Document DMDK9OpEjkVynVV7KV2yN4E4
INTERNAL CORRESPONDENCE
UNION CARBIDE CORPORATION TECHNICAL CENTER
P.Q. BOX 83B 1, SOUTH CHARLESTON, WV 2530
Location Ares
P.Copy to D. Gossage, 701/4 C. P. Maxwell, 701/256 R. G. Rowe, M.D., 791 R. E. Sergent, 725
August 17, 1987
EM&TS - HS&EA Area Industrial Hygiene
Asbestos Exposure Monitoring
Attached are the results of the asbestos exposure monitoring performed on J. A. Ingram on July 8, 1987. He was monitored while pulling computer wire above ceiling tile and through pipe chases in Building 770. He was equipped with a Willson R12A Half-face HEPA Filter respirator. (Please note that he did not remove the ceiling tile. The tile was removed by the carpenters.)
The--------- exposure monitoring-----r,------------- ---------------------..-J results indicate--------------------------------------- ------------ that tvh.,e l'e--vels were we*ll* below the 0.1 fiber/cc Action Level, established by OSHA for an 8-hour work day (TWAg). However these emloyees are required to wear the respiratory equipment, as mentioned above, whenever doing this job until enough data is collected to indicate that an exposure problem does not exist.
Please notify J. A. Ingram of his exposure monitoring results as soon as possible. Please have him sign and date this report and return to M. A. Patel at Building 701-330. If we can be of further assistance, please feel free to call us on extension 4779 or 3750.
Work By:
Approved By:
VES:ab:rab 261 IP
Manhar A. Patel UCC 024315
ASBESTOS EXPOSURE MONITORING
CorTp. ref. W2256
Sample Type/
Sampling Air Cone TVIAq
Date Enployee Name
Time
Fibers/cc Fibers/cc
CCWENTS
7-8-87
Personal/ J. A. Ingram
7 hrs 34 min 0.023
0.022
Collected while pulling caiputer cable through pipe chases and above ceiling in Building 770.
ASBESTOS
Permissible Exposure Level TWfi 0.2 Fiber/cc fiction Level 0.1 Fiber/cc
OSHA
261 IP
UCC 024316
UNION CARBIDE CORPORATION technical center
.
P.O. BOX 0361, SOUTH CHARLESTON, WV 25303
TolWani. F. Divison 704 Location 511
Area
Terry
cooym ^ Liana - 740/2322
C. P. Maxwell - 701/2 R. G. Rowe, M.D. - 791 ~ C. L. Ruddle - 704 R. E. Sergent - 704
May 27, 1987
Originating Oapt
_ HS&EA
ATMB SlJt"ecr
Industrial Hygiene Asbestos Exposure Monitoring
Attached are the results of the Asbestos exposure monitoring performed on R. P. Hess and J. W. Greenlee. The monitoring was done on May 7, 1987 while they removed approximately 50 feet of insulation in the Building 705 Electrical room, which was enclosed with a negative pressure enclosure (HEPA filtered). Since it was inside of the electrical room, the removal was done dry. .
The insulators were equipped with full face supplied air, 2 pair of coveralls with headcover, boots and coveralls. They showered before reapplying street clothes.
The exposure results indicate that the levels were more than five times the 0.2 fiber/cc Permissible Exposure Level (PEL) established by OSHA. The area sample, collected just outside of the enclosure near the exhaust air stream and an exit, was higher than what we would expect. Extra care should be taken whenever entering or exiting the enclosure to prevent airborne fibers from escaping. An 8-hour Time Weighted Average (TWAg) was not calculated because it is not known if Asbestos Exposure occurred during the period of time before or after the monitoring.
Since the monitoring results were very high, we require the continuation of wearing Full Face Supplied Air, even if the Insulators are wearing monitoring pumps. We are also recommending the use of the HEPA Vacuum cleaner located at the source, whenever dry removal takes place, in order to capture fibers immediately upon becoming airborne.
UCC 024317
ASBESTOS MONITORING - continued
-2-
May 27, 1987
Please notify R. P. Hess, J. W. Greenlee and F. R. Creech of these monitoring results as soon as possible. (F. R. Creech was involved with the removal but was not monitored.) Please have them sign and date this report and return to M. A. Patel at Building 701-330. If we can be of further assistance, please feel free to call us on extension 4779 or 3750.
WORK BY:
APPROVED BY:
Vance E. Stover
Attachment
VES:MAP:rab 2348P
UCC 024318
ASBESTOS EXPOSURE MONITORING
Computer ref. W22G8
Date 5-7-87
Sample Type/ Enployee Name
Sarrpling Time
Air Cone fibers/cc
TM8 fibers/cc
COMMENTS
Personal/
5hrs 29min
1.139
-
Collected while dry removing approx.
R. P. Hess
50 feet of Asbestos from steam
lines in electrical roam.
5-7-87
Personal/
5hrs 24min
j. W. Greenlee
5-7-87
Area
5hrs 25min
1.136 0.0226
-
"
Collected while assisting R. P. Hess i.e., bagging, cleaning up, etc.
Collected just outside of the enclosure near the exhaust air stream (HEPA filtered). An exit door was also established near the fan.
ASBESTOS
Permissible Exposure Level
TUAg
0.2 fibers/cc OSHA
Action Level 0.1 fibers/cc
2348P
UCC 024319
INDUSTRIAL HYGIENE MONITORING FOR
ASBESTOS
TO: w. T. Shelton 704 Shop
Computer Ref.W-1088
CC: a. F. Hurley, 701-334 H. L. Robinson, 701-401
PERSON MONITORED
.___________________Services Insulators___________
Location Bldg. 705 - Cell 8 Date ________________9/9/80
EXPOSURE RESULTS
Sample 1 2 3 4 5 6
Cone. fibers
1.17 fibers
1.30
Sampling Time
24 minutes
@ 2 LPM 24 minutes @ 2 LPM
Comments D. M. Lawrence R. Raines
Time-Weighted Average Concentration (TWA) Ceiling Concentration
Not enough data Not exceeded
ALLOWABLE EXPOSURE
TWA
2 fibers/cc > 5 (im
Ceiling 10"__________"
UCC UCC
Other Other
COMMENTS
Stripping approximately 50 feet of old insulation in Cell 8 of Building 705. Employees were protected by respirators and coveralls, proper disposal of asbestos was followed.
Qualitative test approved by NIOSH showed no asbestos in stripped material. Fibers counted were, thus, not asbestos.
WORK BY _____ APPROVED BY
UCC 024320
INTERNAL - CORRESPONDENCE
UNION CARBIDE CORPORATION te,cmn,cai. :
p o ' . >' li.
