Document 70pZnKdD5zNabr5jez0338vzo

f ZONOLITE' FIREPROOFING MONO - KOTE' ...... W l 0*AC A CO ZONOLITE CONITRUCtlON PRODUCT! OIVIISION It \ Mono-Kote* cementitious 0450*619 spray-applied fireproofing Mono-Kote is the trade name for a fire protection material developed by Construction Products Division. W. R. Grace & Co., specifically for fast application, high fire resistance, and low cost. The material is spray applied by any one of several plastering machines. Mono-Kote is a cementitious (plaster), mill-mixed material requiring only the addition of water at the 10b. It is applied directly to steel, concrete and other surfaces requiring fire protection. S00"Sd c#m#nr<riouf Mono-*ot* wfntono 11' oroaion. orovonrs auit/nf i* Sir conditioning grid vsntiistmg lyitfmi page 2 technical data TIRE RESISTANCE: Mono-Kote he* been fire tested and reted by Underwriters' Laboratories. Inc., in accordance with test method ASTM E-X19. Fire ratings up to 4 hours have been achieved. Each bag of matenai bears the UL label venfying compliance with UL's quality control inspection program and the appropriate fire resistance rating. The reports and details of these tests are available upon request IN 1970. A MAJOR REVISION TO TEST METHOD E-119 WAS ACCEPTED BY ASTM AND UL BASICALLY. THE REVISION (1) INTRODUCES A NEW SYSTEM FOR RATING THE HOURLY PERFORMANCE OF ASSEMBLIES ANO STRUCTURAL MEMBERS AND (2) PROVIDES FOR TWO RATINGS FROM THE SAME FIRE TEST. THE UNDERWRITERS' LABORATORIES INDEX OF FIRE RESISTANCE RATINGS WILL IN GENERAL REFER TO TWO RATINGS -- ONE BASED ON TIME-TEMPERATURE PERFORMANCE ANO THE OTHER BASED ON A COMBINATION OF STRUCTURAL AND LESSER TIMETEMPERATURE PERFORMANCE CRITERIA. BECAUSE LOCAL BUILDING COOES MAY NOT YET HAVE ADOPTED THIS NEW UL CRITERIA. CONTACT THE JURISDICTIONAL MUNICIPAL AUTHORITY FOR VERIFICATION. Mono-Kote has been tested for other properties such as corrosion resistance, deflection, bond impact, surface hardness, etc. The test results comply with G.S.A. requirements and are available upon request. FIRE HAZARD: Tested and reported in accordance with ASTM E-84 by Underwriters' Laboratories. Inc. Flame Spread-10. Fuel Contributed-5, Smoke Developed 0 DRY DENSITY. Approximately 22 p c.f. RESISTANCE ~0 air EROSION- Independent laboratory test subjected standard, machine-applied Mono Kcte surface to winds exceeding hurricane velocity ever 100 M.P.H. for 87 hours . . . with no erosion Copies of test description available. SPECIFICATION S-ORT FORM! Sprayed fireproofing material shall be Mono-Kote as manufactured by Constructidn Products Division. W R. Grace A Co or its processing distributor it snail be applied by machine to the thickness required by local codes anc m the areas shown on the drawings. The method :f mixing and abO'-cat on snail comply with the manufacturer s -eccmmendations  specifications l U. nA i. score a) Work Included Provide al! 't1-. mater-a'* and ecu:/---: it --icjired for complete .rstallation of ail sprayed firecoctmg and related work as shown on the drawings or specified herein, and in accordance with all applicable requirements of the Contract Documents. b) Work Not Included 1. Structural steel encased in cone. . ,e. 2. Trowelled plaster fireproofing as specified under appropriate section. 3. The cleaning of the surfaces to receive sprayed fireproofing. c) Codes and Regulations This specification shall be supplemented by the applicable requirements of the Building Codes and all authorities having jurisdiction. Conflicts and/or discrepancies between Contract Documents, ordinances, etc., noted by the subcontractor shall be immediately brought to the architect's attention. 2. MATERIALS a) The sprayed fireproofing shall be plaster cementitious setting-twe. and shall be Mono-Kote as manufactured by Construction Products Division, W. R. Grace & Co.. or its processing distributors. All manufactured materials shall be mill-mixed and shall be delivered in original, unopened packages beanng the manufacturer's name and the Underwriters' Laboratories, Inc. label. The materials shall be stored off the ground, under cover, and away from damp surfaces. Materials shall be kept dry until ready for use. Materials that have been exposed to water before actual usa shall be discarded. b) Water shall be clean, fresh end free from organic and mineral impurities which would be harmful to the sprayed fireproofing materials. 