Document 8RX6wwkzbk1gqnmEK1Dg8Z1om
CG ^4
CODE K0-769-D PKG
NOV 1 0 1982
L2J56
517?* /
7~d a t e ~'>
< l ot >
< EST WGJL)
r~ PROCESSES
APPROVE
y /? < ) K0-789-D (I) FWP 11/04/82
/r CCOMTYP JOB NAME: 04KO789DMI
"
WAREHOUSE REQUEST NO* __
DRY*
DRY NO. PKG TOTAL ACTUAL
LOCATN CG CODE PQ
LOT
WEIGHT
CONT
PKG 's5S
WGT
WEIGHT
USE LBS ss'sssssa
01 YC016B 93
h1100.00
50
c^cpd>c)
01 YC016B 93 01 YC016B 93 mm mmm mmm ,, %xm ,,r-
100.00 ____ .__* 100.00
50 50
01 YC016B 93 ^__
____ 100.00
50
01 YC016B 93
100.00
50
-- ---------- -- -------*
-- * -- -- -- *--
- --- -------
EQUIP
NAME 'KROLOR" ORANGE Y
NON-BLEEDING
BEFORE USING SV MAKE SURE N-28-D LINE (HYDROHLORIC ACID) IF ANY IS BLANKED OFF*'
RUN 60"(990 G> WATER IN V-211. SET AGITATOR ON GH SPEED.
GH IN DRUM AND POUR IN (SODIUM SILICATE) DUMP IN AND STIR 5 MIN (MOLYBDATE ORANGE)
RECORD:
bMuQ.
f in
USE LBS
.530 84X5
I I ACCT 1N-CODEI LBS I-------- 1-------- -
lI I 32-D I 530 IYC16B I 42O0 II
zzzzzzl
I 4<r^JUST TO 75* (1275 G) *N0TE" VOLUMES HIGHER
*N 75* MAY CAUSE DUSTING IN EXHAUST HOOD. I/'RECORD PH: /<> ? (9.0-10.5) Vty^TH AGITATOR ON LOW SPEED PUMP V-211 THRU
TOMOG AT 2800-3200 PSI INTO V-208
IN V--.211 MTY,WASH COLOR THRU HDMOG WITH MIN lATER AT 2800-3200 PSI INTO V-208
JORD: V-208 VOL^t#___ * t, ADJUST TO 54*(1890G) In s p e c t h d mo g s t r a in e r a. c l e a n if n e c e s s a r y
RUN 10" (514 G) WATER INTO V-*#*? START
& I J^-^AGITATOR & INSTALL TEMP CHART
SV HO I PUMP V-208 THRU HOMOG AT 4800-5200 PSI INTOw S> yy.* | | RECORD: TIME START CZ.zJt. TOTAL MINUTES J9
2 I I MQJE: IF HOMOG PRESSURE FALLS BELOW 4800 P:,Ss i , I >"UPWAY VALVE WILL RECIRCULATE SLURRY TO V-208 11*7 WHEN V-208 MT, RUN IN 5*(240 G) WATER 6 PUMP
I THRU HOMOG AT 4800-5200 PSI INTO SV
349 \\T\
LE HOMOG. RUN 6* (284 G) WATER INTO V-349
a, 13**T*RUIN 1000# WATER INTO V-384 & HEAT TO 110-120*F
384 14<j^WTfH INTO V-384 G PUMP TO V-34?
15HJSUN 1000# WATER INTO V-384 & PUMP TO V-34?
16^ADJ V-349 TO 22*..LI040 G) & STIR 15 MIN
X7r\ RECORD DENSITY: 'l s J?-.G/ML (1.082-1.086)
2545
SV S-10 HOMOGcCOMPLETEi ADJ SV TO 45*(2300 G)
RECORD; PH
ADJ TO 11.1-11 .3 USING N-7-D
4 (CAUSTIC SODA SOLN) AT 5% (10 PARTS WATER TO
rK^ART N-7-D)
. ASSUME 50%
SIPHON N-7-D INTO SV a. RECORD: PH
HEAT TO 1 901 94*F IN 55-65 MIN a, REC: HT/J?_?_*F
| a. RECORD: /0_*F. STRIKE MUST START IMMEDIATELY
l ACTCD UCTAT I ID
I 7-D 1
I
LOT: EQUIP MENTI
____ COMTYP JOB NAME: 4K0789DMI | | PA^2 CG 04 K0-789-D
PAGE 02
DATE PRINTED:10/05/82 I USE | N~ |ACCT I LBS | CODE I LBS
-- I------ -----I[
(24*n WHILE HEATING SV, RUN 52* (1430 G) WATER INTO I
|
|
343 t l^-V-343
111
6 \2&T MpFERTN (SULFURIC ACID 60%) FROM V-386
| 27-D | 390
386 |
/Z^*/GAL^TiifGAL
| ||
5 127T \ JSrm 15 MIN OR LONGER
`
||
|
12VT REC0RD: DENSITY $LC-tG/ML (1.018-1.020)
||
|
I l NOTE: THIS PROCESS CALLS FOR N-27-D ON SURFACE.I
|
i
I | BENSURE HOSE IS NOT IN UNDERSURFACE STRIKE LINE!