A. F. Terry
p. D. Gossage C. P. Maxwell R. G. Rowe, M.O. C. L. Ruddle R. E. Sergent
^ U-. ...
^
October 7, 1986 KS&EA Industrial Hygiene Asbestos Exposure Monitoring
Attached are the results of the Asbestos' exposure monitoring performed on F. R. Creech and R. E. Raines on September 13, 1986 while stripping Asbestos from miscellaneous valves and lines, during a main steam header shutdown. Most of the work was done inside of Building 707 and 706.
They were equipped with two pair of disposable Tyvek coveralls, boots, gloves and a Willson half-face respirator containing R-12 HEPA filter cartridges. They removed their outer coverall and discarded before exiting each barricaded area and proceeding to the next. Upon completion of the job F. R. Creech and R. E. Raines showered, before reapplying their street clothes.
F. R. Creech had not worked with Asbestos containing materials before or after the monitoring period. However, R. E. Raines did work with insulation (Asbestos) after his monitoring pump shut down, due to low flow. Therefore a Time Weighted Average cannot be reported for Mr. Raines.
F. R. Creech's exposure monitoring results indicate that the levels were below the Permissible Exposure Level (PEL) of 0.2 fiber/cc, established by OSHA for an 8-hour workday (TWAg). However, the levels were above the action level of 0.1 fiber/cc also established by OSHA. R. F. Raines' breathing zone air concentration was 0.221 fiber/cc, which indicates that his average exposure would be in excess of 0.1 fiber/cc (action level), even after assuming no exposure to Asbestos during balance of the day.
We are recommending more water (when possible) and more care in stripping and cleaning up the Asbestos.
UCC 024321
Asbestos Monitoring - continued
-2-
October 7, 1986
Please notify F. R. Creech and R. E. Raines of their exposure monitoring results as soon as possible. Please have them sign and date this report and return to M. A. Patel at Building 701-330.
If we can be of further assistance or if you have any questions, please contact us on extension 4779 or 3750.
WORK BY:
APPROVED BY:
Vance E. Stover
Attachment
VES:MAP:rab 1779P
Manhar A. Patel
UCC 024322
ASBESTOS EXPOSURE MONITORING
Carp. ref. W2035
Date 9-13-86
9-13-86
Sanple Type/ Enployee Name
Personal/ F. R. Creech
Personal/ R. E. Raines
Sanpling Time
5 hrs 53 min.
4 hrs 32 min.
Air Cone, fibers/cc 0.164
0.221
TWq fibers/cc 0.103
-
COMMENTS
Collected while stripping and cleaning up Asbestos from miscellaneous valves, lines, etc. during steam header shutdown.
Collected while stripping and cleaning up Asbestos from miscellaneous valves, lines, etc. A Time Weighted Average (TWAg) was not reported because his sanpling puip shut down because of low flow (pinched sanple train). Therefore, he had Asbestos exposure that did not show on the sanple.
ASBESTOS
Permi ssi bl e Exposure Level TWQft O.F~fibers/cc
OSHA
1779P
UCC 024323
INDUSTRIAL HYGIENE MONITORING FOR
ASBESTOS
TO: W. T. Shelton,
Computer Ref. W-1077
1
CC: G. F. Hurley H. L. Robinson
PERSON MONITORED __________________________R. E. Raines______________________
Location Bldg. 706 - West End, Date Second and Third Level
EXPOSURE RESULTS
8/19/80
Sample 1 2 3 4 5 6
Cone.
libers > 0.1 5 (iEi/cra^
Sampling Time
93 minutes
Comments
Stripping and insulation on autoclave and lines.
bagging G-101 adjacent
Time-Weighted Average Concentration (TWA) Not enough time to calculate
Ceiling Concentration
TWA
ALLOWABLE EXPOSURE
TWA 2 fibers > 5 pm/cm^ Ceiling ________________________
OSHA
UCC UCC
Other Other
COMMENTS
UCC 024324
V "industrial hygiene monitoring for
asbestos
TO: W. T. Shelton, 704
Computer Ref. w-1077
CC:
G. F. Hurley H. L. Robinson
PERSON MONITORED __________________J. W. Greenlee____________________________
Location Bldg, 706 - West End, Second and Third Level
EXPOSURE RESULTS
Date
8/19/80
Sample 1 2 3 4 5 6
Cone.
fibers > 0*3 5 Ltm/cm^
Sampling 95 minutes
Comments
Stripping and bagging insulation on G-101 auto clave and adjacent lines.
Time-Weighted Average Concentration (TWA) Not Calculated Ceiling Concentration ______________________
ALLOWABLE EXPOSURE
TWA
2 fibers > 5 gm/cm3 (ToSH'SaT'J"*.
Ceiling _________
OSHA
UCC UCC
Other Other
COMMENTS
UCC 024325
ro: R. F. Painter, Trlr. 5583
Computer Ref. W-1315 Date April 26, 1982
=c: B. H. Avashia, M.D., 23-512 G. W. Bott, 701-330 M. L. Mills, 2149-512
L. R. Noble, 2149-512 R. E. Peele, 701-334 E. C. Shipley, 2009-512
PERSON MONITORED __________________________D. C. Shamblin________________________
Locaxion Bldg. 706
Date
04/21/82
EXPOSURE RESULTS
Sample No.
Cone.
fibers > 5 1 1-2 u.m/cc
fibers > b 2 1.0 tim/cc
Sampling Time
92 Mins. 93 Mins.
3
4
5
6
Comments Personal sample Area sample
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 fibers >5 pm/cc
Ceiling
x OSHA ____OSHA
UCC UCC
Other Other
COMMENTS
Personal and area samples were collected while Mr. Shamblin and Mr. Templeton were stripping insulation from a steam line and condensate line in the old compressor room, Building 706. We recommend the insulators continue to wear protective clothing, respirators, gloves and the area to be stripped wet down. Please inform IH Department of the next stripping
job in this area and inform concerned employees of their exposure.
ORK BY ~ y Mark E. Bell
APPROVED BY
UCC 024326
2\ . (fLui
Manhar A. Patel
[union BUSINESS [CAAMIDC CONFIDENTIAL INDUSTRIAL HYGIENE MONITORING FOR
TO: r. F. Painter, Trlr. 5583
ASBESTOS
FILE COPY
Computer Ref. W-1315 Date April 26, 1982
CC: B. H. Avasbia, M.D., 23-512 - G. W. Bott, 701-330
M. L. Mills, 2149-512
L. R. Noble, 2149-512 R. E. Peele, 701-334 E. C. Shipley, 2009-512
PERSON MONITORED _____________________R. E. Templeton_____________________________
Location
Bldg. 706
Date
04/21/82
EXPOSURE RESULTS
Sample No.
