Document 8O7JvBdZX2VDpK5a999gGNMde

RBB 00205 SC-ELEC-03480 THESE ARE SOME OF THE MANY PRODUCTS AND APPLICATIONS USING INSULATED WIRE OR CABLE BY CONTINENTAL . . . Air Conditioners Airplanes Bakeries Bake Ovens Ballast Transformers Boiler Rooms Buses Central Stations Clothes Dryers Commercial Refrigerators Cranes Dry Kilns Oectric Furnaces Electric Motors Electric Ranges Hair Dryers Heat Controls Heating Elements Infra-red Heat Lighting Fixtures Locomotives Mercury Switches Motion Picture Machines Oil Burners Panel Boards Paper Mills Permanent Wave Machines Power Houses Pyrometers Radios Range Lights Range Timers Resistance Soldering Restaurant Warming Equipment Rheostats Sewing Machines Show Case Lights Smokehouses Soldering Irons Spotlights Stage Lights Steel Mills Switchboards Table Stoves Thermostats Toasters Waffle Irons Water Heaters and many other electrical and electronic applications STANDARDS of the National Electrical Code, NEMA, ASA, Underwriters' Laboratories Inc., and various Federal Military Specifications are strictly complied with, where applicable. FROM STOCK. A complete line of standard insulated wires is available from stock . . . your assurance of prompt delivery and economical prices. SPECIAL WIRES and CABLES. For specific applications. Continental can recommend and manufacture special insulated wires and cables. RBB 00206 Stranded capper conductor, asbettos, varnished cambric and asbestos insulation, asbettos braid. Heat, flame, and moisture resistant impregnation and finish. USES--Open or in conduit installation where advantages of ex cellent current carrying capacity and resistance to high tempera ture are desired. Type AVA may be used where oil, grease, cor rosive vapors or moisture are present. The maximum operating temperature is 110C (230 F). APPROVED BY--Underwriters' laboratories Incorporated. CONFORMS TO-N. E. Code Standard and NEMA Standard WC11955 and ASA CS8.36-1955. Sizes 16 and 18 not listed in N. E. Code Standard. POWER CABLE TYPE AVA 600 VOLT SERVICE AVAILABLE SIZES: 18 AWG to 1,000,000 CM inclusive STRANDED COPPER PELTED ASSESTOS VARNISHED CELLOPHANE CAMSRIC SEPARATOR PELTED ASBESTOS [ILLUSTRATION SHOWS CONSTRUCTION POR SIZES 4 AND SMALLER! SLACK ASBESTOS BRAID TABLE AVA - PS600 CONSTRUCTION SPECIFICATIONS Six* 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4/0 AWG 3/0 2/0 1/0 1 2 3 4 5 6 8 10 12 14 16 18 CONDUCTOR Strand 61 .128 61 '.1215 61 .1145 61 '.1109 61 .1071 61.1032 61 .0992 61 '.095 37 .1162 37/.1103 37/. 104 37/.0973 37/.090 37/.0822 19/. 1055 19/.094 19/.0837 19/.0745 19 .'.0664 7/.0974 7 .0867 7/.0772 7/. 0688 7/.0612 7, .0486 7 .0385 7 .0305 7/.0242 7/.0192 7, .0152 (art Diam. Jin.) 1.152 1.094 1.031 .998 .964 .929 .893 .855 .813 .772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 .146 .116 .092 .073 .058 .046 JN5ULATION Wall in Milt Asbestos V.C. 30 40 30 40 30 40 30 40 30 40 30 40 30 40 30 40 25 40 25 40 25 40 25 40 25 40 25 40 20 30 20 30 20 30 20 30 20 30 15 30 15 30 15 30 15 30 15 30 10 30 10 30 10 30 10 30 10 30 10 30 A:b*stas 40 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 20 20 20 20 20 15 15 15 15 15 15 * Finished diameters are average and are subject to a plus or minus NOMINAL* OUTSIDE DJAM. (in.) 1.462 1.404 1.341 1.308 1.274 1.239 1.203 1.165 1.113 1.072 1.028 .981 .930 .875 .778 .720 .669 .623 .582 .512 .480 .452 .426 .404 .350 .310 .282 .263 .248 .235 WEIGHT IN LIS. M Ft. 3490 3170 2840 2670 2500 2340 2180 2005 1825 1660 1490 1325 1155 985 815 665 54 5 455 370 288 240 200 166 141 100 70 55 45 35 30 lOiero nee STANDARD SHIPPING LENGTHS (u*i) Coils Root* 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1.000 1.000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00207 2 continental wire POWER CABLE TYPE AVA 1000 VOLT SERVICE AVAILABLE SIZES: 14 AWG to 1,000,000 CM inclusive Stranded Copper conductor, asbestos, varnished cambric and asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish. USES--Open or in conduit installation where advantages of ex cellent currant carrying capacity and resistance to high tempera ture are desired. Type AVA may be used where oil, grease, cor rosive vapors or moisture are present. The maximum operating temperature is 1T0C (230 F). APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WC11955 and ASA C8.36-1955. 1 BUCK ASBESTOS BRAID FELTED ASBESTOS CELLOPHANE separator varnished FELTED ASBESTOS CAMBRIC STftANOEO COPPER ILLUSTRATION SHOWS CONSTRUCTION FOR SIZES 6 AND SMALLER TABLE AVA - PS1O00 CONSTRUCTION SPECIFICATIONS Sis* 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4 0 AWG 30 2/0 1. 0 1 2 3 4 5 6 8 10 12 14 CONDUCTOR Strand 61/.128 61 .'.1215 61 /.l 145 61 '.1109 61/.1071 61 '.1032 61 .0992 61 -'.095 37 .1162 37, .1103 37 .104 37 .0973 37/.090 37 .0822 19 .1055 19 .094 19 .0837 19 .0745 19 .0664 7 .0974 7 ,0867 7 ,0772 7 .0688 7 .0612 7 ,0486 7 .0385 7 .0305 7 .0242 tar* Ptam, fin.) 1.152 1.094 1.031 .998 .964 .929 .893 .855 .813 .772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 , 1 46 .116 .092 .073 AibitioL 30 30 30 30 30 30 30 30 25 25 25 25 25 25 20 20 20 20 20 15 15 15 15 15 15 15 15 15 INSULATION WaH in Mil* V,C, 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 Afcb*ts 40 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 25 25 25 25 25 25 25 25 25 NOMINAL* OUTSIDE DIAM. (in.) 1.472 1.414 1.351 1.318 1.284 1.249 1.213 1.175 1.123 1.062 1.038 .991 .940 .885 .808 .750 .699 .653 .612 .552 .520 .492 .466 .444 .406 .376 .352 .323 WEIGHT IN IBS MFi 3500 3180 2850 2680 2520 2350 2190 2020 1840 1670 1500 1330 1160 1000 830 690 560 470 380 320 260 220 180 160 120 90 70 60 * Finished diameters are average and are subject to a plus or minus 5% tolerance. STANDARD SHIRRING LENGTHS (feet) Coil, R**Ji 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 500 1,000 500 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00208 WIRE CORPORATION Stranded, copper conductor, asbestos, varnished cambric and asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish. - USES--Open or in conduit installation where advantages of ex cellent current carrying capacity and resistance to high tempera ture ore desired. Type AVA may be used where oil, grease, cor rosive vopors or moisture are present. The maximum operating temperature is 109 C (228.2 F). APPROVED BY--Underwriters' laboratories Incorporated. CONFORMS TO--N. 6. Code Standard and NEMA Standard WC1 19S5 and ASA C8.36-1955. POWER CABLE TYPE AVA 2000 VOLT SERVICE AVAILABLE SIZES: 14 AWG to 1,000,000 CM inclusive STRANDED COFFER FELTED ASBESTOS VA1NISHED CELLOFHANE CAMSRIC SEPARATOR FELTED ASBESTOS 'ILLUSTRATION SHOWS CONSTRUCTION FOB SIZES 6 AND SMALLER! Black COTTON BRAID TABLE AVA - PS2000 CONSTRUCTION SPECIFICATIONS 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4/0 AWG 3,0 20 1. 0 1 2 3 4 5 6 8 10 12 14 CONDUCTOR (trend 61 .128 61/.1215 61 '.1145 61 '.1109 61 /.1071 61 .1032 61/.0992 61/.095 37/.1162 37/.1103 37/. 104 37/.0973 37/.090 37/.0822 19/. 1055 19/.094 19, .0837 19, .0745 19, .0664 7 .0974 7, .0867 7 .0772 7 .0688 7. .0612 7 .0486 7 .0385 7 .0305 7 .0242 ler* Diem. fin.) 1.152 1.094 1.031 .998 .964 .929 .893 .855 .813 .772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 .146 .116 .092 .073 INSUtATION Wolf in Mils Atbtttei v.c 30 60 30 60 30 60 30 60 30 60 30 60 30 60 30 60 25 60 25 60 25 60 25 60 25 60 25 60 20 60 20 60 20 60 20 60 20 60 15 60 15 60 15 60 15 60 15 60 15 60 15 60 15 60 15 60 Aibtitoi 40 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 25 25 25 25 25 25 25 25 25 NOMINAL* OUTSIDE 01AM. (in.) 1.502 1.444 1.381 1.348 1.314 1.279 1.243 1.205 1.153 1.112 1.068 1.021 .970 .915 .838 .780 .729 .683 .642 .582 .550 .522 .496 .474 .436 .406 .382 .363 WEIGHT IN IRS. M ft. 3560 3190 2910 2735 2570 2400 2250 2070 1900 1720 1550 1375 1200 1040 880 740 600 510 430 350 290 225 190 170 130 100 80 70 STANDARD SHIPPING LENGTHS 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 * Finished diameters are average and are subject to a plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00209 ^CONTINENTAL WIRE CORPORATION POWER CABLE TYPE AVA 3000 VOLT SERVICE AVAILABLE SIZES. 14 AWG Id 1,000,000 CM inclusive Stranded copper conductor, asbestos, varnished cambric and asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish. USES--Open or in conduit installation where advantages of ex cellent current carrying capacity and resistance to high tempera ture are desired. Type AVA may be used where ail, grease, cor rosive vapors or moisture are present. The maximum operating temperature is 106 C (222.8 F). APPROVED BY--Underwriters' Loboroiories Incorporated. CONFORMS TO--N. . Code Standard and NEMA Standard WC11955 and ASA C8.36-T955. slack. asbestos braid felted asbestos cellophane separator varnished felted asbestos CAMBRIC stranded copper NUUSTRATION SHOWS CONSTRUCTION FOR SIZES t AND SMALLER: TABLE AVA * PS3000 CONSTRUCTION SPECIFICATIONS Sit* 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4 0 AWG 30 20 10 1 2 3 4 5 6 8 10 12 14 CONDUCTOR Strong 6t .128 6T/.1215 61/. 1145 61 All 09 61A1071 61/.1032 61/.09V2 61 ,'.095 37 .1162 37/.1103 37.'.104 37/.Q973 37/.090 37/-0822 19 .1055 19. .094 19 .0837 19 .0745 19 .0664 7 .0974 7 .0867 7 .0772 7 .0688 7 .0612 7 .0486 7 .0385 7 .0305 7 .0242 Bar* Diam. (in,) 1.152 1.094 1.031 .998 .964 .929 .893 .855 .813 .772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 .146 .116 .092 .073 Aiblf*l 30 30 30 30 30 30 30 30 25 25 25 25 25 25 20 20 20 20 20 15 15 15 15 15 15 15 15 15 INSULATION Wall in Milt v.c. 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 Atbtiot 40 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 25 25 25 25 25 25 25 25 25 NOMINAL* OUTSIDE DIAM. (in.J 1.542 1.484 1.421 1.388 1.354 1.319 1.283 1.245 1.193 1.152 1.108 1.061 1.010 .955 .878 .620 .769 .723 .682 .622 .590 .562 .536 .514 .476 .446 .422 .403 WEIGHT IN IBS. M Ft. 3650 3300 2975 2805 2630 2450 2300 2119 1950 1780 1600 1440 1230 1085 920 750 630 540 465 350 310 240 225 180 140 ` 110 95 90 STANDARD SHIRRING LENGTHS (f**t| Cailt RhIi 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 t,000 1,000 1,000 1,000 1,000 1,000 1,000 * Finished diornelers are average and are subject to a plus or minus 5%i tolerance. FOR FASTEST SERVICE PHONE OR WIRE FOR FASTEST SERVICE PHONE OR WIRE rBB 00210 Stranded copper conductor, asbestos, varnished eombric and asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish. ' USES--Open or in conduit installation where advantages of ex cellent current carrying capacity and resistance to high tempera ture are desired. Type AVA may be used where oil, greose. cor rosive vapors or moisture are present. The maximum operating temperature is 100 C (212 F). APPROVED BY--Underwriters' Laboratories incorporated. CONFORMS TO-N. E. Code Standard and NEMA Standard WC11955 and ASA C8.36-1955. STRANDED COPPER TEWED ASBESTOS VARNI5HE5 CELLOPHANE CAMBRIC SEPARATOR ftltto ASBESTOS nilUStRATION SHOWS CONSTRUCTION fOR SUES 6 AND SMALLER' SLACK COTTON BRAID TABLE AVA PS5000 CONSTRUCTION SPECIFICATIONS Silt 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4/0 AWG 3/0 2/0 1/0 1 2 3 4 5 6. 8 10 12 14 CONDUCTOR Strand 61/.128 6T/.1215 61/.1145 61/.1109 61/.1071 61/.1032 61/.0992 61/.095 37/. 1162 37/. 1103 37/. 104 37/.0973 37/.090 37/.0822 19/. 1055 19/.094 . 19/.0837 19/.0745 19/. 0664 7/.0974 7/.08 67 7/.0772 7/'.0688 7/.0612 7/.0486 7/.0385 7/.0305 7 .0242 Sort Orem. lin.) 1.152 1.094 1.031 .998 .964 .929 .893 .855 .813 .772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 .146 .116 .092 .073 Atbettot 30 30 30 30 30 30 30 30 25 25 25 25 25 25 20 20 20 20 20 15 15 15 15 15 15 15 15 15 INSULATION Watt in Milt V. C. 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 120 Atbtstes 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 30 25 25 25 25 25 25 25 25 25 NOMINAL* OUT5IDE DIAM. (in.) 1.622 1.564 1.501 1.468 1.434 1.399 1.363 1.325 1.273 1.232 1.188 1.141 1.090 1.035 .958 .900 .849 .803 .762 .702 .670 .642 .616 .594 .556 .526 .502 .483 WEIGHT IN LSS. M Ft. 3720 3360 3040 2880 2700 2530 2370 2200 2000 1830 1665 1485 1310 1140 960 800 680 580 490 410 340 300 260 230 190 150 120 no * Finished diameters are average and ore subject to o plus or minus 5% tolerance. STANDARD SHIPPING LENGTHS ffMt) Ceitt Riel* 500 500 500 500 500 500 500 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1.000 1,000 1,000 1,000 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00211 CONTINENTAL WIRE CORPORATIONS, Solid or stranded copper conductor, vornishod cambric and asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish* USES-Open or in conduit wiring of boiler rooms ond apparatus in such rooms. Type AVA Boiler Room Wire may be used where oil, grease, corrosive vapors or moisture are present. The moximum operating temperature is 110C (230 F). APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E. Code Stondord and NEMA Standard WC1 1955 and ASA C8.36-1955. (Solid only). Sizes 16 and 18 not listed in N. E. Code Standard. s BLACK i ASBESTOS BRAID FELTED ASSESTOS cellophane separator varnished CAMStlC (ILLUSTRATION SHOWS CONSTRUCTION IOR SUES AND SMALLER) coffer CONDUCTOR TABLE AVA - 600 CONSTRUCTION SPECIFICATIONS Sit# CONDUCTOR Diam. (in.) 4/0 AWG 3/0 2/0 VO 1 2 4 6 8 10 12 14 16 18 .460 .410 .365 .325 .289 .258 .204 .162 .128 .102 .031 .064 .051 .040 SOLID CONDUCTOR Aibfifti 20 20 20 20 20 15 15 15 -- -- ~ -- -- -- INSULATION Wall m Milt v.c. 30 30 30 30 30 30 30 30 30 30 30 30 30 30 Asbettoi 30 30 30 30 30 20 20 20 20 20 20 20 20 20 nominal* OUTSIDE DIAM. lift.) .710 .660 .615 .575 .539 .478 .424 .382 .308 .282 .261 .244 .231 .220 WEIGHT IN LBS. M ft. 790 630 523 430 350 260 185 130 82 61 45 37 30 22 STANDARD shipping"" LENGTHS (F**n C*ili R**H 1.000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 500 1,000 500 1,000 500 1,000 500 1,000 500 1,000 TABLE AVA BS600 CONSTRUCTION SPECIFICATIONS STRANDED CONDUCTOR CONDUCTOR Strand 8 AWG 7 .0486 10 7 .0385 12 7 .0305 1 4 7 .0242 16 7 .0192 18 7 .0152 BARE DIAM. tin.) .146 .116 .092 .073 .058 .056 INSULATION WdII in Mils V.C. 30 30 30 30 30 30 Asbestos 20 20 20 20 20 20 NOMINAL' OL/TSIOE MAM. (in.) .326 .296 .272 .253 .238 .226 WEIGHT IN M Hr 92 70 53 41 34 25 ' Finished diameters are overage ond are sub[ect to a plus or minus 5% tolerance. STANDARD SHIPPING LENGTHS Coils Riel) 500 1,000 500 1,000 500 1,000 500 1,000 500 500 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00212 CONTINENTAL WIRE COR Flexible tinned copper conductor, oibettos, varnished cambric and asbestos insulation, asbestos braid. Heat, flame and mois ture-resistant impregnation and finish. For sices larger than 4/0, refer to Motor lead and Apparatus Cable, Type AVA. USES--Designed to operate equipment used in the mining indus try and can be used where oil, grease, corrosive vapors, or mois ture are present along with elevated temperatures. MAXIMUM OPERATING TEMPERATURE: 110C (230F). 