Document 6wVEDv85v3M1babqgkj96QqK4

Y<\ SPECIFIC GRAVITY (H50=1): 2.45 VOLATILE CONTENT: Absorbed Water 1 -- 4% By Weight. Structural Water Approximately 13% by Weight APPEARANCE: Pellets or Fine White Powder. No odor. Very Slight Solubility in Water. j A. :r.i*. >rV;15` . v :.. a ; 1 Material is not Combustible. No Fire or Explosion Hazard. ^ ;: t- sr iv f-- - -`V'- 1 -* " *\ V: *>. r. 11Vr ^ ; w i U ^ ;v.: INERT MATERIAL: No Decomposition or Polymerization Conditions. Hi--- l&tx'i* r.4.,'iit ^4/ 1 ?!'- -it - frs-- T~% PERMISSIBLE EXPOSURE TO AIRBORNE CONCENTRATION: The current standard of the Occupational Safety and Health Act of 1970 contains the following exposure limits: "The S-hour time-weighted average airborne concentration of asbestos fibers to which employees are exposed shall not exceed 5 fibers per milliliter greater than 5 microns in length, as determined by the membrane filter method at 400-450X magnification (4 millimeter objective] phase contrast illumination. No employee shall be exposed at any time to airborne concentrations of asbestos fibers in excess of 10 fibers per milliliter, longer than 5 microns." (Federal Register -- Vol. 37, June 7, 1972, page 11320}. EFFECTS Or OVER EXPOSURE: Prolonged over exposure wwy result in lung damage. i. .4 <---* 6<t EMERGENCY AND FIRST AID PROCEDURES: tsk* ml- r ! . *- xV/' *r > * - * ? i Tf t : ; V i STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: spilled material by vacuum cleaner or by water wash, Avoid inhalation of dust. Remove V, ^ fay^ . - X? ."V, ,, A. WASTE DISPOSAL METHOD: If reasonably foreseeable handling will not produce airborne concentrations in excess of exposure limits, no special procedures are required. When limits are likely to be exceeded, waste and scrap shall be collected and disposed of in impermeable sealed bags or other closed, impermeable containers, suitably labelled. - *% t'..\ 'kfe'' . ' \ r ` V" Union Carbide Corporation assumes no responsibility and makes no warranty/expressed or implied, repre sentation, promise, or statement as to completeness, accuracy, or currency of any data provided. UCC 025106 w-.-wr--Vy-,- ****?- \Mh . >y:'- i',:Ai\. jr'f VENTILATION: Local exhaust for each operation is preferable. (See American National Standards Institute booklet. 29.2 -- 1971.) General area exhaust is acceptable. No special considerations. PROTECTIVE GLOVES: None EYE PROTECTION: None OTHER PROTECTIVE EQUIPMENT: If tirv.u weighted average or ceiling concentration limits are exceeded, clothing providing whole body covering shall be supplied and its use required.______________ _______________________________________ RESPIRATORY PROTECTION*1 2> The current standard of the Occupational Safety and Health Act of 1970 contains the following guidelines: AIRBORNE CONCENTRATION12* 8-HOUR EXPOSURE13* CEILING CONCENTRATION REQUIRED MASK TYPE ' ' ACCEPTABLE MODEL*4* 5 maximum 10 maximum None required. - 50 maximum 500 maximum Over 500 100 maximum 1000 maximum -' U.S. Bureau of Mines Schedule 21B, Negative pressure on breathing. Covers nose and mouth. U.S. Bureau of Mines Schedule 21B Powered filter positive pressure. U.S. Bureau of Mines Schedule 19B Type C positive pressure, air supplied. Willson Model 1009 with R-520 Filter and M-S-A No. 86432 with Type H, Ultra Filter and others. Personal Environment Systems, Inc. Hood 330 or 351 with 1900 Series filter.. Willson GA2H M-S-A ' Lead-Foe and others. (1) Allowed only during the time required for installation of engineering controls, when engineering controls are not technically feasible or adequate, and in emergencies. An employee may not be assigned to tasks requiring respirator if his most recent medical examination indicates he will be unable to function normally. (2) Fibers per milliliter greater than 5 microns in length, as determined by the membrane filter method at 400-45GX magnification (4 millimeter objective! phase contrast illumination. (3) 8-Hour time weighted average. .. (4) Examples of masks approved by U.S. Bureau of Mines under the appropriate schedule. Reference -- Federal Register, Volume 37, Pages 11318-11322, June 7, 1972. If the time weighted average and ceiling concentration limits are not exceeded, no special precautions are required except: . a) Bag damage and dusting should be minimized and dust inhalation avoided. b) Every place of employment where asbestos fibers are released must be monitored by December 7, 1972 to determine exposure levels. c) A comprehensive medical examination is required for any employee exposed to airborne fibers within 30 days of first such employment, annually thereafter and on termination of employment. When exposure limits are exceeded, reference should be made to the regulation for details on caution signs, monitoring, change rooms, protective clothing laundering and record keeping. UCC 025107