Document G9ZMKyxNymnD1az9Ox3QkEJv

MATERIAL SAFETY DATA SHEET Emergency Telephone Consumer Products Division. Division of Borden. Inc. 180 EAST BROAD STREET, COLUMBUS. OHIO 43215 (614) 431-6600 For ordering Information, additional copies of MSOS, etc., 600-848-9400 For technical Information only, 614-431-8680 THE OSHA HAZARD COMMUNICATION STANDARD 29 CFR 1910.1200 REQUIRES THAT THE INFORMATION CONTAINED ON THIS SHEET BE MADE AVAILABLE TO YOUR WORKERS. INSTRUCT YOUR WORKERS TO HANDLE THIS PRODUCT PROPERLY NAME: KflYLON CRYSTAL CLEAR SPRAY COATING TYPE AEROSOL ACRYUC SPRAY APPLICATION: ITEMS 1301.1302.1303,1304.13012 P C_ 0^ ^ V *v M-Dec-86 SIGNAL WORD--OANGERI THIS MATERIAL IS A -HEALTH HAZARD" AND/OR A "PHYSICAL HAZARD" AS DETERMINED WHEN REVIEWED ACCORDING TO THE REQUIREMENTS OF THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION 29 CFR PART 1910.1200 "HAZARD COMMUNICATION" STANDARD. _______ CHEMICAL HAZARO RATING HEALTH =2 (MODERATE) FIRE = 4 (EXTREME) REACTIVITY = 0 (LEAST) CHRONIC = 29CFR1910.1200 HAZAflOOUS IN6REOIENTS/BEPORTEO HEALTH EFFECTS CAS REGISTRY NO. MATERIAL DESCRIPTION* RANGE 67-64-1 ACETONE 5-15 CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION. SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE. DIZZINESS. NAUSEA. VOMITING, UNCONSCIOUSNESS AND EVEN ASPHYXIATION -SEE FOOTNOTES) C ACGIH TLV. 750 PPM (1780 MG/M3) TWA: 1000 PPM (2375 MG/M3) STEL OSHA PEL 1000 PPM (2400 MG/M3) TWA NIOSH DOCUMENT NUMBER: 78-173 74-98-6 PROPANE 5-15 THIS MATERIAL IS A SIMPLE ASPHYXIANT. SIGNS AND SYMPTOMS OF OVEREXPOSURE INCLUDE CYANOSIS, RESPIRATORY DISTRESS. HEADACHE. DIZZINESS, DROWSINESS. UNCONSCIOUSNESS AND ASPHYXIATION. CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION. -SEE FOOTNOTE(S) C. ACGIH TLV: SIMPLE ASPHYXIANT-SEE ACGIH TLVS, APPENDIX E OSHA PEL: 1000 PPM (1800 MG/M3) TWA___________________________ 75-28-5 ISOBUTANE -SEE FOOTNOTE(S) C ACGIH TLV: NONE ESTABLISHED OSHA PEL NONE ESTABLISHED 15-30 108-88-3 TOLUENE 5-15 OVEREXPOSURE MAY CAUSE LIVER DAMAGE. OVEREXPOSURE MAY CAUSE KIDNEY DAMAGE. CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION. SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE, DIZZINESS, NAUSEA. VOMITING. UNCONSCIOUSNESS AND ASPHYXIATION. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE WITH PERMANENT BRAIN AND NERVOUS SYSTEM OAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND INHALING THE CONTENTS MAY LEAD TO AODICTION AND MAY BE HARMFUL OR FATAL.-SEE FOOTNOTE(S) C ACGIH TLV: 100 PPM (375 MG/M3) TWA; 150 PPM (560 MG/M3) STEL OSHA PEL: 200 PPM TWA; 300 PPM CEILING: 500 PPM 10-MIN. PEAK NIOSH DOCUMENT NUM8ER: 73-11023_____________________________ 142-82-5 HEPTANE 15-30 CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION. SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE. DIZZINESS. NAUSEA. VOMITING. UNCONSCIOUSNESS AND EVEN ASPHYXIATION.-SEE FOOTNOTED) C ACGIH TLV; 400 PPM, 8-HR TWA OSHA PEL 500 PPM, 8-HR TWA NIOSH DOCUMENT NUMBER: 77-151 1330-20-7 XYLENE OVEREXPOSURE MAY CAUSE LIVER DAMAGE. 