7 STRANDED COFFER FELTED ASltSTOS VARNISHED CELLOPHANE CAMIR1C SEPARATOR FELTED ASBESTOS (ILLUSTRATION SHOWS CONSTRUCTION FOR SIZES 4 AND SMALLER! SLA' K COTTON BRAID TABLE AVA MS600 CONSTRUCTION SPECIFICATIONS CONDUCTOR Silt Stroud 4/OAWG 3/0 2/0 1/0 1 2 3 4 5 6 8 10 12 14 259/.0286 259/.0255 259/.0227 259/.0202 259/.0T8 133/.0223 133/.0199 133/-0177 133/.0158 T33/.014 133/.0111 105/.010 65/.010 41/.010 Br D*a(fUrl .600 .536 .477 .424 .378 .336 .299 .266 .237 .212 .168 .120 .095 .075 Atbttfoi INSULATION WU * Mill v. c. Atbtttoi 15 40 15 40 15 40 15 40 15 40 10 35 10 35 10 35 10 35 10 35 10 35 10 35 10 35 10 35 15 15 15 15 15 15 15 15 10 10 10 10 14 14 NOMINAL* OVHSiDS DIAM. (in.) .310 .746 .687 .634 .588 .519 .482 .449 .410 .385 .341 .293 .276 .256 WEIGHT m im. M Fttf 835 680 560 460 370 280 235 185 155 130 92 64 48 37 STANDARD SHIPPING LENGTHS (foot) Calls Rttlt 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 500 1,000 500 1,000 500 1,000 `Finished diameters ore averoge ond are subject to o plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00213 CONTINENTAL WIRE CORPORATION*.: APPARATUS OR MOTOR LEAD CABLE TYPE AVA 600 VOLT SERVICE AVAILABLE SIZES: IS AWG to 1,000,000 CM inclusive Flexible tinned copper conductor, asbestos, varnished cambric and asbestos insulation, asbestos braid. Heat, flame and mois ture resistant impregnation and finish. USES--Open or in conduit installation where high current carry ing capacity and resistance to high temperature are required. Type AVA is used to wire low voltage apparatus where flexibility is necessary. MAXIMUM OPERATING TEMPERATURE IS 110`C (230 F). APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E, Code Standard and NEMA Standard WC11955 and ASA C8.36-1955. (Sizes 16 end 18 are not listed in N. E. Code Standard). BLACK ASBESTOS BftAID BELTED asbestos CELLOPHANE separator VARNISHED FEtTED ASBESTOS CAMBRIC (ILLUSTRATION SHOWS CONSTRUCTION FOR SI2E5 6 AND SMALLER; STRAND60 COPPER TABLE AVA - X600 CONSTRUCTION SPECIFICATIONS Sic* CONDUCTOR Strand Aar* Diam. (in.) INSULATION Wall in Milt Aftbatte* V.C. NOMINAL* OUTSIDE DJAM. Atbatfct (in.) STANDARD SHIPPING WEIGHT IN LENGTHS U**t> Lb*. M ft. Coil* fi**l 1,000 MCM 900 800 750 700 600 500 450 400 350 300 250 4 0 AWG 30 20 10 1 2 3 4 5 6 8 10 12 14 T6 18 427/.0484 427/.0459 427/.0433 427/.0419 427/.0405 427/.0375 427/.0342 427/.0325 427/.0306 427/.0286 427/.0265 427/.Q242 259 .0286 259 .0255 259 .0227 259 .0202 259 .018 133 .0223 133 .0199 133 .0177 133 .0158 133 .014 133 .0111 105 .010 65 .010 41 .010 26 .010 16 .010 1.295 1.222 1.153 1.134 1.088 1.027 .923 .878 .826 .772 .716 .653 .600 .536 .477 .424 .378 .336 .299 .266 .237 .212 .168 .120 .095 .075 .059 .045 30 40 30 40 30 40 30 40 30 40 30 40 25 40 25 40 25 40 25 40 25 40 25 40 20 30 20 30 20 30 20 30 20 30 15 30 15 30 15 30 15 30 15 30 10 30 10 30 10 30 10 30 10 30 10 30 40 1.605 3590 1,000 40 1.532 3220 1,000 40 1.463 2860 1,000 40 1.444 2780 1,000 40 1.398 2570 1,000 40 1.337 2300 1,000 40 1.223 1910 1.000 40 1.T78 1740 1,000 40 1.126 1560 1,000 40 1.072 1380 1,000 40 1.016 1210 1,000 40 .953 1030 1,000 30 .850 850 1,000 30 .786 700 1,000 30 .727 570 1,000 30 .674 470 1,000 30 .628 390 1,000 20 .556 310 1,000 20 .519 250 1,000 20 .486 210 1,000 20 .457 175 1,000 20 .432 150 1,000 15 .368 100 500 1,000 15 .310 75 500 1,000 15 .285 55 500 1,000 15 .265 45 500 1,000 15 .249 35 500 1,000 15 .235 31 500 1,000 * finished diameters ore average and ore subject to a plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00214 CONTINENTAt&WIRE CORPORATION Am V.' > * _ r ` t , ..fe. 1- - * - Tinned copper, felted asbetfos, varnished cambric insert, wall of felted asbestos, and cotton braid colored according to NEMA Control Cable Color Code far multi-conductor cables, individual conductors are cabled with jute fillers where necessary, a layer of cable tape, and asbestos braid finished with black flame, heat, and moisture-resistant compound. Twisted pair standard on two conductor cable. Parallel construc tion furnished if preferred. USES--In circuits and apparatus in metal making milts, power plants, boiler rooms . . . wherever heat, oil, grease, corrosive vapors and flame are present. MAXIMUM OPERATING TEM PERATURE: 110 C (230 F). STATION CONTROL CABLE TYPE AVA 600 VOLT SERVICE AVAILABLE SIZES: 9 and 12 AWG CONDUCTCtt INSULATION TAPE ASSJS1 OS BRAID TABLE AVA - CS600 CONSTRUCTION SPECIFICATIONS Numbov of Conductors ** i 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 #12 (19/25) Shipping Wi. Lb*. p*r 1000 foot 87 376 404 449 481 533 543 595 771 798 846 869 922 946 1005 1029 1150 1174 1197 . Nominal O.D. in Inch**' .30 .59 .63 .69 .75 .82 .82 .90 .97 1.06 1.09 1.09 1.16 1.16 1.22 1.22 1.29 1.29 1.29 Number of Conductors ** i 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 #9 (19/22) Shipping Wt. lb*> por tooo p**f 112 433 488 558 612 691 716 885 1000 1045 1120 1162 1317 1350 1449 1502 1570 1612 1655 Data on cable over 19 conductors furnished on request ' Subject 5% variation. _ ** Single conductor has single 45 mil asbestos braid only. (No Cotton Braid) Minimum ordering quantity per item -- 250 feet. Nominal 0*0. In Inchm* .33 .66 .71 .78 .85 .94 .94 1.02 1.10 1.21 1.25 1.25 1.32 1.32 1.40 1.40 1.48 1.48 1.48 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00215 10 t----------------- POWER CABLE TYPE AVI 600 VOLT SERVICE AVAILABLE SIZES; 8 AWG to 1,000,000 CM inclusive Stranded topper conductor, asbestos, varnished cambric, asbestos insulation, lead jacket. USES--Power circuits in wet or dry locations, exposed or in con duit. Withsrands constant high temperatures. APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WC11955 and ASA C8.36-1955- (tuusttmriON shows tonstsuctics for sizes t *nd smaueb TABLE AVL PS600 CONSTRUCTION SPECIFICATIONS INSULATION THICKNESS IN MILS No. *f Sil* Strands 1 A*b. V.c 2nd Atb l*ad 64rhs SINGLE CONDUCTOR 8 AWGi 7 10 30 25 3 6 7 15 30 25 3 4 7 15 30 25 3 2 7 15 30 25 4 1 19 20 30 30 4 1 0 19 20 30 30 4 2 0 19 20 30 30 4 3 0 19 20 30 30 4 4 0 19 20 30 30 5 250 MCM 37 25 40 40 5 350 37 25 40 40 5 500 37 25 40 40 6 750 61 30 40 40 6 1000 61 30 40 40 6 THREE CONDUCTOR 8 AWGi 7 10 30 25 4 6 7 15 30 25 5 4 7 15 30 25 5 2 7 15 30 25 5 1 19 20 30 30 6 1 0 19 20 30 30 6 2 0 19 20 30 30 6 3 0 19 20 30 30 6 4 0 19 20 30 30 7 250 MCM 37 25 40 40 7 500 37 25 40 40 8 -misned diameter* are averoge and are subject to 5% tolerance. Not. O.D. In liuhn* .374 .422 .500 .592 .652 .693 .738 .790 .878 .975 1.081 1.246 1.440 1.594 .759 .893 .996 1.126 1.287 1.376 1.472 1.583 1.738 1.948 2.494 Ship. Wt. Lb. 1000 Ft* 386 476 585 903 1060 1197 1363 1564 1807 2398 2954 3744 5448 6692 1324 1842 2100 2760 3600 4065 4664 5300 6632 7846 12900 , Minimum Ordr>A9 Quantity In Ft. 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 250 .... .. RBB 00216 CONTINENTAL WIRE asaaroiffK n Stranded copper conductor, asbestos, varnished cambric and asbestos insulation, blade cotton braid. Hoot, flame and moisture resistant impregnation and finish. USES--Open or in conduit installation where advantages of good current carrying capacity and resistance to high temperature are desired. Maximum operating temperature is 90" C 094 F). For higher operating temperatures Type AVA is recommended. APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WC119SS and ASA C8.36-1955. Sizes 16 and 18 not listed in N. E. Code Standard. POWER CABLE tyre avb 600 VOLT SERVICE AVAILABLE SIZES: 18 AWG to 1,000,000 CM inclusive STRANDED COFFER FELTED ASSISTOS VARNISHED CELLOFHANE CAMSRIC SEPARATOR FELTED ASSESTOS I ILLUSTRATION SHOWS CONSTRUCTION FOR SUES 4 AND SMA1LER TABLE AVB - PS600 CONSTRUCTION SPECIFICATIONS SLACK COTTON BRAID Sin 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4/0 AWG 3/0 2/0 1/0 1 2 3 4 5 6 8 10 . 12 14 16 18 CONDUCTOR Streflrf 61/.128 61/.1215 61/.1145 61/.1109 61/.1071 61/.1032 61/.0992 61/.Q95 37/. 1162 37/. 1103 37/. 104 37/.0973 37/.090 37/.0822 19/. 1055 19/.094 : 19/.0837 19/.0745 19/.0664 7/.0974 7/.0867 7/.0772 7/.0688 7/.0612 7/.0436 7/.0385 7/.0305 7/.0242 7/.0192 7. .0152 1.152 1.094 1.031 :998 .964 .929 .893 .355 .813 .772 .728 .631 .630 .575 .528 .470 .419 .373 .332 .292 .260 .232 .206 .184 .146 .116 .092 .073 .058 .046 Aibfitii 30 30 30 30 30 30 30 30 25 25 25 25 25 25 20 20 20 20 20 15 15 15 15 15 10 10 10 10 10 10 INSULATION Wall m Mb v.c. 40 40 40 40 40 40 40 40 40 40 40 40 40 40 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 30 Atbst* 40 40 40 40 40 40. 40 40 40 40 40 40 40 40 30 30 30 30 30 20 20 20 20 20 15 15 15 15 15 15 NOMINAL* OUTSIDE DIAM. (in,) 1.424 1.366 1.303 1.270 1.236 1.201 1.165 1.127 1.075 1.034 .990 .943 .892 .825 .728 .670 ,619 .573 .532 .462 .430 .402 .370 .348 .290 .260 .234 .215 .200 .186 WEIGHT IN LBS. M h. 3480 3150 2830 2665 2490 2330 2180 2000 1825 1660 1495 1330 1150 970 790 650 525 430 355 270 220 185 155 130 85 60 45 35 30 25 * Finished diameters ore overage and ore subject to a plus or minus 5% tolerance. STANDARD SHIPPING LENGTHS Ccih Rttls 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 500 1,000 500 500 500 500 1,000 1,000 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00217 CONTINENTAL WIRE CORPORAXffittH| SWITCHBOARD AND RHEOSTAT WIRE TYPE AIA 600 VOLT SERVICE AVAILABLE SIZES: 18 to 4/0 AWG inclusive Solid copper conductor, asbestos insulation, asbestos braid. Heat, flame and moisture resistant impregnation and finish. For stranded conductor, refer to Power and Rheostat Cable. Type AIA. ' Standard colors Black or White. Other colors also available USES--Open wiring of rheostats, switchboards, control ponels, and ovens where oil, grease, corrosive vapors or moisture are present along with elevated temperatures. The MAXIMUM OP ERATING TEMPERATURE IS 125 C (257'' F). APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WC11955 and ASA C8.36*1955. Sties 16 and 18 not listed in N. E. Code Standard. AS9E5T05 MAID A5IEST05 I SOLID COME* CONDUCTOR I TABLE AIA * 600 CONSTRUCTION SPECIFICATIONS Sib AWG CONDUCTOR tor* Diem, (in.) 40 3/0 2/0 1/0 1 2 3 4 5 6 8 10 12 14 16 18 .460 .410 .365 .325 .289 .258 .229 .204 .182 .162 .128 .102 .031 .064 .051 .040 INSULATION Aitmtof NOMINAL* OUTSIDE Well in Milt CHAM. <<n.) 60 .670 60 .620 60 .575 60 .535 60 .499 40 .423 40 .399 40 .374 40 .352 40 .322 30 .268 30 .242 30 .221 30 .204 30 .191 30 .180 WEIGHT IN IBS. M Ft. 750 610 430 385 320 245 200 165 135 114 75 53 40 31 26 20 * Finished diameters are average and are subject to a pius or minus 5% tolerance* STANDARD SHIPPING LENGTHS (f**t) Ceil* ft**Is 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1.000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00218 CONTINENTAL WIRE CORPORATION 13 Stranded copper conductor, asbestos inflation, asbestos braid. Heat, flams and moisture-resistant impregnation and finish. For solid conductor, refer to Switchboard and Rheostat Cabin, Type AtA. Standard colors, Slack or White. Other colors also available USES--Open installation where operating temperatures are high. Type AIA may be used where oil, grease, corrosive vapors or moisture are present. MAXIMUM OPERATING TEMPERATURE: 125 C (257 F). APPROVED BY--Underwriters' Laboratories Incorporated. CONFORMS TO-N. E. Code Standard and NEMA Standard WC11955 and ASA CS.36-195S. (Sizes 16 and 16 not listed in N. E. Code Standard. POWER AND RHEOSTAT CABLE TYPE AIA 600 VOIT SERVICE AVAILABLE SIZES. IB AWG to 1,000,000 CM inclusive SttANDEO corset FELTED AStEStos ASIEJTOS SEAID TABLE AIA S600 CONSTRUCTION SPECIFICATIONS Silt 1,000 MCM 900 800 750 700 650 600 550 500 450 400 350 300 250 4/0 AWG 3/0 2/0 1/0 1 2 3 4 5 6 8 10 12 14 16 18 CONPUCTOE Stmn4 61/.128 61/.1215 61/. 1145 61/.1109 61/.1071 61/.1032 61/.0992 61/.095 37/. 1162 37/. 1103 37/. 104 37/.0973 37/.090 37/.0822 19/. 1055 19/.094 19/.0837 19/.0745 19/.0664 7/.0974 7/.0867 7/.0772 7/.0688 7/.0612 7/.0486 7/.0385 7/.0305 7/. 0242 7/.0192 7/.0152 tar* (farm. (in.) 1.152 1.094 1.031 .998 .964 .929 ,893 .855 .813 ,772 .728 .681 .630 .575 .528 .470 .419 .373 .332 .292 .260 ,232 .206 .184 .146 .116 .092 .073 .058 .046 INSULATION Atbtttot Wotl In Mh 105 105 105 105 105 105 105 105 90 90 90 90 90 90 75 75 75 75 75 60 60 60 60 60 : 40 40 40 30 30 30 NOMINAL* OUTSIDE DIAM. lie.) 1.452 1.394 1.331 1.298 1.264 1.229 1.193 1.155 1.083 1.042 .998 .951 .900 .845 .768 .710 .659 .613 .572 .502 .470 .442 .416 .394 .306 .276 .252 .213 .198 .186 WEIGHT IN LftS. M Ft. 3400 3100 2800 2600 2450 2300 2150 1900 1750 1600 1450 1300 1150 925 800 680 550 430 340 250 210 180 155 130 90 65 45 30 27 24 STANDAtP :SHIPPING LENGTHS (Pm*) Coil, Rl> 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,0(50 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 500 1,000 500 1,000 500 1,000 500 1,000 500 1,000 * Finished diameters are average and are subject to a plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00219 CONTINENTAL WIRE CORPORATIONS Flexible tinned copper conductor, asbestos insulation, asbestos braid. Hoot, flame and moisture-resistant impregnation and finish. USES--Open installation where flexibility under high temperature conditions is desired. This type may be used where oil, grease, corrosive vapors or moisture are present along with elevated temperature. MAXIMUM OPERATING TEMPERATURE. 