Cone..
1 0.9 fibers >5 pm/c<
2
3
4
5
6
Sampling Time
92 Mins.
Comments Personal sample
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 fibers >5 um/cc
Ceiling
_________________.
X OSHA .____OSHA
_____UCC UCC
Other Other
:OMMENTS
Personal and area samples were collected while Mr. Shamblin and Mr. Templeton were stripping insulation from a steam line and condensate line in the old compressor room, Building 706. We recommend the insulators continue1to wear protective clothing, respirators, gloves and the area to be stripped wet down. Please inform IH Department of the next stripping job in this area, and inform concerned employees of their exposure.
0RK BY
Mark E. Bell
________
APPROVED BY
UCC 024327
X.
Manhar A. Patel
BUSINESS CONFIDENTIAL
FILE OPY*
INDUSTRIAL HYGIENE MONITORING FOR _________ASBESTOS
TO: W. T. Shelton, 704 Shop
Computer Ref. W-1287 Date March 9. 1982
cc: r. E. Peele, 701-334 R. G. Rowe, M.D., 791
PERSON MONITORED __________________________________J. W. Greenlee_______________________
Location
Bldg. 706, 2nd Level
Date
03/01/82
EXPOSURE RESULTS
Sample No.
Cone.
1 0.53 fibers/ cc
2
3
4
5 6
Sampling Time
15 Mins.
Comments
Personal sample - collected on
filter cassette
~
Time-Weighted Average Concentration (TWA) _______________________ Ceiling Concentration 0.53 fibers/cc
ALLOWABLE EXPOSURE
TWA Ceiling
2 fibers/cc
X OSHA _____OSHA
____UCC UCC
Other Other
COMMENTS
Mr. Greenlee was monitored while stripping old insulation from approximately nine feet of steam line in Building 706. In addition to wetting the insulation material, Mr. Greenlee wore coveralls, gloves, and a disposable respirator. Please notify employee of exposure results.
YORK BY
Mario F. Stowers
APPROVED BY
AW Manhar A. Patel
UCC 024328
f|CJU|RNI*OJNDj|
BUSINESS CONFIDENTIAL
INDUSTRIAL HYGIENE MONITORING FOR
T0: W. T. Shelton, 704 Shop
Us* 5 3 >*'
.1 r
COP'
ASBESTOS
Computer Ref. w-1553 Date___April 7. 1QS4
c. L. Ruddle, 704 -2 R. E. Peele, 701- 334 R. G. Rowe, M -D. , 791
PERSON MONITORED Location
j. w. Greenlee Bldg. 706, Cell 13 Date
03/20/84
EXPOSURE RESULTS
Sample No.
Cone.
Sampling Time
1 1.5 fibers/cc 2 Hours 2
3
4
5
6
Comments
Sample collected on filter cassette
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE (8-Hour)
TWA
0.5 fibers/cc
Ceiling i
X OSHA OSHA
_____UCC UCC
_____Other Other
COMMENTS See Attachment.
WORK BY
/U
(v-1 APPROVED BY
UCC 024329
p\A
/V
l
ATTACHMENT TO W-1553
J. W. Greenlee was monitored for exposure to asbestos fibers while stripping approximately 30 feet of old insulation from a Dowtherm line both on the inside and outside of Building 706, Cell 13. Analysis cf the material indicated that asbestos was present. Dur ing the stripping operation and subsequent cleanup, Mr. Greenlee wore a disposable respirator, coveralls, and gloves for protection. The area was barricaded and a water spray was used to keep dust to a minimum.
Microscopic evaluation of the sample indicated an exposure level of three times the allowable exposure level. This sub stantiates the need for continued usage of preventive measures and protective equipment to avoid the inhalation of asbestos fibers. Although the job was completed within a two-hour period, if a simi lar job under the same conditions were to run for eight hours, the exposure level could be expected to be as much as three times greater.
Please notify employee of the exposure results.
UCC 024330
TO:
BUSINESS CONFIDENTIAL INDUSTRIAL HYGIENE MONITORING FOR
W. T. Shelton, 704 Shop
HIE COPY
ASBESTOS
Computer Ref. W1612
Date August 21. 1984
cc:
R. E. Peele, 701-334 C. L. Ruddle, 704-2 R. G > Rowe, M .D., 791
PERSON MONITORED _______________J, L. Greenlee
Location
Bldg. 706, Cell 13
_____________
Date _________08-01-84
EXPOSURE RESULTS
Sample No. 1
Cone .
Sampling Time
0.52 firs 2 hrs. 10 min.
2
0.08
2 hrs. 10 min.
0.01 fprs
3 2 hrs. 5 min.
4
5
6
Comments
Personal Sample:
Collected on filter cassette.
Area Sample: Area Sample:
Collected on filter cassette in middle of cell 13 2nd leve
Collected on filter cassette
in middle of cell 13 1st leve
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 fibers/cc
Ceiling __________-______
COMMENTS
See attachment to W1612.
x_OSHA OSHA
_____UCC ____UCC
_____Other Other
WORK BY
^
Mario F. Stowers
APPROVED BY
UCC 024331
P
Manhar A. Patel
\) -.if
ATTACHMENT TO W1612
COMMENTS :
J. L. Greenlee was monitored while stripping approximately 60 ft. of asbestos containing insulation from a Dowtherm line on the second level of Cell 13 in Bldg. 706. Area samples were collected on both levels of the cell as the stripped insulation fell through the second level grating to the floor of the first level. Most of the insulation had to be cleaned up from the floor of the first level. A barricade was placed in front of the door to the cell area and a water spray was used to limit dust dispersion. Mr. Greenlee wore coveralls, gloves, and a disposable respirator while stripping and cleaning up.
Microscopic evaluation of the samples indicated area levels well below the allowable limit. Personal exposure, however, was found to be equal to the 8 hr. limit of o.s. fibers/cc. This indicates a definite need for continued usage of respiratory protection during stripping operations. Although the job required only approximately two hours to complete, a similar job of longer duration would probably have resulted in a significantly higher exposure level.
Please notify employee of exposure resutls.
Mario F. Stowers
UCC 024332
ASBESTOS - EVALUATION AND SURVEY
Date /Sf /97S" Projecr
Department ^^/C'V/C^S Location
^ 0 & 3Bldg. No.
Requested by
C. Reason
^<
General Conditions;
lig^r ^/*TVsSf % DstSfisX/ </, ks*___/Z** ------ ---------------
/^u &
ve~; J?z/.____o
____0 /cf
/C>K 7~*T> 0 cs
&/*/.
