Document MoKvL0eGmenEM39MQjJVRmXqx
mm <"DflTTE ) '___ ________
< LOT )
LOCATN CG CODE PQ
PKG 5084*
< EST WGT )
DRY* LOT ; WEIGHT
PROCESS
APPROVED^
< ) K0-786-D <P) FWP 09/08/82
NAME: 04K0786DMP
M. STANDARD HRS. 10.5
DRY -NO. . C0NT PKG
PKG WGT
TOTAL WEIGHT
ACTUAL USE LBS
01 YC-I& ?i 01 YC-10 93 01 YC-10 93 01 YC-10 93 SUBSTANDARD BLEND-BACK
jiio_ , lt ,jir
FOR S-40
Sao SoCO
&l)
/bo ^ ao Cl tip , ip
-* **4*`.
~T
o_ jit: '
Lrs sM'
~3e>o
3oo
-JhESsd.
REG. imi//o&/ >
NON-BLEEDING
EQUIP MENT |
NAME 'KROLOR* ORANGE R
USE N ACCT LBS CODE LBS
a BEFORE USING SV, MAKE SURE THAT N-28-D (HYDRO I
CHLORIC ACID) LINE, IF ANY IS BLANKED OFF*.
{ RUN 60*<990 G) WATER IN V-211 & ADD ASSUME 50%I 30 I 7-D | 15
6 i(CAUSTIC SODA SOLN) 6 SET AGITATOR ON HIGH SPEED
208
"WEIGH IN DRUM' AND POUR IN (SODIUM SILICATE)
I 270
32-D
270
DUMP IN AND-STIR 5 MIN (MOLYBDATE ORANGE)
i80X50 YC10B 4000
RECORD : START. LOT FIN
VC/06 | _ 3<? _
I AJLiUST TO 75* (1275.0 *NOTE: VOLUMES HIGHER
V ,,^?HAN 75* MAY CAUSE DUSTING IN EXHAUST HOOD.
I _fef-f.iL..
l-Z^aSQ. I___ _
I I WITfcL-AGITATOR ON LOW SPEED PUMP V-211 - THRU:
4-
i ij^nTOMOG AT 1800-2200 PS I INTO V-208
I
WHEN V-211 MT, WASH COLOR THRU HOMOG WITH MIN i
HOT UATER AT 1800-220 PSI INTO V-208
:CORD: V-208 VOL.$t_* & ADJUST TO 50* (1840G)
INSPECT HOMOG. STRAINER 6 CLEAN IF NECESSARY
RUN 15* (771 G) WATER INTO V-
START
j
iGTTATOR 6 INSTALL TEMP CHART
I
PUMP V-208 THRU HOMOG
0-52 0 PSI INTO SV.
RECORD: TIME START^a So t Mj TOTAL MINUTES L&g_
NQIS: IF HOMOG PRESSURE FALLS BELOW 480 PSI,
JAY VALVE WILL RECIRCULATE SLURRY TO V-208
WHEN V-208 MT, RUN IN 5*(240 G) WATER 6 PUMP
I I THRU HOMOG AT 4800-5200 PSI INTO SV . -
\^r\
RUN 6-" (284 G) WATER INTO V-349
1000* WATER INTO V-384 6 HEAT TO 110-120*F
INTO V-384 6 PUMP TO V-349
000*. WATER INTO Vr-384 6 PUMP TO V-349
ADJ V-349 TO 22*, (J.040 G) & STIR 15 MIN
RED
DENSITY:
/ML (1.078-1.081)
24O0
i. ! 32-D 1 2400 .I
S-11
COMPLETE, ADJ SV TO 66"(3400 G)|
|T2*>,*t RECO0 RD: PH
6 ADJ TO 10.4-10.8 USING N-7-D ]
f** I DILUTED TO oX (10 PARTS WATER TO 1 PART N-7-D) i
j t ASSUME 50% i
1 SIPHON N-7-D INTO SV 6 RECORD: PH fixEsf
I
[ HEAT TO 190-194*F IN 55-65 MIN 6 REC:HT LlSL*F i
j 6 RECORD : 1$J*F
!'