125eC (257F). APPROVED BY--Underwriters' laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WCI-1P55. and ASA C8.36*1955. (Size 16 and 18 not listed in N. E. Code Standard.) CONDUCTOR Si** 500 MCM 450 400 350 300 250 4 0 AWG 30 20 !0 1 2 3 4 5 6 8 10 12 14 16 18 Srrond 427/.0342 427/.0325 427/.03 06 427/.0286 427/.0265 427/.0242 259 .0286 259 .0255 259, .0227 259 .0202 259 .018 133 .0223 133 .0199 133 .0177 133 .0158 133 .014 133 .0111 105 .010 65 .010 41 .010 26 .010 16 .010 &ar* piorn. fin.) .923 .878 .826 .772 .716 .653 .600 .536 .477 .424 .378 .336 .299 .266 .237 .212 .168 .120 .095 .075 .059 .045 INSULATION Asbsttoc Wolf in MUt 90 90 90 90 90 90 75 75 75 75 75 60 60 60 60 60 40 40 40 30 30 30 KQWHAl* OUTSIDE DIAM. (in.) 1.193 1.148 1.096 1.042 .986 .923 .840 .776 .717 .664 .618 .546 .509 .476 .447 .422 .328 .280 .255 .215 .199 .185 WEIGHT IN IBS. M Fr. 1870 1710 1520 1330 1160 1005 850 700 560 440 380 300 240 190 165 135 90 65 45 33 27 22 ' Finished diameters are average and are subject to a plus or minus 5% tolerance. STANDARD SHIPPING LENGTHS (flit) Coil. RmIi 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 liooo 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00220 WIRE CORPORATION IS Stranded copper conductor, asbestos insulation, asbestos braid. Heat and flame resistant finish. USES--Wiring of professional type motion picture protectors. Type AA Cable's flexibility and heat resistance make it suitable, too, for leads on electric cranes, furnaces, flood lights, searchlights, and spotlights. This cable is also desirable for secondary leads on resistance soldering equipment where high current carrying capacity and heat resistance are important. MAXIMUM OPERATING TEMPERATURE: 200 C (392s F). APPROVED BY--Underwriters' Laboratories incorporated. CONFORMS TO- N. E. Code Standard and NEMA Standard WC11955 and ASA C-8.36-1955. (Sizes 16 and IS not listed in N. E. Code Standard.) APPARATUS OR MOTION PICTURE MACHINE CABLE TYPE AA 300 VOLT SERVICE AVAILABLE SIZES: 18 to AWG inclusive 4/0 FLEXIBLE OF EXTEA FLEXIBLE CONDUCTOt A$lStOS WHITE ASBESTOS MAID Sis* AWG 40 3/0 2/0 1/0 1 2 3 4 56 8 TO 12 14 16 18. - CONOUCTOK Strand 8512 36 6713/36 5292/36 4214/36 3332/36 2646/36 2104/36 1666/36 1330/36 1050/36 665/36 413/36 259/36 105/34 65/34 41/34 Sara Divm. (i.i insulation Atbittpj WoH ifi Mill TABLE AA - X300 .640 .570 .500 .440 .400 .350 .310 .275 .250 .205 .165 .130 .102 .077 .061 .047 60 60 60 60 60 40 40 40 40 40 30 30 30 30 30 30 NOMINAL* OUTSIDE DIAM, tin.) WEIGHT IN Lb*. M ft. STANDARD SHIPPING LENGTHS (W) Ceils RmI. CONSTRUCTION SPECIFICATIONS .850 800 .780 650 .710 530 .650 430 .610 350 .520 270 .480 210 .445 175 .420 135 .375 120 .305 75 500 .270 55 500 .242 38 500 .217 28 500 .201 24 500 .187 20 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 4/0 3/0 2/0. 1/0 1 2 3 4 5 6 8 TO 12 14 16 18 259/.0286 259/.0255 259/ 0227 259/.0202 259/.0180 133/.0223 133/.0199 133/.0177 133/.0158 133/.0140 ,133/.0111 105/.010 65/.010 41/.010 26/.010 16/.010 TABLE AA - S300 .600 .536 .477 .424 .378 .336 .299 .266 .237 .212 .168 .120 .095 .075 .059 .045 60 60 60 60 60 40 40 40 40 40 30 30 30 30 30 30 CONSTRUCTION SPECIFICATIONS .810 .746 .687 .634 .588 .506 .469 .436 .407 .382 .308 .260 .235 .215 .199 .185 790 640 520 420 340 260 200 175 125 110 70 50 35 26 22 18 500 500 500 500 500 500 To'oo 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 * Finished Diameters are average and are subject to a plus or minus 5% toleronce. FOR FASTEST SERVICE PHONE 'OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00221 !6 APPARATUS OR MOTOR LEAD CABLE TYPE ve 600 and 3000 VOLT SERVICE AVAILABLE SIZES: lfi to 4/0 AWG inclusive i P. I B Stranded tinned copper, varnished glass tape, lacquered plots or nylon braid*. Standard color: white. USES--For open or in conduit u*e where resistance to moisture, heot, grease, oil, petroleum solvents is desired. Used as leads on electric motors in oil refineries, as well as other important appli cations. Motor Lead, Type VG, is insulated with varnished glass tape that meets the Al, standard classification for Class "B", (130'C) insulated material. IS (RAID INSULATION STRANDED CONDUCTOR i'11 AWG r Stranding Welt Thickncn NOWWAl 0.0. (INCHES) VG Top* IMilt) _________ Cl Erqid___________ Nylen Eraid Shipping Weight Ibt. M Feet TABLE VG - X600 CONSTRUCTION SPECIFICATIONS 18 16/.010 47 .160 16 26/.010 47 .174 14 41/.010 47 .190 12 65/.010 47 .210 10 105/.010 47 .235 8 133/.0111 47 .298 6 133/.014 63 .374 4 133/.0177 63 .430 3 133/.0199 63 .461 2 133 .0223 63 .498 1 259/.018 78 .570 1/0 259/.0202 78 .616 2/0 259/.0227 78 .669 3/0 259/.0255 78 .728 4/0 259/.0286 78 .792 .155 .169 .185 .205 .230 .288 .364 .420 .451 .488 .560 .606 ,659 .718 .782 13 19 27 36 50 72 118 174 200 259 330 405 500 615 760 TABLE VG - X3000 CONSTRUCTION SPECIFICATIONS 10 8 6 4 3 2 1 1/0 2/0 3/0 4/0 10S/.0W 133/.om 133 .014 133. .0177 133 '.0199 133 .0223 259 .018 259 .0202 259 .0227 259/.0255 259 .0286 94 " 94 94 94 94 94 94 94 94 94 94 .344 .392 .436 .490 .523 .560 .602 .648 .701 .760 .824 .334 .382 .426 .480 .513 .550 .592 .638 .691 .750 .814 65 88 141 191 220 279 355 430 525 645 785 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB Q0222 CONTINENTAL WIRE arnoi ON 17 Solid or stranded conductor of coppor, nickel, monel, or nickel dad copper, oibtttoi insulation, giost braid. Silicone impregno* tion and finish. USES--Wiring motors, infra-red ovens, ovens, furnace* or other apparatus where extreme high temperature may be encountered. APPROVED BY--Underwriters' Laboratories Incorporated. ' Copper is recommended for operation at 150C maximum, where individual strand diameter is less than .015. inches. ; ' V-w&figBnpi : HIGH TEMPERATURE j POWER CABLE ii 300 VOLT SERVICE g 200 C (302* F) MAXIMUM OP. i ERATING TEMPERATURE* ' AVAILABLE SITES: IB to 4/0 : AWG indusive :w SOLID OS STRANDED CONDUCTOR FELTED ASBESTOS SILICONE VARNISH CLASS TARN BRAID SILICONE VARNISH SOLID CONDUCTOR TABLE ACS - 300 CONSTRUCTION SPECIFICATIONS Six* AWG 4/0 AWG 3/0 2/0 1/0 1 2 3 4 5 6 8 10 12 14 16 18 CONDUCTOt .460 .410 .365 .325 .289 .258 .229 .204 .182 .162 .128 .102 .081 .064 .051 .040 INSULATION Atbttlci WbH in NUt> 90 90 90 90 90 60 60 60 60 60 40 40 40 40 40 40 NOMINAL* OUTSIDE WAM. tin.) .670 .620 .575 .535 .499 .408 .379 .354 .332 .312 .238 .212 .191 .174 .161 .150 WEIGHT IN LBS. M ft. 850 740 630 460 390 290 250 200 170 140 90 60 45 40 35 30 STANDARD SHIPPING LENGTHS (fwtj Cailc R**Jf 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 500 500 500 500 500 1,000 1,000 1,000 1,000 1,000 1,000 1,000 STRANDED CONDUCTOR TABLE AGS - S300 CONSTRUCTION SPECIFICATIONS CONDUCTOR Six* AWG Stfond - Caar-- Fhxiblit 4/0 AWG 19/.1055 259/.0286 3/0 19/.094 259/.0255 2/0 T9/.0837 259/.0277 1/0 19/.0745 259/.0202 1 19/.0664 259/.018 2 7/.0974 133/.0223 3 7/.0867 133/.0199 4 7/.0772 133/.0177 5 7/.0688 133/.01 $8 6 7/.0612 133/.0141 8 7/.0486 133/.0111 10 7/.0385 104/.010 12 7/.0305 65/.010 14 7/.0242 41/.010 16 7/.0192 26/.010 18 7/.0152 16/.010 Bar* Oiam. (i.) .528 .470 .419 .373 .332 ,292 .260 .232 ,206 ,.184 .146 .116 .092 .073 ,.058 .045 INSULATION NOMlNALt Atlmtot OUTSIDE Walt* in Mils D1AM, fin.) 90 .738 90 .680 90 .629 90 .583 90 .542 60 .442 60 .410 60 .382 60 .356 60 .334 40 .256 40 .226 40 .202 40 .183 40 .168 40 .155 WEIGHT IN Lt$. M Ft. 870 755 640 470 400 300 270 210 180 145 95 75 50 45 40 34 STANDARD SHIPPING LENGTHS (fnt) CaiU &%*u 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 1,000 500 1,000 1,000 500 1,000 500 500 500 1,000 1,000 1,000 500 1,000 t Finished diameters are average and are subject to a plus or minus 5% tolerance. X Flexible strand cannot be furnished with copper conductor on sizes smaller than 5 AWG, if UL fisting is required. RBB 00223 '.8 CONTINENTAL WIRE COR * SWITCHBOARD WIRE and HINGE CABLE TYPE AVB 600 VOLT SERVICE AVAILABLE SIZES 8 to 18 AWG inclusive Tinned copper conductor insulated with varnished cambric tape, asbestos and a cotton braid. Finish is flame retarding paint. The standard color is gray. USES--Wiring of switchboards and apparatus where resistance to flame, heat and oil may be required. The maximum operating temperature is 90 C (194 F). APPROVED BY--Underwriters' Laboratories, Incorporated. CONFORMS TO-N. E. Code Standard ond NEMA Stondard WC11955. (Sizes 16 and 18 hinge wire not listed in N. E. Code Standard.) 3 COTICN UU.lt) AiSSTOS INSUlAttON VASNlSHft) CAMS*;: $0110 Olt tAPE SIRANOSJ C0PPE3 (lUgsuAtiON shows construction fo types Avseoo Ant> avs.woo only TABLE AVB * 600 CONSTRUCTION SPECIFICATIONS i Silt AWG 8 10 12 14 16 18 8 10 12 14 16 18 Dio, Bor* Wir* In In. 128 .102 .081 .064 .051 .040 Stranding -- -- -- -- -- - Wall of Intularion (In Mils)* v,c. Aibitfos 30 20 30 20 30 20 30 20 30 20 30 20 fcrc'rd 17 17 16 16 16 16 OuMdv Dia. In In.t .260 .235 .215 .195 .185 .170 w. In Lbi M f**r 85 62 47 35 30 26 TABLE AVB - S600 CONSTRUCTION SPECIFICATIONS .146 .116 .092 .073 .058 .045 7/.0486 7/.0385 7/-0305 7/-0242 7/-0192 7 '.0152 30 20 17 .280 90 30 20 17 .250 66 30 20 16 .225 50 30 20 16 .205 37 30 20 16 .190 31 30 20 16 ,175 26 HINGE WIRE TABLE AVB - X60Q CONSTRUCTION SPECIFICATIONS Standard ftiC 500 500 500 500 500 500 500 500 500 500 500 500 Sizt AWG 8 10 12 14 16 18 Dia. 6or* Wit* In In. .157 .120 .095 .075 .059 .045 Stranding i68'.oio 105 -010 65 .010 41/.010 26-.010 16,-.010 Wall c# Iftiutation (In Mil*)' Asb*itot v.c. Asb*toi 10 30 15 10 30 15 10 30 15 10 30 15 10 30 15 IQ 30 15 Braid 17 17 17 16 16 16 In ln.+ .300 ,265 .240 .215 .200 .185 " These are minimum walls. * The finished diameiers are subject to a manufacturing tolerance plus or minus 5TL. ; Long Lengths can be furnished on non-returnable plywood reels. Wt. In lbi P*r M Fa*t 92 66 46 37 30 25 Colt lf> 500 500 500 500 500 500 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00224 CONTINENTAL WIRE CORPORATION 19 Tinned copper conductor inwloted with thermoplastic, asbestos and a cotton braid. The finish has flame retarding character istics. The standard color it gray, but other colors such at black, white, red, etc., can be supplied if desired. USES--Wiring switchboards and other apparatus where resistance to oil, flame and heat up to a maximum of 90 C (194 f) may be needed. APPROVED BY--Underwriters Laboratories, Incorporated. CONFORMS TO-N. E. Code Stondard and NEMA Standard WC11955. (Sizes 14 and larger.) SWITCHBOARD WIRE TYPE TA 600 VOLT SERVICE AVAILABLE SIZES: 18 AWC to 500 MCM inclusive SOLID OR STRANDED THERMOPLASTIC CONDUCTOR INSULATION ASBESTOS COTTON BRaid SOLID CONDUCTOR TABLE TA - 600 CONSTRUCTION SPECIFICATIONS $i AWC 4 6 8 10 12 14 16 18 StrdlW* -- -- -- -- '- -- -- - Vinyl 30 30 20 20 20 20 20 20 TH'CKNESS IN MILS* Atbtttos Braid 25 18 25 18 20 17 20 16 20 16 20 16 20 16 20 16 Outside Diem. In Inchest .360 .315 .250 .220 .200 .185 .170 .160 Wt, Lbs. p*r 1000 Ft. 200 140 80 60 40 35 32 27 STANDARD PACK Coil Reel _ 500' _ 500 500' 1000 500 500 500 1000 2000 2000 500 2500 500 2500 STRANDED CONDUCTOR TABLE TA - S600 CONSTRUCTION SPECIFICATIONS 4/0 19 40 30 20 3/0 19 40 30 20 2/0 19 40 30 20 1/0 19 40 30 20 1 19 40 30 20 2 7 30 25 20 4 7 30 25 20 6 7 30 25 18 8 7 20 20 18 10 7 20 20 16 12 7 20 20 16 14 7 20 20 16 16 7 20 20 16 18 7 20 20 16 .710 .655 .600 .560 .520 .450 .390 .340 .270 .240 .210 .190 .180 .170 920 750 620 500 400 310 210 150 90 65 45 38 35 30 -- -- -- -- -- -- _ _ 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1000 1000 2000 2000 2500 2500 * These are minimum walls. t The finished diameters ore subject to a manufacturing tolerance plus or minus 5%. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00225  CONTINENTAL WIRE CORPORATION % Flexible tinned copper conductor insulated with thermoplastic, as bestos and a cotton braid. The finish has flame retarding char acteristics. The standard color is gray, but other colors such as black, white, red, ate., can be supplied if desired. USES--Wiring swinging panel*, switchboards ond other appara tus where resistance to oil, flame and heat up to a maximum of 90'' C (194tr F) may be needed, APPROVED SY--Underwriters laboratories. Incorporated. CONFORMS TO--N. E. Cede Standard and NEMA Standard WC11955. (Sizes 14 through 4/0 only.) Cl:. COTTON BRAID OtAT FLAME. RE5I5TANT FINISH FELTED ASBESTOS thermoplastic INSULATION flexible stranded COATED COfPER CONDUCTOR f TABLE TA - X60Q CONSTRUCTION SPECIFICATIONS AWG 750 500 350 250 40 20 10 1 2 4 6 8 10 12 14 16 Strands 703 427 427 427 259 259 259 259 133 133 133 133 105 65 41 26 FLEXIBLE STRANDED CONDUCTOR THICKNESS IN IMIS" Vinyl Aibitoi 75 50 50 50 40 40 40 40 30 30 30 20 20 20 20 20 40 40 40 40 30 30 30 30 25 25 25 20 20 20 20 20 Braid 25 25 25 25 20 20 20 20 20 20 20 17.5 17.5 16 16 16 Outbid* Diam. In ln<h*|T 1.403 . 1.171 1.018 .901 .799 .673 .620 .559 .498 .425 .366 .290 .250 .220 .200 .185 Vft, Lb*. P*r 1000 Ft. 3282 2228 1586 1173 945 640 520 420 340 228 156 92 66 46. 37 30 * These are minimum waJU. 1 The finished diameters ore subject to a manufacturing tolerance plus or minus 514. standard rack . Ceil >Hf -- -* -- -- -- -- -- -- -- 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 500 1000 1000 2000 2000 2500 FOR FASTEST SERVICE % PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00226 TAL WIRE CORPORATION 21 Tinned or bare copper* conductor, paper separator, thermo plastic insulated, cotton braid, finished with gray, flame-resistant paint. Other colors available on request. USES--Wiring switchboards, and all other types of control ap paratus. Resists heat, moisture, flome, oil and corrosive vapors. APPROVED BY--Underwriters Laboratories, Incorporated. Maximum temperature rating 90C (194F) SOHO OR STRANDED CONDUCTOR PAPER SEPARATOR THERMOPLASTIC INSULATION COTTON MAID GRAY, 'IAME~RE$I$TANT FINISH SOLID CONDUCTOR TABLE TBS * 600 CONSTRUCTION SPECIFICATIONS Sii* AWG 14 12 10 8 6 Thtrnioplattic Wall in 64thi Nominal O.O. i 2 .160 i 2 .180 i 2 .200 l 3 .260 i 4 .330 Ship. Wt. Jbi./iM' 24 33 47 78 121 Standard Pock Ceili FmI 500' 500 500 500 500 STRANDED CONDUCTOR TABLE TBS - S600 CONSTRUCTION SPECIFICATIONS 14 7 2 .170 25 500 12 7 2 .190 34 500 10 7 2 .210 49 500 8 7 3 .280 81 500 6 7 4 .350 129 500 HINGE WIRE TABLE TBS - X600 CONSTRUCTION SPECIFICATIONS 14 41 2 .180 25 500 12 65 2 .190 35 500 10 105 2 .220 50 500 8 133 3 .300 88 500 6 133 4 .360 133 500 * Aluminum conductor mcy be substituted. Minimum guage size #12 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COiony 9-1421 RBB 00227 NAVY SWITCHBOARD WIRE TYPE SHFS 600 VOLT SERVICE AVAILABLE SIZES: SHFS 1 to SHFS 100 inclusive WIRE CORPORATION Bare copper, polyvinyl iniulation, asbestos, cotton or rayon braid, pray finish. (Available in other colors.) OSES--For use on switchboards and simiior equipment for U. S. Navy, CONFORMS TO--Specification MIL-C-915A (Ships). t TYPE SHFS CONSTRUCTION SPECIFICATIONS Six* SHFS Strand Approx. AWC Aroo in Circular Milt THICKNESS IN MI1.S Polyvrnyl A*b*itot ftroid O.D.* In lnch*t Shipping Wl. lb*. M ft. i 10/.010 20 1005 VA 41 /.0063 18 1630 2 Vi 26/.010 16 2613 3 19/.0126 15 3036 4 7/.0253 14 4497 6 7/.0305 12 6512 9 7.'.03 59 11 9016 14 140'.010 9 14070 26 7/7/.0234 6 26250 42 7 7, .0305 4 41740 66 19 7 .0226 2 66370 100 61 .0403 1/0 99060 15 17.5 7.5 15 17.5 7.5 15 15.0 7.5 15 20.0 7.5 20 20.0 15.0 25 20.0 15.0 30 17.5 17.5 30 17.5 17.5 30 22.5 17.5 32 22.5 20.0 37 22.5 20.0 37 25.0 20.0 .120 .135 .140 .155 .190 .213 2A1 .278 .358 .415 .495 .533 13 17 22 25 36 48 62 88 152 234 336 458 * Since these wires are made to conform with minimum ond maximum diameter requirements of specification MSI-C-915A, oil diameters shown, are nominal. