Document N2XvnVodMZQknavEmpn1kZn2R

National Foam MATERIAL SAFETY DATA SHEET #NMS300 Aer-O-Lite 3% AQUEOUS FILM FORMING FOAM (AFFF) Liquid Concentrate Section 1. CHEMICAL PRODUCT/COMPANY IDENTIFICATION Material Identification Product: Aer-O-Lite 3%, Fire Fighting Foam Concentrate Synonyms: Aqueous Film Forming Foam (AFFF) CAS No: Mixture - No single CAS # applicable Company Identification Manufacturer: National Foam, Inc. 180 Sheree Boulevard, Suite 3900 P.O. Box 695 Exton, PA 19341-0695 Emergency Phone Number (Red Alert): (610) 363-1400 (U.S.A.) Fax (610) 524-9073 www.Kidde-Fire.com Section 2. COMPOSITION / INFORMATION ON INGREDIENTS Components Water 1, 2 Propanediol Synthetic Detergents (2-Methoxymethylethoxy) Propanol Fluoroalkyl Surfactant CAS Number 7732-18-5 57-55-6 No single CAS # applicable 34590-94-8 Confidential % Weieht 61-88% 5-15% 4-10% 3-10% 0.5-2.0% NMS#300 Page 1 of 8 10/01/07 US00008315 Section 3. HAZARDS IDENTIFICATION Potential Health Effects Inhalation Vapors are minimal at room temperature. If product is heated or sprayed as an aerosol, airborne material may cause respiratory irritation. . Skin Contact ' Contact with liquid may cause moderate irritation or dermatitis due to removal of oils from the skin. Eye Contact Product is an eye irritant. Ingestion Not a hazard in normal industrial use. Small amounts swallowed during normal handling operations are not likely to cause injury; swallowing large amounts may cause injury or irritation. Additional Health Effects Existing eye or skin sensitivity may be aggravated by exposure. Carcinogenicity Information No data available. Section 4. FIRST AID MEASURES Inhalation No specific treatment is necessary since this material is not likely to be hazardous by inhalation. If exposed to excessive levels of airborne aerosol mists, remove to fresh air. Seek medical attention if effects occur. Skin Contact In case of skin contact, wash off in flowing water or shower. Launder clothing before reuse. Eye Contact In case of eye contact, flush eyes promptly with water for 15 minutes. Retract eyelids often to ensure thorough rinsing. Consult a physician if irritation persists. Ingestion Swallowing less than an ounce is not expected to cause significant harm. For larger amounts, do not induce vomiting. Give milk or water. Never give anything by mouth to an unconscious person. Seek medical attention. NMS#300 Page 2 of 8 10/01/07 US00008316 Section 5. FIRE FIGHTING MEASURES . Flammable Properties Flash Point: >200F Fire and Explosion Hazards Avoid contact with water reactive materials, burning metals and electrically energized equipment. Extinguishing Media Product is an extinguishing media. Use media appropriate for surrounding materials. Special Fire Fighting Instructions This product will produce foam when mixed with water. Section 6. ACCIDENTAL RELEASE MEASURES ' Safeguards (Personnel) NOTE: Review FIRE FIGHTING MEASURES and HANDLING (Personnel) sections before proceeding with clean-up. Use appropriate Personal Protective Equipment during clean-up. Accidental Release Measures Concentrate Stop flow if possible. Use appropriate protective equipment during clean up. For small volume releases, collect spilled concentrate with absorbent material; place in approved container. For large volume releases, contain and collect for use where possible. Flush area with water until it no longer foams. Exercise caution, surfaces may be slippery. Prevent discharge of concentrate to waterways. Disposal should be made in accordance with federal, state and local regulations. Foam/Foam Solution See above. Flush with water. Prevent discharge of foam/foam solution to waterways. Do not discharge into biological sewer treatment systems without prior approval. Disposal should be made in accordance with federal,-state and local regulations. Section 7. HANDLING AND STORAGE Handling (Personnel) Avoid contact with eyes, skin or clothing. Avoid ingestion or inhalation. Rinse skin and eyes thoroughly in case of contact. Review HAZARDS and FIRST AID sections. Storage Recommended storage environment is between 20F (-7C) and 120F (49C). Store product in original shipping container or tanks designed for product storage. NMS#300 Page 3 of 8 10/01/07 Section 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Engineering Controls Special ventilation is not required. Personal Protective Equipment Respiratory Recommended exposure limits (OSHA-PEL and ACGIH-TLV) have not been determined for this material. The need for respiratory protection should be evaluated by a qualified health specialist. Protective Clothing Rubber or PVC gloves recommended. Eye Protection Safety glasses, face shield or chemical splash goggles must be worn when possibility exists for eye contact. Contact lenses should not be worn. Eye wash facilities are recommended. Other Hygienic Practices Use good personal hygiene practices. Wash hands before eating,, drinking, smoking, or using toilet facilities. Promptly remove soiled clothing and wash thoroughly before re-use. Exposure Guidelines Exposure Limits (2-Methoxymethylethoxy) Propanol (34590-94-8) PEL(OSHA) 100 ppm, 8 hr. TWA Skin 150 ppm, 15 min. STEL Skin TLV (ACGIH) 100 ppm, 8 hr. TWA Skin 150 ppm, 15 min. STEL Skin Section 9. PHYSICAL AND CHEMICAL PROPERTIES Physical Data Boiling Point: Not applicable Vapor Pressure: Not applicable Vapor Density: Not applicable Melting Point: Not applicable Evaporation Rate: <1 (Butyl Acetate = 1.0) Solubility in Water: 100% NMS#300 Page 4 of 8 10/01/07 US00008318 pH: Specific Gravity: Freezing Point: Odor: Form: Color: 8.0 1.03 @ 25C 12F (-11C) Mild, pleasant Liquid Straw yellow Section 10. STABILITY AND REACTIVITY Chemical