II
I 7-D |.
LOT= __
EQUIP MENT |
COMTYP JOB NAME = 04K0786DMP PAGE 02
PAGE 2 CG 04 l< 0-786-D
V
DATE PRINTED: 9/14/32
) USE I: N- IACCT 1 LBS I CODE | LBS
| WHILE HEATING SV, RUN 51' (1 4Q0 0) WATER INTO
V-343
.
MMJTER IN <SULFURIC ACID 60%) FROM V-386 &JL, //U^/g a l , 3&/.g a l
^IR 15 MIN OR LOMGHfc
H RECORD: DENSITX^^G/ML (1 *-018-1 .020)
I I l
i
! 1
i 27-D | 355
"1
I
i i-
I\
WHEN S 20 HEATING COMPLETE, RECORD: PH__]t.<3 .
SET V-343 ACID PUMP AT 72 SETTING <225 MIN)
SET V--349 SILICATE PUMP AT 66 SETTING <180 MIN)
IMMEDIATELY METER IN V-343 & V-349. MAINTAIN SV
AT 190-194*F DURING STRIKE
I
RECORD:
START
V-343
F,tNI
MINUTES_-4--' j
V-349
J&t
,i
TIME V-343
V-349
NORMAL - I
INCHES INCHES
'22MU7).._#P C20)
PH I
_ -10.0)!
JMl <43
<i7)jla ,SU<3-i0.O)t
i^..<38 >M> <15)/JC ;j3L-<9.-3-10.0) i
wm. (24)JL < 7)Jt_
(9.3-10.0)1
/&&&. <io) FINISH /&*?** < 0)
LJM-P-
(9.3-10.0)| xfe 7.5-8.5)I
NOTE: IF PH DROPS BELOW 9.3 IN FIRST HOUR, STOP I
PUMPS 6 SEE SUPV. IF FINAL PH IS ABOVE 1
8.5, ADJ TO--75-8.5 6 RECORD
ASSUME 77% j__rz:
j 27-
ADD 67*"<514 o'WA^ER T0"v-3i5" ADD^JL STIR 2 MIN
150 7-D | 75
WHEN"v-349~MT7_RINsi~lN"wiTH"MINIMUM~WATlR l
P AT ZERO SETTING
343 MT, RINSE IN'WITH MINIMUM WATER &
' \ TURN-. OFF RUMP MOTOR
I II
} STEAM
I I Ic
ISS^rfMJN IN LIQUID ALUM USING BADGER METER .
1- 600 1 115-D I 300
ALUM LINE WITH WATER.
I! J i ! --
RECORD: PHJJJ? <3.3-3.7) G IF NECESSARY ADJ I i
(DOWN ONLY) TO 3.3-3.7 6 RECORD: PH.____
II
NOTE: USE LIQUID ALUM, N-115-A. ADD TO SV VIA |
1
BADGER METER. STIR 5 MIN AFTER EACH
I
I
ADDITION.
ASSUME 50%!__J^2_i 115- D jJZ!
5UN IN N-7--D. FROM $ 33 IN 4-6 MIN % STIR 5 MIN I
I
RECORD: PH..X.Z <4.0-4.2)' & IF NECESSARY ADJ TO |
I
PH 4.0-4.2. RECORD: PH __
ASSUME 77%|___
27-D
DILUTE N-7-D 10 TO 1 WITH WATER
ASSUME 58%|____r
7-D
'SIPHON N-7-D INTO SV
: 't
WHEN SCHEDULED ON TOP OF PAGE 1, DUMP IN
I
SUBSTANDARD TO BE BLENDED BACK..................... - | :
RECORD: CODE LOT-*
I
STOP AGITATOR
|
/
m-
START
FINISH
OPERATOi
-
JL2-i M
f
v, jr-
&rr*i
DUP050103544
DUP050103545
u
DUP050103546
DUP050103547