-/SfJtiL____2-g.oX_____ho____/^,
&</ 0f3ssT*S >*>?/: S&eLjCs#* __________________________________
Sampling Method and Equipment | ^-J3? 5 X*
*~ /^ /CL-_____ ________________
Sample Number
if /
Sampling Time -Min.
Plow Rate
CONCENTRATION
Fibers/ml >5 p
JSL -2 X/h . -Jhf r'./V
Sampled by
Conditions
</.7S
o,>H
, 03/f/~ V</X /Mo
i---
Calculation: (Avg. Fiber Count - Ayg. Blank Count) Total Filter Area * Concentration, fibers per
(Counting Area) (Vol. Air-Liters) (1000)
mill i liters >5p
Rema rks-; S/fG^S /s*/?, Sjt'PS'
Sketch - See reverse side. Reference No, /?/f Analyzed by^__________ Date
/ /f?S
UCC 024333
,'
flow
A8Bf:3TOa COUWT RECiOnD SHEET
________ tl* Fi?3AT IOM
,,- .
........ - ...----------------------------
- - TUVtE --_ VOLUME
........- - OATE^2
/?JT~
INITIALS
______ F.AHEA
-.....-- BLK.CNT.AV._________
AV. COUNT___________ _____ CONCENTRATION
- -- ............. .......... - --.
COMMENTS
. ____ -- .
--
.
--
..................--....
UCC 024334
ASBESTOS - EVALUATION AND SURVEY
Date
Project
/~c4<j
ZPsfyss
Deportment ^yev/g,<&JT Locotion 74< -706 -/_______ ____ Bldg. No.
cRequested by jtuJ
/^ss's^/e __Reason_
General Conditions:
btu
/b/*sts--Tl/P.
#..........................
- "
,,,
ave /sfrf / /^ "/
C.
Sampling Method and Equipment_
-2-9x- z&A^.
(Sample Number
1^2-
Sampling Time -Min.
32
Flow Rate
CONCENTRATION Fibers/ml>5 p
Sampled by Special Conditions
% / JM*y ^gT"
,^/fX 7 6 X/^e
/'fA'-b
*'
Calculation: (Avg. Fiber Count - Avg. Blank Count) Total Filter Area - Concentration, fibers per
(Counting Area) (Vol. Air-Liters) (1000)
milliliters >5ju
RemarksL:i <S/t(/eS
S9, /*?'?>
Sketch " See reverse side. Reference No. fcft. Analyzed by
_______ Date fc-
UCC 024335
A8K^'3TQ8 COUNT RECORD SHEET
2SAMPLE^, ^ -
2L* PESATIOIM ____ --------------- ")a?v/s
FLOW---------
TliV.:
VOLUME
oat[^2 //f/ps~
INITIALS
F. AREA
LK.CNT.AV.
AV. COUNT.
CONCENTRATION -------------
COMMENTS
UCC 024336
ASBESTOS - EVALUATION AND SURVEY
Date *4jL /S; /97S Project_
DepartmentLocation 12//o 7C> & -/
StsSs*r&/<~
_____Bldg. No.
Requested by /Cujc.
Reason
General Conditions:
tytu p. an "jz/lZ
/-fe. '/
jrA/4
.
c.
Sampling Method and Equipment^
P?>_
{Sample plumber
7L,
Sampling Time -Min.
JS
Flow Rate
JtlA.
CONCENTRATION Fibers/m!>5 ju
Sampled by Special Conditions ^ 2- ^
,^fX 76 X/^
.
Calculation: (Avg. Fiber Count - Avg. Blank Count)Total Filter Area Concentration, fibers per
(Counting Area) (Vol, Air-Liters) (1000)
milliliters >5yu
Remarks: S/lc/trS
/9/ /<?
Sketch - See reverse side. Reference No. A/e Analyzed by
Date A*/3/ /9>
'-St UCC 024337
ASBESTOS - EVALUATION AND SURVEY
Date // /j;
"Project
Department
Location
Bldg. No.
Requested by
C. Reason
/7*S& ^5*^+**'**
General Conditions:______^ !>*S?s^S /vf /Z* *
-----------
yff-4/ 4> &//? y e. ^ __ ^'S. 4* 7Z'fyf&____^
____,/o
^ ^W/. 7F/C/C. 0</ ^/rfA/
/<*' c/e>>~T______________________________'__________:________
Sampling Method and Equipment JTC. -jl?X<S-//<=_:
[Sample Number
Sampling Time -Min .
JJ- -?-2_
\\
Flow Rate
A/k
CONCENTRATION Fibers/ml>5 jj
(g~
O./g
\j
Sampled by Special Conditions
Or3-3
e>. *-
,
!
i.
i *-</
Af
T jp 90
, 03/fX </</X /00o
; -------------------------- i__________
Calculation: (Avg. Fiber Count ~ Ayg, Blank Count) Total Filter Area Concentration, fibers per
(Counting Area) (Vol. Air-Liters) (1000)
milliliters >5/j
Remarks-:
t /?, X'X'PS'
Sketch - See reverse side. Reference No.fi/e Analyzed by
Date,Jl J /f7<l
UCC 024338
^ /, *
..
.
:
AB::r;3Taa saurv? reciord sheet
SAMPLE -~#LL----------. L? FETATION ,
-------------------------------------------------------------------
FLOW ...................-.... TtiV.E VOLUME , OATS^^/jyJr^--
INITIALS _. ._ , ,,,_ F.AREA
----------- EJLK.CIMT.AV,_______________________________
Av. COUNT_________________ COlMCEiMTRATIOIM ,, .................................................,,.......;
COMMENTS
____
.. ---------------
..
UCC 024339
ASBESTOS - EVALUATION AND SURVEY
Date
Project
Department ^SjC^'/C^S Location
Requested by
C. Reason
*-
& & ~ -?Bldg, No.
S vsc
General Conditions;72^*, Atry^f
_ .Y C. y
D*/?s^S S, kSC /*e + -----------------------------
J /cf
^
-Z
fife An.
*Doo/c
-b>____ __________________________________________________
Sampling Method and Equlpment_
?xV- /g /q-
Sample Number
4/
Sampling Time -Min.
