Document 6BqkzQQX8OvK3O0M0v01X5Xn4

**" _ Scumisn Snemoimm General Construction OONTBAOT 6 Drrmxos htvti i Painting DIVISION XXVIII PAINTING Seeth* 1--GENERAL 1- The Contractor for 'work under this Division is referred to the "Instruction* to Bidders", "Pom of Proposal", "Pom of Contract", "General Conditions", "Special Conditions* if any, and "Contract Drawings", all of which are hereby made part of this Division of the work. Seetiaa 2--WORK NOT IN CONTRACT 1. Painting of the following is not included under this Contract: (a) Elevator oaks and doors. (b> Hatchway doors and bocks, except as otherwise specified. (e) Pomps, motors, boOora, breeching, blowers and oil honors and other -machinery. (d) Pipes and pipe covering in shafts and in cellars in locations where wall material is designated "UNPL" or "UNPL-PAINT* in Schedule of Interior Finiahse, except in Community Center. (a) Pipes and mechanical equipment in elevator and tank rooms. (f) Vents above roof. Section 3--WORK OF OTHER DIVISIONS L Painting of the following items is eaBod for as part of the work of other Divisions: (a) Hollow metal toilet partitions. (b) Kitchen Catenate and Wood Broom Closets. (e) Shop ooats where specified. (d) Medicine Catenets. (e) Metal Lookers and Miscellaneous Metal Units. Seeds* 4--SURFACES NOT TO HE PAINTED 1. No painting will ha required on the following: (a) Abrasive and bronze saddles and abrasive noting of stair treads. (b) All masonry sarfscas (intending concrete) throughout cellars, except laundries. Community Center rooms, management spaces, maintenance offices, toilets, passages, corridors and such other spaces as may he noted in the Schedule of Interior Finishes to be painted. (e) Masonry wall snrfaces inside of elevator shafts and pump and tank rooms. (d) Sloan. 0007NHA 1 000647297 R0155.cit(2137.iiycha22.nydia.orc) caseyd@nycha22jiycha.org. The Mar 1717:06:27 EST 1998 0007-N HA-000647297 N 4456 r* _ SttstuMD Snamuxxnm General Construction CONTEACT 6 Drnsmx T't vm Painting Seaton 4--SURFACES NOT TO BE PAlN1ia~.(CaatiaMd) () Overhead clothes dryers. (f) Mail bona. (g) Glased Facing Tile. <b) Galvanized iron poles in dothes closet*. <i) Aluminum windows and aluminum trim unless otherwise specified. (j) Stainless steeL Section 5--SCOPE OF VOIR 1. Excepting item* Ested under "Work Not in Contract", "Work of Other Divi sions", and "Snrfaoea Not to be Painted", the work under this Division consist of famishing all labor, materials, equipment, scaffolding and appliances for tbs complete painting and finishing of all interior plaster, masonry and concrete surfaces, all interior and exterior expoeed metal and wood surfaces in aooordanee with the Contract Sedton 6--SCHEDULE OF PA1NI1N6 L "WINDOWS (a) AH surfaces of all parts of steel sash and frames, and all surfaces of carings, trim and anchors shall be painted under tins Division with one coat of No. 7 or No. 8 paint as directed (depending on coIot selected by the Authority), before erection. Boles for futon screens shall be filled with putty before painting. 2. EXTEBIOB it bd* m (a) 8ted Saab, Frames, Lintels, (Baring Compound and Caulking................................................................. OJ>. 7or8 7or8 (7 or 8 as directed, depending on oolor selected by ' the Authority.) Notes: fad mot before erection, see Paragraph 1 above. 3rd coat (winch shall be slightly darker than second coat) shall be applied after sash is erected and glased and frames have bean csnlked, gluing compound and caulk ing reoeiving 3rd coat only. For Alnu'wiss Window: Paint lintels only; aluminum glaring compound and caulking left unpainted. 007NHA 00647298 (b) Pipe railing and all other exterior ferrous metal work which is not galvanised...................................... OJ>. 7 7 () Hollow metal and kalamrin doors, frames, carings, transoms and ridalighta ............................................... OJ>. 7 7 (d) Wood doors, frames, casings, transoms and side lights .............................................................................. OJ>. 2 7 2 R0155.cit(2137.nycha22.nycha.org) cascyd@tqrcba22.iqrcha.org. The Mar 1717:06:27 EST1998 0007-N HA-000647298 StUDOD General Construction CONTRACT 6 Dmutnr XXVTH Painting Sottas 6--SCHEDULE OF FACmNC--(CostSased) Coats 1st 3. INTERIOR: Apartments, Comnmnity Center Booms, Management Offices, Children's Center, Child Health Station. M (a) Plaster walk except in Kitchens, bathrooms and toilets ...................................................... ..................... i Note: The first printing coat shall be tinted the same color as fbe second coat (b) Concrete Ceilings, except in Kitchens, bathrooms and toilets ........................................................................ *i Note: Km first coat to be white and the second coat to be off-white. 3 4 None None (c) Exposed concrete beams and cohmma, except in Kitchens, bathroom* and toilets................................... *1 1 3 Note: To match walls. (d) Plaster walk in Bafhrocsns and toilets................. 1 5 None Note: The first priming coat ehall be tinted the same color as the second oast () Concrete oeflingt end exposed concrete beams and eohmtns in Bathrooms and toikte................................. *1 1 5 (1) Plaster walk in Kitebens...................................... 1 2 5 (g) Concrete ceilings and exposed concrete beams and columns in Kitchens ........................................................ l 2 5 *Exposed concrete columns and beams are to be primed at the same time and with the same primer aa used for concrete writings. (h) Masonry walk including columns in unplnstered spaces of Cammmtity Center........................................ 12 None None (i) Steel window sash, frames; steel trim ................... OD. 7 6 Notes: (1) This painting is in addition to that specified in Paragraph l.{a). (2) Interior of Aluminum sash friraae not to be painted. (j) Metal doors, bncka, partition ends and all other metal wort................................................................ 0D. 2 6 (k) Metal Base ...................................... .................... OD. 6 None Note: Should any wall paint ran orer metal base, the runs shall be thoroughly brushed out suitably to receive finish coat Paint imita tion base on exposed concrete columns of color and material aa need for metal base. Painted base to line op with adjoining metal base. 000&ojss 3 R0155.rit(2137.nycha22.nycha.org) casqd@nycha22jiycha.org. Tue Mar 1717:06:27 EST1998 0007-N HA-000647299 iMI Beaman Bnarasnom General Construction CONTRACT 6 Drrunow XXVlit Painting Section 6--SCHEDULE OF PADrtlNC--<Coatined) (1) Interior wood doom........... .................. ............. 1st 9 Wood Beats ........................................................... 9 Exposed wood sorfaeee of counters and desks in Mnnngmiamt ........................................... 9 Interior of desk drawers ...................................... 9 Movable Wood Toy Storage Cabinets and Wood Lockers, in Children's Center.................... ........... 9 Note: Finish of Wood Clothe* Locker* and Toy Storage Cabinets shall include all interior surfaces and back*. Cert* ted 13 13 Srd U 11 13 11 13 None 13 11 (m) Chair rails, dado strips, shelving, shelving dost* and ooat strips ............................................................. (Same as ad- None joining walls) Wickets, bulletin board frames, blanket storage units, and all other woodwork unless otherwise noted ...................................................................... OJ). 2 5 (a) That portion of combination sink and tray which does not hare vitreous enamel finish........................ OJD. 1 3 (o) Begister faces end Grilles .................................. OJ). 2 3 ELEVATOB BULKHEADS (a) Steel window seek, frames; steel trim.................. OJ). 7 Notes: (1) Tins painting is in addition to that oept soffits), stair railing, newels and stringers, metal doors, bucks, incinerator hopper door* and frames .. (b) Metal Stair Soffits................................................... OJ). 3 (e) Guard rails, hand rails, metal parts of stain (ex cept soffits), stair railing, newels and stringers, metal doors, bocks, incinerator hopper doors and and frames........................................ (d) Plaster walls and exposed concrete columns which form part of wall surfaces in Public Halls...................... 1 3 (a) Concrete ceilings, beams and spandrels in Public Halls and slop rink and janitors closets......................... 1 4 (f) Wells at slop sink end janitors closets.................... 1 5 (g) All masonry block, oonerete and plaster wall and ceilmg surfaces of Stairway*, Brit Halls, Stair Bulk heads and Elevator Machine Booms, including columns, beams, spandrels, soffits of concrete stain.................. 18 None (h) Underside of all slop sinks and support.................. O.D. 3 (i) Begister frees and grilles........................... . 