Document 6wy4VodX0EO010mna2wg37qe4
CODE YE-69B-D"r*
- HfiY -0*81-^,1448
T~d at e~7"~ "7l o t ~n u mber J~
ESTIMATED WGT
5632 UBS,
PROCESSES
APPROVED BY
q \X
< > YE-69B-D (S) FWP 04/14/81
4f>
()
(>
<)
<>
COMTYP JOB NAME: 01YE698DMS
' STANDARD HRS*
TIME_______ M
EQUIP i f MENT ]
NAME: MOLYBDATE ORANGE
I USE I N-CODE | ACCT
I LBS I
1 LBS
PREP 1
r| OBTAIN FOR S-22
I 2 -TwEIGH FOR S 25
I O-t OBTAIN FOR S-30 f *4--f OBTAIN FOR S-34
j 5 I OBTAIN FOR S-36 i -4rf OBTAIN FOR S.-38
TAIN FOR S-40 WEIGH IN DRUM FOR S-42 OBTAIN FOR S-42
MjL-/i?..f.-2
WEIGH INTO V-351 CHECKED BY:
WEIGH INTO V-359 CHECKED
1 84 l 108--A 1. 7 .7 1 33"-D 1 734 1 4"-A 1 146 | 3"-A i 237 1 32"-D 1 367 1 15--A 1 243 | 3--A f. 28--D 1 70 v 1 711--B i --i li-.L-.-il 10-D
1
I. I 423-D
i 84 1 Sb 6^ 1 734 1 146 1 237 1 367 1 243 1 70 1 70
J 1885
I I 303
^pt *. , .RUN 20" <996 G) WATER^ INTO V- *h.~ _
I
J
XA&*rmm in f r o m v-354 c h ec k ed m/HNS&.<3>iLl22\ _~Zi
RECORD: G/MI_______(1*270-1.328)
1I
> RECORD: PH...<2.2-3.7)
I1
L#*r I ADJ TO 79" (3770G) AT 67~69F
l -I
1 >| RECORD: TEMP__J?J__P , STIR 5 MIN 6 RECORD: 'p H,,t Y<2.2-3.7)
\^A4iPi .J
IF NECESSARY,ADJ TO PH` 3" .0" -3"*1` ASSUME 602}
1 RECORD: 'PH-,,-l-jt*..
.I
1 NOTE: DILUTE N-7-D 10:1 WITH WATER BEFORE I
{ ADDING. .,0
ASSUME 5021
\yr r ec o r d : ALAi ^/h l < 1 135-1.138)
f | NOTE: IF G/ML OUT OF LIMITS FILL OUT
1 J< CHECK LIST & ATTACH
l>0r| STIR AT 67-69*F FOR S 28
41-D
| 5110 iS&o
358 RUN 10" (50 G) WATER INTO V-358
3 o
RUN V-359 INTO' V-351 & PUMP IN V-351 ADJ TO 55" <2600 G) SIFT IN N-108-A FROM SI*.
_ STIR 5 MIN & RECORD: PH.J.JL.<9.0~10.0)
2**T ADJ TO PH 9.8-9.9 & RECORD: PH__$!t.g ASSUME 502
, ASSUME 602
iaa< ADD N-33-D FROM S 2 (PUMP FROM V-351,
^FLUSH WITH 1000# WATER )
^Sr^ADJ TO 66" <3121 G> AT 67-69*F
j RECORD: V0L/.4-" & .....A 1 F
j27V..] STIR 5 MIN & RECORD: PH,,*J_.<7.4-7.6) &
G/ML
.080-1 .083)
1 NOTE IF G/ML OUT OF LIMITS FILL OUT CHECK
I LIST ATTACH
I
I *V ~
EQUIP I:
PAGE
CG 01 YE-698-D EST WGT 5632*
\
I USE 1 UBS
KI ii ii ii
OBTAIN 1 QT SAMPLES OF S-18 & S~27
SOLUTIONS 6 TITRATE TWICE
RECORD: LOWEST PH ___ & ML N-10-D______
LOWEST PH
5, ML N-10-D
NOTIFY SUPV IF ML N-IO-D IS NOT IN RANGE""
6.8-7.1 OR IF THE TWO TITRATIONS DIFFER
BY MORE THAN 0*10 ML N-10-D <IF YES,
. FLUSH ALL EQUIPMENT & REPEAT TITRATIONS)
DO NOT PROCEED IF N-10-D.TITRATION IS OUT
OF RANGE
cJy
ADJUST V-358 TO OBTAIN A TITRATION PM
(^LuOXX^rt-O-?
sn
"WHiN"s-2i"TifRATI0FoK"7""iTRIKi"v"55i"fHRU""""" BOTH UNDERSURFACE DISTRIBUTORS INTO SV IN
6 16-18 MIN
,c
RECORD: START
_____ , TOTAL MIN___ LK____
NOTE: STRIKE TIME UP WHEN 1/2 VAT BOTTOM SHOWS
& BUBBLES APPEAR IN SIGHT GLASSES '
IMMEDIATELY DUMP IN N-4-A FROM S 3 & SET TIMER
>3<t FOR.15 MINUTES DURING S 30, WASH IN V-358
&S^ STIR 2 MIN & RECORD PH..&JL.<1 .8-2.3)
PBXS,
__( MUST BE * )
STIR TOTAL OF 15 MIN FROM S-30 &
Ur
RECORD : TEMP.JtS--.#F
DUMP N-3--A FROM S-4
\j&I STIR 3 MIN
JSt POUR IN N-32-D FROM S-5
STIR o MIN
<67~73*F>
DUMP IN N-15 FROM S-6
STIR 3 MIN
>UMP IN N-3 FROM S-7
STIR 4 MIN FOR S-44
I N- I USE CODE I LBS
iI i1 j 33-D |. I 7-D I,
mm\JST DURING S-41 SIFT N-711-B FROM 5-9 INTO DRUM
7 T. > OF N-28-D FROM S-8 IN 1-2 MIN. yzr Ss TIR 1-2 MIN WITH PADDLE TO MILKY SOLUTION
I * mm *r V iiiM^WHEN S-41 COMPLETE, IMMEDIATELY POUR N-711-B
$ II SOLUTION GRADUALLY OVER 5 MIN PERIOD INTO SV
WATCH FOAM!!! IF FOAMING IS EXCESSIVE, STOP - POURING UNTIL FOAM SUBSIDES >r DUMP IN
IsM-TTSTtR 10 MIN ^ ^rT RECORD: PH_,,j .3-.-<5.8-6.0)
IF NECESSARY, ADJ TO PH 5.8-6.0
- * RECORD: PH- ~r_______ RECORD: TIMETO,,^CM
X&4T- FLOOD TO 153" <7619 G>
STOP AGITATOR
ASSUME 50% ASSUME 66%
350 I 128-AI 3.50
1 J
7-D! 33-D ]
START
FINISH OPTR -iLtfCfet
HELPER
1
DUP050095929