3. ACCEPTANCE AND PERFORMANCE CRITERIA a) The sprayed fireproofing shall have been tested by Underwriters' Laboratones. Inc. in accordance with the procedures of ASTM E-X19. The structural steel members shall be protected with adequate fireproofing thicknesses and densities to provide the following fire resistance ratings: Steel columns............................................. Primary steel members (Girders) Secondary steel members (Beams) -Hours -Hours -Hours b) The sprayed fireproofing beneath the deck assembly together with adequately proportioned concrete fill above the metal decking shall provide a hour fire resistant deck assembly as substantiated by a fire test in accordance with the procedures of ASTM El 19, and performed by Underwriters' Laboratones. Inc. - c) The f.T r-oofing material shall not be subject to losses from the r ushed application by sifting, flaking or dusting. This performance shall be measured by the results of a test for erosion resistance when subjected to high velocity air flow across the surface of dried samples. The samples thus tested must be representative of machine applied material similar to that which can be expected on the project. The air velocity shall be not less than feet per minute, and the -- - ' f, a. -a -- 11 fh Note to Specifier Recommended Quality Criteria: TESTS a) The architect will select and the owner will pay an independent testing laboratory to sample and verify the density of ths direct-to-stsel fireproofing as applied. b) Contractor shall control thickness, utilizing a workable depth gauge to meet minimum thickness es required. He shall cooperate with the owner's Inspector in furnishing samples for tests. 4. SAMPLES Samples of sprayed fireproofing shall be submitted for approval in accordance with the applicable provisions of the Special Conditions. These samples shall be representative of the material as applieo in accordance with Acceptance & Performance Critena as stated below. 5. INSTALLATION a) Application of sprayed fireproofing shall be in accordance with the primed instructions 0f f- -- aterial manufacturer and the tire test report information. b) Upon request a qualified manufacturer's representative can be present for initial application to guide and assist applicator's personnel. c) All surfaces to which sprayed fireproofing will be applied shall be free of oil. grease, dirt, loose paint, mill seal# or any othar matter which would impair bond. d) All clips, hangers, supports, sleeves and other attachments to the fireproofing bases, as covered under other sections of the specifications, are to be placed by others prior to the application of the fireproofing material, where these attachments can be anticipated m advance. e) All patching and repairing of sprayed fireproofing, due to cutting by other trades, shall be performed under this section and paid for by the trade(s) that performed the cutting. 6. TEMPERATURE AND VENTILATION When the prevailing outdoor temperature at the building site is less than 40*F. an interior temperature of 40*F shall be maintained for 24 hours before and 24 hours after application of Mono-Kote. The plastering contractor shall provide natural ventilation to properly dry the Mono-Kote during and subsequent to its application. In glazed buildings, this shall be accomplished by keeping windows open approximately 2' top and bottom (or side pivoted windows approximately 4') to provide air circulation: and in enclosed areas or buildings lacking openings for natural ventilation by circulating exterior air and exhausting it to the outside by use of temporary circulators, exhaust fans or the air-conditioning system. 