0J>. 2 6 None OJ).26 None None None None None 3 0007NNA 000647300 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22.nycha.org. Tue Mar 1717:06:27 EST 1998 0007-N HA-000647300 M4 SzAsiusD SncmomoKB General Construction CONTRACT 6 DmooR XXVm Painting Section 6--SCHEDULE OF PAINTING--(Confined) 5. CELLARS, BASEMENTS, ETC. Cm lat ted (a) Walk and ceilings of passageways, corridors, toilets, locker rooms, maintenance offices, perambula tor rooms, tenant storage and other exposed concrete surface*, hollow tile, rinder block and brick surfaces in speoes noted an Schedule of Interior Finishes to be Pnted ............................................................................. 12 None None (b) Concrete end masonry block wall and column sur faces of Laundry............................................................ 17 17 None (c) Steel window sash, frames; steel trim................. OJX 7 6 Notes: (1) This painting is in addition to that specified in Paragraph 1(a). (2) Interior of Aluminum sash and frames not to he painted. (d) Metal doors and metal backs.................................. 0J). 6 None Note: AH interior doors below {he first floor have the top and bottom edges painted as specified for finish. (e) All exposed ferrous metal...................................... OD. 6 None 6. MISCELLANEOUS (a) Steel butte, spring binges, door closers and brack ets where delivered prime coated.................................. O.D. (b) Exposed parts of foundation vents, incinerator doors and frames in ceDars........................................... OJ>. (c) Electric panel covers snd frames throughout........ OJD. (d) Inside and outside of lire Hose Cabinets and ac cessories throughout (except where made of stainless steel or specified under Plumbing Contract to be com pletely finished) ............................................................. OJX 26 6 None 6 None 26 7. RADIATORS, CONVECTORS AND PIPING (a) Cast iron radiators and convector radiator enclo sures throughout.............................................................. .0JD. Note: The first field coat on east iron radiators to be applied before setting. (b) 3h all locations (except in the Community Center), where will material is designated "UNPL" or "UNPLPAINT", pipe lines will be painted by the Contractors for Contracts 7,8 and 9. In the Cammunity Center all piping shall be painted under this Division (color to harmonize with well aa directed), radndtsy ail spaces noted "UNPL" or "UNPL-PAETT. 5 2 14 0007NHA 000647301 R0155.cit(2137.nycha22.nycha.org) cascyd@nycha22jiycha.org. Tue Mar 17 17:06:27 EST1998 0007-N HA-000647301 Simian Snamcsxmxs General Construction CONTRACT 6 Dmaiow XXVm Painting Section 6--SCHEDULE OF PAINTING--(Continued) In other locations paint as follows: (c) Jin Standpipe lino............................ ................. (d) All exposed uncovered steam piping ..................... (e) All exposed plumbing and gas piping which ia not braae or chromium plated............................ ............... (f) All expoaed covered piping .................................... (g) All pipe hangers, etc................................................ Note: When painting is called for hereinabove in Section 6, on exposed uncovered steam piping and on Fire Standpipe tinea, the tint coat painting (primer) on expoaed uncov ered steam piping and the first eoat painting (finish coat) on the Fir* Standpipe tinea shall be applied immediately upon instal lation of piping. 1st 16 15 1 1 1 -Cmm me 6 2 3 S 3 ltd None 14 None None None 8. GENERAL NOTES (a) 'Where dadoes are called for on Schedule of Interior Finishes, dadoes shall be punted in contrasting color as selected. (b) Attention ia called to Section IS of Standard Specifications of Contract 6, Division IX--Combination Metal Bucks and Trim and Hollow Metal Doors. In the event the Contractor for General Construction exercises this option to furnish and install inch thick flush hollow metal doors in lien of interior Kalamein doors, painting of these hollow metal doors shall be the same as herein specified for Kaiamein doors. Section 7--MATERIALS FOB PAINTING 1. The numerals noted under Schedule of Painting (Section 6) refer to the paints tisted below: OJX ia the abbreviation for Shop Cost Under other Divisions of Specifica tions or under other Contracts. All coats other than Shop Coats shall be provided under tins Division. Material No. 1 Primer