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00228 CONTINENTAL WIRE CORPORATION PLAIN FIXTURE WIRE--Solid or Stranded copper, flame, heat, and moisture-resistant asbestos insulation. BRAIDED FIXTURE WIRE--Solid or stranded copper, flame, heat, and moisture-resistant asbestos insulation with cotton or rayon braid. USES--Wiring all types of commercial and industrial fixtures de signed for interior illumination: incandescent lamp fixtures, fluo rescent lamp fixtures, sun lamps, therapeutic devices, and show case lighting. Also ideal for wiring high-wattage unils where socket temperature exceeds 90C (194F), Standard colors for plain type are black and white. Other colors can be obtained on request (at no extro cost in quantities of 1,000 feet or more). The braided type may be obtained in royon or cotton with or with out tracer. All colors based on NEMA color specifications are available. APPROVED BY--Underwriters Laboratories Incorporated. CONFORMS TO--N. E. Code Standard and NEMA Standard WC 1-1955 FIXTURE WIRE TYPE AF 300 VOLT SERVICE 15$C (302F) SOLID OR STRANDED COPPER ACETATE SOLID OR STRANDED COPPER ACETATE ASBESTOS HEAT AND MOISTURE RESISTANT ASBESTOS INSULATION COTTON, GLASS OR RAYON BRAID TYPE AF CONSTRUCTION SPECIFICATIONS : AWC .. 10 12 14 16 18 Stranding ' " -- D1A- BAM WISE IN IN. WALL IN MILS OUTSIDE* DIAMETER PLAIN outside* DIAMETER braided WT. IN US. STANDARD PACKAGE PER IN FEET M FEET Smell Spool Largfl Spool SOLID COPPER - TABLE AF-P - TABLE AF-B .102 47 .196 .226 41 500 1000 .081 47 .175 .205 27 500 1000 .064 32 .128 .158 19 500 2000 .051 32 .115 .145 13 500 2500 .040 32 .104 .134 10 500 2500 STRANDED COPPER - TABLE AF-SP - TABLE AF-SB 10 105/30 .123 47 .217 .247 44 500 1000 12 65/30 .097 47 .191 .221 30 500 1000 14 41/30 .077 32 .141 .171 20 500 2000 16 26/30 .059 32 .123 .153 14 500 2500 18 16/30 .047 32 .111 .141 10 500 2500 * Subject to plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00229 CONTINENTAL WIRE CORPORATION*&*'.* FLEXIBLE CORDS TYPES AFC, AFPD, AFPO 300 VOLT SERVICE Flexible stranded copper conductors, heat, flame and moisture resistant asbestos insulation, asbestos, cotton or rayon braid. Up AFC - AFPD ASBESTOS INSULATION STRANDED COPPER CONDUCTOR* ASBESTOS COTTON OR RATON BRAID AFPO ASBESTOS INSULATION STRANDED COPPER CONDUCTORS A5SE5TOS COTTON OB BATON BRAID ASBESTOS INSULATION STRANDED COMER CONDUCTORS USES--Lighting fixtures, range lights, permanent wave machines, and small spotlights. These cords are made with multiple con ductors of type Af fixture wire. The standard strandings use No. 30 AWG copper. For extra flexible stranded conductors No. 34 AWG copper is employed. Types AFC and AFPD cords can be made with three conductors if desired. APPROVED BY--Underwriters Laboratories Incorporated. CONFORMS TO-N. E. Code Standard and NEMA Standard 48 131. TYPE AFC--Two cotton or rayon braided type AF conductors twill ed together. . Cotton -- Toble AFC-2C Rayon -- Table AFC-2R TYPE AFPD--Two conductors of plain type AF wire twisted and a braid of cotton or rayon overall. Cotton - Table AFPD-2C Rayon -- Table AFPD-2R TYPE AFPO--Two conductors of type AF wire in poraliel with cot ton or royon braid overall. Cotton - Table AFPO-C Rayon -- Toble AFPO-R NOTE: For all tables referred to here, see next page FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COtony 9-1421 RBB 00230 CONTINENTAL WIRE CORPORATION SPECIFICATIONS FOR FLEXIBLE CORDS TYPES AFC, AFPD, AFPO Sill AWG Fltxibl* STRANDING Extra fiiublt OUTSIDE DIAMETE* IN INCHES* Cotton Droid Rayon Braid Standard Wiight In Lbi. Ceil PM Ft. TYPE AFC - TWO PLAIN CONDUCTORS EACH BRAIDED AND TWISTED TOGETHER Cotton -Table AFC-2C Rayon-Table AFC-2R 10 105/30 12 65/30 14 41/30 16 26/30 18 16/30 261/34 164/34 105/34 65/34 41/34 .495 .445 .345 .315 .290 .465 .415 .315 .280 .255 250 88 250 59 250 40 250 31 250 24 TYPE AFPD - TWO PLAIN CONDUCTORS TWISTED TOGETHER WITH BRAID OVERALL Cotton -Table AFPD-2C Rayon-Table AFPD-2R 10 105/30 12 65/30 14 41/30 16 26/30 18 16/30 261/34 164/34 105/34 65/34 41/34 .465 .415 .315 .280 .255 .450 .400 .300 .265 .240 250 87 250 58 250 40 250 30 250 23 TYPE AFPO - TWO PLAIN CONDUCTORS IN PARALLEL WITH BRAID OVERALL Cotton - Table AFPO-2C Royon -- Table AFPO-2R 10 105/30 12 65/30 14 41/30 16 26/30 18 16/30 _ _ -- -- - .220* .407 .202 * .389 250 85 .194* .355 .176*.337 250 57 .174 x .315 .156 *.297 250 39 .166 x .279 ,138 x .261 250 29 .144 x .255 .126 * .237 250 21 TYPE AFPD - TWO PLAIN CONDUCTORS - ASBESTOS BRAID-TABLE AFPD-A Six* AWG 10 12 14 16 18 Stranding 105/30 65/30 41/30 26/30 16/30 Dip. Bor* Wire Irv Inchit .123 .095 .075 .059 .045 Well In Mill 47 47 32 32 32 Braid In Mill 45 45 45 45 45 O.O. In lachtt* .525 .475 .375 .340 .315 Standard Ceil 250 500 500 500 500 WtigKi In lb*. P#r M Ft. 120 85 63 50 40 TYPE AFPO - TWO PLAIN CONDUCTORS IN PARALLEL - ASBESTOS BRAID - TABLE AFPO-A 10 105/30 .123 47 45 .307 x .525 250 120 12 65/30 .095 47 45 .281 x .475 500 85 14 41/30 .075 32 45 .231 x .372 500 63 16 26/30 .059 32 45 .213 x .336 500 50 18 16/30 .045 32 45 .201 x .312 500 40 * Subject to plus or minus 5% tolerance. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00231 :} CONTINENTAL WIRE CORPORATION 111 1 APPLIANCE HINGE WIRE TYPES A and AG 300 VOLT SERVICE AVAILABLE SIZES: IS and 16 APPLIANCE LEAD WIRE TYPE AG 300 VOLT SERVICE '^1 AVAILABLE SIZES: 18 to 8 in- elusive APPLIANCE HINGE WIRE--Type A - Extra flexible nickel conductor, smokeless asbestos insulation. APPLIANCE HINGE WIRE--Type A Extra flexible nickel conductor, smokeless asbestos insulation. Type AG--Similar to type A Hinge Wire except treated glass braid over primary insulation. USES--Type A - Connecting the upper and lower healing surfoces of waffle irons, or sandwich grills. The wire has the flexibility and abrasion resistance required for this use, and smoking is re duced to a minimum. Type AG--Some as Type A, especially for high grade or heavy duty appliances. APPLIANCE LEAD WIRE--Type AG-Solid or Stranded, copper or nickel conductor, USES--For small motor leads or appliances. Maximum operating temperature is 200C (392F). Copper is recommended for operation ot 150C maximum where indi vidual strand diameter is less than .015 inches. AWG Six* 18 16 Strand 41 34 65. 34 Diamttar of ftar* Wirt r Jnchtt .048 .060 Atbvt'Ot Well in Inchai .032 .032 Nam'maf O.D.* Inch** .112 .124 Standard Span! 2500' 2500' TABLE AG-XN CONSTRUCTION SPECIFICATIONS 18 41 34 .048 .027 .005 .112 2500' 16 65 34 .060 .027 .005 .124 2500' TABLE AG SOLID CONSTRUCTION SPECIFICATIONS 18 1 .040 .027 .005 .104 2500' 16 1 .051 .027 .005 .115 250C U 1 .064 .027 .005 .128 , 2500' 12 1 .081 .027 .005 .145 1000' 10 1 .102 .027 .005 .166 1000' 8 1 .128 .027 .005 .192 1000- TABLE AG STRANDED CONSTRUCTION SPECIFICATIONS 18 16 30 .048 .027 ,005 .112 2500' 16 26 30 .060 .027 .005 .124 2500' 14 41 30 .078 .027 .005 .142 . 2000' 12 65 30 .101 .027 .005 .165 1000' 10 105 30 .126 .027 .005 .190 1000' 8 165 30 .157 .027 .005 .221 1000' IDENTIFYING - TABLE APPLIANCE LEAD WIRE COPPER NICKEl SOLID AG-C AG-N Subject to a plus or minus 5o due to variations in manufacturing process. STMNDEO AG-SC AG-SN W*i0hr IbiVM' 12 16 11 14 10 12 18 25 38 64 11 14 19 28 42 66 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlotty 9-1421 RBB 00232 CONTINENTAL, WIRE CORPORATION Solid and stranded conductors of copper or nickel covered with .032" or .040" wall of asbestos insulation. USES--Type A - Wiring space heaters, toasters, waffle irons, and similar appliances. Type Al - Wiring electric clothes dryers, ironers, sterilizers, water heaters, etc., where resistance to both heat and moisture is necessary. CONFORMS TO--NEC Code Standard (copper only) Sizes 14 thru 8. Meets ASA CB.36-1955 and NEMA Standard WC1-1955 (copper only). APPROVED BY--Underwriters Laboratories, Inc. (copper only) Sizes 14 thru 8 on items annotated UL. Type A - Maximum operating temperature 200'C (392'F). Cop per is recommended for operation ot 150'C maximum, where individual strand diameter is less than .015 inches. Type Al - Maximum operating temperature 125 C (275 F). APPLIANCE LEAD WIRE TYPES A and Al 300 VOLT SERVICE AVAILABLE SIZES: 20 to 10 AWG inclusive SOHO Ot STtANDEC cotttt rELTED A5SESTOS CONSTRUCTION SPECIFICATIONS Size AWG Dio. bon Wire In Inches Strand Qvttide Diameter* Jn Inches .032" .040" Standard Spool* Weight In lbs, far M Feet .M2" ,0*0" SOLID CONDUCTOR 3 .128 1 .192 .208 UL 1000 72 76 10 .102 1 .166 .182 UL 1000 40 43 12 .081 1 .145 .161 UL 1000 27 30 14 .064 1 .128 UL .1 44 UL 2000 19 21 14 .051 1 .115 .131 2500 13 15 18 .040 1 .104 .120 2500 10 12 20 .032 1 .096 .112 2500 7 9 STRANDED CONDUCTOR 8 .157 165 30 10 .120 105-30 12 .095 65 30 14 .075 41/30 16 .059 26/30 18 .045 16/30 20 .040 10/30 * Subject to plus or m inus 5% tolerance. .221 .237 UL 1000 76 81 .134 .200 UL 1000 43 46 .159 .175 UL 1000 29 31 .139 UL .155 UL 2000 20 22 .123 .139 2500 14 16 .109 .125 2500 10 12 .104 .120 2500 8 10 X long lengths can be supplied on non-returnable plywood reels. IDENTIFYING TABLE APPLIANCE LEAD WIRE TYPE A COPPER NICKEL TYPE Al COPPER NICKEL .032" WAU SOLID A-C32 A-N32 STRANDED A-SC32 A-SN32 AI-C32 A1-N32 A1-SC32 AI-SN32 .040" WAU SOLID A-C40 A-N40 STRANDED A-SC40 A-SN40 AI-C40 AJ-N40 AI-SC40 AI-SN40 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00233 CONTINENTALWIREiCORPORATIONffe ELECTRIC RANGE WIRE TYPE Al 300 VOLT SERVICE Vassal Solid or stranded copper conductor, acetate tape, impregnated aibtttot, .033" or .043" watt of insulation. CONFORMS TO-N.E. Code Standard and NEMA Standard WC1 1955. APPROVED BY--Underwriters laboratories Inc., sizes 14 thru 8 On items annotated UL. RECOMMENDED FOR--Wiring of electric ranges, water heaters, clothes dryers, and ironert. The .033" wall is standard but some customers hove a preference for .043" insulation wall. The ace tate tape increases the dielectric strength and moisture resistance The compound used to impregnate the asbestos wall is resistant to flame, heat and moisture. The standard colors are block, white, red, green, blue, gray and yellow. 125'C (257"?) Maximum operating temperature. fELTEO ASSKTOS ACETATE TAPE COPPER CONDUCTOR CONSTRUCTION SPECIFICATIONS Sil* AWG Dia, tar* Wirt In in. Stranding OUTSIDE OIAMETEA IK IN.* .033" WALL .043" WALL Standard Spool'* Woight In ibi. Per M Fa*f .033" .043" SOLID CONDUCTOR Table AI-T33 Table AI-T43 10 .102 12 .081 14 .064 16 .051 18 .040 -- -- - .168 .188 Ul 1000 40 43 .147 .167 UL 1000 27 30 .130 UL .150 UL 2000 19 21 .117 .137 2500 13 15 .106 .128 2500 10 12 STRANDED CONDUCTOR Table AI-ST33 Table A1-ST43 10 .120 105,30 .186 .206 UL 1000 44 47 12 .095 65 30 .161 .181 UL T 000 30 32 14 .075 41 '30 .141 UL .161 UL 2000 20 22 16 .059 26'30 .125 .145 2500 14 16 18 .045 16 30 .111 .131 2500 to 12 GROUNDING WIRE - TABLE AI-S15 The Notional Electrical Code requires grounding the metallic ports of electric ranges. This wire is made with o wall of .015" asbestos and green compound. Site 14 Diameter Aar# Wire .073 Strand 7 .0242 Otihidt PiouHtir .105" Standard Spools 2500 Wt. In Ibi, Par M Ft. 16 * Subject to plus or minus 5% tolerance. ** long Lengths con be supplied on non-returnable ply wood reels. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00234 CONTINENTAL WIRE CORPORATION* Solid or stranded copper, synthetic tapes, felted asbestos, lacquered braid- USES--Originally designed for military applications this wire has found use wherever small diameter, easy stripping, non-flowing insulation and high dielectric characteristics are important. It is resistant to cold, heat, moisture, flame, grease, and oil. AHG-1000 and AHG-300 types, both solid and stranded, are approved by Underwriters Laboratories Inc., in the sizes listed. APPLIANCE AND MOTOR LEAD TYPES AHG and AHC 300 and 1000 VOLT SERVICE AVAILABLE SIZES: 26 to 4 in clusive (AHG-1000) AVAILABLE SIZES: 26 to 16 in clusive (AHG-300) AVAILABLE SIZES: 14 and 12 (AHC-ML1000) SOLID OR STRANDED COPPER SINIMEIIC TAPES PELTED AStESTOS CONSTRUCTION SPECIFICATIONS LACQUERED SRAID TABLE AHG-1000 (STRANDED OR SOLID BARE COPPER) AWC Six* 26 24 22 20 18 16 14 12 10 S 6 4 Solid 1 1 1 1 1 1 1 1 T 1 1 1 Strondtd 7, .0063 7 .008 7 .010 10, .010 16, .010 26 .010 41,.010 65/.010 105A010 3 33/.0 111 133A014 T33/.0177 NOM. WALL THICKNESS (MILS) Top* Atbltloi Glofi ftraid* 68 685 685 685 985 98S 13 9 5 13 9 5 13 9 5 16 9 5 16 9 5 16 9 5 NOM. O.Da Solid Sirondtd .054 .057 .058 .062 .063 .070 .068 .076 .084 .092 .095 .118 .104 .132 .135 .155 .156 .188 .222 .180 .217 .262 .264 .332 WT. L&S./M' Solid Strand*d 2.3 2.5 2.9 3.2 3.8 4.2 5.2 5.4 7.8 8.2 11.3 11.9 17.5 183 26.0 27.0 38.5 40.7 59.4 64.1 91.0 99.7 140.0 153.4 TABLE AHG-300 (SOLID OR STRANDED, TINNED OR BARE! COPPER) Sienderd Pack F**+ 500 500 500 500 500 500 500 500 500 500 500 500 26 1 24 1 22 1 20 1 18 1 16 1 7/.0063 7/.008 7/.010 10/.010 16/.010 26/.010 6 10 5 .058 .061 6 10 5 .062 .066 6 10 5 .067 .072 6 10 5 .074 .080 6 10 5 .082 .090 6 10 5 .093 .102 2.5 3.1 4.1 5.5 7.7 11.1 2.7 3.5 4.5 5.7 8.1 11.8 " 500 500 500 500 500 500 TABLE AHC-ML1000 (STRANDED TINNED COPPER) 14 19/.0142 10 20 12.5 .156 12 19A0179 10 20 12.5 .175 28.0 36.0 500 500 * Rayon or Cotton Braids available on Request. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00235 CONTINENTAL WIRE CORPORATION- ELECTRIC STOVE WIRE TYPES AA and AIA 300 VOLT SERVICE AVAILABLE SIZES: 18 to 8 AWG Solid or stranded conductors of copper or nickel, heat and flame resistant asbestos insulation, asbestos braid. USES--Type AA - Wiring commercial type electric grills and ranges, space heaters, and other heavy duty electrical heating devices. Type AIA - Wiring bake ovens, commercial electric ranges, and water heaters. APPROVED BY--Underwriters Laboratories Incorporated. CONFORMS TO--N, E. Code Standard and NEMA Standard WC1 1955 (Sizes 16 and 18 not listed in N. E. Code Standard). Type AA - Asbestos insulation is treated with smokeless com pounds. The maximum operating temperature is 200'C {391 F;. Nickel is recommended for higher temperatures. Type AIA - Primary asbestos insulation is impregnoted with heat, flame, and moisture resistant compound. Maximum operating temperature is 125C (257F). ASSESTOS SCAID ASSESTOS INSULATION SOHO OK StKANOfP CONDUCTO* CONSTRUCTION SPECIFICATIONS $ixv AWG Stranding Dia. ftar* Wtf* In Inchas Wall In Mil* Braid In Milt OvHid* Diom. In In.