JJL
Flow Rate
3U/H
CONCENTRATION
Fibers/ml>5 ju
'-- ^
Sampled by Special Conditions
y? 7-*"
<?.Yf
, 03/f/. V<// /00o
-
Calculation: (Avg. Fiber Count -Avg. Blank Count)Total Filter Area *> Concentration, fibers per
(Counting Area) (Vol. Air-Liters) (1000)
milliliters >5p
& UCC 024340
INTERNAL - CORRESPONDENCE
UNION CARBIDE CORPORATION TECHNICAL CENTER -, j
]
P.D. BOX 836 j SOUTH CHA'flLESTpriJ. WV 25303
--^ yt Shelton C . H.Of I D: ' c5 CX" 1 1
' T. L. Collins C. P. Maxwell G. C. Merz R. G. Rowe, M.D. R. R. Sergent
Date November 22, 1985 Or-i{Uincu..-'q Q-- HSSiEA Area Industrial Hygiene
Asbestos Monitoring
Attached are the results of personal exposure monitoring conducted on November 11 and November 12, 1985 while R. P. Hess and R. E. Raines stripped asbestos from lines and equipment in Building 707-Cell 4.
The stripping, bagging and cleanup was done by the two insulators. Water was used to wet down the insulation. The cell area was barricaded and signs were posted designating the potential asbestos hazard. Both Mr. Hess and Mr. Raines wore disposable respirators, disposable coveralls with head cover, rubber boots and gloves. Protective equipment was removed when leaving the hazard area.
The samples collected on Mr. Hess and Mr. Raines on November 11, 1985 were both above the action level of 1 fiber/cm3, but below the allowable exposure level of 2 fibers/cm3. The samples collected on November 12, 1985 were below the action level.
It is apparent from the first day that more of a water spray is needed to saturate the asbestos and control the airborne dusts before, and during the stripping and bagging process.
Please notify Mr. Hess and Mr. Raines of their exposure results. we can be of further assistance, please contact us on extension 4779 or extension 3750.
If
0766P
Work By:
___
Vance Stover
Approved By:
^
Manhar A. Patel
UCC 024341
cn >, c i--* r* OJ
Q.+J
CL id
i-- S-
'iE--E
-M X
cn Q 00
1/1 i- O
4-> a> CL 4->
C r-- Cl oo
<c=u
-l-- <d a; .O
E Cn oo
o E= rd
o -CJ r--
OJ cn 4--
S- Cn o
CD id
_o =tt=
*r"-
CtJO O co E <d
cn >i c: rr-- OJ CL+- Cl rd i-- E
i--
-P X 00 O oo
S- o a> CL 4-1 r-- CL oo T~~ rd 03 -C JC
Cn vo c rd O OJ cn<4i- cn o o Id -P =**= T~ c T3 O o CO s: rd
Co
if--
CO
i-
nUr OJ loo ccmo
CO U-
cfm-o*. ccori oo
PERSONAL EXPOSURE MONITORING FOR ASBESTOS
AT BUILDING 707 - CELL 4 Computer re fe re n c e # W 1854
o
cCo_>
CO
a>
jD
X- *-
< --Li_
CM
OJ
'^r
IT)
oco
cm
d"
oo
>cc:n- tao? a0 3 EEC co O tIo'd *hr" *Ef" i<--d"- *3-
C-*. CO
CM O^3-
*Or~
-adP
cn CU
_oi
rc
cu O-
Ed *
DC
cn OcJ: id oc
* LU
DC
ccnn 30Z3
a. . or
on *rOc--:) id
*
LU *
a;
cn 001
ccnoi
-0rPd3
f-- 1
i-- r--f
Q 1--
cn m coi co CM CM
r---
i--1 F--i i-- r*-"
UCC 024342
` I Ij WiOM j * w w * < *- -f --
I CONFIDENT!AL
INDUSTRIAL HYGIENE MONITORING FOR TO: W. T. Shelton, 704-Shop
Asbestos Computer Ref. W1778 Date May 3, 1985
cc: T. L. Collins, 740-2318 C. P. Maxwel1, 725
R. G. Rowe, M.D., 791 C. L. Ruddle, 704-202
PERSONS MONITOREDR. E. Raines, D. M. Lawrentz _________________________
Location Bldg. 707 - 2nd Floor Operating Area
Date 4-26-85
EXPOSURE RESULTS
Sample No.
Cone.
Sampling Time
1 0.38 fibers/cc 35 min.
2 0.27 fibers/cc 35 min.
Comments
Personal sample: R. . Raines Collected on filter cassette.
Personal sample: D. M. Lawrentz Collected on filter cassette.
Time-Weighted Average Concentration (TWA)
Ceiling Concentration
ALLOWABLE EXPOSURE (8 Hr.)
TWA 2 fibers/cc
Ceiling
--
X 0SHA UCC Other 0SHA UCC Other
COMMENTS
R. E. Raines and D. M. Lawrentz were monitored while working together to strip approximately 8 ft. of old insulation from a heliflo system in Bldg. 707. Both men wore disposable respirators, coveralls, gloves and boots while stripping and cleaning up. The stripped insulation was placed in plastic bags for disposal. A barricade was set up around the work area and signs were posted. A water spray was used to wet down the insulation.
Examination of the samples indicated levels of asbestos fibers well
below the allowable exposure limit. Please notify employees of their exposure
results.
'
WORK BY
>,? Stowers
APPROVED BY
Manhar A. Patel
UCC 024343
INDUSTRIAL HYGIENE MONITORING FDR: ASBESTOS
!,*!<* I business l**">* I CONFIDENTIAL
C o I'm p u t e r R e f : W --15 0 8 Date: Dec. 20, 1.983
To:
W. T. Shelton, 704 Shop
CC:
R. E. Peele, 701-334
R. G. Rowe, M. It , 791
C. L. Ruddle, 704-2
PERSON MONITORED:
R. P. Hess
LOCATION: EXPOSURE RESULTS
Bldg. 707 Cell 11, First Level
Date:
11/10/83
Sample No.
Cone.
Sampling Time
Comments
1
0.07 fib ers/cc
30 Minutes
Personal sample - collected on filtercassette.
Time-Weighted Average Concentration (TWA>: Ceiling Concentration:
-
ALLOWABLE EXPOSURE
TWA: Ceiling:
COMMENTS
.5 fibers/cc
_X__OSHA ______OSHA
______UCC ______UCC
Other Illlother
See next page.
WORK BY:
dV Mario F. Stowers
by;m^(L. A. 'Qj
APPROVED Manhar A. Patel
UCC 024344
INDUSTRIAL HYGIENE MONITORING FOR: ASBESTOS
BUSINESS CONFIDENTIAL
Computer Ref: UJ- 1508 Date: Dec. 20, 1983
To:
W. T. Shelton, 704 Shop
CC :
R. E. F'eele, 701-334
R. G. Rowe, M.D., 791
C. L. Ruddle, 704-2
PERSON MONITORED:
R. E. Raines
LOCATION:
Bldg. 707 Cell 11, First Level
Date:
11/10/83
EXPOSURE RESULTS
Sample No.