shall be of tame manufacture as the 2nd and/or 3rd costa and shall be the type and kind recommended by the manufacturers of 2nd and 3rd coats, all as approved by the Director, except as otherwise specified in Section 6, Paragraph 3, Subparagraphs (c) and (e). Material No. 2 Undercoat shall be of aame manufacture as the 2nd and/or 3rd coats and shall be the type and kind recommended by the manufacturers of 2nd and 3rd costa, all as approved by the Director. Material No. 3 M. J. Meridn Paint Co., N.Y.CJLA., Long (til Stippling Flat, or equal as approved by the Director. M. J. Meridn Paint Co., N.Y.CJLA., Long Oil Stippling Fiat or any other paint submitted under the "or equal" clause, will be required to pass the wash test specified under this Section. 6 0007NHA 000647302 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22.nycha.org. The Mar 1717:06:27 EST1998 0007-N HA-000647302 Sxasmbo Snoxnusaxs General Construction CONTRACT 6 Dxvumnr ZXVH1 Painting Section 7--MATERIALS FOR PAINTING--{Continued) Material No. 4 Barreled Sunlight Paint Co., Indnatrial list, or equal, aa approved by the Director. Material No. 5 Thomson, Heavy Bodied Porcelite Enamel, or equal as approved by the Director. Material No. Thomson Metal Trim Enamel, or equal, as approved by the Director. Material No. 7 Pittsburgh Sun-Proof House Paint, Trim Color (800 Series-- dark colors), alkyd Exterior Gloss Type, or equal, as approved by the Director. Material No. 8 National Lead Co^ Soft White Lead Paste; National Lead Co., color in oil; Pore Baw Linseed Oil; Dryers and Thinners mixed in proportions recommended by the National Lead Co., or equal as approved by the Director. Material No. 9 Factory Mixed, Pratt and Lambert, Varnish Stain and. linseed Oil, or equal, as approved by the Director; it shall be of color as selected by the Director. Material No. 10 McCloskey, Man O'War Ultra Bpar Varnish, or equal, as approved by the Director. Material No. 11 Interior Varnish, TT-V-Tla, Federal Specifications. Material No. 12 Cold Water Paint, Soybean protein tender, Type H, TT-P-23&, Federal Specifications. Material No. 13 Shellac, TT-S-271, Federal Specifications. ' Material No. 14 Heat Besisting Enamel--Pigment Composition: Zino Oxide 90%, Ooloidal Calcium Carbonate 10%; Pigment aa specified, ground in Damar Varnish, thinned with Palo Backing Varnish and Mineral Spirits and tinted as required. Pigment 42%--Non-Volatile 31 %--Volatile 27%. Material No. 15 iEnc Chromate prime paint, alkyd type, Joint Army-Navy Speci fication JAN-P-735. in,Material No. 16 Bed Lead paint, TTP-86a, Type Federal Specifications. Material No. 17 Texolite Duraval as manufactured by 1J. S. Gypsum Company, or equal, as approved by the Director. Material shall be used in strict accordance with manufacturer's directions. Material No. 18 Bean-base emulsion paint, TT-P-88a, Federal Specifications. Material No. 19 Cement Water Paint, TT-P-21, Class "A" Federal Specifications, Current Edition. Note.- Should the Contractor desire to substitute, under the "or equal" clauses, other paints than those specified, he shall submit five one-gallon samples for testing, at least three months before he proposes to use the material. The Authority will have the alternate material and the Standard paint listed above under materials, tested by * Testing Laboratory to be selected by the Authority, to determine if the alternate paint is equal to the paint listed in these specifications. The method of testing shall be as outlined in the following Federal Specifications. Primer TT-P-56 Enamel Type A of TT-E-508b 7 0007NHA 000647303 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22jiycha.org. Tue Mar 1717:06:27 EST 1998 0007-N HA-000647303 * finsnum Sracmamoxs General Conetraction CONTRACT 6 Dmsxow XXVHI Painting Sedkn 7--MATERIALS FOR PAIPrn?G--(Ctinved) The tTall Flat, however, shall be subjected to the chemieal and physical analysis of Federal Specification TT-P*61b and to a wash test to be conducted in the following manner: One week after the flat paint has been applied to the test panel, a portion of the painted area, not less than three (3) square feet in size shall be marked with the following materials: No. 2 Black Pencil, Bed and Bine crayons. Bed and Bine Inks, Vegetable, animal and Mineral oils and greases. The markings shall remain on the area to be tested, fifteen (IB) minutes or longer before washing. Straight Tri-Sodium Phosphate on a damp sponge or doth Bhall be