* Wt. In lbs. Bar M Fm Standard Coils In F*C i SOLID CONDUCTOR 3 10 -- 12 -- 14 -- 16 -- 18 -- .128 .102 .081 .064 .051 .040 31 31 31 31 31 31 45 .280 75 250 45 .255 49 500 45 .235 35 500 45 .220 26 500 45 .205 21 500 45 .195 16 500 STRANDED CONDUCTOR 8 7 .0486 10 7 .0385 12 7 .0305 14 7 .0242 16 7 .0193 18 7 .0151 , 146 .116 .092 .073 .058 .045 31 31 31 31 31 31 45 .300 73 250 45 .270 50 500 45 .245 36 500 45 .225 28 50Q 45 .210 22 500 45 .200 17 500 ' Subject to plus or minus 5% tolerance, + Long lengths eon be supplied on non-returnable plywood reels. TYPE AA COPPER--Solid--Table AA-C Stranded--Table AA-SC NICKEL--Solid--Table AA-N Stranded--Table AA-SN TYPE AIA Solid--Table AIA-C Stranded--Table AtA-SC Solid--Table AIA-N Stranded--Table AIA-SN FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00236 CONTINENTAL WIRE CORPORATION Solid or stranded copper or nickel conductor, felted asbestos. Can be furnished with overall braid. USES--For wiring sandwich toasters, grills and waffle irons. APPROVED BY--Canadian Standards Association. CONFORMS TO--C.5.A. C22.2 No. 28-1949. A-16a - A-16NC: Maximum operating temperature 200iC (392F). Copper is recommended for operation at 150C maximum, where individual strand diometer is less than .015 inches. A-16b - A-16Nb: Maximum operating lemperature 125'C (257F). CANADIAN APPLIANCE WIRE CSA TYPE A-16 300 VOLT SERVICE AVAILABLE SIZES; 18 to B AWG. CONDUCTOR FELTED ASSESTOS CONSTRUCTION SPECIFICATIONS Siz. AWG Stranding Die. bora Wirt In Inches Wall In Milt SOLID CONDUCTOR O.D.+ In Inches Weight Lb*. M feet Standard Spool 810 12 -- 14 -- 16 -- 18 - .128 47 .220 66 500 .102 47 .200 47 500 .081 47 .175 34 500 .064 47 .160 24 500 .051 40 .135 15 500 .040 40 .120 12 500 STRANDED CONDUCTOR 8 165/.010 .151 47 .245 70 500 10 105/.010 .120 47 .215 51 500 12 65/. 010 .095 47 .190 36 500 14 41/.010 .075 47 .170 25 500 16 26/.010 .059 40 .140 16 500 18 16/.010 .045 40 .125 12 500 * Subject to plus or minus 5% tolerance. . Type A-16a has smokeless or high temperature impregnation of asbestos. Type A-16b designates moisture re sisting impregncnt. When nickel conductor is wanted, specify A-16N with letter "a" or "b" following. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COiony 9-1421 RBB 00237 CONTINENTAL WIRE CORPORATION CANADIAN RANGE WIRE Type CSA A-17 300 VOLT SERVICE AVAILABLE SIZES 18 to B AW inclusive. Solid or stranded topper or nickel conductor, extruded polyvinyl or tapes of varnished cambric, felted asbestos impregnated for resistance to moisture, flame and heat. Can be furnished with overall braid. USES--For the wiring of electric stoves, ranges, and similar appli ances where eonducior temperature does not exceed 100 C(212'"F). APPROVED BY--Canadian Standards Association. CONFORMS TO--C.S.A. C22.2 No. 28-1949. PEUED ASSESTOS V.C. TAPE CONOUCTOt Sir* AWG 8 10 12 14 16 18 8 10 12 14 16 18 Stranding - 7 .0486 7 .0385 7 .0305 7 .0242 7 .0193 7 .0151 CONSTRUCTION SPECIFICATIONS LaN Ota. In Inch** WALL THICKNESS MILS V.C. SOLID CONDUCTOR .128 .102 .081 .064 .051 .040 15 47 15 47 15 47 15 47 10 40 10 40 STRANDED CONDUCTOR .146 .116 .092 .073 .058 .045 15 47 15 47 15 47 15 47 10 40 10 40 0.0. in tactm .250 .225 .205 .185 .150 .140 .270 .240 -215 .195 .155 .145 Weight Lbi, MM Standard Pack 70 250 50 500 35 500 26 500 19 500 15 JQ0 75 52 37 27 20 16 250 500 500 500 500 500 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00238 CONTINENTAL WIRE m Solid or stranded copper or nickel conductor, varnished cambric tope, felted asbestos, asbestos braid impregnated for resistance to moisture, flame and heat. U5ES--For wiring stoves, ranges and similar electrical appliances. APPROVED BY--Canadian Standards Association. CONFORMS TO-C.S.A. C22.2 No. 28-1949. MAXIMUM OPERATING TEMPERATURE: 110''C (230F) CANADIAN STOVE WIRE CSA TYPE A-15 300 VOLT SERVICE AVAILABLE SIZES: >8 to 4 AWG. inclusive. 1. s,;-3Tpijei v.c. t*r asbestos A.&KSTOS SSAIO CONSTRUCTION SPECIFICATIONS Sr AWG 4 6 8 10 12 14 16 . 18 4 6 8 10 12 14 16 18 Stranding _ - -- -- -- -- 7/.0775 7/.0612 7/.0486 7/.0385 7/.0305 7/.0242 7/.0193 7/.0151 Dio. &r Wit (Inch#*) WAU THICKNESS IN MUS v,c. ftroid SOLID CONDUCTOR .204 20 20 .040 .162 20 20 .040 .128 15 15 .040 .102 15 15 .040 .081 15 15 .040 .064 15 15 .040 .051 15 15 .040 .040 15 15 .040 STRANDED CONDUCTOR .232 20 20 .040 .184 20 20 .040 .146 15 15 .040 .116 15 15 .040 .092 15 15 .040 .073 15 15 .040 .058 15 15 .040 .045 15 15 .040 OtD. in Inch#! Wt. Lbi. M F*t Patk .365 ,325 .270 .245 .225 .205 .195 .180 170 118 78 56 42 32 26 22 250 250 500 500 500 500 500 500 .395 .345 .290 .260 .235 .215 .200 .185 177 123 80 60 44 34 27 23 250 250 500 500 500 500 500 500 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00239 34 SILICONE RUBBER APPLIANCE and FIXTURE WIRE 300 AND 600 VOLT SERVICE AVAILABLE SIZES: 22 to 10 AWO inclusive Tinned copper*, extruded silicone rubber, glo braid. USES--Silicone Rubber insulation is recommended for radio ond electronic wiring os well os for appliances where moisture, cold and or heat may be present. * Other metals and alloys may be used where required. APPROVED BY--Underwriters laboratories Inc. All items ap proved as appliance wiring materials. SF and SFF types ap proved as fixture wire. (Tinned, Nickel Plated, or Silver Plated Copper conductor only.) Also approved by Canadian Standards Association for equipment wiring. MAXIMUM OPERATING TEMPERATURE 150 C CONSTRUCTION SPECIFICATIONS TABLES SRG-X300 and SRG-X600 K.E.C. Typ* Duignatien SFF-l SFF-2 SFF-2 SFF-2 C-S.A. Typ* SEWF-l SEWF-1 SEWF-l SEWF-2 5EWF-2 SEWF-2 SEWF-2 SEWF-2 SEWF-2 Six* AWG 22 20 18 22 20 18 16 14 12 Strand 7/.010 10/.010 16/.010 7/.010 10 .010 16-' .010 26 .010 41 .010 65 .010 insulation Wall in 64! hi i i i 2 2 2 2 2 2 Vokag Rating 300 300 300 600 600 600 600 600 600 Inch** 0.0. In .080 .090 .100 .111 .120 .130 .140 .170 .190 Weight in lb* M fHl 5 7 9 8 9 12 16 22 32 Standard Pock In f**r Spools Rcolj 500 500 500 500 500 500 500 500 500 10000 10000 10000 7500 7500 5000 5000 5000 5000 MAXIMUM OPERATING TEMPERATURE 200 C CONSTRUCTION SPECIFICATIONS TABLE SRG-S600 SF-2 SF-2 SF-2 SEW-2 18 7 .0153 2 600 .130 12 500 SEW-2 16 7 .0192 2 600 .140 16 500 SEW-2 14 7 .0242 2 600 .170 22 500 SEW-2 12 19 .0185 2 600 .190 32 500 SEW-2 10 19 .0234 3 600 .230 52 500 500 500 500 500 5000 Standard color of braid is white. Color coding of white background with colored tracers in braid is recom mended. Where necessary solid colors of Black, Red, Gray, Blue, Yellow, Green, Purple and Orange are supplied. ?OR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COtony 9-1421 RBB 00240 CONTINENTAL WIRE CORPORATION Tinned copper, silicone rubber, black asbestos braid, flame and moisture resistant finish. USES--For power circuits in wet or dry locations, exposed or in conduit, to withstand constant high temperatures. Maximum operating temperature 125C. POWER CABLE SILICONE RUBBER ASBESTOS BRAID 600 and 5KV SERVICE AVAILABLE SIZES: 14 AWG to 500 MCM Inclusive STRANDED CONDUCTOR SILICONE ItUIBtE SLACK ASSESTOS BRAID-FLAME AND MOISTURE resistant finish AWG or MCM 14 12 10 8 6 4 2 1 1/0 2/0 3/0 4/0 250 350 500 8 6 4 2 1 1/0 2/0 3/0 4/0 250 350 500 TABLE SRA-S600 SINGLE CONDUCTOR 600 VOLTS Stranding 7 7 7 7 7 7 7 19 19 19 19 19 37 37 37 TABU SRA-S5000 19 19 19 19 19 19 19 19 19 37 37 37 Initiation Wall in 64thi 3 3 3 4 4 4 4 5 5 5 5 5 6 6 6 Aibttiof Braid in MILS 45 45 45 45 45 45 45 45 45 45 45 45 45 45 45 Approx. O.D in Inch** .260 .280 .300 .370 .400 .450 .510 .580 .630 .670 .720 .780 .860 .970 1.100 SINGLE CONDUCTOR 5 KV GROUNDED NEUTRAL 10 45 .560 10 45 .600 10 45 .650 10 45 .710 10 45 .750 TO 45 .790 10 45 .840 10 45 .890 10 45 .950 n 45 1.020 IT 45 1.130 11 45 1.260 Approx. Ship Wt. in Intlm 43 56 74 115 160 230 336 425 525 635 780 975 1150 1560 2150 210 270 340 470 550 645 780 940 1130 1330 1750 2370 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00241 36 CONTINENTAL WIRE CORPORATION SILICONE RUBBER APPARATUS LEADS AIEE-CLASS H 600 VOLT SERVICE AVAILABLE SIZES: 8 to 4/0 inclusive "t'aL.g^auhdr.v.-:, Tinned or nickel dad copper, silkone robber, rilicone varnish treated braid. USES--for high temperature application* where flexibility is re quired, such as leads for motors, transformers etc. Maximum conductor temperature is 200C (392F). Nickel clad copper condoctors are recommended where the conductor temperature exceeds 150'C. SUICONE VARNISH treated braid AWO Sii* 8 6 4 7 1 10 20 30 40 Stranding 37 24 61 24 105 24 150 24 225 24 275 24 375 24 450 24 550 24 TABLE SRA-X600 SINGLE CONDUCTOR Insulation WU in *4ths 4 4 4 4 5 5 5 5 5 Approx. O.D. in Inch#* .360 .400 .490 .550 .640 .700 .730 .770 .870 Nr W, in lbs. ptr M 92 131 203 273 397 481 617 726 881 Ship. Wt. in lbs* ptr M fttt no 157 244 328 476 577 740 871 1057 Srpndofd Hh! Six# 2000 2000 1000 1000 1000 1000 1000 1000 1000 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00242 . CONTINENTAL WIRE CORPORATION 37 USES--For high temperature applications; switch leads, etc. High temperature insulation available with Teflon primary and glass braid or in conjunction with asbestos. Conductors may be Copper, Nickel Clad Copper or Nickel. Recommended operating temperature 200 C (392LF). Informa tion concerning higher temperature rated constructions, available on request. * Dato on larger AWG sizes ovoiloble on request. APPLIANCE WIRE (Teflon) t TYPE TG and TAA SIZES: 18 to 10 AWG inclusive* COPfEt CONDUCtOr INSULATION SltAID Size 18 16 14 12 10 CONSTRUCTION SPECIFICATIONS TYPE TG Strand 16 30 26, 30 41 '30 65 30 105 '30 Teflon Primary Inches .015 .015 .015 .015 .015 Glass Braid Inches .008 .008 .008 .008 .008 Nominal O.O. Inches .093 .106 .123 .143 .166 TYPE TAA Six* 18 16 14 12 10 Strand 16/30 26/30 41/30 65'30 105 30 Tefien Primary Inches .015 .015 .015 .015 .015 Felted Asbestos Inches .020 .020 .020 .020 .020 Asbestos Braid inches .040 .040 .040 .040 .040 Nominal O.O. Inches .197 . .210 .227 .247 .270 tduPont's trade name for Polytetrafluoroethylene, FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9*1421 RBB 00243 38 USES--Interno! wiring of electrical appliances. APPROVED BY--Underwriters' Laboratories, Inc., for 105C in air, 60 or 80 C in oil. Also approved by Canadian Standards Associ ation as type TEW, rated for 105C. i CONSTRUCTION SPECIFICATIONS SiX* AWG 20 18 18 16 16 14 U 12 12 10 10 8 8 Strand 10/.010 solid 16/.010 solid 26/.010 solid 41/.010 solid 65/.010 solid 105/.010 solid 133/.0112 Wall In Mlh* 2 2 2 2 2 2 2 2 2 2 2 3 3 O.D. In inch** .105 .105 .110 .114 .122 .128 .140 .148 .159 .169 .180 .230 .250 N*t Weight Lb*. M F**t 8 9 10 13 14 19 20 28 29 41 43 69 75 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00244 CONTINENTAL, WIRE CORPORATIONS PETROL Stranded bare copper--Thermoplastic Insulation--Nylon Jacket. USES--For wiring gasoline pumps and for use in refineries. APPROVED BY--Underwriters' Laboratories, Incorporated, as TW wire for 60C in air or oil. (18 and 16 approved os appliance wire) Standard Colors: #14 and #12 -- Black, White, Red, Green, Orange #10 to #6-Block, White, Red TYPE TW Stranded bare copper. Thermoplastic insulation, STANDARD COLORS: Sizes 14 to 10--black, white, red, green, blue, yellow, orange, and brown. Size 8 to 2--black, white and red. Size 1 and larger--black. APPROVED BY--Underwriters' Laboratories for SO^C in air. BUILDING WIRE TYPE TW and PETROL 600 VOLT 5ERVICE AVAILABLE SIZES: TW - 14 to 500,000 CM PETROL - 18 to 6 AWG c*4-WU.'--um COPPER CONDUCTOR INSULATION NYLON JACKET -PETROL ONLY Six* AWG 18 16 14 , 12 10 .$ 6 . . $j AWG 14 12 10 8 6 4 2 .. 1 1/0 2/0 ' 3/0 4/0 250 300 350 400 500 GASOLINE AND OIL RESISTANT PETROL CONSTRUCTION SPECIFICATIONS Strand 7 .0153 7 .0192 7 .0242 7 '.0305 7/.0385 7.,0486 7/.0612 Wall In 64thi 2 2 3 3 3 3 4 0.0. In inch** .119 .131 .190 .210 .230 .260 .330 N*t Waight Ibt. M F**t 15 17 30 40 55 76 122 TYPE TW CONSTRUCTION SPECIFICATIONS Strand 7/.0242 7/.0305 7/.0385 7/.0486 7/.0612 7/.0772 7/.0974 19/.0664 19/.0745 19/.0837 19/.0940 19/. 1055 37/.0822 37/.0900 37/.0973 37/.1040 37/.1162 Wail In 64tkt 2 2 2 3 4 4 4 5 5 5 5 .5 6 6 6 6 6 O.D. In lneh .139 .158 .182 .244 .314 .362 .422 .496 .538 .583 .634 ...682 .763 .819 .870 .920 1.00 Nt Weight Lbt. M F**t 21 29 43 71 115 170 256 339 416 514 633 787 914 1084 1267 1415 1750 Standard Pock 500' Coil 500' Coil 500' Coil 500' Coil 500' Coil 500' Coil 500' Coil Standard Pack 500' Coil 500' Coil 500' Coi! 500' Coi! 500' Coil 500' Coil 500' Coil 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel 1000' Reel FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00245 CONTINENTAL WIREk MACHINE TOOL WIRE 600 VOLT SERVICE AVAILABLE SIZES: 18 to 4/0 AWG inclusive Solid or stranded copper, thermoplastic insulation. USES--For control wiring of machine tools. LISTED BY--Underwriter*' Laboratories, Inc., for 80'C or 90cC in air, 60C in oil. Maximum operating temperature, UL Types TF and TFF, 60 C (140F) THESMOPLASTIC INSULATION SAKE COPTER CONOUCTO* CONSTRUCTION SPECIFICATIONS s ULTyp* Six* AWG TF 18 TF 16 14 12 10 8 TFF 18 TFF 16 14 14 12 12 10 10 8 8 8 6 6 6 4 4 4 2 2 2 1 1/0 2/0 3/0 4/0 Strand Solid Solid Solid Solid Solid Solid 16/.010 26/.010 7/.025 19/.0147 7/.0305 19/.0185 7/.0385 19/.0234 7/.0486 19/.0295 49/.0184 7/.0612 19/.0372 49/.0231 7/.0772 19/.0469 61/.0262 7/.0974 19/. 0591 61/.0330 19/.0664 19/.0745 19/.0837 19' .0940 19/.1055 STANDARD 400 VOLT INSULATION . Wan in 44th i 2 2 2 2 2 3 2 2 2 2 2 2 2 2 3 3 3 4 4 4 4 4 4 4 4 4 5 5 5 5 5 Or D. in (nthts .103 .114 .131 .148 .169 .230 .110 .122 .140 .140 .158 .159 .180 .180 .250 .250 .270 .320 .320 .340 .360 .365 .370 .420 .430 .430 .500 .540 .580 .640 .690 Weight tbi. 1000* 9 13 20 28 42 69 10 13 21 21 29 30 43 43 73 80 83 119 119 136 174 188 200 261 276 257 339 416 514 633 787 HEAVY INSULATION 14 Solid 3 .161 23 14 7/.025 3 .168 25 14 19/0147 3 .169 25 12 Solid 3 .178 32 12 7/.0305 3 .184 35 12 19/.0T85 3 .184 35 10 Solid 3 .199 45 10 7/.0385 3 .222 50 10 19/0234 3 .222 50 8 Solid 4 .258 74 8 7 .0486 4 .278 80 8 19 .0295 4 .278 80 Standard Colors: Sizes 18 to 10 AWG -- Black, White, Red, Green, Blue, Yellow, Orange, Brown. 