Document N2m1kz6kVr0gVarKNLmw9nxD
ts i. wo r./-
: 'i O i h ;< S.
14 YC-3-B 14 YC-3-B 14 YC-3-B
C.v. PKCJ
TIME
LotAllM
LotJ0 lot3273
D. V
PROCESSES
APPROVED BY
('> KY-788-D (I) EWK 10--19--77_
< j Alter hate_ [j 3CGIQ-28-77J
L 0L>"
........ ^W 10-26-77
ii._..................... '< >" FWP 01-15-79
F.WP..Ql:-24.-29....
IPMEHT
NAME; KR0L0R YELLOW LIGHT
203 J-^Run 50" (827 G water lnto~V'-2'C>3'
& "Wei gh~i n drum pour in
205 ^3edllBiP.J.n.r 5.mifl
1 Record: Starts
________.Fi n ___
7Q~*
I
Mi to
_________________________
^uinpV-203 thru Homog at 2400-2600 psi into V-205
.-^r-Men V-203 MTY, wash color thru Homog at 1800-2200 psi using
minimuin water . Use Hot Water________________ _ V-205 Vol yV & adj to 60" (2100 G)
Inspect Homog strraai'ni heedr & clean if necessary
sv :a: .Sun.3=r & jaai ta.tor.
205 gimp V-205 thru Homog at 4800-5200 psi into SV-,
2 Record: Time Start /7>cyr/tfota1 Min
NOTE: If homog pressure fails below 4800 psi, 3-way valve
____ _________ will recciirrccuulate sslluurrry to V-2Z0055"________ ________ wJJ4r>'iKlhen V-205 MTY, run in 5" (240 ~G) water & pump thru Homog
While Homog. run 6" (284 G) water into V-J349
Weigh into V-384 & pump to V-349 n 1000# water into~V-3SOT>ump to V-34<T
~Z5& '3Z=ti$2r
sv,^ When s' liMomoq complete, adl SV to I4'1 (2420 g T
-Eec-ord: ,_p.H ml & ad.j tj 11.0-1L2 ysing N-7-D diluted to
5% (10 parts water to 1 part N-7-D
Assume-!)OK
_S_ip_h__o_n_in_to__S_V__&_R__e_co_r_d: pH 777 0
.s^etfTlifeeartoTg'O^I^orinl5-45~niin W-Zffi^rW~55-65'mTn
07-243, 244, 246 , IMj
MMrmMMElM NOTE: Strike must be started immediately on completion
of heating
____
_____I_____1______ .
heatihq SV, run 56*' (Ii)io g ) water into V-343^ _
i n from V-386"'__________, W7WSLil&VW*/7$'\
15 min or longer ___________ _____________ _
Record; pBe?' / n jy (2r45--0-7-iy--(x ^VO~~-- /.0/ 7
^
'7-'D
N 27595
\J ~ 7- Ip *7-"
JIPMENT sv,,
*r
pag e 2 c g 03 c o d e KY-788-D (I) es t . w g t .
7340 l bs .
USE LBS.
TJhen S 20 heatinq complete. Record: pH /*/ (9.5-10.1)
-Set V-343 acid Dump at 69 setting ( 255 mini
-Set V-349 silicate pump at 60 setting (210 min)
Immediately meter in V-343 & V-349. Maintain SV at 190-194OF
^^^TJurfng strike
Record: V-343
Start 40M 4rO
Fin
Min A^j~
....... ....... V-349 ____ f* ......... ....... lifts.*.
jzao
Record:
Time
V-343
V-349 sv Normal
at 20 min 40 min 1 hr 2% hrs
33s hrs Finish NOTE: (1)
1 "SfTn fc!Q (52)^%
tST in (22)*4
9,3-10.( '
silo (48) + (20)8.1
9.3-10.C
ft:AO
43
(27)
&+-
(18 74( 9))e>
far 9.3-10.C b 8 9.3-lOiC
...uluSL. ukjSzz (-Ol.k*___
9.3-10.C
tnsz
7.5- 8.
If pH nolt as specified, notify Supervisor & note
\
:_________
in log
__________
(2) li final pH is above 8.5. ad.i pH to 7.5--8.5
_____________Record: pH
_________ Assume 782
N CODE
27-D
ACCT LBS.
330 lo Jim 22" (431 G) water into V-330 & heat to 16Q-170OF.
7 2kld in 12-13 min
.,
Stir 5 min & Record: pH f&/(9.5-10.5)
j "Stir 20 min or longer to dissolve for S 46
700/, S' 530-A 700 ' '
357* "Run 29" (210 G) water into V-357 & heat to 135-14QQF___________ 8. -S5- "OuhiD in & stir to dissolve for S 42
302* **S!o~ Ru bf -36" ^440 G) water into V-302 9 'Add & Stir 2. min for S 44 . --'.
Assume 502
450i. z7 15-A 450 . .
440 . 7-0 220
SV Tdhen V-349 MTY. rinse in with minimum water then set dump at 10 --efo setting When V-343 MTV, rinse in wi minimum water then t off
^-rTTump motor
6#* Turn-off steam
Jg liun-l'n V-357 *rom S 35 & st-ir 5 min
B*cford: pH 3.5 13.7-4.2)-
"
"
------STF7T- ""'ftED*n,w T?O0 ~
"?p Run in N-7-' -rom S 37 in 10-12 min & stir 5 min
Record: pH
(9.0-9.5) & if necessary, adj to pH 9.0-9.5 !
& Record: d H
Assume 782
27-D
Dilute 10 parts water to 1 Dart N-7-D
Assume 5055
7-D
^Siphon N-7-D into SV -J&T Run in V-330 thru 20 mesh screen & stir 20 min 4
x
313
11
S4iKr
fctfn 15" Stir 5
222 G) water into min to dissolve for
V-313 S 49
&
dump
in
270, f 20-A 270
*
SV Run V-313 into SV in 15-20 min
12
Record: pH VT915rlO')
'Stop aqitatof dir AP-f S-titP Y'Ptp-
_____
1-
Steo
V-262 (20 #M) V-243, 244,246, 24 7
'
q 2" w--------------------------jg-----------------------
4" ; 47"
- -*
START
^a
-*--------- ---..,
......................
FIN in Oor> fit* t> pty
0PTR -z-3.5-.r 8"-V.*C ^ ' iSf
,*<
DUP050094929
23
\ }
i
DUP050094930
3 r*
i
>
DUP050094931
DUP050094932