need to remove the marks. In order to pass the washing teat, all of the above named stains shall be removed without injnry to Cm paint There shall remain a clean film, which shall not be marred or worn, and shall be free from blemishes. This paint film shall not exhibit n marked variation from the original finish by reason of the washing operations. The oost of making the teats wiD he bone by the Authority, provided the material passes the teats and is approved by the Authority. However, should the material fail to pass the tests and be disapproved by the Authority, the Contrac tor shall reimburse the Authority for the attire cost of making the tests on both tbs paints submitted as an alternate and the Standard paint Seaton ft--kUTKRIALS 1. The term "materials" as used herein shall Inetnde paint, oOa, enamels, colors, etc, that make np the products required for this branch of the work. 2. Materials shall be high grade products of reputable manufacturers, and when approved by the Director, shall be delivered to the Project in their original, unbroken containers, bearing the maker's name sad brand. Second or off grade materials will not be acceptable. 3. Colors shall be pure, non-fading pigments, finely ground in linseed oil. Colors to be used on plaster or concrete shall be limeproof. A AB materials shall be used in accordance with the direction of their manu facturer, subject to approval of the Director. Note: The Contractor shall not bring to the work or site any paint container bearing the name or brand of any material that has not been approved by the Director. Seeds* 9--PREPARATION FOK PAINUNC 1. Surfaces shall be clean sad dry and no painting shall be done in wet or freezing weather. 2. No prime painting of any kind win be permitted until the building is wall enclosed and the not made weathextight 8 0007NHA 000647304 R0155.cit(2137.nycha22.nycha.org) cascyd@nycha22.nycha.org. Tue Mar 1717:06:27 EST1998 0007- N HA-000647304 -U SxAmixD SwarauTtnuB General Construction CONTRACT 6 Dromon XXV1H Painting Section 9--PREPARATION FOB PAINTING--(Cootiaaed) 3. All metal surfaces shall be wire-brushed, removing all abrasions in the priming coat, rust, scale, hum, sad shall be thoroughly sanded, cleaned and touched up to matdi priming eoat. 4. All concrete masonry and plaster, bard white and cement surfaces specified to be painted above Cellars shall he cleaned of aU accumulated dirt and foreign substances; they shall he dry brushed and left dean, ready for painting. Before painting all holes, dents, hollow places, joints, cracks and irregularities in piaster, cement, concrete or metal work, shall be filled with an approved "Sparkle" mix ture suitable for the material and purposes. Sparkled places shall he finished to a smooth hard even surface. Holes in concrete caused by air bubbles % inch and less in diameter need not be sparkled unless occurring in dusters which impair the appearance of the work, in which case, they shall be sparkled. Any exposed concrete reinforcing ohairs or other accessories shall be sanded free of all rnst or scale and touched up with one coat of an approved primer designed to seal off stains. 5. Previous to painting or finishing, all woodwork shall be thoroughly cleaned and sandpapered, and all nail and sorew holes, dents, hollow places, joints, cracks and irregularities shall be puttied up with linseed oil putty. 6. Snots and pitch streaks shall be shellacked before painting. 7. The woodwork shall be smooth and free from aB raised grain or other surface imperfections before finish coats are applied. 8. 'Where painting is called for an concrete surfaces, the concrete shall be thoroughly cored and dry. and free from all foreign substances. Where cement paint. Material No. 19 is to be applied to concrete surfaces, after all patching, cleaning and rubbing, the entire surface shall be etched and wire brushed for proper cement point bond with a dilute solution of muriatic add and then washed off with dear water. Section 10--FAINTING 1. The Contractor shall he assigned by the Inspector to certain rooms in the Cellars of the Buildings in which he shall store his materials. All paint rooms shall he provided with lock said keys; 1 key for each room shall be furnished to the Inspector who shall have access to those rooms at all times. 