Document MGKaKM5wxjpXkBeYNKK2Yqnza
APPROVED BY: FWP 06/24/82
.\.ji>ft**
NAME: MOLYBDATE ORANGE
i ^L^OBTAIN FOR S-34
I ^T>-OBTAIN FOR S-23 I OBTAIN FOR 5-38 OBTAIN FOR S-40 OBTAIN FOR S-43
j I DRUM FOR S-4? I'7 f DISSOLVE IN 30 C |. 1 DRUM FOR S-51
100-12*F IN 100-12*F IN
i r ac c t : I N-CODE 1 LBS
1 315 | 4--A 1 315
1 . 42 | 108-A l 42
i 105 1 3-A 1 105
i 58 I 32-D I 58
i 47 | 3-A 1 47
I1
1
1 17 | 765-A 1 17
I1
1
1 60 1 994--A 1 60
WEIGH IN
OPTR
OPTR OPTR
MK 33g_, JSZ&SL* 1 ___ MK ____, ___J% I
i
MK t. t -3M> MK___ , T-_,,
-7/LT-i .%l
. 10--D 423-D
) 1407 1
1 I .252
1 FLUSH DISTRIBUTOR LINES UNTIL WATER COMES {
| i OUT ALL JETS RECORD:____ .(OK)
tI
SV UKT RUN IN 40* (1992 G> WATER ,
%
,,I
,i
\%2^\ RUN IN FROM V-354. OPTR AX.,
t_*FiloOgfiJU)
yfeto.,} I PH_/_;.7_<2.8-3.7> G/ML2iIJJ-_(1 *270-1.328)
U.oojgA I
IL
SEE SUPV IF NOT IN RANGE* I7
IB'j ADJ TO 3294 GAL AT 67-6*F. RECORD:"Ji_*F]
_
1
*^7|
| (67* IN V--240 & 246;/^9pIN V-241. 242, 245)
I
II STIR 5MIN. &RECORD: PKjfcJl <2.8-3,6)
Il
115 i IF NECESSARY. ADJJTO PH 3.8-3.9 ASSUME 32%L___ ___l
I | & RECORD: PHJ?_7_ (3.8-3.9)
ASSUME 50%I_ftI,,l
I i NOTE: DILUTE N-7-D 10:1 WITH WATER BEFORE {-
I ADDING , ..
I
I4E I RECORD :liXG/ML (1.117-1.118)
I
I | NOTE ; IF G/ML OUT OF LIMITS, FILL OUT CHECK I
I L^"' LIST 6 ATTACH
I
STIR AT 67--69*F FDR S-28. TAKE 1 QT SAMPLE, i
41-D | 3800 t I
57-A | l !
28-D |_____ 7-d
I
lS#n RUN 2* (110 G) WATER INTO V-358
lT~\ RUN V-359 INTO V-351
PUMP V-351 INTO V-358
1ZA'l TURN ON AGITATOR 358 iSKTT,SIFT IN N-108-A FROM S-2
1CT 07)1982
5 i23n ADJUST TO 68* (.3216 G) AT 6?~69*F
i
rJ
RECORD
II
!>rLsTIF! 3 MIN. 6 RECORD: PH^i.s(9.0-9.5)I _ I
l^f IF NECESSARY, ADJ.TO PH 9.0-9.5 ASSUME 32%|_j~f___I 28-D I__4
rI
6 RECORD: p h _37__
ASSUME 50% 1_______ I 7-D
124^T RECORD ; G/MLA.QSJL <1.059-1,060)
II
I I NOTE: G/ML OUT OF LIMITS FILL OUT CHECK
I
'!
I i-
LIST & ATTACH
Ii
\27 I STIR AT 6?~69*F FOR S-28. TAKE 1 Q1 SAMPLE.1
I
Ii
DUP050102887
LOT*_____ EQUIP i MENT
. COMTYP JOB NAME = OiYE735DMK
PAGE 02
DATE PRINTED: 9/03/&2
USE N USE LBS CODE LBS
RECORD: LOWEST PH
& ML N-IO-D
LOWEST PH _3Lq _ & ML N-iO-D JtiZ.9
NOTIFY SUPV IF ML N-IO-D IS NOT IN RANGE
lx 8-8*2 OR IF THE TWO TITRATIONS DIFFER
BY MORE THAN 0.10 ML N-IO-D (IF YES,
FLUSH ALL EQUIPMENT i, REPEAT TITRATIONS)
i
$ x t* *
i -i
DO NOT PROCEED IF N-IO-D TITRATION IS OUT OF RANGE
*8P'lSrT WHEN TITRATION IN S-28 OK, STRIKE V-358 THRU
6v :| i BOTH UNDERSURFACE DISTRIBUTORS INTO SV IN
-
I ' I 21--23 MIN. j /~}l 1 I I RECORD : STARr&'/fiToJrAL MIN.
--n (67-71 *r]) 7' '/
NOTE: STRIKE TIME UP WHEN 1/2 V-358 BOTTOM
SHOWS , BUBBLES APPEARS IN SIGHT GLASSES
IMMEDIATELY AT END OF STRIKE WASH IN V-358
IS^T SET TIMER FOR 10 MIN.
tXJ^T RUN IN USING BADGER METER A.F.A.P.
II
OPTR--sjTx , MK_jfL,______ _
L Att.
28-D
Ii
OPTR__;, MK___ ______ , 7.
i3>-r DUMP IN N-4-A FROM S-1 A.F.A.P.
I^T AFTER N-4-A IS ADDED, STIR 2 MIN. i$Pr TAKE 8 02,i SAMPLE & RECORD: PHjfejJk<2.4-2.5)
i PBXS,__JT__(MUST BE + ) STIR 10 MIN AFTER ADDITION OF N-4-A
misd'
DUMP STIR
IN N-3-A 3 MIN
FROM
S-3
-32-D FROM S--4
x s a RUN IN USING BADGER METER-
14^ STIR 3 MIN & FLUSH ALUM LINE WITH MINIMUM WATER DUMP IN N-3-A FROM S-5
336 1115-D
144 J STIR 3 MIN.-' -p
14^I
RECORD: PH
<3-B-6.0) '
IF NECESSARY-; ADJUST TO PH 5.S-6.0
RECORD: PHAl _7_
POUR IN N-765-A SOLN FROM S-6
ASSUME 32%
.! 3-A 28-B-
!4<rT STIR 5 MIN .-a
!4P^r RECORD: PHjl__7_ < 5.8-6.0)
I5^f IF NECESSARY, ADJUSJ^TO PH 5.8-6.0
! J 6 RECORD : PH___ ASSUME 32% !5f^! POUR IN N-994-A SOLN FROM S-7 (MUST BE DISSOL
3-A 28-D
! ^ VED) ! 52^4 STIR 2 MIN. 153 J DURING S-52 DUMP IN I54^i DUMP IN THE SUB-STANjBj&ftD TO' BE BLENDED BACK
22\/| 128-A
is^i (IF ANY^iSLS'HOWN 0$.'TOP-FRONT OF CARD)
STIR 20
SUB-STANDARD
15^-1 FLQ^D TO 153' (7298' G) L%TOP AGITATOR
II
' a# i,
I!
FINISH,
JJPTR
20
168
4o
22
DUP050102888