazard x Delayed (Chronic) Health Hazard x Fire __ Sudden Release of Pressure __ Reactive __ Not Applicable NOTE: See Section II for the concentration of any ingredients classified as hazardous by OSHA. SECTION 313 - List of Toxic Chemicals (40 CFR 372) The materia] contains the following chemical(s) at a level of 1.0% or greater (0.1% for carcinogens) on the list of Toxic Chemicals and is subject to toxic chemical release reporting requirements. Toxic Chemical Benzene CAS RcgfotlY 71-43-2 Approx. Concentration --(Vppff Bwtf)-- 2.0% TOXIC SUBSTANCES CONTROL ACT (TSCA), 40 CFR 710 This material is a mixture as defined by TSCA. The chemical ingredients in this material are in Section 8(b) Chemical Substance Inventory and/or are otherwise in compliance with TSCA. In the case of ingredients obtained from other manufacturers, Conoco relies on the assurance of responsible third parties in providing this statement MISC0011/August 1989 4 MCD 000023503 RESOURCE CONSERVATION AND RECOVERY ACT (RCRA), 4* CFR MI* SUBPART C AND D The material, when discarded or disposed of, is not specifically listed as a hazardous waste in Federal regulation* however, it could be considered hazardous if it meets criteria for being toxic, corrosive, ignitable or reactive according to US* EPA definitions (40 CFR 261). Additionally, it could be designated m hazardous according to state regulations. This material could also become a hazardous waste if it to mixed with or comes in contact with a listed hazardous waste. If such contact or mixing occurs, check 40 CFR 261 to determine whether it to a hazardous waste. If it is a hazardous waste. Regulations 40 CFR 262, 263, 264 and 268 may apply. FEDERAL WATER POLLUTION CONTROL ACT, CLEAN WATER ACT, 40 CFR 116, SECnOMll The material contains the following ingredients) which to considered hazardous if spilled in navigable Ingredient Petroleum Hydrocarbon Reportable Quantity Film or sheen upon or discoloration of the water surface or adjoining shoreline. HAZARDOUS MATERIALS TRANSPORTATION REGULATIONS, 49 CFR 171-178 Not Applicable FOREIGN REGULATION CANADIAN HAZARDOUS PRODUCTS ACT (WHMW) The material to a WHMIS Controlled Product and a f*--<hi MSDS to available. STATE REGULATIONS CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986 (PROPOSITION 650 The material contains ingredients) known to the State of California to cause cancer, birth defects or other reproductive harm. Read and follow label directions and use care when handling or using all petroleum products. Ingredient Benzene PENNSYLVANIA WORKER AND COMMUNITY RIGHT TO KNOW ACT The material contains the following hazardous substances: Categories: S Special Hazardous Substance ( 0.01%) H -- Hazardous Substance ( 1.0%) E Environmental Hazard (i 1D%) Ingredient Benzene Petroleum DtotiBatea CAS Registry Number 71-43-2 Mixture Category E H Nonhaztrdous ingredients) information is withheld as trade secret in accordance with Section 11 of the MSDS Code: MBCODlf DATE OF LATEST REVISION/REVIEW: DEPARTMENT RESPONSIBLE FOR MSDSt PRODUCT INFORMATION CONTACT: 8/89 - Replaces MSDS dated 3/89 Environmental and Occupational Health Services MSDS Analyst Conoco Inc. (713) 293-5550 MISC0011/August 1909 5 MCD 000023504 The above data are based on tests, experience, and other information which Conoco believes reliable and are supplied for informational purposes only. However, some ingredients may have been purchased or obtained from third-party manufacturers. In these instances, Conoco, in good faith relies on information provided by those third parties. Since conditions of use are outside our control, CONOCO DISCLAIMS ANY LIABILITY FOR DAMAGE OR INJURY WHICH RESULTS FROM THE USE OF THE ABOVE DATA NOTHING CONTAINED HEREIN SHALL CONSTITUTE A GUARANTEE, WARRANTY (INCLUDING WARRANTY OF MER CHANTABILITY) OR REPRESENTATION (INCLUDING FREEDOM FROM PATENT LIABILITY) BY CONOCO WITH RESPECT TO THE DATA THE MATERIAL DESCRIBED, OR ITS USE FOR ANY SPECIFIC PURPOSE, EVEN IF THAT PURPOSE IS KNOWN TO CONOCO. MISCOOU/August 1989 6 HCD 000023505