Document 994qxKGmbqJ4x4Y64ELQ8672R
(IMPORTANT: Type or print; read instructions before completing form)
Form Approved OMB Number: 2070-0092 Approval Expires: 11/92
PAGE 1 OF 9
SPA
Jnited States | Environmental j Protection | Agency I
FORM R
TOXIC CHEMICAL RELEASE INVENTORY REPORTING FORM
Section 313 of the Emergency Planning and Comnunity Right-to-Know Act of 1986, also known as Title III of the Superfund Amendments and Reauthorization Act
TRI FACILITY ID NUMBER 7076STHDWCHIGHW
Chem., Cat., or Gen. Name
GLYCOL ETHERS
| WHERE TO SEND COMPLETED FORMS:
1. EPCRA Reporting Center P.O. Box 3348 Mernfleld, VA 22116-3348 ATTN: TOXIC CHEMICAL RELEASE INVENTORY
2. APPROPRIATE STATE OFFICE (See instructions in Appendix F)
|Enter "X* here if | this is a revision
IMPORTANT:
See instructions to determine when "Not Applicable (NA)" boxes should be checked.
...................
1 1
PART I. FACILITY IDENTIFICATION INFORMATION
SECTION 1. REPORTING
YEAR
1995
| |Section 2. TRADE SECRET INFORMATION
1 +-------+-------------------------------------------------------------------------
| | 2.11 Are you claiming the toxic chemical identified on page 3 trade secret?
|| | [ ] Yes (Answer question 2.2;
[X] No (Do not answer 2.2;
Go to Section 3)
| +---------------------------------- --------------*--------*----- *----- ***
| | 2.2| If ye* in 2.1, it this copy:
[ ] Sanitized
( ] Unsanitized
| SECTION 3. CERTIFICATION (Important: Read and sign after completing all form sections.)
' hearby certify that I have reviewed the attached documents and that, to the beat of my knowledge and belief, the submitted
|
-nformation is true and complete and that the amounts and values in this report are accurate based on reasonable estimates using!
I data available to the preparers of this report.
I
| | Facility or Establishment Name | | THE DOW CHEMICAL COMPANYLOUISIANA DIVISION
| TRI Facility ID Number | 70765THDWCHIGHW
Street Address
HIGHWAY 1 SOUTH;P.O. BOX 150
City PLAQUEMINE
|County j IBERVILLE/WBR PARISH
State LA
Mailing Address (if different frost street address) fi / A
City N/A
State LA
Zip Code 70765-0150
|Zip Code |70765-0150
i
11 ___________ *.
|
1
X* _______ _______________________________ 11 1 PUT LABELHERE
1
i ..
1
EPA Form 92S0-1 (Rev. 12/4/94) - Previous editions are obsolete.
|
1 1
EPA United States
wironmental -protection Agency
EPA FORM R PART I. FACILITY IDENTIFICATION
INFORMATION (CONTINUED)
PAGE 2 OF 9
| |TRI FACILITY ID NUMBER
| | 70765THDWCHIGHW j +-------------- ------------- ----- --------- ----| |Chem., Cat., or Gen. Name I -------------- ----------- --------| | GLYCOL ETHERS
*--------------------------------------------------------------------- ------------ ---------------
|SECTION 4. FACILITY IDENTIFICATION (Continued)
4.2 This report contains information for:|
(Important: check only one)
j a. [X] An entire facility
b. [ ] Part of a facility
c. [ ) Federal Facility
I j
4.3 Technical| Name Contact | DOYLE A. HANEY
4.4 Public | Name Contact | GERRY DAIGRE
Telephone Number (include area code) (504)353-6128
Telephone Number (include area code) (504)353-1602
4.5 SIC Code | (4-digit) j a. 2812
I Latitude + -
4.6 and
I -
I Longitude |
Degrees 030
b. 2821 Latitude Minutes
19
c. 2869
d. NA
Seconds
Degrees
Longitude Minutes
16
Seconds 20
4.7 Dun k Bradstreet Number(s)
11
11 11
(9 digits)
I |4.8
1 | EPA Identification Number(s)
|
I 1
(RCRA I.D. No.) (12 characters)
11 |4.9 | Facility NPDES Permit Number(s)
11 ii ii
ii
(9 characters)
14.10j Underground Injection Hell Code (UIC) I.D.
j j Number(s)
(12 digits)
11 11
SECTION 5. PARENT COMPANY INFORMATION
................
