Document QL4X8ZKJvvoyayb1LK2LZYD6
!t--
.-..................<. i-'
S
U.S. DEPARTMENT OF LABOR Occupational Safety and Health Administration
IATERIAL SAFETY BATA SHEE1
Required under |JSDL Safety and Health Regulations for Ship Repairing, Shipbuilding, and Shipbreaktng <29 CFR 1915, 1916, 1917)
form Appimd OM0 No. 4.ni37
Prepared By: Dr. E.E. Wane
Rev. 1-16-86
MANUFACTURER'S NAME
J-M A/C Pipe Corporation
ADDRESS ttf*mbcr. Slrttt, CUy. Suit. tad ZJfCodt
1051 Snerry Road. Stockton. Ct
CHEMICAL NAME AND SYNONYMS
Asbestos-Cement Pipe
chm*caL family
Mineral
SECTION 1
EMERGENCY TELEPHONE NO.
(209) 982-1500
95206
TRADE NAME AND SYNONYMS
................
TRANSITH Pine
FORMUtJ*
N/A
SECTION II - HAZARDOUS INGREDIENTS
PAINTS. PRESERVATIVES, & SOLVENTS
PICMENTS
N/A
X TLV lUnlnl
ALLOYS AND METALLIC COAT1NOS
RASE METAL
CATALYST
N/A
ALU>VS
N/A
VEHICLE SOLVENTS ADDITIVES
N/A N/A N/A
METALLIC COATINGS
FILLER METAL
.. . .
PLUS COATING OH CORE FLUX N/A
OTHERS
N/A
OTHERS
N/A
HAZARDOUS MIXTURES OP OTHER LIQUIDS. SOUDS, OR GASES
Asbestos [CAS 1: 1332-21-41, A Carcinogen Determined By IARC Silica [CAS #: 7631-86-9]
Portland Cement
TLVs Refer To Airborne Concentrations Over 8-Hr TWA.
*
TLV {Unltsl
X TLV* lUnin)
15 2f/cc 35 5mg/m^
50 lSng/ra
POIUNO POINT fF4 VAPOR PRESSURE (mm VAPOR DENSITY (AJR-1J SOLUBILITY IN WATER appearance AND ooor
SECTION III - PHYSICAL DATA
N/A N/A
N/A
SPECIFIC GRAVITY (HjO-ll
PERCENT, VOLATILE BY VOLUME CHJ
EVAPORATION RATE
1 *1>
N/A
Grayish-White Pipe; Odorless;
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash point (Mvtnod um>
N/A
rI FLAMMABLE LIMITS N/A
EXTINGUISHING MEOIA
N/A
SPECIAL PIRE FIGHTING PROCEDURES
N/A
1.85 N/A
N/A
UNUSUAL FIRE AND EXPLOSION HAZAROS
None
(Continued on rtvana tid.l
P--WUWN
Form OSHA-20 An. Mty 7)
802
IX, LP"1 '*,
SC-JMM-3085
w.ntfiw any*.
BBBMHMBiMWIMBH
A/C Pipe
SECTION V - HEALTH HAZARD DATA
THRESHOLD LIMIT VALVE
Shown On first Page; Inhalation Of Excessive Silica Mar Cause Silicosis.________
BffECTS Of OVEREXPOSURE Ycr- Exposure To LExcessive Concentrations Of Airborne Asbestos Fibers May Cause
Pulmonary Disease. Smoking Greatly Increases Risk From Asbestos Exposure.__
EMERGENCY AND FIRST AID PROCEDURES
.
Inhalation: Move Person To Fresh Air. Eves: Hash With Water For IS Minutes.
Skin: Clean Area Of Contact. Ingestion: Seek Medical Attention If Necessary.
SECTION VI - REACTIVITY DATA
STABILITY
UNSTABLE
conditions to avoid rower Driven Saws with Abrasive Discs Should NOT Be Used For Dry Cutting Or
incompatabiuty fMeivuli to avoid)
None___________________
HAZARDOUS DECOMPOSITION PRODUCTS
Beveling Asbestos-Cement Pipe. Always Avoid Creating And urcatning mist.
HAZARDOUS POLYMERIZATION
MAY OCCUR WILL NOT OCCUR
CONDITIONS TO AVOID
N/A
SECTION VII SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASe MATERIAL IS RELEASED OR SPILLED
Pipe Fragments And Installation Debris Must Be Handled In A Manner Which Avoids Airborne Dispersion Of Asbestos Dust. Use Wet Or Vacuum Method For Clean-Up.
WASTE DISPOSAL METHOD
Comply With All Applicable Local. State. And Fedfrrnl Re pulnfirms
SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (Spttify lypt)
Not Required When Recommended Work Praer.iri: 4-re Fntlnued
VENTILATION
LOCAL EXHAUST
.
. N/A
MECHANICAL (General)
N/A
SPECIAL OTHER
N/A N/A
PROTECTIVE gloves
Not Required
.
EVE PROTECTION
_________________ Not Required________________
OTHen PROTECTIVE EQUIPMENT
^.
Not Required When Recommended Work Practices Are Followed.
SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Follow "Recommended Work Practices For A/C Pipe" Published Bv A/P Pi re producers Association.
OTHER PRECAUTIONS
All Tools Which May Release Ashestns Fibers In Ftrp nf Thn i xpivmm limits Shall Be Provided With Local Exhaust Ventilation Systems.
Note: This Information Is Given Without Warranty, Representation, Inducement Or PAGE |2) License Of Any Kind, hutjil That It Is Accurate To The Best Of Our Knowledge ere >.<u 0r Obtained From Sources Believed By Us To Be Accurate, And We Do Not
Assume Any legal Responsibility Fur Use Or Reliance Upon Same.
803