Cone.
Sampling Time
Comments
X 0.18 fibers/cc 30 Minutes
Personal sample collected on filter cassette.
Time-Weighted Average Concentration (TWA): Ceiling Concentration:
A L L 0 U A B L E E X P 0 S U RE
TWA: Ceiling:
COMMENTS
.5 fibers/cc
_X___OSHA ______OSHA
______UCC ______UCC
____Other ______Other
Insulators monitored while working together to strip approximately 35 feet of old insulation from a water line just outside of Cell 11 on first level of Building 707. While stripping the insulation, both workers wore disposable suits and respirators. A water spray was used to keep the dust down, the area was barricaded, and plastic was spread on the ground to catch falling debris. Exposure levels were found to be well below the allowable exposure limit. Please notify employees of exposure results.
WORK BY:
Mario F. Stowers
APPROVED v.^ P'IcwAa- A . r?Jv!
Manhar A. Patel
UCC 024345
'
INDUSTRIAL HYGIENE MONITORING FOR
TO: w. t. Shelton, 704 Shop
I FILE COPY
ASBESTOS
Computer Ref. W-1373 Date Sept. 2, 1982
cc: R,, E. Peele, 701-334 R. G. Rowe, M.D., 791
PERSON MONITORED _____________:______________J. W. Greenlee________________________
Location
Bldg. 707, Room 101
Date
07/23/82
EXPOSURE RESULTS
Sample No. 1 2 3 4
Cone.
Sampling Time
2 Hrs. 12 Mins 2 fibers/cc (0904-1114)
fibers/ 2 Hrs. 12 Mins
0.56 1.6
cc ro904-ni4'i fibers/ 2 Hrs. 21 Mins
cc ^0250-1511)
fibers/ 2 Hrs. 21 Mins
0.71 cc
(1250-1511)
Comments Personal sample
Area sample - middle of Room 101
Personal sample Area sample - middle of Room 101
5
6
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE (8 HrS . )
TWA
2 fibers/cc
Ceiling
X OSHA 0SHA
UCC UCC
Other Other
COMMENTS
J. W. Greenlee was monitored while stripping old insulation from approximately two hundred feet of steam line in Building 707, Room 101. Mr. Greenlee wore gloves, coveralls and a respirator throughout the duration of the work period. A water spray cannister was used to wet the insulation, however, the exterior of the insulation was so hard that the water did not soak through well. Both entrance ways to Room 101 were barricaded and marked with signs indicating a potential asbestos hazard. Please notify employee of results.
WORK BY ________: ! Av, ^ . -/ K y,--._________ Mario F. Stowers
APPROVED BY `
Manhar A. Patel
UCC 024346
CONFIDENTIAL INDUSTRIAL HYGIENE MONITORING FOR
TO: W. T. Shelton, 704 Shop
copyASBESTOS
file
Computer Ref. W-1212 Date August 6, 1981
cc: R. E. Peele, 701-334 H. L. Robinson, 701-401
PERSONSMONITORED ____________J. W. Greenlee and D. E. Lawrentz_______________ Location Bldg. 707 Cell 11, 2nd Level Date 08/05/81
EXPOSURE RESULTS
Sample No.
Cone.
Fibers 1 0.074 cc
Fibers 2 0.04 o cc
3
Sampling Time
16 Mins. 15 Mins.
Comments Personal sample - J. W. Greenlee Personal sample - D. E. Lawrentz
4
5
6
J.W. Greenlee: <0.074 Fibers
Time-Weighted Average Concentration (TWA) p.E. Lawrentz: <0.045
cc
Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 Fibers/cc
Ceiling _____________________
__X_OSHA OSHA
JJCC UCC
_____Other Other
COMMENTS Insulators -were monitored while stripping old insulation from about
20 feet of steam line on the second level of Cell 11 in Building 707. Both insulators wore gloves and respirators. Water spray was used to wet the insulation in order to keep the dust down. The fiber concentra tions in the samples taken on both men were found to be considerably less than the allowable exposure of 2 fibers/cc.
WORK BY
Mario F. Stowers
APPROVED BY
UCC 024347
Manhar A. Patel
INDUSTRIAL HYGIENE MONITORING FOR TO: Yf. T. Shelton, 704 Shop
ASBESTOS -FILE COP _____ Computer Ref. W1121
CC: G. F. Hurley H. L. Robinson
PERSON MONITORED ______________John Hackney, Ralph Hess_______________
Location
Bldg. 707, Cell 3
Date
10/29/80
EXPOSURE RESULTS
Sample 1 2 3 4 5 6
Cone. 3.1 fibers/ zc
Sampling Time
56 minutes
Comments Sample taken on John Hackney
11.9
"
56 minutes Sample taken on Ralph Hess
14.9
"
30 minutes Sample taken on John Hackney
Too dense to count.
30 minutes Sample taken on Ralph Hess
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA Ceiling
OSHA 0SHA
UCC UCC
Other Other
COMMENTS Samples taken during stripping of Dowtherm lines in Cell 3 of
Building 707. The lines were wetted down with water, however the
insulation material was very hard on the outside and the water did not soak through very well. Respirators and gloves were used by the persons monitored. Analysis of the insulation material being stripped showed that it was not asbestos.
WORK BY APPROVED BY
UCC 024348
INDUSTRIAL HYGIENE MONITORING FOR
ASBESTOS
TO: W. T. Shelton, 704
Computer Ref. 1070
CC:
G. F. Hurley H. L. Robinson R. G. Rowe, M.D.
PERSON MONITORED __________________Greenlee, J. W.__________________________
Location Bldg. 707, Fourth Level, Date
8/5/80
--ft------------r ceil n-------------------
----------------------------
EXPOSURE RESULTS
.
Sample 1 2 3 4 5 6
Cone.
fibers > . 92 5 (ini/cm^
Sampling Time
78 mins.
Comments
Stripping and bagging suspected asbestos containing insulation from approximately 50 feet of I/2-Z" steam line.
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 fibers >5 gm/cnr
Ceiling _____
____
UCC UCC
COMMENTS
Other Other
UCC 024349
INDUSTRIAL HYGIENE MONITORING FOR
ASBESTOS
TO: W. T. Shelton,
Computer Ref. 1070
CC:
G. F. Hurley H. L. Robinson
R. G. Rowe, M,
PERSON MONITORED
Raines, R. E,
Location Bldg. 707, Fourth Level, Cell 11
EXPOSURE RESULTS
Date
8/5/80
Sample 1 2 3 4 5 6
Cone. fibers
1.85 >5 um/c
Sampling Time
79 mins.