5.1|Name of Parent Company |
I I M NA
I |
THE DON CHEMICAL COMPANY
5.2|Parent Company's Dun k Bradstreet Number|
----------- ----------------------------------------------------------- +
--
+
I I[ 1 NA
I
|
(9 Digits)
001381581
--------+------------------------------------------ +..............................................................................................................................................................................................
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
1 1
1 1 i
1
1 1 i
i i
i i
i '
b. a. b. a. b. a. b.
008167080 NA LAD008187080 NA LA0003301 LA0049638 NA
p ^ ( p C -J >- - -
co;\r tdtn: i al
EPA
United States 'nvironmental rotection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION
PAGE 3 OP 9
1 |TRI FACILITY ID NUMBER l 1 | 70765THDWCHIGHW 1 1 |Chem., Cat., or Gen. Name 1 1 | GLYCOL ETHERS
|SECTION 1. TOXIC CHEMICAL IDENTITY (Important: DO NOT complete this section j if you complete Section 2 below.)
l.li CAS Number (Important: Enter only one number exactly as it appears on the Section 313 list.
1 1 N230 - 1-2 i Toxic Chemical or Chemical Category Name (Important: Enter only one name exactly as it appears on the Section 313 list.) i i GLYCOL ETHERS
|1.3| Generic Chemical Name (Important: Complete only if Part I, Section 2.1 is checked "yes.*
I I
1
1 1 i
i 1
I
II
NA
|SECTION 2. MIXTURE COMPONENT IDENTITY (Important: DO NOT complete this j section if you complete Section 1 above.)
|2.1| Generic Chemical Name Provided by Supplier (Important: Max. of 70 chars., including numbers, letters, spaces, and punct.)
II
II
NA
|SECTION 3. ACTIVITIES AND USES OF THE CHEMICAL AT THE FACILITY
11 1 {Manufacture
|the toxic |chemical:
,->11 11 11 1| 11
1 | { a. [X] Produce 1 | b. [ ] Import
1 f |1 1
(Important: Check all that apply.) If produce or import:
c. [ ] For on-site use/processing d. [X] For sale/distribution e. [ J As a byproduct f. [ ) As an impurity
13 2 | 11 11 11 11
ii
Process the toxic chemical
ii 133 |
11 11 11
Otherwise use the toxic chemical:
1 1 1 1 1
i
i i i i i
a. [ ] As a reactant b. [ 1 As a formulation coeponent
a. [ 1 As a chemical processing aid b. t ] As a manufacturing aid
c. [ ) As an article component d. [ ] Repackaging
c. [ ] Ancillary or other use
| Section 4. MAXIMUM AMOUNT OF THE TOXIC CHEMICAL OH-SITB AT ANY TIME | DURING THE CALENDAR YEAR
i 4. l j 03 (Enter two-digit code frosi instruction package.) EPA Form 9250-1 (Rev. 12/4/94) Previous editions are obsolete.
f^ A Or,.v,v-
r ONr T OFNT TAi'
| EPA
I 1 United States
'nvironmental rotection
i Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 4 OF 9
__|TRI FACILITY ID NUMBER
_________________________________ - -
| 70765THDHCHIGHW
4......................
|Chem., Cat., or Gen. Name
---------------------------------
| GLYCOL ETHERS
| SECTION 5. RELEASES OF THE TOXIC CHEMICAL TO THE ENVIRONMENT ON-SITE
i | A Total Release (pounds/year) | B.
1
1
(enter range code from
1
1 1 instructions or estimate) 1
1 11
1 j 5.1 |
i
1 |Fugitive or non-point air |emissions
i
i |5.2 1
i
|5.3 j |
i |Stack or point air emissions 1
i
|Discharges to receiving jstreams or water bodies |(enter one name per box)
|5.3.1 Stream or Hater Body Name
|NA 1
|5.3.2 Stream or Water Body Name i i
'.3.3 Stream or Hater Body Name
i
i
|5.4 | i
i
[Underground injections [on-site i !