Stability Stable. Incompatibility, Materials to Avoid Avoid use of product on burning metals, electrically-energized equipment and contact with water reactive materials. Polymerization Will not occur. Section 11. TOXICOLOGICAL INFORMATION Mammalian Toxicity . Ingestion This material was not toxic when administered to Wistar Albino rats at an acute oral dose of 5g/kg body weight. Eye _ Animal testing indicates this material is a primary eye irritant when tested undiluted on New Zealand Albino Rabbits. Skin Animal testing indicates this material is not a primary skin irritant when tested undiluted on New Zealand Albino Rabbits. Inhalation No data available at this time. Carcinogenic, Developmental, Reproductive, Mutagenic Effects No data available on this material. NMS#300 Page 5 of 8 10/01/07 US00008319 Section 12. ECOLOGICAL INFORMATION Ecotoxicological Information Aquatic Toxicity 96 hr. Flow Through LC50 for Fathead Minnows (pimephales promelas) is reported to be greater than 1000 ppm. Environmental Fate BOD5 Concentrate 239,000 mg/kg BOD5 3% solution 8,750 mg/kg COD Concentrate 400,000 mg/kg Section 13. DISPOSAL CONSIDERATIONS Aer-O-Lite 3%, as sold, is not a RCRA-listed waste or hazardous waste as characterized by 40 CFR 261. However, State and local requirements for waste disposal may be more restrictive or otherwise different from Federal regulations. .Therefore, applicable local and state regulatory agencies should be contacted regarding disposal of waste foam concentrate or foam/foam solution. Concentrate Do not discharge into biological sewer treatment systems without prior approval. Specific concerns are high BOD load and foaming tendency. Low dosage flow rate or antifoaming agents acceptable to the treatment plant may be helpful. Do not flush to waterways. Disposal should be made in accordance with federal, state and local regulations. Foam/Foam Solution Aer-O-Lite 3% foam solution can be treated by waste water treatment facilities. Discharge into biological sewer treatment facilities may be done with prior approval. Specific concerns are high BOD load. Dilution will reduce BOD and COD factors proportionately. Low dosage flow rate or antifoaming agents acceptable to the treatment plant may be helpful. Do not flush to waterways. Disposal should be made in accordance with federal, state and local regulations. NOTE: As a service to our customers, National Foam has approvals in place with disposal facilities throughout the U.S. for waste water treatment and solidification and landfill of our foam liquid concentrates and foam solutions. If required, National Foam, Inc. can also provide information on the disposal of drums used for shipping our concentrates. Please contact National Foam's Risk Management Administrator at (610) 363-1400 for additional information. NMS#300 Page 6 of 8 10/01/07 US00008320 Section 14. TRANSPORTATION INFORMATION Shipping Information Proper Shipping Name: Fire Extinguisher Charges or Compounds N.O.I., Class 70 National Motor Freight Code: 69160, Sub 0 Hazard Class: None UN Number: None Section 15. REGULATORY INFORMATION U.S. Federal Regulations Toxic Substances Control Act (TSCA) All components of this product are listed in the TSCA inventory. Superfund Amendments and Reauthorization Act of 1986 (SARA), Title III Section 302/304 There are no components of this material with known CAS numbers which are on the Extremely Hazardous Substances (EHS) list. Section 311 & 312 Based on available information, this material contains the following components which are classified as the following health and/or physical hazards according to Section 311 & 312: (2-Methoxymethylethoxy) Propanol 34590-94-8 (Flammability) Section 313 This material does not contain any chemical components subject to Section 313 reporting requirements. COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND LIABILITY ACT (CERCLA) This material does not contain any components subject to the reporting requirements of CERCLA. OTHER REGULATORY INFORMATION Canadian Environmental Protection Act (CEPA). All ingredients are listed on the DSL (Domestic Substance List). STATE REGULATIONS PENNSYLVANIA RIGHT-TO-KNOW HAZARDOUS SUBSTANCES LIST PA Hazardous Substances present at levels greater than 1%: 1, 2 Propanediol 57-55-6 (2-Methoxymethylethoxy) Propanol 34590-94-8 NMS#300 Page 7 of 8 10/01/07 Section 16. OTHER INFORMATION NFP'A Rating WHMIS Ratine Health 0 Flammability 0 , Reactivity 0 D2B ADDITIONAL INFORMATION Revision Summary 5/3/96............Revised to ANSI format. 10/2/96......... Updated Section 12 - Environmental Fate. 2/5/99 .......Added MSDS number, updated Sections 1,3,4,6,7,9,11,12,13,15. 08/10/00......Revised Section 1 and 2. 09/10/03 .......Updated Sections 2, 5, 9, 14, 15, 16. 05/03/05 ......Updated Section 9. 10/01/07....... Updated Address. For further information, see National Foam Product Data Sheet for Aer-O-Lite 3%. The information contained herein is furnished without warranty either expressed or implied. This data sheet is not a part of any contract of sale. The information contained herein is believed to be correct or is obtained from sources believed to be generally reliable. However, it is the responsibility of the user of these materials to investigate, understand and comply with federal, state and local guidelines and procedures for safe handling and use of these materials1. National Foam, Inc. shall not be liable for any loss or damage arising directly or indirectly from the use of this product and National Foam, Inc. assumes no obligation or liabilities for reliance on the information contained herein or omissions herefrom. October 1, 2007 NMS#300 Page 8 o f 8 10/01/07