8 to 2 AWG -- Black, White, Red. 1 and Larger -- Block FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00246 CONTINENTAL WIRE CORPORATION Stranded copper, polyvinyl insulation, jute filler*, tape, polyvinyl jacket. USES--Designed for flexible branch circuits from overhead low voltage bus feeders to machine tools and equipment per section 3646 (Notional Electrical Code). Made in three conductors for three-phase power. Each conductor has a stranded grounding wire lord in the volleys between insulated conductors. ADVANTAGES--Quick installation without use of conduit; easy disconnecting and connecting when machines are moved. Resist ant to oil, grease, ocids, cutting fluids and mechanical abuse. BUS DROP CABLE 600 VOLT SERVICE AVAILABLE SIZES: 14 to 2 AWG inclusive CONDUCTORS INSULATION fULESS TAK JACKET Silt AWG 14 12 10 8 6 4 2 CONSTRUCTION SPECIFICATIONS Strand 7/.0242 7/.0305 7/.0385 7/.0486 7/.0612 - 7/.0772 7/.0974 Insulation Thisknots In 64th* 2 2 2 3 4 4 4 Jackot Thicknoss In 64th* 3 3 4 4 5 5 5 O. D. In liKhst .400 .450 .530 .670 .850 .950 1.10 Shipping Weight Lbs. M Foot 170 205 310 460 550 800 1270 sif Ground Wirot #18 #18 #14 #14 #14 #12 #10 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00247 CONTINENTAL WIRE CORPORATION Solid boro copper, polyethylene insulation, tape, polyvinyl iacket. CONFORMS TO: IMSA SPECIFICATION 19-1-1956. ' Solid bare copper, polyethylene insulation, tape, polyvinyl chlo ride jacket. CONFORMS TO: IMSA SPECIFICATION 20-1956. USES: For wiring controls of traffic signals and similar systems operating at voltages up to 600. INSULATION CONDUCTOR IMSA 19-1-1956 CONSTRUCTION SPECIFICATIONS (POLYETHYLENE) Number of Conductors 4 6 7 B 9 12 4 6 7 8 9 12 4 6 7 8 9 12 #14 SOLID ` Insulation Thickntis in Milt .025 .025 .025 .025 .025 .025 Jack*! Thicknois In 64th* A* 8* 35 35 35 35 46 46 Approximate 0D. in Inchti A' |* .400 .470 .470 .510 .570 .610 .460 .530 .530 .570 .640 .670 #12 SOLID Shipping Weight Lbi./'M Foot A4 8* 130 160 170 210 190 225 215 260 270 320 325 370 .030 .030 35 46 .470 .580 .530 .650 185 290 .030 46 .580 .650 300 .030 46 .630 .690 350 .030 46 .670 .730 395 .030 46 .710 .780 480 IMSA 20-1-1956 CONSTRUCTION SPECIFICATIONS (POLYVINYL CHLORIDE) 225 335 345 365 445 535 #14 SOLID .030 .030 .030 .030 .030 .030 35 35 35 46 46 46 .430 .500 .500 .570 .610 .650 .490 .560 .560 .640 .670 .720 #12 SOLID 150 190 210 255 290 350 170 230 240 275 330 395 .030 .030 .030 .030 .030 .030 35 46 46 46 46 46 .470 .580 .580 .630 .670 .710 .530 .650 .650 .690 .730 .780 210 235 280 345 295 370 330 420 370 465 460 570 A - Light jacket for u neferground conduit, aerial on messenger, or building installation. B - Heavy jacket for direct earth burial. Color Code oi INDIVIDUAL WIRES CONFORMS TO NEMA-NELA and IMSA. RBB 00248 CONTINENTAL.WIRE CORPORATION Stranded bare copper, 3/64" polyvinyl insulation, tape*, poly vinyl jacket. USES--For control circuits, motor leads, leads from switchboard to transformers or temperature recording devices. May be used in air, in conduit or for direct burial in earth. CONBUCTOSS CASE COPSES WISES POLYVINYL INSULATION TAM JACKET CONSTRUCTION SPECIFICATIONS Number of Candvtor #12 (7/.0305) Jacket Thickness in 64th* 0.0. In Inches 2*. 3 33 44 5 4. 64 7 '4 8 ' 4 9 . -4' 10 5 12 5 .29*. 48 .530 .610 .670 .720 .720 .790 .880 .920 .930 #12 (19/.0179) 2 3 T:,/4 T:'5 ' 6 ::7 ' 8 V-?"9 10 12 3 3 4 4 4 4 4 4 5. 5 .30x,49 .540 .620 .670 .730 .730 .800 .860 .930 .940 Shipping Wt. Lbs, M feet 155 210 305 350 395 420 480 528 615 682 Number of Conductor* 2** 3 4 5 6 7 8 9 10 12 170 2 217 3 298 4 340 5 383 !! 6 405 i: 7 465 i1 8 535 1! 9 595 j 10 658 I #10 (7 .0385) Jacket Thickness In 64th* O.D. In Inches 4 .35*.57 4 .610 4 .670 4 .730 4 .800 4 .800 5 .900 5 .970 5 1.01 5 1.02 #9 (19/.0254) 4 .36*.59 4 .640 4 .700 4 .760 4 .830 4 .830 5 .940 5 1.01 5 1.05 5 1.07 Shipping Wt. lbs. M feet 200 265 360 415 492 532 640 708 730 880 235 340 405 490 545 600 730 805 960 1075 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00249 CONTINENTAL, WIR* CORPORATIONS Stranded tinned copper conductor, polyethylene insulated, nylon jacketed singles. Cabled with fillers where needed, binder tape, polyvinyl jacket. MAXIMUM OPERATING TEMPERATURE: 75 C (167 F). USES--Where small diameter, lightweight ond toughness ore im portant. This cable is resistant to oil, grease, alcohol, gasoline, chemical fumes ond weather. It may be placed in conduit, ex posed in air or buried directly irt the earth. POLYVINYL JACKET TAPE POLYETHYLENE AND NYLON CONDUCTOK Nwfnbtf of Conductors 2 3 4 5 6 7 8 9 10 11 12 13 14 IS 16 17 18 19 CONSTRUCTION SPECIFICATIONS 600 VOLTS #14 (19/27) 1000 VOLTS .0165" POLYETHYLENE, .004" NYLON io<k*t Tfci<bns In 64Hu 3 3 3 3 3 3 3 4 4 4 4 4 4 4 4 4 4 4 O.D, In Inch** .130 .360 .380 .410 .445 .480 .480 .515 .585 .630 .630 .650 .660 .680 .700 .715 .735 .750 .750 Shipping Wt. Lbs- M Ft. 20 82 103 131 156 187 200 218 268 293 306 331 350 375 400 425 , 443 468 461 ,0J" POLYETHYLENE. .004" NYLON Number of Conductor* i 2 3 4 5 6 7 .8 9 10 11 12 13 14 15 16 17 18 19 Jocbot Thtticntsi In 64th* -- 3 3 3 3 4 4 4 A A 4 4 4 4 4 4 4 4 4 O.D. In Inches .145 .400 .420 .455 .495 .565 .565 .605 .645 .690 .695 .720 .730 .750 .775 .790 .815 .830 .830 Shipping Wt. Lb*. M Foot 22 90 115 143 175 225 231 268 300 325 337 362 387 412 437 462 493 518 525 (Continued on next page) FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00250 CONTINENTAL WIRE CORPORATION CONTROL CABLE -- (Continued from page 44) #12 (19/25) Number of Conductors 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 IP 600 VOLTS .0165" POLYETHYLENE, .004" NYLON Jacket Thick* fis* In 64ths Inches 0.0. In Shipping Wt. lbs. M Ft. .150 30 3 .400 110 3 .420 140 3 .455 180 3 .500 220 4 .570 275 4 .570 290 4 .615 340 4 .655 375 4 .705 405 4 .705 425 4 .730 460 4 .740 490 4 .765 525 4 .785 560 4 .805 590 4 .830 630 5 .880 690 5 .880 710 1000 VOLTS .024" FOlYITHYLENt. .004" NYLON Number of Conductors Jacktt Thkknest In 44fhs 0,0 In Inches i .165 2 3 .435 3 3 .460 4 3 .500 5 4 .580 6 4 .620 7 4 .620 8 4 .670 9 4 .715 10 4 .765 11 4 .775 12 4 .795 13 4 .810 14 5 .870 15 5 .895 16 5 .915 17 5 .940 18 5 .960 19 5 .960 Shipping Wt. lbs. M Ft. 32 125 150 190 255 280 310 355 390 440 455 500 525 590 635 670 705 740 760 Number of Conductors i 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 #9 (19/22) 600 VOLTS .0165" POLYETHYLENE, .004" NYLON Jacktl Thickness In 64ths 3 3 4 4 -44 4 4 5 5 5 5 5 5 5 5 5 5 O.D, in Inches .185 475 -500 .580 .630 .680 .680 .735 .790 .690 .890 .915 -935 .960 .990 1.02 1.04 1.07 1-07 Shipping Wt. Lbt. M Ft. 56 185 235 320 390 455 500 570 635 740 780 845 890 945 1010 1075 1135 1200 1240 : " 1000 VOLTS .024" POLYETHYLENE, .004" NYLON Number of Conductors i 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 Jacket Thick* nets In 64ths -- 3 4 4 4 4 4 4 4 5 5 5 5 5 5 5 5 5 5 0.0. In Inches .200 .510 .575 .620 .680 .735 .735 .790 .885 .945 .955 .985 1.00 1.04 1.07 1.09 1.12 1.15 1.15 Shipping Wt. lbs. M Ft. 58 T90 265 330 410 460 525 585 705 765 805 890 930 940 1060 1130 1190 1270 1300 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00251 CONTINENTAL WIRE CORPORATION* . STREET LIGHTING CABLE 5000 VOLT SERVICE AVAILABLE SIZES: 8 and 6 AWG. MINE TELEPHONE CABLE AVAILABLE SIZES: 18 and 14 AWG. 600 VOLT SERVICE Solid bore copper polyvinyl insulation. USES--Designed for series street-lighting circuits--tor installation in conduit or direct burial in earth. Solid copper or copperwold conductors, polyvinyl insulation. USE5--For communications in mines and other locations where moisture, heat, oil, grease, corrosive vapor are present. INSULATION INSULATION tONDUeiOt CONDUCTOtS JACKET LUotk) Six* AWG 8 6 16 14 16 14 iNSULAtrON CONOUCTOSS CONSTRUCTION SPECIFICATIONS STREET LIGHTING CABLE Stroud solid solid Well In Mtht 10 10 0.0, In Inch** .450 .480 Shipping Weight lb*. M F**t 186 237 MINE - TELEPHONE CABLE Standard Fade 3000' Reel 3000' Reel solid solid solid solid PLAIN - NO JACKET 2 .230 2 .260 WITH JACKET 2 .330 2 .350 30 45 82 110 2000' Reel 2000" Reel 2000' Reel 2000- Reel FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00252 wixi n y i ? WIRE CORPORATION All conductors and shields ore of tinned copper. Microphone cord is insulated with polyethylene. Ati others have polyvinyl insulation. USES--Wiring intercom and public address systems or as a micro phone cord. AUDIO-PUBLIC ADDRESS SYSTEM CABLE AVAILABLE SIZES: 24 to 18 in dgsive. CONDUCTOR INSULATION SHIELD CONSTRUCTION SPECIFICATIONS JACKET AWG Number f Conductors Strand THICKNESS IN INCHES lnutatifl Shield iatlter PARALLEL PAIR - SHIELDED - JACKETED O.D. In Inch** Standard Speol 20 2 10'30 .015 .020 .015 .12 x .21 500' TWISTED PAIR - SHIELDED - NO JACKET 22 2 22 2 20 2 20 2 18 2 18 2 solid 16 34 solid 10 30 solid 16/30 .015 .015 .015 .015 .015 .015 .025 .025 .025 .025 .025 .025 _ -- -- - TWISTED PAIR - SHIELDED - JACKETED .140 .150 .155 .165 .175 .185 1000' 1000' 1000' 1000' 1000' 1000' 22 2 solid .015 .025 .015 .170 1000' 22 2 16/34 .015 .025 .015 .180 1000' 20 2 solid .015 .025 .015 .180 1000' 20 2 10/30 .015 .025 .015 .190 1000' 18 2 solid .015 .025 .015 .200 1000' 18 2 16/30 .015 .025 .015 .210 1000' MICROPHONE CORD - SHIELDED - JACKETED 24 2 16/36 .027 24 1 16/36 .028 22 2 16/34 .016 20 2 26/34 .020 18 2 41/34 .030 .025 .023 .034 .025 .032 .247 .150 .230 .247 .328 The polyvinyl jackets are Black for the Microphone Cord ond Brown for other jacketed wires. 500' 1000' 500' 500500' W*ighl lb* M f**i 25 17 19 le 22 25 28 23 25 27 29 33 37 34 15 35 48 50 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00253 WIRE CORPORATION EE33 ii THERMOSTAT n CONTROL CABLE TYPE TC AVAILABLE SIZES: T8 AWG USES--For low voltage intercommunications, signal and alarm systems, oil burner controls, ovens, gas pilot lights, air condition ers, industrial dryers, etc. ^. . .. ___ LU--T-.H ^ fPol,vmT|, INSULATION CONDUCTOR CONSTRUCTION SPECIFICATIONS $iz* AWG 18 18 18 18 18 18 18 -- 18 18 18 ' 18 18 18 18 18 18 18 18 Number ef Conductor* INSULATION Typo Thkknots Outer Cftvlfini Nom. O.O. lit Inch** Standard Pact POLYVINYL INSULATION - PARALLEL (With Tracer) 2 pvc .015-025 none .08x.l7 500' 3 PVC .015-025 none .08x.25 500' POLYVINYL INSULATION - TWISTED 2 PVC ` .015 3 pvc .015 4 PVC .015 5 PVC .015 none none none none .140 .150 .170 .190 500' 500" 500' 500' POLYVINYL INSULATION - TWISTED (With Jacket) 2 PVC .015 3 pvc .015 .4 PVC .015 5 PVC .015 PVC PVC pvc PVC .185 .195 .215 .235 500' 500' 500* 50(7 ENAMEL & ASBESTOS TYPE - TWISTED (With Waxed Cotton Braid) 2 ASB. .0125 3 ASB. .0125 4 ASB. .0125 s ASB. .0125 Cotton Cotton Cotton Cotton .150 .160 .175 .195 500500' 500' 500' ENAMEL & ASBESTOS TYPE - TWISTED (Armor) 2 ASB. .0125 3 ASB. .0125 4 ASB. .0125 5 ASB. .0125 Steel Steel Steel Steel .160 .170 .185 .205 50(7 500' 500' 500' Ship- Wr. Lb*. M ft. 15 22 16 25 30 35 20 28 34 40 22 31 38 44 27 37 46 53 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00254 CONTINENTAL. WIRE CORPORATION TYPE \ -- Extruded polyvinyl, extruded clear nylon. TYPE II -- Extruded polyvinyl, glass braid* extruded clear nylon {sizes 22 thru 12) or nylon braid and lacquer (sizes 10 thru 4 0). TYPE III -- Construction same as Type II, except extruded poly vinyl between glass braid and nylon (extruded or braided) outer jacket. USES--For general wiring of aircraft at temperatures up to 105cC. This wire has excellent resistance to abrasion, cold, moisture, fungus, solvents, and flame. CONFORMS TO--Specification MIL-W-5086A. AIRCRAFT < WIRE | (Unshielded) / 600 VOLT SERVICE I AVAILABLE SIZES: AN 22 to 4/0 \i________ STRANDED TIPPED COPPER POLYVINYL INSULATION (White, ILLUSTRATION SHOWS CONSTRUCTION PER TYPE l OnI* EXTRUDED NYLON . JACKET AN Size 22 20 IS 16 14 12 10 8 6 4 2 1 1/0 2/0 3/0 4/0 StfOfiding 19 .0063 19. .0079 19/.010 19/.0113 19/.0142 19/.Q179 49/.0142 133/.0U3 133/.0142 133/.0179 665/.010 817/.010 1045/.010 1330/.010 1665/.010 2109/.010 CONSTRUCTION SPECIFICATIONS TYPE I TYPE II Nm. O-D- .068 .078 .088 .098 .117 .137 Mox. Wt. Lbi./M' 4.4 6.3 8.6 10.7 16.4 24.7 Nam. 0,0 .075 .085 .095 .105 .125 .143 .189 .240 .293 .355 .425 .470 .525 .590 .650 .720 Max. Wt. Lbl./M' 4.7 6.8 9.5 11.9 18.3 26.0 44.0 70.0 1 10.0 165.0 250.0 305.0 400.0 500.0 620.0 785.0 TYPE 111 Nqid. 0.0 .085 .095 .110 .125 .143 .163 .193 .248 .303 .360 .435 .485 .535 .595 .665 .735 Max. Wt. lbv/M' 5.7 7.6 11.0 14.0 20.0 28.3 44.0 70.0 1 13.0 170.0 250.0 310.0 400.0 500.0 620.0 785.0 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00255 50 CONTINE 2HS! AIRCRAFT WIRE (Shielded) 600 VOLT SERVICE AVAILABLE SIZES: AN 22 to 4/0. n !J Continental Types I, II, and III Aircraft Wires per M1L-W-5086A with tinned copper braid shielding overall. USES--For general wiring of aircraft. Resistant to heat, coid, abrasion, fungus, solvents and flame. CONFORMS TO-Specifieotion MIL- C -7078 A Type 1. TINNED corrtt SHIELDING IKAIO NTLON JACKET tOLTYINYl INSULATION STRANDED TINNED COMER (ILLUSTRATION SHOWS RASE CONSTRUCTION HR TYRE I. MU-W-30WA ONLY' CONSTRUCTION SPECIFICATIONS AN Six* 22 20 18 16 >4 12 10 8 6 4 2 1 10 20 30 40 Stranding 19/.0063 19/.0079 19/.010 19-'.Ol 13 19/. 0142 19 .0179 49/.0142 133/.0113 133/-0142 133/.0179 665 .010 817/.010 1045 '.010 1330 .0t0 1665 .010 2109 .010 5086A TYPE 1 BASE Nom. 0,D. i Inchts Ship. Wi. Lbi. M Feel .093 .103 .113 .123 .142 .162 11.5 14 18 21 29 40 5086A TYPE II BASE hem. O.O. in Inch** Ship. Wt. Lb. M Feel .100 .110 .120 .130 .150 12 16 19 24 31 .168 .214 .265 .318 .380 .460 43 66 99 145 220 337 .505 .560 .625 .685 .755 406 508 628 750 887 S086A TYPE III BASE N*m. O-D. Ship, Wt. lbs. in Inches M Fen .110 .120 .135 .150 .168 .188 .218 .273 .328 .385 .470 .520 .570 .630 .700 .770 14 17 22 26 35 46 70 106 157 230 346 410 518 638 760 900 FOR FASTEST SERVICE # PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00256 CONTINENTAL WIRE CORPORATION Types I, II and III Aircraft Wires per M1L-W-5086A with addition of tinned copper shield and nylon jacket. USES--For general wiring of aircraft. Resistant to heat, cold, abrasion, fungus, solvents, and flame. CONFORMS TO--Specification MIL-C-7078 Typo II. AIRCRAFT WIRE (Shielded and Jacketed) 600 VOLT 5ERVICE AVAILABLE SIZES: AN 22 to 8. StRANDtD TINNED COPPER THERMOPLASTIC INSULATION (Whitt] EXTRUDED NY10N JACKET TINNED COPPER SHIELDING MAID .ILLUSTRATION SHOWS base CONSTRUCTION per TYPE i. MIL-W-S0B6A ONLY; NYLON JACKET AN Size 22 20 18 16 14 12 10 8 Stranding 19/.0063 19/.0079 19/.010 19/.0113 19/.0142 19/.0179 49/.0142 133/.0113 CONSTRUCTION SPECIFICATIONS 5086A TYPE I BASE Nom, O-D. in inches .101 .ni .123 .133 .143 .164 Ship. Wt, lbs. M Feet 12.5 15 19 23 31 43 64 99 5086A TYPE II BASE Nam. O.D. in Inchfi .108 .118 .130 .140 .160 .180 .226 .277 Ship. Wt. Lbs. M Feet 13 17 22 26 34 46 68 101 5086A TYPE 111 BASE Nam. O-Din inches .118 .128 .145 .160 .178 .200 .230 .285 Ship. Wt. Lbf. M Feet 15 19 25 29 38 49 73 109 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIorty 9-1421 RBB 00257 CONTINENTAL WIRE CORPORATION CONSTRUCTION PER MIL-W-7139A-Silver coated copper, high temperature insulation, glass braid, high temperature finish. USES--Recommended for general purpose wiring in aircraft and missiles, where continuous temperatures of 400F ore likely, and good resistance to abrasion, oils, solvents, moisture, and flame ore needed. APPROVED--Under specification MIL-W-7139A (Sizes RM22 - 6 in clusive) as qualified product. CONSTRUCTION PER MIL-W-2S03S-Same as for MIL-W-7139A except nickel clad copper conductor. USES--Recommended where a 600 volt, high temperature, fire resistant wire is required for aircraft electrical use, particularly for fire detection and related circuits which must operate without foilure for short time emergencies in the event of exposure to flame up to 2000F. Also recommended for other critical circuits which moy be subjected to o total temperature of 750SF. WHITE TEFLON MATED CLASS MAID TEFLON TAPE SILICONE IMFSECNATED ASSESTOS TEFLON TAPE Sthanded CONDUCTOR CONSTRUCTION SPECIFICATIONS Six* AWC 22 20 18 16 1i 12 10 8 6 Number of Conductor Strond* (min.) 19 19 19 19 19 19 37 133 133 Max Dta. Strand (in.) .033 .041 .052 .061 .076 .096 .132 .176 .218 Max Rtiiian< Finilhod Wir (Ohm, ptr 1000 ft.) 16.45 10.25 6.44 4.76 2.99 1.88 1.10 0.70 0.436 400* F 27.97 17.43 10.95 8.10 5.10 3.20 1.67 1.19 0.742 * du Font's Trade name for Poiytetrafluorethylene Max O.O. .090 .100 .115 .130 .150 .170 .200 .255 .310 Max. Wt. 8.0 10.0 14.0 18.0 25.0 34.0 52.0 78.0 118.0 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-t421 RBB 00258 CONTINENTAL WIRE CORPORATION Stranded tinned copper, synthetic tapes, asbestos, lacquered braid. Moisture-resistant, cellulose acetate wrap, impregnated asbestos, lacquered braid. USES--For aircraft wiring forward of firewall and in instruments. This wire is resistant to cold, heat, flame, moisture, grease and oil. MAXIMUM OPERATING TEMPERATURE SO^C. CONFORMS TO-Specification AN-J-C-48a AIRCRAFT OR RADIO HOOK-UP WIRE 1000 VOLT SERVICE AVAILABLE SIZES: AN 22 to 4/0. TINNED corn* CONDUCTOR MOISTURE RESISTANT CELLULOSE ACETATE WRAP IMPREGNATED AStiStOS LACQUERED RRAID CONSTRUCTION SPECIFICATIONS Sixt AN or AWG 22 20 18 16 14 12 ' 10 8 6 i 2 1 1/0 2/0 3/0 4/0 Stranding 7/. 