|
|
ISTJ^WHIN S 20 HEATING COMPLETE, RECORD: PHJQj* |2W^k*SET V-343 ACID PUMP AT 65 SETTING (255 MIN)
I
13*T|Se*r'^-349 SILICATE PUMP AT 54 SETTING (210 MIN)
I C^THiMEDI ATELY METER IN V-343 & V-349. MAINTAIN SV
SV I >"^AT 1 90-1 94*F DURING STRIKE
6 129 I RECORD:
START
FINISH
MINUTES
V-343 r'CL
I
I V-349
I|
TIME V-343
V-349
SV NORMAL
!I
INCHES INCHES
.PH
PH
I I AT 20 HI(49)
(20)i
JSL&i 9.3-10.0)
40 MIN ^I>(45)4 (l8)Zj ^>^(9.3-10.0)
1 HR
(41 )_V/ (16).
-Z*C<9.3-10.)
2 1/4 HR
( 8)3St_ 5(9. 3-1 0.0)
3 1/2 HRjfe'4T( 9)_'_ ( 0)rL_ 7/3_(9,3-1.0)
FINISH^ ( >_-r_
%&.< 7.5-8.5)
NOTE: IF PH DROPS BELOW 9.3 IN FIRST HOUR, STOP
PUMPS 6 SEE SUPV. IF FINAL PH IS ABOVE
8.5, ADJ TO 7.5-8 .5 6 RECORD; _T__PH
ASSUME 77% I_______ I 27-D l______
385 130 7'5^r67*"(5T4~G)_WATiR''T0~V-3i5' 7 (31 |-^ADD 6 STIR 2 MIN
III I 330 I 7-0 | 165
~sv~7S5' l^QtJEN V-349 MT, RINSE IN WITH MINIMUM WATER 6 i j/'CSET PUMP AT ZERO SETTING 8 133 I^OyEN V-343 MT, RINSE IN WITH MINIMUM WATER 6
I l/^PURN OFF PUMP MOTOR r, 134 JxS^IR 3 MIN AT 190-194#F, THEN TURN OFF STEAM ' W I Ix^VRECORD: START %.?>.
135 'IN LIQUID ALUM USING BADGER METER 136 yfUiSH ALM LINE WITH WATER 137 J^ECORD: PH^tSu. (3.4-3.3) 6 IF NECESSARY ADJ
1060 L113-D 530
I (DOWN ONLY) TO 3.4-3.8 & RECORD: PHJT7_ I NOTE: USE LIQUID ALUM, N-115-A. ADD TO SV VIA
I BADGER METER. STIR 5 MIN AFTER EACH
i
II
ADDITION.
ASSUME 50% ___ _! 115-D
138 IN N-7-D FROM. S31 IN 10-12 MIN 6 STIR 5 MIN I
139 i^gECORD: PH^il (6.2-6.4) 6 IF NECESSARY ADJ TO
IA
J/>FH 6.2-6.4. RECORD: PH(gjSLr
ASSUME 77% _______ I 27^D
I KDJMJTE N-7-D 10 TO f WITH WATER
ASSUME 50% _ZL_I 7-D
I l/^JRHON N-7-D INTO SV
140 J^POyR IN (PLASTOLEIN 9746A) 6 STIR 15 MIN
50 1978-A
.2z.iL. 50
141 J^SfOP AGITATOR
II I
TART
FINISH
OPERATOR
I I*
zMSt
J
i
i DUP050060160
DUP050060161
DUP050060162
DUP050060163