11 1| 11 1 [X] NA[ 11
ii
11 ]NA| 11
1
1 1 1
i
NA
i 1 i
i
i i
i
i ii
ii 1 [X] NA| 11
i
NA
1200
1 1 1 1
1 1 1
I 1 1 1
1 1 1 1 i 1 i i
i i i i
|5.5 1
|Releases to land on-site 1 1
1 1
ii
i
|5.5.1| Landfill 11
i
|5.5.2| Land treatment/ j | application farming 11
ii
1 [XIKA| 11 ii
11 1 IX]NA| 11
ii
NA NA
i i
i i i i i
15.5.3 | Surface impoundment 11
ii
1 tX]NA| 11
ii
NA
i i
i
15.5.4 | Other disposal I1
1 [X]NA| NA 11
i i
Basis of Estimate (enter code)
0
j [ ] Check here only if additional Section 5.3 information is provided on page 5 of this form.
1 C. % From 1 Stormwater 1 1
1 1 1 1 i i i
i i i i i i i i i i i i i
i i i
i i i i
i i i i
i I i
i i
EPA Form 92S0-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes: A - 1-10 pounds; B - 11-499 pounds; C - 500 - 999 pounds.
DO A 003030 (.,,! j i to 1 -
EPA
United States nvironmental rotection
Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 5 OP 9
| | TRI FACILITY ID NUMBER
|
| | 7076STHDWCHIGHW
1
| -------------------- ----- .----------------------- --
| |Chem., Cat., orGen. Name | | +----------- --------- --------- --------------------*
| | GLYCOL ETHERS
1
| Section 5.3 ADDITIONAL INFORMATION ON RELEASES OF THE TOXIC CHEMICAL TO THE I ENVIRONMENT ON-SITE
|5.3 | |
|Discharges to receiving |streams or water bodies j(enter one name per box)
|A. Total Release (pounds/year)
I (enter range code from instructions or estimate)
|5.3.4 Stream or Hater Body Name
B. Basis of Estimate
(enter code)
|C. * From I Stormwater |
| | I
|5.3.5 Stream or Hater Body Name |5.3.5 Stream or Hater Body Name
| SECTION 6. TRANSFERS OF THE TOXIC CHEMICAL IN HASTES TO OFF-SITE LOCATIONS I
6.1 DISCHARGES TO PUBLICLY OWNED TREATMENT WORKS (POTW)
|6.1.A Total Quantity Transferred to POTWs and Basis of Estimate
I 6.1.A.1 Total Transfers (pounds/year) (enter range code or estimate)
6.1.A.2 Basis of Estimate (enter code)
NA
|6.1.B POTW Name and Location Information
---------- ---------------------------------------------
I6.1.B.1I POTW Name
6.1.B.2 POTW Name
Street Address
Street Address
I I I I
I
I City I
|County
City
lCounty
| State
|Zip Cod* i
State
|Zip Code
I If additional pages of Part II, Sections 5.3 and/or 6.1 are attached, indicate the total number of | pages in this box [ ] and indicate which Part II, Sections 5.3/6.1 page this is, here. [1 } I (example: 1,2,3,etc.)
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes: A 1-10 pounds; B - 11-499 pounds; C 500 - 999 pounds.
I I I
f ONF TOFNT 1 F!
EPA
United States Tnvironmental
rotection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 6 OF 9
| | TRI FACILITY ID NUMBER
| | 7076 5THDWCHIGHW | - --------------- -------- ------- - - - | |Chem., Cat., or Gen. Name | -f - - ------------- -- ---------- ------------ - | | GLYCOL ETHERS
|SECTION 6.2 TRANSFERS TO OTHER OFF-SITE LOCATIONS
I
*----------------------- ------ ------- ------------------------ . ------------------------------------------------------------------- -------------------------------------------------------------------- ----------------*
(6.2.1 Off-site EPA Identification Number (RCRA ID No.)
]
I NA
|
I Off-Site Location Name
| Street Address
I City
County
| State
|Zip Code
| Is location under control of reporting
[ ] YES
[ I NO
A. Total Transfers (pounds/year) (enter range code or estimate)
1. 2. 3. 4.
|B. Basis of Estimate | (enter code) 1 i
Ui
1 2. i
13 i
1 4.
|C. Type of Waste Treatment/Disposal/ | Recycling/Energy Recovery (enter code) 1 i
|1i
12 i
13 i
14
` "ECTION 6.2 TRANSFERS TO OTHER OFF-SITE LOCATIONS .2.2 Off-site EPA Identification Number (RCRA ID No.) NA
| Off-Site Location Name | Street Address
I City
County
| State
I Zip Code
| Is location under control of reporting
[ ] YES
[ 1 NO
A. Total Transfers (pounds/year) (enter range code or estimate)
1.
|B. Basis of Estimate | (enter code) 1 i
|1-
|C. Type of Waste Treatment/Disposal/ | Recycling/Energy Recovery (enter code) 1 i
ii-
|2- la-
Ia
I |3. |3-
I3
I 14- |4- 14 - I
| If additional pages of Part II, Section 6.2 are attached, indicate the total number of pages in | this box [ ] and indicate which Part II, Sections 6.2 page this is, here. (1 ] | (example: 1,2,3,etc.)