15-30 DISCLAIMER--SEE REVERSE SIDE OVEREXPOSURE MAY CAUSE KIDNEY DAMAGE. CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE. DIZZINESS NAUSEA VOMITING UNCONSCIOUSNESS AND EVEN ASPHYXIATION.-SEE FOOTNOTED) C ACGIH TLV: 100 PPM (435 MG/M3) TWA; 150 PPM (5 MG/M3) STEL OSHA PEL 100 PPM (435 MG/M3) TWA NIOSH DOCUMENT NUMBER: 75-168 64742-94-5 HEAVY AROMATIC SOLVENT NAPHTHA (PETROLEUM) 1 -5 CAN CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION SIGNS AND SYMPTOMS MAY INCLUDE HEADACHE. DIZZINESS. NAUSEA VOMITING UNCONSCIOUSNESS AND EVEN ASPHYXIATION--SEE FOOTNOTE^} C ACGIH TLV: NONE ESTABLISHED OSHA PEL: NONE ESTABLISHED FOOTNOTE C: AS OF THE DATE OF ISSUANCE OF THIS DOCUMENT THIS MATERIAL HAS NOT BEEN LISTED 8Y NTP, (ARC OR OSHA AS A CARCINOGEN. PHYSICAL QATA VAPOR PRESSURE-SEE CAN PRESSURE VAPOR DENSITY HEAVIER THAN AIR SOLUBILITY IN WATER-SLIGHT SPECIFIC GRAVITY LIGHTER THAN WATER EVAP RATE FASTER THAN BUTYL ACETATE BOILING POINT. APPEARANCE; ODOR-NA PERCENT VOLATILE BY WEIGHT--94 PERCENT NON-VOLATILE BY WEIGHT--6 PRESSURE IN CONTAINER, PS1G @ 70F. APPROX 60________ ACUTE HEALTH HAZARD DATA SKIN ABSORPTION: NO HAZARDS KNOWN TO BORD0L iNGESTION: NOT EXPECTED TO BE HARMFUL UNDER NORMAL CONDITIONS OF USE. INHALATION: MAY BE HARMFUL IF INHALED. LIQUID OR VAPOR CAN CAUSE IRRITATION OF NOSE, THROAT AND LUNGS. SKIN: CAUSES IRRITATION. EYES: CAUSES IRRITATION. HANDLING PRECAUTIONS INHALATION: AVOiD BREATHING VAPOR OR MIST USE WITH ADEQUATE VENTILATION. SKIN: AVOIO CONTACT WITH SKIN. EYES: AVOID CONTACT WITH EYES. HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICES. THESE PRACTICES INCLUDE AVOIDING UNNECESSARY EXPOSURE AND REMOVAL OF THE MATERIAL FROM EYES SKIN AND CLOTHING. WASH THOROUGHLY AFTER HANDLING__________________ EMERGENCY ANO FIRST AIO PROCEDURES INGESTION: IF ACCIDENTLY SWALLOWED. DILUTE BY DRINKING LARGE QUANTITIES OF WATER. IMMEDIATELY CONTACT POISON CONTROL CENTER OR HOSPITAL EMERGENCY ROOM FOR ANY OTHER ADDITIONAL TREATMENT DIRECTIONS. INHALATION' REMOVE TO FRESH'AIR IF NOT BREAT'H'NG. GIVE ARTIFICIAL SAL 000009913 ----- SEE REVERSE SIDE---------------------------------NOR(M) KD-1301 D 26-JUN-86 P CO 37 RESPIRATION PREFERABLY MOUTH-TO-MOUTH. IF BREATHING IS DIFFICULT. GIVE OXYGEN CALL A PHYSICIAN" SKIN CONTACT FLUSH SKIN WITH WATER IF IRRITATION PERSISTS. CALL A PHYSICIAN EVE CONTACT IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES EYELIDS SHOULD BE HELD APART DURING IRRIGATION TO INSURE WATER CONTACT WITH ENTIRE SURFACE OF EYES AND UPS CALL A PHYSICIAN_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ FIRE AND EXPLOSION HAZARD DATA EXTREMELY FLAMMA8LE. CONTENTS UNDER PRESSURE EXPOSURE TO HIGH TEMPERATURE MAY CAUSE BURSTING. AVOID RADIATORS. STOVES. DIRECT SUNLIGHT OR OTHER HEAT SOURCE DO NOT PUNCTURE OR INCINERATE CONTAINER DO NOT SPRAY NEAR OPEN FLAME IN CASE OF FIRE. USE DRY CHEMICAL. FOAM OR 002. WATER MAY BE INEFFECTIVE. BUT SHOULD BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL REACTIVITY DATA NORMALLY STABLE AS DEFINED IN NFPA 704-12 (4-31). HAZARDOUS POLYMERIZATION WILL NOT