Document 9D5oOenDwR2n5ypYnydoOme5

8006 1245 ARC-MELDIMG - See Melding. ASBESTOS - See Brake and Clutch Linings and pads. BATTERY ACIDS - See Acids and Alkalies. Oases released during charging are explosive. Never use naked flames,or allow sparks near charging or recently charged batteries. BRAKE AND CLUTCH FLUIDS (polyalkylene glycols) - See Fire Combustible Splashes to the skin and eyes are slightly Irritating. Avoid skin and eye contact as far as possible. Inhalation vapour hazards do not arise at ambient temperatures because of the very low vapour pressure. BRAKE AND CLUTCH LININGS AND PADS - See Legal Aspects ~ IThese items contain asbestos, which If {Inhaled may cause lung damage and In some I cases, cancer. [The normal handling and fitting of these . items should not cause any hazard, but any drilling, grinding or filing of friction materials may produce asbestos dust, and should only be carried out under strictly controlled conditions. The dust in brake drums etc. contains, very little asbestos but care should be taken to avoid inhalation of this dust during servicing of brakes and clutches. The use of drum cleaning units, vacuum cleaning or damp wiping is preferred to the use of air jets for *blowing-outV The dust should bO'Collected in a sealed plastic bag and disMsed with according to ~ law*- and regulations. - BRAZING - sed^NdT-dfhg, CHEMICAL MATERIALS - GENERAL - See Legal Aspects - Chemical materials such as solvents, sealers, adhesives, paints, resin fOams, battery acids, antifreezes, brake fluids, oils and grease should always be used-with caution and stored and bandied with care. They mxy be toxic, harmful, corrosive, irritant or highly Inflammable and give rise to hazardous fumes and dusts. The effects of excessive exposure to chemicals nay be Immediate or delayed; briefly' experienced or permanent; cumulative; superficial; life threatening; or may reduce , life-expectancy. July 1981 HFM- 005831 DO'S Do remove chemical materials from the skin and clothing as soon as practicable after soiling. Change heavily soiled clothing and have It cleaned. Do carefully read and observe hazard and * precaution warnings given on material containers (labels) and In any accompanying leaflets, posters or other instructions. Material health and safety data sheets can be obtained from Manufacturers. Do organise work practices and protective clothing to avoid soiling of the skin and eyes; breathing vapours/aerosols/dusts/fumes; Inadequate container labelling; fire and explosion hazards. Do wash before Job breaks, before eating, smoking, drinking or using toilet facilities when handling chemical materials. Oo keep work areas clean, uncluttered and free of. spills. Do store according to national and local regulations. Do keep chemical materials out of the reach of children. DO HOTS Do not mix chemical materials except under the manufacturers Instructions; same chemicals can form other toxic or harmful chemicals; give off toxic or harmful fumes; be explosive * when mixed together. Oo not spray chemical materials, particularly those based on solvents, in confined spaces e.g. when people are inside a vehicle. Do not apply heat or fl one to chemical Mtmkils except under the manufacturers'' . Instructions-: Somaane highly inflamaMe and some nay release toxic or harmful fumas. i ' ,-j ' - ' '" -v-i'-'j Do not leave containers open. Fumes given . off can build up to toxic, harmful or explosive concentrations. Some fumes are heavlerthan air and will accumulate in. >; confined areas, pits etc. Po^nottransfer chemical materials to unTabelled containers. Do not clean hands or clothing with chemical materials, Chemicals, particularly solvents and fuels will dry the skin and nay cause irritation with dermatitis. Some can be absorbed through the skin In toxic or harmful quantities. Do not use emptied containers for other materials except when they have been cleaned under supervised conditions. ' FORD GRANADA '82 ONWARDS: SECTION 05-3 `