Document 7OpYzOebGbvNMLM2Z7Xa51LE8

(conoco) Interoffice Communication to Louis Legendre, Keith Fogg From Tom Grumbles Da December 17, 1981 Subject INDUSTRIAL HYGIENEAUDIT OF THE LCCP M This letter is to confirm your participation in the subject audit to be done on January 20, 21, and 22. The audit will begin the morning of the 20th and should conclude by 2:00 p.m. on the 22nd. Please let me know what your travel plans are. or^ Thomas G. Grumbles ajo CCR 000001622 6. REACTIVITY DATA CONDITIONS CONTRIBUTING TO INSTABILITY High temperatures INCOMPATIBILITY Strong oxidizers HAZARDOUS DECOMPOSITION PRODUCTS CO, C02 CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION 7. SPILL OR LEAK PROCEDURES STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED Evacuate the area and remove all sources of ignition. Avoid inhalation of vapors. Increase ventilation if spilled in an enclosed area. Vacuum large amounts. Smaller amounts may be absorbed and picked up mechanically. NEUTRALIZING CHEMICALS WASTE DISPOSAL METHOD Incinerate under controlled conditions in accordance with local, state or federal regulations. SPECIAL PROTECTION INFORMATION VENTILATION REQUIREMENTS Mechanical ventilation when in use. Local exhaust wherever possible. SPECIFIC PERSONAL PROTECTIVE EQUIPMENT RESPIRATORY (SPECIFY IN DETAIL): Organic vapor air purifying cartridge respirator or air supplied equipment dependent on concentration. EYE: Chemical goggles and face shield. GLOVES: Butyl rubber or other impervious material when handling liquid. CX R 000001626 OTHER CLOTHING AND EQUIPMENT: Other impervious clothing as needed to avoid skin contact. 5. HEALTH HAZARD INFORMATION 1 FIRST AID EYB: Flush with large amounts of water for at least 15 minutes. Seel medical aid. Wash skin thoroughly with non-abrasive soap and water. If irritation persists, seek medical aid. INHALATION-Remove v1ctilT1 to Fresh air. If breathing has stopped, administer 'artificial respiration or oxygen and cardio-pulmonary resusci tation if necessary. Seek medical aid. iiurKTinN* Do Not Induce Vomiting. If possible administer gastric lavage. u ' Avoid aspiration. Seek medical aid. NATURE OF HAZARD EYES: Vapors or liquid are irritation to the eyes. SKIN- Repeated or prolonged skin contact may cause defatting and lead to dermatitis. Percutaneous absorption may occur. INHALATION: Irritation to nose and upper respiratory tract. May cause CNS depression and reversible effects on liver and kidneys. INGESTION. syStemic effects may occur. EFFECTS OF OVEREXPOSURE: ACUTE OVEREXPOSURE: Dizziness, nausea; vomiting; anesthesia leading ____ to unconciousness and coma. CHRONIC OVEREXPOSURE: Unknown. Contains benzene which is a suspect Ipukemonpn THRESHOLD LIMIT VALUE (TLV) TOXICITY DATA None established. Based on the benzene content a value of 10 ppm for an eight howr TWA is recommended. SKIN CONTACT: No specif-jc data available EYECONTACT: No specific data available INHALATION: No specific data available 000001625 INGESTION: No specific data available SPECIAL PRECAUTIONS:. COfrmGT ' ' t/- ; interoffice Communication To Mike Marshall From Tom Grumbles D*t December 16, 1981 Subject VCM EXPOSURES TO PERSONNEL HANDLING CONOCO PVC RESIN Extensive personnel monitoring has been done on employees handling PVC resins in our plant at Aberdeen. After monitoring from 1974 to 1978 the monitoring result? -T-vr these workers were analyzed statistically. The results of this anal) ni.s showed that assuming a normal distribution, even two standard deviations from the average was less than 0.5 ppm. Please let me know if you need further information concerning this issue. Thomas G. Grumbles ajo 000001628 OCR