Comments
Stripping and bagging suspected asbestos contain ing insulation from approximately 50 feet of 1/2 - 2 inch steam line.
Time-Weighted Average Concentration (TWA) Ceiling Concentration
ALLOWABLE EXPOSURE
TWA
2 fibers >5 um/cm3<^'oSHA^
Ceiling ________________________
OSHA
UCC UCC
Other Other
COMMENTS
Even though the exposure concentration is near the allowable exposure, Mr. Raines wore a disposable 3M dust respirator which would give him further protection.
UCC 024350
'iEMICALS AND PLASTICS
{Name) 5iOA ation
>y 10
Mr. D. H. Cook Trlr. 5583 (511)
Mr. G. F. Hurley Mr. R. F. Painter Mr. H. L. Robinson Mr. E. C. Shipley
P. O. BOX 8361, SOUTH CHARLESTON, WEST VIRGINIA 25303
Date May 25, 1979
Originating Dept. Technical Center IH/EP
Subject
Asbestos - Stripping Old Insulation
PROJECT Survey for asbestos exposure of insulators stripping insula
tion from still column in Building 707.
DATE OF SURVEY
May 15, 1979
SUMMARY Exposures were higher than expected for this demolition job,
2.2 and 0.9 fibers/cc TWA for Finney and Miller respectively. The fact that they were wearing respirators allowed the normal standard without protection of 2 fibers/cc TWA to be extended ten times when employees are protected during demolition or removal of material containing asbestos. This exception only pertains to work situations where it is not feasible to control dust with engineering controls.
DISCUSSION
Construction insulators were asked to remove insulation from BS-62 in Cell-11 of Building 707. This still column extends through three levels of the cell and is approximately eight inches in diameter. The insulation was wet down with water as much as possible and every precaution to reduce asbestos exposure to employees was followed. These precautions include; approved dis posable dust respirators, coveralls, gloves and bagging and labeling of stripped insulation for landfill.
UCC 024351
D. H. Cook
2
5/25/79
The Technical Center Industrial Hygiene group sampled the insulators in the morning of the fifteenth and for a portion of the stripping job in the afternoon. From the data collected, we were able to determine the time-weighted average of asbestos exposure for Mr. Charles Miller and Mr. M. Finney. (See following results.)
RECOMMENDATION
The best control for asbestos exposure is wetting the material down before demolition starts and to follow the outline prescribed in the Construction Department Safety Procedure Manual, Section VIII, Procedure 22. We would like to emphasize the importance of this procedure and especially the instructions found in paragraph three.
RESULTS
Date 5/15/79 5/15/79 5/15/79 5/15/79
Personnel M. Finney M. Finney C. Miller C. Miller
Time 0950-1115 1300-1400 0950-1115 1300-1400
Liters of Air
170 120 170 120
Exposure, Fibers/cc >5 [im
4.6] <-------------
6. l|
TWA 2.2
2.0]
< 2.lJ
------->> 0.9
REFERENCES
Volume( 38C-29X4-Rla,
Asbestos, Dust Determination By Membrane
Filter Technique Using Phase Contrast Microscopy
REPORT PREPARED BY
G. W. Bott Technical Center Industrial Hygiene Department
APPROVED BY GZ F . Hurley
UCC 024352
INTERNAL CORRESPONDENCE
HEMICALS AND PLASTICS
*
(Name) vision cation
,py to
Mr. W. T. Shelton 704 Shop
Mr. G. F. Hurley Mr. G. C. Merz Mr. M. E. Perry Mr. H. L. Robinson
P. O. BOX 8361 r SOUTH CHARLESTON, WEST VIRGINIA 25303
Dale May 25, 1979
Originating Dept. Technical Center IH/EP
Subject
Asbestos - Stripping Old Insulation
PROJECT
Survey for asbestos exposure of insulators stripping insula tion from approximately ten feet of 1" steam condensate line in Building 707, service room.
DATE OF SURVEY
May 9, 1979
SUMMARY
Good -work practices and proper housekeeping by insulators kept the exposure to asbestos fibers at a minimum. The insulation -was wet down with water and the dismantled material was bagged and labelled for landfill.
DISCUSSION
Approximately ten feet of 1" steam condensate line was stripped of asbestos-type insulation in the service room of Building 707. This job was particularly hazardous due to the location of the line and the small area in which to work. By using the garden-type sprayer and wetting down the insulation, the dust level was kept to a minimum. Personal and area samples were collected to determine asbestos fibers in the ambient air of the service room during the stripping and cleanup of the insulation. (See following results.)
UCC 024353
Mr. W. T. Shelton
2- -
5/25/79
RESULTS
Date 5/9/79 5/9/79 5/9/79
Personnel Ed Davis R. Raines Area
Time 1021-1105 1021-1105 1021-1105
Liters of Air
88
88 88
Exposure, Fibers/cc >5 um
0.03
0.09 0.12
REFERENCES
Volume 38C-29X4-Rla Asbestos - Dust Determination By Membrane Filter Technique Using Phase Contrast Microscopy
REPORT PREPARED BY
G. W. Bott Technical Center Industrial Hygiene Department
APPROVED BY
S3- h
G". F. Hurley
GWB/sc
UCC 024354
BiUifS
INTERNAL CORRESPONDENCE
CHEMICALS AND PLASTICS
o >ivi$on otation
Zcpy to
Mr. W. T. Shelton 704 Shop
Mr. G. F. Hurley Mr. G. C. Merz Mr. M. E. Perry Mr. H. L. Robinson
P. O. BOX 8361, SOUTH CHARLESTON, WEST VIRGINIA 25303
Date November 27, 1978
Originating Dept, Technical Center IH/EP
Sub|ect
Asbestos - Stripping Old Insulation
PROJECT
Survey for asbestos exposure of insulator
stripping insulation from Dowtherm lines in
Building 707, Cell 3.
SUMMARY
Good work practices and proper housekeeping
by insulators kept the exposure to asbestos
fibers at a minimum. Less than 0.20 fibers/cc > 5 |im - TWA
for eight hours. The insulation was wet down with a water hose
and the dismantled material was labeled and bagged for disposal
at the landfill.
DISCUSSION
A large stripping job of old insulation con
taining asbestos fiber was started on November 16,
1978, in Cell 3 of Building 707. The lines serviced a Dowtherm
heater and ran through three levels of the cell floor. To
facilitate the removal of this insulation containing asbestos, it
was recommended that the piping be removed with the insulation
intact and stripped at the Insulators' Shop. To remove the pipe,
flanges and couplings had to be stripped of insulation for the
pipefitters and riggers to unbolt and remove the lines from the
cell.
