Document DGGjQ3Y885nzbpn0k2q081qo4

least 8S percent from the following sources, as ScMmS: a) Tar decanter, which is a rectangular vessel - used to separate tar and riushlng liquor by means of gravity: b) Light oil sump, which receives wastewater fro* process equipment froa the light oil recovery portion of a coke by-product recovery plant; i b) Identify all leaking opponents so that.they are obvious and can be located by plant ' ' personnel performing visual Inspections and Agency personnel performing Inspections: and l c) Record In the monitoring log. the information for each leaking component as required by the , provisions of Section 21S.S14. .(Source: Adopted at 9 111. Reg. .13960. effective August IS. 1985) ej Light oil condensor/separator. which Is a device used, to condense qr . separate light oil from which the rvon^condeniable constituents are vented; and d) Tar condensate swap, M)cb receives water condensate streams from the tar recovery .process equipment. (Source: Adopted at 9 111. keg. 13980. effective August 28. I98SI - `Section 21S:St4i- Recordkeeping Requirements .. ' ' .' 'a) The owner or operator of finite by-product - < recovery plant shall maintain a monitoring log that shall contain, at. a minimum, the ' J following Information' fmi' each" component i found leaking: i 1) The. name, afthepcocesvunltwftere the observed leaking component'Is located: ; Sect ion.21S.S12 -.Coke, By-Product Recovery Plant leaks a) The owner or operator of a coke by-product recovery plant shall conduct a visual Inspection program designed to detect. Identify, and facilitate repair:of leaks from components In light oti liquid service. Components.servicing coke oven gas lines. " operating flare headers or vapor, recovery devices (Including pressure relief devices) are exempt from the Inspection, program. b) In conducting such a.program, the owner or - Operator of a coke by-product, feeover/ plant : shall: 1) Develop and conduct a weekly Inspection ' program consistent with the provisions of Section 215.SIS. 2) Record all visible leaking components In Itght oil liquid service and Identify each component observed leaking consistent with the provisions of Section 215.513. . 2) Identic leftIon of the. type Of component i * -(e.g.. valve;- seal):' ' - . 3) Thedateon- wMcH-the1 leaking component- Is first`observed; 4) The date On Milch a leaking component Is repaired; ' 5) IdcfltUlcitlon.ot.U>e..tjpeo( leaking. . . components which cannot be repaired until '. unit shutdown; and 1 6) Identification ofcaaponenC Teak's wflftlV - are aet repaired within 21 days after < dlscovery because of the unavailability . of rigiaceniiHttii.. tocludlngLthe date the.repair part-was.ordered and the date the repair part was received. b) The monitoring log shaTT #i''retanied'Djr tl*e" ;othtr or operator for a minimum of twoi years .after the. date.on which (he record was made. c) Copies of the monitoring log shall be made available to the AgenCy upon.verbal' or written request at rreasonable' timer 3) Repair the leaking components as soon as practicable..but no later than 21 days afteir the leak Is discovered unless the peaking component cannot be repaired until the unit is shut down or until parts needed to correct the leak are available. (Source: Adopted at 9 Hi. Reg. 3960. effective August 28. 1985). Section 285.SI3 Inspection Program The owner or operator shall prepare .and conduct an'Inspection program which, at a minimum, shall require the owner or operator to: ij Observe visually for leaks from ail components subject to Section 2IS.SI2 on a weekly basis; (Source: Adopted at 9 ill. .Reg. 1396.0, effective .-August-28i 198S) Section 2IS.SIS Reporting Requirements - The earner or operator of `a coke by-product recovery, plant .shall, submit td.the_Ageftcy. pr lor to the first day of Hay and August of .each year, a signed statement attesting that all'monitoring and-repairs were performed as required under . Section 215.512. > (Source: Adopted at 9 111. Reg. 13960. effective August 28. 1985) Section 2IS.S16 Compliance Dates The cMier or operator of an emission source subject to: 120 -