OCCUR. MAJOR DECOMPOSITION PRODUCTS OXIDES OF CARBON. CONTROL MEASURES IF AIRBORNE CONTAMINANTS ARE GENERATED WHEN THE MATERIAL IS HEATED OR HANDLED SUFFICIENT VENTILATION IN VOLUME AND AIR FLOW PATTERNS SHOULD 8E PROVIDED TO KEEP AIR CONTAMINANT CONCENTRATION LEVELS BELOW ACCEPTABLE CRITERIA. ENGINEERING CONTROLS THE FOLLOWING EXPOSURE CONTROL TECHNIQUES MAY BE USED TO EFFECTIVELY MINIMI2E EMPLOYEE EXPOSURE LOCAL EXHAUST VENTILATION. ENCLOSED SYSTEM DESIGN. PROCESS ISOLATION AND REMOTE CONTROL IN COMBINATION WITH APPROPRIATE USE OF PERSONAL PROTECTIVE EQUIPMENT ANO PRUDENT WORK PRACTICES THESE TECHNIQUES MAY NOT NECESSARILY ADDRESS ALL ISSUES PERTAINING TO YOUR OPERATIONS WE. THEREFORE. RECOMMEND THAT YOU CONSULT WITH EXPERTS OF YOUR CHOICE TO DETERMINE WHETHER OR NOT YOUR PROGRAMS ARE ADEQUATE_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ PERSONAL PROTECTION INFORMATION WHERE AIR CONTAMINANTS CAN EXCEED ACCEPTABLE CRITERIA USE NlOSH/MSHA APPROVED RESPIRATORY PROTECTION EQUIPMENT RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION OF CONTAMINANTS IN AIR IN ACCORDANCE WITH OSHA 29 CFR 1910.134 OR OTHER APPLICABLE STANOAROS OR GUIDELINES USE GOGGLES IF CONTACT IS LIKELY WEAR IMPERVIOUS GLOVES AS REQUIRED TO PREVENT SKIN CONTACT. SPILL OR LEAK PROCEDURES ELIMINATE ALL IGNITION SOURCES SOAK UP WITH ABSORBENT MATERIAL ANO REMOVE TO A CHEMICAL DISPOSAL AREA. PREVENT ENTRY INTO NATURAL BODIES OF WATER WASTE DISPOSAL METHOD DISPOSE OF ACCORDING TO LOCAL STATE. ANO FEOERAL REQUIREMENTS EMPTY CONTAINER: MAY CONTAIN EXPLOSIVE VAPORS DO NOT CUT PUNCTURE OR WELD ON OR NEARBY. INCINERATION WILL CAUSE CONTAINER TO BURST VIOLENTLY STORAGE PRECAUTIONS DO NOT STORE AT TEMPERATURES OVER 120F DOT CLASSIFICATION ORM-D CONSUMER COMMODITY NOR(M) K0-1301 D 26-JUN-86 ! SAL 000009924 DISCLAIMER SELLER MAKES NO WARRANTY, EXPRESS OR IMPLIED. CONCERNING THE PRODUCT OR THE MERCHANTABILITY OR FITNESS THEREOF FOR ANY PURPOSE OR CONCERNING THE ACCURACY OF ANY INFORMATION PROVIDED BY BORDEN, except that the product shall conform to contracted specifications, and that the product does not infringe any valid United States patent. The information provided herein was believed by Borden to be accurate at the time of preparation or prepared from sources believed to be reliable, but it is the responsibility of the user to investigate and understand other pertinent sources of information, to comply with all laws and procedures applicable to the safe handling and use of product and to determine the suitability of the product for its intended use. Buyer's exclusive remedy shall be for damages and no claim of any kind, whether as to product delivered or for non-detivery of product, and whether based on contract, breach of warranty, negligence or otherwise shall be greaier in amount than the purchase price of the quantity of product in respect of which damages are claimed. In no event shall Seller be liable for incidental or consequential damages, whether Buyer's claim is based on contract, breach ol warranty, negligence or otherwise.