EPA Form 92S0-1 (Rev. 12/4/94) - Previous editions are obsolete.
Range Codes: A - 1-10 pounds; B 11-499 pounds; C S00 - 999 pounds.
I I I
EPA
United States Environmental
rotection gency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 7 OF 9
1 |TRI FACILITY ID NUMBER
|
1 | 70765THDHCHIGHH
|
| ---------------------------------------------------- --
| |Chem., Cat., or Gen. Name | 1 -------------------------------------------- ------+
| | GLYCOL ETHERS
1
|Section 7A. ON-SITE HASTE TREATMENT METHODS AND EFFICIENCY
[ ] Not Applicable (NA) - Check here if no on-site treatment is applied to any waste stream containing the toxic chemical or chemical category.
General Haste Stream (enter code )
b. Haste Treatment Method(s) Sequence [enter 3-character code(a)]
c. Range of Influent Concentration
7A.la
7A. lb
1 Fll
2 NA
7A.1C
d. Treatment Efficiency Estimate
7A. Id
093.99
%
e. Based on Operating Data?
7A.le
tX ]
No []
I | 7A.2a I
7A.3a
7A.4a
7A.5a
7A. 2b
7A.3b
3I
6I 7A.4b
1 Fll
-+ +-
I I
-+ +-
I 7|
2 I5
NA
1 | Bll
- -
I 7|
| 2 | NA
------
---------
I 5 | --- ------
I B|
1 | Bll -------
* I.............
2 | NA
|
7A.Sb
*I
1 | A07 | 2 | NA
|
----------------
---------------- + +----------------
I I ------- - - I 5 |
|
-------------
I 7|
---------------- ---
| 8|
|
7A.2C 7A.3C 7A.4C 7A.5C
7A.2d
099.99
t
7A.2e
Yes [X1
No [
7A.3d
098.00
t
7A.3e
Yes t1
No [X
7A.4d
098.00
%
7A.4e
Yes [1
No [X]
7A.Sd
090.00
t
7A.5e
Yes []
No [X]
If additional pages are attached, indicate the total number of pages in this box [2 ]1 and indicate which page this is, here [1]. EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
fON!FTr:FNT1Ai
*--------------------------| EPA
I | United States
nvironmental rotection igency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
PAGE 7 OF 9 TRI FACILITY ID NUMBER
7076STHDWCHIGHW Chem., Cat., or Gen. Nane
GLYCOL ETHERS
|Section 7A. ON- SITE WASTE TREATMENT METHODS AND EFFICIENCY
| ( ] Not Applicable (NA) - Check here if no on-site treatment is applied to | any waste stream containing the toxic chemical or chemical category.
|a. General
|
| Haste Stream (
| (enter code ) |
b. Waste Treatment Method(s) Sequence [enter 3-character code(s)]
|c Range of Influent 1
| Concentration
1
11
<* Treatment Efficiency
Estimate
1 1 1
1 |7A.lb
| 7A.lc
1
7A. Id
1
1 1 i 1 NA 1 i 1 i 1 7A.2a i1 1 i 1 I i 11 i
7A.3a
7A. 4a
7A.5a
i |3 |
l 1
|7A.2b 1 1 13 1
l 1
|7A.3b 1 11 13 | 6i
1I
i 4i *
i 7i *
|1
4
i 4i 4
i 7i
1
! 4i
i 7i
|7A.4b 1 |1 13 |
1* 1
11
* i 4I
44
i 7i
(7A.Sb 1 1
13 |
IS 1 1 ---- - -
11
4
i 4i
44
ii 7 ----
I 2| 4
i 5i
i Bi
i 11
44
i 5i
i Bi
11 I 5i i 8i
11 11
4
i Si
++
i ai
l1 |1
iI 5
+* i Si
-
1 i 1I
1 1 1 i 1 1
i
1| ) 1
i 1 1 1
i 1 1
i
11 1 |
! i1 1
i j1
i
1l 111 1
i 11 i |1
1 1
i
I1 1
\
i i 11 1
i i i
7A.2C 7A.3C 7A.4C 7A.5C
1 1 %1 1 |
1 |1
i
7A. 2d
1
11 1I 11 1 %1 11 I1
11 11
i
7A. 3d
1
I1 |J I1
1 %1 |1 ||
11
1 1
i
7A.4d
1
|1 11 |1 l %1 |1 |j
11 1|
i
7A.5d
1
I1 |1 |1
it % 1I1 |1
i1 i1
e. Based on Operating Data?