Mr. R,, Raines, an insulator (wearing an organic vapor respir ator), made the necessary openings in the insulation for removal. The insulation was wet down before cutting and the stripped mate rial was bagged and labeled for disposal.
When the lines are dismantled and removed from the cell and transported to the shop area, additional personal and area samples
UCC 024355
of the ambient air will be collected and analyzed for asbestos. The exposure was well below the TWA of 2 fibers/cc and a ceiling value of 10 fibers/cc.
RESULTS
DATE
PERSONNEL TIME-MIN-LITERS/AIR
11/16/78 R. Raines* 1252-1345 = 53/95.4
11/16/78 R. Raines* 1345-1425 = 40/72
TWA = 1.05 x 93 = 0.20 fibers/cc >5 pin 480
EXPOSURE FIBERS/CC >5 pm
0.44
0.61
*Willson 122510 Half-face respirator.
REFERENCES
Volume 38C-29X4-Rla Asbestos Dust Determina
tion by Membrane Filter Technique Using Phase
Contrast Microscopy.
REPORT PREPARED BY
G. W. Bott Technical Center Industrial
Hygiene Department
GWB/sc
G. W. Bott
UCC 024356
LA
<y\
f-
O2 H OS S
E
X oN u X
D c
*
o >. 3o
& i-^. 'Q
iT )o
i^o.
r>
O
Z
Ou
<rt
SAMPLING DATA TYPE
BZ - BREATHING ZONE P - PERMANENT STATION 0 - OPERATIONAL TASK A - AMBIENT S -SOURCE
METHOD CT - CARBON TUBE Mi - MIDGET IMPINGER PC - FILTER CASSETTE G- GRAB DTDETECTOR TUBE DR] - DIRECT READING INSTRUMENT
RATE UNIT CCM CC PER MINUTE lPM . LITERS PER MINUTE CEM . CUBIC FEET PER MINUTE
VOLUME UNIT CC . CUBIC CENTIMETER5 L - LITERS CF - CUBIC FEET
ANALYTICAL DATA UNIT
-g - MiCROGRAMS me - M1 LLiGRAMS
EQUIPMENT IDENTIFICATION
GLOSSARY
ANALYTICAL DATA - CONTD. AIR CONCENTRATION IN UNIT
PPM PARTS PER MILLION (BY VOL.} mg/MJ- MILLIGRAMS PER CUBIC METER F/CC - FIBERS PER CUBIC CENTIMETER MPPCF - MILLION PARTICLES PER CUBIC FOOT
METHOD GC - GAS CHROMATOGRAPHY IR - INFRA RED SPECTROPHOTOMETRY UV - ULTRAVIOLET SP . VISUAL SPECTROPHOTOMETRY AA - ATOMIC ABSORPTION SPEC. GV - GRAVIMETRIC ANALYSIS MIC - MICROSCOPY
PERSONNEL DATA PROTECTION USED
FS - FACE SHIELD BC - BARRIER CREAM
B BOOTS RESP - RESPIRATOR PROTECTION GLV - GLOVES CLTH- PROTECTIVE CLOTHING
GOG-GOGGLES
TOBACCO HABITS SMK - SMOKING CHY - CHEWING
CALIBRATION DATA DATE
METHOD
PUMP NO.
SAMPLING PUMP DATA START
STOP
AVERAGE RATE
Back - UCC-C&P-IH-C 1 9/75
UCC 024358
A53ESTOS - EVALUATION AND SURVEY
Date
/ *? JS Project-
Department^^/^V/ C.C-S Location
CRequested by jtlQ
_Reason_
/Z?
^
General Conditions;
Jy^*-
__T"K^<fr*v>
A&AC-cf
12 7- S<S/b ~Z>sC-
& ~ /_____ Bldg. No.
-Z./i.____
_?
'T^f/x/^
___/X ^ *-XJ t
<3 -)/*-$/<. -S".
Sampling Method and Equipment
.j^C -3-?x-
____________
Sample Number
\2L
t
Sampling Time -Min.
J?
Flow Rate
CONCENTRATION Fibers/ml>5>J
uu
o. &*/
Sampled by_ Spec tat Conditions
, /2-s^
f
L
jLjry fTT-S"
,
,^/fX 7LX-/**0
t.
Calculation: (Avg. Fiber Count -Avg. Blank Count) Total Filter Area * Concentration, fibers per'
(Counting Area) (Vol. Air-Liters) (1000)
milliliters >5//
l: Rema rks:
fZ*/***S ^ S9j /97S
Sketch - See reverse side. Reference No. ^//< Analyzed by
Date /&/3/ /9.
UCC 024359
> `. , A/ 4H" - '
Aarz-sraa count record sheet
SA!V!F>l.F=^ .J5L3k- CSPEPSATIOW _ _ _ _ _ _ _ _ 'Zl/SX.tJf.
FLOW
-
TliVtE
- - VOLLJVf
. date=.2 /rs/?j~
IIMITIALC! .
____ F.AREA
............ BLK.CIMT.AV.
Av.CauTJT_________________COISJCEMTWATIOW ,
COMMENTS ________ ZTjfyzS*----------------i4o<^. y.
, .... ...I
rr.^
UCC 024360
INDUSTRIAL HYGIENE - ENVIRONMENTAL PROTECTION ENVIRONMENTAL HAZARD REPORT
DATE
/H A ^ 3 y 1*1 ______________ TIME
PERSON REQUESTING ASSISTANCE LOCATION & Uj *)Ci~ Sky
\AJ - T-
DEPARTMENT
__________
IH DEPARTMENT CONTACT
ft l i 8 tkc__________ _____
REQUEST
A, -ho ri
/ s\ & lf*) o *1
^ t cv o n ^ P'fif i
QjA -- d i^? ^ A
, P ^ (i / / / Y .
ACTION TAKEN
A /> <_/ <?rt 1 ------- 1-----------------
^ u. f * <t- 7At' J ......
,f ,si>
c\ ^ /e. r> ^ r
< *1 St Ctj /'<-*/ <5
t\ A' ^ vi> 4 C c tn-^hr^j"j'irt
7"* Ye. > /Cc . Air. A Jf wtJ /.
>Vaf<> r , 7~/j iv c o* t c e*x
f ts*S t. M ii&f o<~>
OSe H~ri
i1/ <>-
~f*rJD Y,W/cL ......
_r i*s f
i't'Crrt
>J U.f .
IH FILE _
/M ^ _ |6 11. QO 1
" y ^w -1 "
(IH #1 2/77)
UCC 024361