7. CLEAN-UP After completion of fireproofing work, equipment shall be removed and all wall and floor areas cleaned of deposits of sprayed fireproofing materials. page 3 Zonolite* plants and sales offices LISTED BELOW GEOGRAPHICALLY ARE THE MARKETS SERVED BY ZONOLITE - MONO-KOTE!' FIREPROOFING FACILiTiES. ARIZONA Phoenix B5031. P. O. Box 14279. (602) 272 6663 ARKANSAS Norrh L;tie Rcc* 72:14. P 0 Box 2=4. (SOI) 945-1678 California LOS ANGELES Los Angeles 90039. 5440 San Fernando Rd. West. (213) 245-6491 SAN FRANCISCO-OAKLAND Newark 94560. P. 0. Box 217. (415) 793-9111 COLORADO Denver 80223. Ill South Navajo Street. (303) 722-5707 FLORIDA Boca Raton 33432. P. 0. Box 67. (305) 395-3103 Jacksonville 32202. 1530 East Adams St.. (904) 355-8431 Tampa 33605. P. 0. Box 5047 Ybor Station. (813) 248-1554 GEORGIA Atlanta 30340. 6300 Button Gwinnett Dr.. (404) 448-5880 HAWAII Honolulu 96819. 842-A Mapunapuna Street. (808) 895-105 ILLINOIS CHICAGO Chicago 60643. 123C0 South Ashland Ave.. (312) 389-4900 Wilmette 60091. 3201 Old Glenview Rd. KANSAS Wichita 67214. 616 Pennsylvania. (316) 264-6251 KENTUCKY LOUISVILLE Wilders. Newport 41071. 112 North St.. (606) 291-3500 LOUISIANA New Orleans 70121. P. 0. Box 10262. (504) 834-5817 MARYLANO BALTIMORE/WASHINGTON. D.C. Beltsville 20705. P. 0. Box 347. (301) 953-2863 MASSACHUSETTS BOSTON Cambridge. 02140. 62 Whittemore Ave.. (617) 876-1400 SPRINGFIELD/WORCESTER Easthampton 01027. P. 0. Box 112. (413) 527-1890 MICHIGAN DETROIT Dearborn 48121. 14300 Henn Avenue. (313) 846-1010 MINNESOTA Minneapolis 55413. 1720 Madison St.. N.E.. (612) 789-2327 MISSOURI St. Louis 63110. 1705 Sulphur Avenue. (314) 645 8786 MONTANA Great Falls 49401. P. 0. Box 1419. (406) 453 1291 NEBRASKA Omaha 68107. 3520 "I" Street. (402) 731 3662 NEW JERSEY Trenton 08619. P.O. Box 2124. 15 Industrial Drive (609) 587-2570; (609) 587 2571 NEW MEXICO Albuquerque 87107. P. 0. Box 6302. (505) 345 1633 C ;w YORK CITY New York City 10017. 51 East 42nd Street <212) 661 3CS5 ROCHESTER.-SYRACUSE Weedsport 13166. P 0. Box 310. (315) 834 7971 -.gn Point 27260, P 0 Esx 1308. (919, 683-5:73 NORTH DAKOTA .Minot 58702. P. 0. Box 1782. (701) 838 1991 OHIO CLEVELAND C eveiand A4H3. 1125 West 11th Street (216) 621 3517 CINCINNATI w.iders Newport. Kentucky. 41071. (606) 291-3500 OKLAHOMA Oklahoma City 73111. P. 0. Box 11402. (405) 232-2058 OREGON Portland 97227. 2303 North Harding Street. (503 ) 288-5195 PENNSYLVANIA PITTSBURGH New Castle 16102. 202 East Cherry Street. (412) 654-7723 PHILADELPHIA Trenton. N. J. 08619. P.O. Box 2124, 15 Industnal Drive. (609) 587-2570; (609) 587-2571 PUERTO RICO San Juan 00905. P. 0. Box 4007. (809) 782 3080 SOUTH CAROLINA GREENVILLE/SPARTANSBURG Travelers Rest 29690. P. 0. Box 517. (803) 834-7272 TENNESSEE Nashville 37204. 4061 Powell Avenue, (615) 242-5496 TEXAS Dallas 75222. P. 0. Box 6306. (214) 637 0900 Houston 77008. P. 0. Box 7327. (713) 869-6663 San Antonio 78204. P. 0. Box 9114. (512) 223-5781 UTAH Salt Lake City 34110. P. 0. Box 2398. (801) 328-0117 WASHINGTON SEATTLE/TACOMA Auburn 98002. P. 0. Box A. (206) 852-5725 SPOKANE Spokane 99201. North 1318 Maple Street (509) 325-2541 WISCONSIN Milwaukee 53208. 900 North 43rd Street (414) 344-6667 CANADA ALBERTA Calgary 21. 701 Bnggs Avenue. (403) 265-6622 Calgary. 1240 Tenth Avenue. S.W.. (403) 244-0811 BRITISH COLUMBIA Vancouver 15. 109 East 69th Avenue. (604) 327 0485 Vancouver. 460 Industrial Avenue. (604) 683-0534 MANITOBA Winnipeg 10. 760 Wall Street. (204) 786-5681 NOVA SCOTIA Truro, 1145 East Prince Street ONTARIO Toronto. 3349A Bloor Street. West. (416) 233-1271 OUESEC Montreal 379. 140 Deslauriers. (514) 332-0520 SASKATCHEWAN Regina. 1035 Angus Street. (306) 569-3808 ZONOLITE PRODUCES OTHER a\D fidfpoocF'NG oODUCtS 3i'E FOR THESE DATA SHEE" PA-97R Zonolite Vermicul ? i;;er Aggregate PA-96R ZcncMe Perute Plaster Aggregate W. ft. CM ACC 4 CO. ZONOLITE CONSTRUCTION PRODUCTS DIVISION :'.S i -Si :;svr l.'t s a F*|'*ter#d rra:e*i'' q( Canti'-ca* - 3"z i -- *j * Co a-:-p -.e i;e. Man Q2UC ":oe *" r*e' * : "e ct*' 't s saic osi a*d ai*t t ta ;t feafl an ttiiemenu recomrre*oat.oni 0' *tr*in .a ca*tnc FI . rn :,,( > cni sJ.f mn.cn JOO'Y J sZOli IviODi'Cd Or Ml aifgm *0 reiBOMi at stattmenti rcem*eA0aT-3M or u<|n<oni not do .nttna at a . zn ':r would -nit i*t Oat' or COOyf'fM 62 WHITTEMORE AVE.. CAMBRIDGE. MASS. 02140 Phone; (617) 876-1400