7A.le
Yes tJ
No []
7A.2e
Yea C]
No (]
7A.3e
Yea [j
No ri
7A. 4e
Yes []
No rI
7A.5e
Yea No ri
I |
j l 1 1
i
I 1 | 1 | I 1 1
i
1 { | 1 | | 1 |
i
I f 1 1 J l 1
i
| | | 1 1 1 i i
| If additional pages are attached, indicate the total number of pages in this box [2 ] and indicate which page this is, here (2] . |
+----------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------- *
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
no A OSOfi4A
| EPA
1 | United States
Environmental rotection agency
1
EPA FORM R PART II. CHEMICAL-SPECIFIC
INFORMATION (CONTINUED)
PAGE 8 OP 9
1 |TRI FACILITY ID NUMBER 1 1 | 7076STHDWCHIGHH 1 1 |Chem., Cat., or Gen. Name 1 1 | GLYCOL ETHERS
Section 7B. ON-SITE ENERGY RECOVERY PROCESSES
[X) Not Applicable (NA) - Check here if no on-site energy recovery is applied to any waste stream containing the toxic chemical or chemical category.
Energy Recovery Methods [enter 3-character code(s)]
1
1 1 | NA
2i i
3j |
i i
I Section 7C. ON-SITE RECYCLING PROCESSES
[X] Not Applicable (NA) - Check here if no on-aite recycling ie applied to any waste stream containing the toxic chemical or chemical category.
Recycling Methods [enter 3-character code(s)]
1 NA 6
2 il
3 8
4 9
10 |
EPA Form 9350-1 (Rev. 12/4/94) Previous editions are obsolete.
\i i.
EPA
Uhited States Environmental 'rotection Agency
EPA FORM R
PART II. CHEMICAL-SPECIFIC INFORMATION (CONTINUED)
I Section 8. SOURCE REDUCTION AND RECYCLING ACTIVITIES
| All estimates can be reported | using up to two significant | figures.
I I 8-1 Quantity released *
Column A 1994
(pounds/year)
1200
Quantity used for energy I 8.2 recovery on-site
Quantity used for energy 18 3 recovery off-site
Column B 1995
(pounds/year)
1200
|8.4 Quantity recycled on-site
18.5 Quantity recycled off-site
PACE 9 OF 9
| |TRI FACILITY ID NUMBER
| 1 70765THDWCHIGHW j ---**--------j |Chem., Cat., or Gen. Itaae
] | GLYCOL ETHERS
Column C 1996
(pounds/year)
1200
Column D 1997
(pounds/year)
1200
j 8.6 Quantity treated on-site
I 8 7 Quantity treated off-site
| 8.8
Quantity released to the environment as a result of remedial actions, catastrophic events, or one-time events not associated with production processes (pounds/year)
|8.9 {Production Ratio or Activity Index -
la 10
{Did your facility engage in any source reduction activities for this chemical during
|the reporting year? If not, enter "NA" In Section 8.10.1 and answer Section 8.11.
0001.09
Source Reduction Activities |
[enter code(s)]
j
Methods to Identify Activity (enter codes)
I a 10.1 | 10.2 |
|8. 10.3 10.4
NA
- -
l.
l+---la.
|b. +- -
lb-
|C. |c-
18. 11| Is additional optional information on source reduction, recycling, or I I pollution control activities included with this report? (Check one box)
YES ()
NO [X]
| * Report releases pursuant to BPRCA Section 329(8) including 'any spilling, leaking, pushing, pouring, emitting, emptying,
|
I discharging, injecting, escaping, leaching, dumping, or disposing into the environment. Do not include any quantity treated|
j on-site or off-site.
I
EPA Form 9250-1 (Rev. 12/4/94) - Previous editions are obsolete.
')0 053^45