Document By2kmkkvg73v3vBbg91Oq7Jbj

maintenance. or Inspection procedures require operator,access. (Spyreef Added at 11 111. Reg. 7650, erfeclWe April 11. WS3)-v- ^ectlon 215.485 leaks The owner or operator or a pharmaceutical manufacturing pi apt shall repalr.anj, conpooent frdm which a leak of volatile organIc llquId can be observed. The repair shall be completed as soon as practicable but no later than IS days after, the Teak. is. found. If.the leaking component cannot tie' repaired until the process unit |s .shut down...the leaking component oust Jthieh.be repaired before.the unit Is restarted. (Source': 7.Added at 12 til. Reg. 7650. effective April 11. 1988) Section 215.486 .'other Eoisston Sources The owner or operator-of a washer, laboratory hood, capsule coating operation* mixing' operation, or any other process emission source not subject to Section 21S.4BT through 21S.48S of this Subpart, and used to manufacture pharmaceuticals shall control the emissions of volatile organic-material from.such:mtss1on sources by: a)Air pollution control equipment which reduces by 81 percent or*more the volatile organic "material that would .'otherwise be emitted to tbe atmosphere, or ' b). A surface condenser which .captures all the volatile, organic material -which would ' otherwise be. emitted to the atmosphere and . which .meets the requirements of Section 215.48)(a) of this Subpart. (Source:* Added, at 12 111. Reg. 7650; effective April 11. 1968) Section 215.487 Testing a) Thy owner 'or .operator of any volatile organic material emission source subject to this Subpart fhal.l,. at his own expense, demonstrate conipl 1 ance. to -the Agency :by methods or procedures listed in Section 215.487(c). b) All tests pursuant to Section .215.487(a) shall .be-.performed. In conformance -with the procedures set forth In 15,111. Adm. -Code 281. c) Test -procedures to determine operation and maintenance compliance with this Subpart Shall be consistent with EPA-450/2-78-041. Incorporated by reference In Section 215.105. Procedures for testing air pollution control equipment to ...determine compliance with this Subpart shall use Part 230. Appendix A Method 2$ (40 CFR 60. Appendix.A Method 25). (Source: Added at 12 111. Reg..7650.. effective April'IT. 1980) Section 215.488 Hon 1 tors fdir Afr Pollution Control Equipment a) At a mlnloum. continuous monitors for the *following parameters shall be Installed on air-pollution control equipment subject to thlsSubpaft; ^ I) Destruction device combustion temperature: :2) Temperature rise acfdis a Catalytic afterburner bed; - 3) Breakthrough of volatile organic.material on a'carbon adsorptlon.lmlt. --1 ,. - ' b) Each monitor shall be equipped Vlth a ' recording device. ..' .v cj Each. monHor-shalT becaVibrated quarterly. 4) Each monitor shall operate at all.times while . - . the associated control equipment Is operating.' (Source: Added at 12 111. Reg. 7650. effective April 11. 1988) | Section 216.489 Compliance- Schedule-- aJThq owner dr operator of ad emlsslpn source subject'to this' Subpart. the construction or - modification' of which has comnenCed prior to April 15. 1988. must complete on^sHe construction or- Installation of .the emission -control or process equipment.-or both'. so as to operate In compliance with this Subpart by April 1. 1989. - b) The owner and operator of any'emission source subject to this Subparl. the construction or . modtflcet-lon-of'-whlch has-not-eonmenced prior to April 15. 1988.. shall construct such source so that it will operate in compliance With EhTs Subpart." (Source: Added at 12 111. Reg. 7650. effective April II. 1988) ' 'SUBPART 1): COKE MANUFACTURE AND BY-PRODUCT RECOVERY' - Section 215.500 Exceptions The provisions^of. Subpart K .shall not apply.lo coke ^by-product recovery plants. (Source: Adopted at 9 111. Reg. 13960. effective August 28. 1985) Section 215.510 Coke By-Product Plants. The owner,,oc operator, of. .a. coke^botrUroduct recovery plant shall reduce the.uncontrolled emissions of volatile organic .materials'by at - 119 -