010 7.'.0126 7, .0159 26/.010 39 .010 61/.010 10S/.010 7/24/.010 19/7/.0141 19/7/.0177 19/35/.010 19/44/.010 19/55/.010 19/70/.010 19/88/.010 37/57/.010 IntulotitB Wall In Mils 12 12 15 15 17.5 20 20 20 22.5 22.5 25 25 25 25 25 25 AHG-1000 .074 .082 .098 .111 .131 .154 .182 .236 .275 .331 .415 .454 .502 .560 .620 .685 Nominal O.D. In Inthlt* AHC-1000 .084 .092 .108 .121 .141 .164 .192 .246 .285 .341 .425 .464 .512 .570 .630 .695 Type AHG has glass braid. AHC has cotton braid. AHR has rayon braid. `Finished diameters are average and subject to plus or minus 5% tolerance. ANROOOO .074 .082 .098 .111 .131 .154 .182 .236 .275 .331 .415 .454 .502 .560 .620 .685 Wfiglit lbs. M Ft. 5 6 9 12 17 27 42 66 101 154 246 300 380 480 600 750 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00259 54 ' .................................................................................................. . ' RADIO HOOK-UP WIRE HOW TO ORDER l WIRE CORPORATION HOW TO ORDER: For convenience and faster pro t. cessing of your order, use this code: (1) Type, (2) Conductor, (3) Size, (4) Strand, (5) Covering (jacket) Code, and (6) Color Code. Specifications JAN-C-76 and MIL-W-76 B f COVERING CODE: U -- non* J -- Jacket B -- Braid S -- Shield JS -- Jacket and Shield BS -- Braid and Shield SJ -- Shield and outer jacket JSJ -- Jacket, shield and outer jacket BSJ -- Braid, shield ond outer jacket COLOR CODE: 0 -- Black 1 -- Brown 2 -- Red 3 -- Orange 4 - Yellow 5 -- Green 6 -- Blue 7 - Violet 8 -- Gray 9 - White EXAMPLE-. MW-C-24-7-J-903, i.e., TYPE: MW Radio Hook Up. CONDUCTOR: C-Copper or copperweld. SIZE: 24. STRAND 7. COVERING: J-Jacket, and COLOR: 903White with black-orange stripes. FOR FASTEST SERVICE e PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00260 CONTINENTAL WIRE CORPORATION 55 Solid or stronded tinned copper polyvinyl insulation either plain or covered with braids of cotton, glass, rayon or a nylon jacket. All braids have lacquer finish. USES--A wide variety of applications in aircraft and communi cations, as well as manufactured products. Among the many uses are: leads for motors, generators, transformers, switches, recti fiers; wiring switchboards, relays, voice recorders, timing devices; and control circuits. OPERATING TEMPERATURES: FROM -40C to 80C CONFORMS TO--Specification JAN-C-76 INSTRUMENT AND RADIO HOOK-UP WIRE TYPES WL, SRIR, SRHV, 5RRF. 600*2500 VOLT SERVICE AVAILABLE SIZES: 24 to 6 AWG inclusive COPPER CONDUCTOR INSULATION BRAID COPPER CONDUCTOR INSULATION CONSTRUCTION SPECIFICATIONS AWG Six* 24 24 22 22 20 20 18 18 16 16 14 14 12 10 8 6 Strand i*m.) 1 7 1 7 1 7 1 7 1 19 1 19 19 37 133 133 TYPE WL 600 V NOM. O.D. IN INCHES Plain Nylon Jackal Ccttan braid .044 .054 .074 .048 .050 .054 .058 .060 .064 .078 .080 .084 .056 .062 .066 .072 .086 .092 ,065 .078 .081 .087 .075 .088 .091 .097 .095 .108 .111 .117 .095 .107 .130 .158 .219 .263 .105 .117 .142 .170 .239 .283 .125 .137 -160 .188 .249 .293 TYPE SRIR 1000 V NOM. O.D. IN INCHE5 Nylon Catron Plain Jackot Braid .053 .056 .058 .063 .066 .068 .083 .086 .088 .062 .064 .072 .074 .092 .094 .070 .080 .100 .073 .084 .084 .083 .094 .094 .103 .114 .114 .092 .105 .111 .T40 ,.162 -233 .277 .102 .117 .123 .152 .174 .253 .297 .122 .135 .140 .170 .192 .263 .307 TYPE SRHV 2500 V NOM. O.D. Cotton Plain Braid .082 .112 .086 .116 .088 .118 .092 .122 .094 .124 .100 .130 .102 .132 .110 .140 .113 .143 .119 .149 .126 .156 .133 .163 .155 .185 .192 .222 .263 .293 .307 .337 TYPE SRRF 1000 V NOM. O.D. Plain Catron Braid .054 .084 .058 .088 .059 .089 .064 .094 .066 .096 .072 .102 .074 .104 .082 .112 .091 .121 .098 .128 .104 .134 .1 1 1 .141 .130 .160 .162 .192 .233 .263 .277 .307 Broid s of glass or rayon show approximately same O.D. as ny Jon jacket. The basic colors are as follows: 0 -- Black, 1 -- Brown, 2 -- Red, 3 -- Orange, 4 -- Yellow, 5 -- Green, 6 -- Blue, 7 -- Violet, 8 -- Gray. Further color coding is had by use of 1, 2, or 3 spiral stripes over plain insulation or as tracers in braid. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00261 56 CONTINENTAL WlRfeC RADIO HOOK-UP WIRE TYPE IW 300 VOLT SERVICE AVAILABLE SIZES: 30 to 20 AWG indutive Tinned copper conductor, extruded polyvinyl chloride insulation with or without further covering. USES--A wide variety of applications in aireroft and communi cations, os well as manufactured products. Among the many uses are: leads for motors, generators, transformers, switches, recti fiers; wiring switchboards, relays, voice recorders, timing devices,and control circuits. CONFORMS TO-Specification MIUW-76 B INSULATION COFFEE CONDUCTOt Strand $' tor* Dia. litcHai (Max.) CONSTRUCTION SPECIFICATIONS LW-U PLAIN LW-J NYLON JACKET LW-B BRAID* Dia. (Mox.) W.t, tbs. M Ft. Dia. (Max,] Wflttbi. M ft. Dia. (Max,) WSt. Ibt. M Ft. LW-J-S SHIELDED Dia. (Max,) Wgr. Ibt. M Ft. 30 Solid .010 .033 .9 .041 30 3/.0063 .014 .037 .9 .045 28 Solid .0126 .037 1.2 .045 28 7/.005 .016 .039 1.3 .047 26 Solid .015? .040 1.6 .048 26 7/.0063 .020 .043 1.7 .053 24 Solid 24 7/.008 .0201 .025 .044 .049 2. 2.1 .054 .059 22 Solid .0254 .049 3. .059 22 7/.010 .033 .057 3.1 .067 20 Solid .032 .056 4.3 .066 20 7/.0126 .041 .065 4.4 .075 i.i .048 1.3 .056 5.8 i.i .052 1.3 .060 6. 1.4 .052 1.6 .065 6.3 1.5 .054 1.7 .067 6.7 1.9 .055 2.1 .068 7.1 2. .058 2.2 .073 7.6 2.3 .05? 2.5 .077 7.9 2.4 .064 2.6 .082 8.1 3.4 .064 3.6 .082 9.5 3.5 .072 3.7 .090 9.7 4.7 .071 4.9 .089 10.9 4.8 .080 5. .098 11.2 * Gloss or Synthetic Fibre LW-B-S SHIELDED Dia, (Max.) W9*. lb*. M PI- .063 .067 .072 .074 .075 .078 .082 .087 .087 .095 .094 .103 6.1 6.3 6.6 7. 7.5 8. 8.4 8.5 10.1 10.3 11.5 11.8 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00262 CONTINENTAL WIRE CORPORATION 57 Tinned copper conductor, extruded polyvinyl insulation will, Qr without further covering. USES--A wide variety of applications in aircraft and .,,,...... cations, os well as manufactured products. Among the ore: leads for motors, generators, transformers, switch,.,, fieri; wiring switchboards, reloys, voice recorders, timinj 'h.vi.,,^ and control circuits. CONFORMS TO-Specification MIL-W-76A RADIO HOOK-UP WIRE TYPE MW 1000 VOLT SERVICE AVAILABLE SIZES: 34 to U AWG inclusive COPPE* CONOUCTO* inSuisii,,,, COPPEt CONOUCTO* INSULATION CONSTRUCTION SPECULATIONS Six* Strand 24 Solid 24 7/008 22 Solid 22 7/010 20 Solid 20 7/0126 18 Solid 18 7/0159 16 Solid 16 19/om 14 Solid 14 19/0142 12 Strand fcor* Dig. Inchtt {Max.) .0201 .025 .0254 .033 .032 .041 .0403 .052 .0508 .065 .0641 .078 .098 MW-U PLAIN 0ia. (Max.) Wg*. Lbi, ft. .057 2.8 .062 3.1 ,062 .070 .069 3.8 4.3 5.4 .078 .077 6.2 7.9 ,089 9.1 ,088 11.7 .102 .101 12.6 18.6 .115 .135 18.6 27.8 MW-J NYLON JACKET Die. (Mo*.) Will ill. M It .073 3n .078 41 .078 44 .086 .085 yv 6 :i .096 .095 .107 7.7 9 HI 1 106 1? V .120 .119 13.It 20 l .133 20.1 .155 29.7, MW *8 BRAID* Dip. max.} Wfft. Lb*. M Ft. .072 4.1 .071 4.6 .077 5.1 085 .084 5.7 6.8 093 7.6 092 9.4 104 10.6 103 13.3 .117 14.3 116 20.5 130 20.6 150 30.2 MW-J-S SHIELDED Wgr. Dio. Ibt. M Ff. .096 8. .101 .101 8.2 8.7 .109 10.3 .108 .119 11.3 12.9 .118 .130 .129 14.6 16.6 19.4 .143 21.5 .142 27.8 .156 29. .178 42.9 MW-B-S SHIELDED Wgt. Dw. (Max.) Ibt M Ft. .095 .094 8.3 8-7 .100 .108 9.2 10.8 .107 11.8 .116 13.3 .115 .127 .126 15. 17.1 19.8 .140 .139 .153 .173 22, 28.2 29.5 43.5 * Glass or Synthetic Fibre. Strands listed above ore minimum required. A greater numb..- -,f sma|jer wires for increased flexibility permitted. Minimum Order Quantity: 5000 feet. Nylon jacketed wire can be furnished in solid colors or striped Braided wire con be furnished in solid colors or tracers. These wires can also be furnished with a nylon jacket over the shield. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00263 CONTINENTAL WIRE CORPORATION RADIO HOOK-UP WIRE TYPE HW 22 to 16 AWG MAXIMUM 2500 VOLT SERVICE 14 to 00 AWG MAXIMUM 600 VOLT SERVICE AVAILABLE SIZES: 22 M00 AWG r'lfiiMliri'ffi Tinned copper conductor, extruded polyvinyl chloride insulation with or without further covering. USES--A wide variety of applications in aircraft ond eommuni. cations, as well as manufactured products. Among the many uses are: leads far motors, generators, transformers, switches, recti fiers; wiring switchboards, relays, voice recorders, timing devices; and control circuits. CONFORMS TO--Specification Mll-W-76 B tNSuutiON cams conoucio* CONSTRUCTION SPECIFICATIONS tar* (Ka. Sir* Strsftrf Inch> (Max.) 22 Solid .0254 22 7./.010 .033 20 Solid .032 20 7/.0126 .041 18 Solid .0403 18 T6/.010 -052 16 Solid .0508 16 19/.0113 .065 U Solid .0641 14 19-.0142 .078 12 19/.0179 .098 10 37/.0159 .122 8 127,.0113 .175 6 127.'.0142 .200 HW-U PLAIN wt. AU IksM Ft. HW-J NYLON JACKET IK*. (Mu.) w* lbs, M ft. .098 .106 .105 .114 .113 .125 .124 .138 .166 .180 .200 .224 .277 .322 5.3 6.1 7.1 7.7 9.4 10. 13.2 13.2 22.4 22.5 31.7 48.7 72. 105. .116 ,124 .123 ,132 ,131 .143 .142 .156 .186 .200 .220 .252 .307 .355 5.9 6.8 7.9 8.6 10.4 11. 14.3 14.4 23.9 24.1 34.2 53.3 78. 113. HW-B BRAID* Dto. (Max.) W,l. lbs. M ft. .113 6.3 .121 7.1 .120 8.2 .129 8.8 .128 10.6 .140 11.3 .139 14.5 .153 14.6 .186 24.1 .200 24.3 .220 33.7 .244 51. .302 73.8 .347 108. HW-J-S SHIELDED Di. (Mas.) Wet. lb,, M Ft. .139 12.4 .147 15.3 .146 16.2 .155 17.4 .154 19.2 .166 20.9 .165 24.2 .179 25. ,209 37.4 .223 40.1 .243 55.2 .279 75.8 .334 106. .382 146. HW-B-S SHIELDED Dio, (Mo*.) lbs. M Ft, .136 .144 .143 .152 .151 .163 .162 .176 .209 .223 .243 .271 .329 .374 12.8 15.6 16.5 17,6 19,4 21.2 24.4 25.2 37.6 42.1 54.7 73.5 101.8 141. 'Gloss or Synthetic Fibre. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COkmy 9-1421 RBB 00264 CORPORATION 59 Stranded tinned copper, polyvinyl insulation with or without nylon jacket. USES--Wherever there is o need for many insulated wires in small space. MAXIMUM OPERATING TEMPERATURE: 105"C; approximately 115SC with nylon jacket. CONFORMS TO-Specificatian MH-W46878C. !i Si ELECTRICAL AND ELECTRONIC INSTRUMENT WIRE TYPES B, C and D 600-3000 VOLT SERVICE AVAILABLE SIZES: 32 to 6 AWC inclusive COPPtlt CONDUCT* INSULATION NYLON JACKET CONSTRUCTION SPECIFICATIONS Six* AWG 32 30 28 26 26 24 24 22 22 20 20 18 18 16 14 12 10 8 6 Strand 7/. 0031 7/.004 7/.005 7/.0063 19/'.004 7 .'.008 19/.005 7/.010 19/.0063 7/.0126 19/.008 7/.0159 19/.010 I9/.0113 19/.0142 19/.0179 41/.0159 133/.0111 133/.0142 TYPE 8 600 V NOM. O.D, INCHES Eton Nylon .028 .031 .034 .038 .038 .043 .043 .049 .049 .057 .057 .067 .067 .077 .032 .035 .038 .042 .042 .047 .047 .053 .053 .061 .061 .072 .072 .082 TYPE C 1000 V MOM. O-O. INCHES Eton Nylon .058 .058 .064 .064 .072 .072 .082 .082 .091 .105 .062 .062 .069 .069 .076 .078 .088 .088 .098 .1 12 TYPE D 3000 V NOM. 0.0- INCHES Eton Nylon .083 .083 .089 .089 .097 .097 .107 .107 .116 .130 .163 .181 .246 .290 .089 .089 .095 .095 .104 .104 .114 .114 .124 .140 .175 .194 .262 .310 Color coding is effected by use of 1, 2, or 3 spiral stripes applied over the polyvinyl insulation. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COtony 9-1421 RBB 00265 ELECTRICAL AND ELECTRONIC INSTRUMENT WIRE TYPES B, C, and D (Shielded or Shielded ond Jacketed) 600*3000 VOLT SERVICE AVAILABLE SIZES: 32 to 6 AWG inclusive Stranded tinned copper, polyvinyl insulation, nylon locket, tinned copper shield with or without polyvinyl jacket. USES--Wherever there is c need for many insulated wires in small space. MAXIMUM OPERATING TEMPERATURE: Approximately 115cC when nylon jacket or braid applied aver primary insulation. CONFORMS TO-Speeificaiion MJL-W-16878C. NYLON JACKET TINNED COPPER Shielding iraid extruded NYLON JACKET THERMOPLASTIC INSULATION rwhii* STRANDED tinned COPPER Sit AWG 32 30 28 26 24 22 20 18 16 14 12 10 8 6 Min. Strand 7 7 7 7 7 7 7 7 19 19 19 41 133 133 CONSTRUCTION SPECIFICATIONS TYPE B NOM. OJ>. INCHES Stott Only Skidd 4 Jntk*t .058 .061 .064 .068 .073 .079 .088 .103 .113 .078 .081 .084 .088 .093 .099 .110 .128 .141 TYPE c NOM. O.O. INCHE5 Shidd Only Shi'ald l Jack* .088 .099 .108 .118 .128 .143 .108 .121 .132 .143 .155 .172 TYPE 0 NOM. 0.0. INCHES Shiald Only shjdd t Jadtni .119 .125 .134 .144 .154 .170 .205 ,224 .292 .340 .145 .153 .164 .176 .188 .208 .250 .273 .356 .415 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00266 WIRE Tinned copper conductor, extruded polyethylene insulation with or without further covering. USES--A wide variety of applications in aircraft and communi cations, as well as manufactured products. Among the many uses are: leads for motors, generators, transformers, switches, recti fiers; wiring switchboards, relays, voice recarders, timing devites; and control circuits. CONFORMS TO--Specification MU.-W-76A 61 com* COMDUCTO* INSULATION BtAID com* CONDUCTOR LNSUUTIOT4 CONSTRUCTION SPECIFICATIONS Bflri Dip. siit Strand Inch** {Mqx.) 24 Solid , .0201 24 7/.008 .025 22 Solid .0254 22 7/.010 .033 20 Solid .032 20 7/.0126 .041 18 Solid .0403 18 16/.010 .052 16 Solid .0508 16 19/.0113 .065 `Glass or Synthetic Fibre HF-U PLAIN Dio. (Max.) W*t. lb*. M ft. .057 .062 .062 .070 .069 .078 .077 .089 .088 .102 1.9 2.1 2.8 3.1 4.1 4.4 6.1 6.2 9.1 9.1 HM NYLON JACKET Dia. (Male.) wr its M ft. .073 .078 .078 .086 .085 .096 .095 .107 .106 .120 2.2 2.4 3.1 3.5 4.5 4.8 6.6 6.8 9.7 9.8 HF-B BRAID* Dta. {Max.) Wft. lbs, M ft. .048 .077 .077 .085 .084 .093 .092 .104 .103 .117 2.4 2.6 3.3 3.8 4.9 5.2 7.2 7.4 10.5 10.6 HF-J-S SHIELDED Dip. {Max,) w,. lbs. M h. .069 .101 .101 .109 .108 .119 .118 .130 .129 .143 7. 