Document GKVYNRe9kK6ZrZXkebwrZzxK4

1 shall comply with those standards and ' limitations In accordance with Section ZIS.452. b) If an emission source Is not located In one of the counties listed below and is also not ' located In .any county cont iguous thereto, the owner or.operator of the emission source shall comply with the requirements of Sections 215.445 through 215.451 no later than December 31. 1987: .Cook OuFage Kane lake Macoupin Madison Monroe Saint Clair (Board Note:. . These counties are proposed to ' be designated as nonattainment by the OSEPA at 47 Fed. Reg.. 31588.,July 21. 1982.} c) Notwithstanding subsection, (b). If any county Is designated asnonattatncnent by the OSIN at aiiy time subsequent to the effective date . of this Section, the owner or operator of an emission, source located In. that county or any - " `.County contiguous to that county.who'would . ' otherwise be subject .to the compliance date in subsection (b) shall comply with the requirements of Sections 215.445 through :215.451 within one year from the date of redesignation but In no case later than Oecember 31. 1987. (Source:' Amended at 7 111. Reg. 1244. effective January 21. 1983) . SUSPART s: RUBBER AND MISCELLANEOUS ; . PLASTIC PRODUCTS . Section' 215.461 Manufacture of Pneumatic Rubber Tires The owner or operator, of. an undertread cementing, treadend cementing or bead dipping operation at a pneumatic rubber tire manufacturing facility shall Install and operate: a) A capture system, with minimum capture efficiency of 65 percent by weight of volatile, organic material.Tor treadend cetnentlrig.of. bead dipping operations and a capture system with a mlnlmra capture . efficiency ofSS.S percent by weight of '.volatile organic material for undertread cementihg; and b) A control device that meets the requirements of one of the following: 1) A carbon adsorption system designed and ..operated In a manner such that there Is at least a 90 percent removal of volatile organic material by weight from the gases ducted to the control device: _ 2) An afterburning system that oxidizes at least 90 percent of the captured nonmethane volatile organic materials (VOH measured as total combustible carbon) to carbon dioxide and water; and 3) Ah alternative volatile organic material emission reduction system, demonstrated to have at least a 9D percent overall reduction efficiency and approved by the Agency. (Source: . Adopted at 7 111. Reg..1244. effective ! January 21. 1983), Section 215.462 Green. Tire Spraying Operations , The owner or operator of a green tire spraying . . operation at a pneumatic rubber tire manufacturing ,facility shall: a) Install and operate: 1) A capture system-witlra mhrtiixjm capture efficiency of 90 percent' by weight of volatile organic material; and 2) A control "<fevfce"tfat meists the requirements of one of the following: 2 ' ' A carbon adsorption system designed and. operated In a'manner such that there, is. at. least,.90. percent, removal, or volatile'orgariic material by weight .from the bases ducted to the control device; B) An afterburning system that oxidizes at least 90 percent of the captured nohmethane volatile organic material ' (measured as total combustible. "carbon) to carbon ..dioxide and water; . or- * C) An alternative volatile organic material,emission reduction system denbnstratedtO hive at Teast a gir percent overall reduction efficiency - and approved by, the Agency. b) Substitute for the normal solvent-based mold ; release compound water-based sprays containing; r* : 1) No more than five percent by volume of volatile, organic -material, as. appl led for 't' \ the Inside of tires; ,,. 2) No more than ten percent by volume of volatile organic material as applied for | the outside of tires. (Source: Adopted at 7 111. Reg. 1244. effective January 21. 1983) i Section 21S.463. Alternative Emission i Reduction Systems In lieu of complying w1th' Secttorr'2>S.46'V~or ... 2IS..462, the owner or operator of an emission source may utilize an alternative volatile organic emission reduction system. Including an alternative production process, which Is demonstrated to be equivalent fo setiWH Zir. W" or 215.462 dn the basis of emissions of volatile organic matter. A treadend cementing operation shall be considered equivalent to Section 116 -