7.4 8.1 9. 10.5 11.4 13. 14.1 17. 18.3 HF-B-S SHIELDED D*a. (Max.) Wf. lbs. M ft. .095 .100 .100 .108 .107 .116 .115 .127 .126 .140 7.2 7.6 8.3 9.3 10.9 11.8 13.6 14.7 17.8 19.1 FOR FASTEST SERVICE a PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00267 62 CONTINENTAL RADIO HOOK-UP WIRE TYPES SRI, SRIB, MRI AVAILABLE SIZES: 30 to 1/0 AWG Q USES--For use in rodip, electronic ond other eommunicotion opplications for U. S. Novy installations. CONFORMS TO--Specification MIL-C-915A (SHIPS) INSULATION COtrtH CONOUCTOt CONSTRUCTION SPECIFICATIONS tin t m 2 Vi 3 4 4 6 6 9 9 14 26 42 66 100 Strandifia 10/010 41/0063 26/010 19/0126 7/025 41/010 7/0305 65/010 7/0359 90/010 140/010 7/7/0234 7/7/0305 19/7/0226 61/0403 Afpnx. awq siu 20 18 16 15 14 14 12 12 11 11 9 6 4 2 1/0 Ian Die. Inthti .038 .049 .061 .063 .076 .077 .092 .097 .108 .120 .145 .210 .260 .330 .363 intWation .015 .0175 .0175 .0175 .021 .0215 .023 .027 .0295 .031 .031 .031 .031 .035 .035 TYPE SRI TYPE SRIB Flai Thirmaplattk______________TKnpopUitlc and Cnftnn troid 0,D, (M Wt. Lbs. M Pi. Jftsvittion TMckmtt O.D. Wji. lbs (Max.) M Ft .075 .090 .102 .105 .125 .125 5. 7.6 11.2 12.7 18.9 18.4 .029 .031 .031 .036 .037 .110 -125 .137 .140 .165 8.5 12. 16.5 18. 26.5 .150 .760 26.7 27.6 .039 .190 36.5 .178 .190 37.9 39.1 .044 .218 49.5 .215 .285 .340 .420 55.7 101.7 165.8 241.7 .047 .048 .045 .053 .255 .325 .380 .465 73. 129.5 206. 307. .453 341.3 All conductors are furnished in plain copper (not tinned) On SRIB the standard is black braid with flame retardent finish Size 20 16 16 Slrandmf 10/010 26 010 26 010 TYPE MRI eiai Ttwmwplesiic in 2 and 1 CpadvOm Notpy Typ- MRI-D-1 MRI-D-2-V4 MRI-T-2-V4 Numbtr of CoMdocton 2 2 3 Dio. ttaglo (Max.) .075 .102 .102 FiAtBhod Dia. (Max.) .150 .204 .220 wt. ut. M Ft. n 25 37 lotuiation Mtgohrm 100 100 100 FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00268 ^CONTINENTAL WIRE CORPORATION CURRENT-CARRYING CAPACITIES ASBESTOS INSULATED CONDUCTORS OF COPPER, NICKEL, AND MONEL For on installation equivalent to three single wires in conduit. Sis* AWG 18 16 14 12 10 8 6 TYPE Al - TYPE A(A Max. Conductor Temp. I254C Copper Nickel Clod Copp*r Nkkel Monel TYPE a - TYPE AA Max. Conductor Temp. 200' C Copper Nkk*l Clod Copper Nickel Monel 17 amps 22 30 40 50 65 85 11.9 15.4 21 28 35 45.5 59.5 7.1 amps 9.2 12.5 16.8 21 ,, 27.3 36 4.1 amps 5.3 7.2 9.7 12 15.6 20.7 18 amps 23 30 40 55 70 95 12.6 16.1 21 28 38.5 49 66.5 7.6 amps 9.7 12.5 16.8 23 30 40 4.4 ompi 5.6 7.3 9.7 13.3 17.3 23.2 In most applications for electrical wiring, copper conductors are used. However, if copper is continuously sub. jeered to temperatures approaching 400F, it will oxidize and become useless. For this reason it is customary to recommend the use of nickel-clad copper, nickel, or monel, for satisfactory service at 150C (302F) or higher. because of the lower current-carrying capacities of nickel-clod copper, nickel or monel os compared to copper, selection of a conductor of the proper size is extremely important. Nickel-clad copper is relatively new in the field of electrical conductors for high temperatures. Therefore, it is often overlooked- However, it stands next to copper in current-carrying capacity having better than 70e of the current conductivity of copper. It has been used successfully on appliations where the heot has been as high os 1000F. Pure nickel or manganese-nickel are most commonly used where resistance to high heot is importont. Their ability to carry electrical current is much less than that of either copper or nickel-clad copper. Monel has the lowest current-carrying rating of all the conductors mentioned. Sometimes it Is selected for its lower cost per pound as against nickel or niekel-ciod copper. The comparison of current-carrying capacities of copper, nickel, and monel, shown in the table obove may be found of value. Information on nickel-clad copper will be furnished on request. NOTE: The current-carrying capacities shown in the table above are based on o temperature ol 30 C. For higher temperatures see Correction Factors on Pages 66 and 67. FOR FASTEST SERVICE RHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00269 i CONTINENTAL WIRE CORPORATION COAXIAL CABLES - RADIO FREQUENCY Eltfirittl Cbarectorittk* MIL-C.17B Specification RG Type Continental Number Formerly RG-r/U 6AU 11 A/U 12A/U CFl * CAA1 CAB1 22B. U C3B2 223'U 5BC-U 122/U CBBCO* 55/BU CEH3* CABBO 57A7U CEG1 S9B,. U CEI2* 62A U 71B U 63B U 79B U 86 U 108, U 11J/U CFB1 CGA2 CFC2 CGI 2 CHFO CA-HO CAAEO 212 U 213 U 215 U 222 -U CBABO* 5B U* CBACO 8A U CBAEO 10A U CBBBO 21A U Nominal Chorector* Maximum Attanuotien wtic At j At Impedance 400 Me ' 1000 Me Nomina) Capaci tance mmfrf/fr. OttcriptieR Approximate Not Woighr Ohm Decibel* per 100 Feet 75 6.5 23.0 75 5.2 18.5 75 5.2 lfr.5 20 20.5 20.5 Similar to 59B/U but higher quality and with double shielding. Medium size, flexible, for video and UHF application. 12A/U is armored for mechanical protection. Lbs. P*r M fi 80 i 03 151 95 50 50 50 95 75 93 93 125 125 200 78 50 10.5 11.7 1 <4.0 18.0 8.8 9.0 8.0 8.0 5.5 5.5 - 32.0 5.6 -- 40.0 50.0 -- 30.0 -- "" - _ 16 29 28.5 29.3 17 20.5 13.5 13.5 10 10 7.8 23.5 29.5 Small size, balanced, twin conduc tor cable. omall size \HF and l>Hr cable. Can oe used for patch cord application. 223/U. Has thinner jacket for extra flexi bility and has double shielding. 58C U has 19 strands for extra flexibility. Large size, balanced, twin conduc tor cable. Video and FM cable with relatively high strength for the size. Small size, low capocitance, air spaced cable, aircraft installation. Medium sized, low capacitance, air spaced cable. Heavy duty twin lead in cable. Twin conductor small size. High temperature insulators for op eration in temperatures of--100eF to 500F. 151 34 30 20 225 39 39 46 92 152 110 34 135 50 6.5 24.0 29.5 High quality, small s?2e, for micro 85 wave transmission. 50 5.5 19.0 29.5 Medium size, flexible, for UHF. no 50 5.5 19.0 29.5 215 TJ is armored for shipboard 160 ` 1 and other severe use. 50 33.0 90.0 29.5 Special high attenuation cable with 86 small temperature coefficient of at tenuation. * Qualified Product These data are approximate and subject to normal manufacturing tolerances. FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony 9-1421 RBB 00270 CONTINENTAL-WIRE CORPORATION COAXIAL CABLES SINGLE CONDUCTOR SEmiSOliO INSULATION SINGLE SHIELD JACKET SINGLE CONDUCTOR INSULATION DOUBLE SHIELD TWIN CONDUCTOR 1N01V1DUAUY SHIELDED OVERALL SHIELD JACKET FOR FASTEST SERVICE PHONE OR WIRE WALLINGFORD, CONNECTICUT COIony '9-1421 RBB 00271 66 Ejgj m CONTINENTAL^ ASAdl 1959 NATIONAL ELECTRICAL CODE - TABLE 310-12 ALLOWABLE CURRENT-CARRYING CAPACITIES OF INSULATED COPPER CONDUCTORS IN AMPERES NOT MORE THAN THREE CONDUCTORS IN RACEWAY OR CABLE OR DIRECT BURIAL (Ba*ad on Room Temperature of 30C. or B6F,) tit* AWG MCM 14 12 10 8 6 4 3 2 1 0 00 000 oooo 250 300 350 400 500 600 700 750 800 900 1,000 1,250 1,500 1,750 2,000 Rubber ire* R lm RW TypetU Type RlfW (14--.2) Type RK-RW See Net* Thwwnplttiic Type T Typ*TW 15 20 30 40 55 70 80 95 110 125 145 165 195 215 240 260 280 320 355 385 400 410 435 455 495 520 545 560 Itubbtr Typ. RH Type tUH (l*-2) Typ* *H+RW Sh Not* 9 Typ* IHW Thtrmoptacttc Typ* TW 15 20 30 45 65 85 100 115 130 150 175 200 230 255 285 310 335 360 420 460 475 490 520 545 590 625 650 665 P.p*r Th.rm.pl.itjcAsb**ti Typ* TA SA | ` V*mjsh*d Cambric Typ* V Aibflte* V*mi*h*4 Cambric Typ* AVI Ml Cable i | 1 KHK* 25 30 40 50 70 90 105 120 140 155 185 210 235 270 300 325 360 405 455 490 500 515 555 585 645 700 735 775 Albtttee Vemtsbed C. fabric Type AVA Type AVI ! | lvnpr*9**t*d Asb.ftos Typ. Al Typ. AIA 30 35 45 60 80 105 120 135 160 190 215 245 275 315 345 390 420 470 525 560 580 600 680 785 840 30 40 50 65 85 115 130 145 170 200 230 265 310 335 380 420 450 500 545 600 620 640 730 Asbast.f Typ. A Typ* AA 30 40 55 70 95 120 145 165 190 225 250 285 340 CORRECTION FACTOR FOR ROOM TEMPERATURES OVER 30F 86F. C. F. 40 104 .82 .88 .90 .94 .95 45 113 .71 .82 .85 .90 .92 50 122 .58 .75 .80 .87 .89 55 131 .41 .67 .74 .83 .86 60 140 .58 .67 .79 .83 70 158 .35 .52 .71 .76 75 167 .43 .66 .72 80 176 .30 .61 .69 90 194 .50 .61 100 212 .51 120 248 140 284 .91 .87 .86 .84 .80 .77 .69 59 * See Notes following Table 310-13 on page 67. RBB 00272 CONTINENTAL WIRE 1959 NATIONAL ELECTRICAL CODE-TABLE 310-13 ALLOWABLE CURRENT-CARRYING CAPACITIES OP INSULATED COPPER CONDUCTORS IN AMPERES SINGLE CONDUCTOR IN FREE AIR (Based an Room Temperature of 30C. or 86 F.) AWG MCM Aubbtr Typ* R Type W Typ* U Typ* RUW 114-J) Typ* RH*ftW Sh Net* 9 7hrm*piaitic Typ* T Typ. TW . 14 20 12 25 10 40 8 55 0 80 4 105 3 120 2 140 1 165 0 195 00 225 000 260 oooo 300 250 340 300 375 350 420 400 455 : 500 515 ' 600 575 700 630 750 655 ' 800 680 900 . 730 1000 780 1250 890 -.1500 980 1750 ; 1070 2000 :: 1155 &vbb*r Typ* RH Typ* HUH (14-1) Typ* RH-RW S** Net* * Typ* RHW Th*rtiwphnttc Typ. THW 20 25 40 65 95 125 145 170 195 230 265 310 360 405 445 505 545 620 690 755 785 815 870 935 1065 1175 1280 1385 ThtrmoptasNeAtbtit : Typ*TA SA V*ntih*d ! Ctmbrie Typ* v Atb*fts> V*rrri*H%d Ctmbric ' Typ* AVfi Ml Cobit RHH* 30 40 55 70 100 135 155 180 210 245 285 330 385 425 480 530 575 660 740 815 845 880 940 1000 1130 1260 1370 1470 i Afb*ttvi* Vtnift*d Cambric Typ* AVA Typ* AVI lmpr*ftn*t*d AiInSIC* Typ* Al (I4-! . Typ* AJA j j f AtWlt*! Typ* A (14-*) Typ* AA 40 50 65 85 120 160 180 210 245 285 330 385 445 495 555 610 665 765 855 940 980 1020 1165 1450 1715 40 50 70 90 125 170 195 225 265 305 355 410 475 530 590 655 710 815 910 1005 1045 1085 1240 45 55 75 100 135 ISO 210 240 280 325 370 430 510 $(* ftvnttap Typ. It 30 40 55 70 100 130 150 175 205 235 275 320 370 410 460 510 555 630 710 780 810 845 905 965 1215 1405 CORRECTION FACTOR FOR ROOM TEMPERATURES OVER 30F 86F. C. F. 40 104 .82 .88 .90 .94 .95 45 113 .71 .82 .85 .90 .92 50 122 .58 .75 .80 .87 .89 55 131 .41 .67 .74 .83 .86 60 f 40 .58 .67 .79 .83 .91 70 158 75 167 .35 .52 .71 .76 .87 .43 -66 .72 .86 80 176 90 194... 100 212 120 '248 140.284 .30 .61 .69 .84 .50 .61 .80 .51 .77 .69 .59 * The cuiTenl-carrying capacities for Type RHH conductors, sizes 14, 12 ond 10 shall be the same as desigrated for type RH conductors in this cable. Note 9. If RH-RW rubber insulated wire is used in wet locations, the allowable current-carrying capacities shall be those of Column 2, Tables 310-12 and 310-13. If used in dry locations, column 3 shall be used. RBB 00273 68 CONTINENTAL WIRE ALPHABETICAL INDEX AIRCRAFT WIRE AN-J-C-48A ............. MIL-W-5086A .................... .... MIL-C-7078A (Type 1) ...................... ... MIL-C-7078A (Type II) ...................... . MIL-W-7139A (Teflon) .................. ..... MIL-W-25038 (Teflon) .................... .... - Page 53 49 50 51 52 52 APPARATUS CABLE Type AA .............................. ........... . Type AIA ............................................... Type AVA ............................. ............ Type SRA (Silicone Rubber)......... Type VG ............................................. ..... APPLIANCE WIRE Type AHG (300V and 1000V) .......... CSA Type A-15...................... . CSA Type A-l 6 .. ...... HINGE: Types A and AG CSA Type A-16 ..................................... .... LEAD WIRE: Types A and Al ........... ............... Type AG .............................................. .......... 15 14 8 36 16 29 33 31 26 31 27 26 RANGE WIRE: Type Al...................................... CSA Type A*17 ........... . Type 5RG (Silicone Rubber) Type TAA (Teflon) . Type TEW Type TG (Teflon) . 105C Polyvinyl Chloride . AUDIO WIRE ............................... BOILER ROOM WIRE Type AIA................................. Type AVA . ........................... BUILDING WIRE Machine Tool Type TW . BUS DROP CABLE COAXIAL CABLE 28 32 34 37 38 37 30 47 12 6 40 39 41 64-65 CONTROL CABLE Type AVA . Type PN Type T ............................... CURRFENT CARRYING CAPACITIES 9 44-45 43 63-66-67 FIXTURE WIRE Type AF Cords Type SEW Type SEWF Type SF Type SFF Types TF and TFF FLEXIBLE CORD GASOLINE RESISTANT WIRE HOOKUP WIRE (See instrument wrre) 23 24 34 34 34 34 40 24-25 .......... 39 INSTRUMENT WIRE AN-J-C-48A JAN-C-76 - Types WL, SRIR, SRHV, SRRF MII-W-76A Type IW Type MW................. Type HW ........................... Type HP .................................. MIL-C-915A--Types SRI, SRIB, MRI MIL-W-16878C--Unshielded MIL-W-16878C--Shielded Poge S3 55 56 57 58 61 62 59 60 MACHINE TOOL WIRE MICROPHONE CABLE 40 47 MINING CABLE Type AVA ......... Telephone 7 46 MOTION PICTURE CABLE IS MOTOR LEAD CABLE (See Apparatus Cable) MOTOR LEAD WIRE--Type AHC 29 NATIONAL ELECTRICAL CODE 66-67 "PETROL WIRE" . 39 POWER CABLE Type AGS Type AIA ... Type AVA (600V) . . AVA (1000V) .. AVA (2000V) AVA (3000V) AVA (5000V) Type AVB Type AVL Type SRA (Silicone Rubber) 17 13 T 2 3 4 5 11 10 . 35 RADIO HOOKUP WIRE (See instrumenr wire) RANGE WIRE Type A CSA Type A-17 28 32 RHEOSTAT WIRE Type AA Type AIA 30 12-13 SPEAKER CABLE ................................................... 47 STOVE WIRE . Types AA and AIA ..................................... CSA Type A-15 .............................................. STREET LIGHTING CABLE........................................ 30 33 46 SWITCHBOARD WIRE Type AIA ........................................................... Type AVB ........................................................... Type AVB Bus ............... Type SHFS ........................................................... Type TA ...................... Type TA Hinge .................................................... Type TBS ................ TELEPHONE WIRE Mine ............... ........................................ ... .... 12 18 11 22 19 20 21 46 THERMOSTAT WIRE ..................................................... 48 TRAFFIC SIGNAL CABLE ...................................... 42 FOR FASTEST SERVICE PHONE OH WIRE WALLINGFORD, CONNECTICUT COlony 9-1421 RBB 00274 V CONTINENTAL . . sales offices -1 . -j : * CALIFORNIA LOS ANGELES SAN FRANCISCO CONNECTICUT rAIRFIELO HAMDEN ILLINOIS CHICAGO LOUISIANA NEW ORLEANS MASSACHUSETTS OSTON MICHIGAN DETROIT MISSOURI ST. LOUIS NEW YORK NEW HTOC PARK NEW YORK City ROCHESTER OHIO CLEVELAND Dayton OREGON PORTLAND PENNSYLVANIA PHILADELPHIA PITTSBURGH TENNESSEE CHATTANOOGA TEXAS DALLAS HOUSTON WISCONSIN MILWAUKEE RBB 00275 4 WALLINGFORD, CONNECTICUT YORK, PENNSYLVANIA i RBB 00276