2. The Contractor shall provide foam type 2% gallon capacity fire extinguishers as required by the New York City lira Department for each paint room. He shall keep all paint rooms dean and free from oil rags, waste and debris. He shall pro tect the finished floors with suitable coverings and shall not nse any plumbing fixture or waste pipe for the disposal of any waste mis, paints or other materials. 3. Paint and finishing materials shall be free from skins, lumps or any foreign matter when used and pigment fillers and other materials shall he kept well stirred while bring applied. 4. Each eoat of paint shall be evenly worked out and allowed to dry before sub sequent coats are applied. Each eoat of paint shall be a different tint from that of the preceding coat. Plaster wall surfaces, except where enamel is used shall have final coat of paint stippled with brush or roller to a fine atipple. The only purpose of Una stippling is to eliminate brush marks 9 0007NHA 000647305 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22.nycha.org. Tue Mar 1717:06:27 EST 1998 0007-N HA-000647305 Sxianuan Sraanomam General Construction CONTRACTS DmnoK XXVm Painting ScdSm 10--TAINTINC--(ConUnaed) 5. Finish coat or coat* of paint ahall be the exact abide, or shades and texture, aa approved by the Director from the samples eohmittod. All eolon shall be as selected by the Director. 6. The finished work shall be free from nms and sags, defective brushing and clogging of lines or angles. 7. 'When required nr necessary, bare or abraded spots in shop ooat shall be tonehed np by the contractor before applying final coats, using the same materials as used in the shop coat, or other material if approved by the Director. 8. No putty for glazing shall be painted and no sash shall be painted (except first field ooat) until after the potty firmly sets. All putty for glazing shall be painted **"* as sash. 9. The top and bottom edges of exterior wood doors, immediately after being fitted, shall be painted a heavy coat of Paint No. A Top and bottom edges of interior flush wood doors shall be thoroughly primed with varnish after any job fitting. Co-ordinate with the work of Division XX. 10. All pit and trench coven and frames shall be painted both aides. 11. Scribe moulds and filler pieces of kitchen cabinets and broom closets shall be touched np aa necessary to cover any damage to finish made by carpenter in scribing in place. Nail holes shall be puttied and the entire atrip shall match the embineta. 12. Before application of cement paint, Material #19, concrete surfaces shall be dampened with a fine fog spray immediately before application. After application of finished coat it shall he kept moist for 48 hours. IS. Where comer beads occur in acoustical plaster they shall be painted after erection, end, after plaster is dry, shall he tonehed np to match the color of the acoustical plaster. 14. AH pipes, registers and grilles painted nnder this Division of the work shall ha painted the same color aa adjoining painted surfaces. Sectiaa 11--LETTERING AND SIGNS L All lettering thronghout the Project, inside and outside, shall be executed under this divirion of the specifications. 2. Special lettering shall he as fisted and specified in the Amendments to this Division. A Apartment entrance doors will not require numerals as same are included in interviewers, famished under another Division. A At each floor of each building unit in Stairways, paint numerals designating floor level, painted in contrasting color from wall finish. Numerals shall be in two eentrasting colors, 6 inches high, placed 6 feet above floor in location as direetad. 5. In Public Tr*n at each floor level and Entrance Moor level paint floor numerals 6 inches high, 1 inch brush stroke, on walls at locations and to height indicated on Drawings. 10 0007NHA 000647306 R0155.cit(2137.nycha22.nycha.org) caseyd@iiycha22.nycha.org. The Mar 1717:06:27 EST1998 0007-N HA-000647306 Smhmp SPBcmciTnare General Gonstrnetioa CONTRACT 6 Dmmxmn Painting SeeOm ll--LETTEWNG AND SIGNS--(Cd) & All elevator shaft doors in all bondings liTl have 6 inch numerals desig nating the floor, painted on the shaft tide. 7. When elevators stop at alternate floors, each elevator door, on the entrance floor level, shall have the floor stops, at which the elevators stop, painted on the door in 1% inch Ugh letters above the glass fnoig thus: "THIS CAB STOPS AT2,4, 6,8,10........ ...FLOORS" 8. At all entrance doors to Community Center Booms, Laundries, Perambulator Rooms, Wheel Toy Booms, Maintenance Offices, Locker Rooms, Service Booms, Storage Rooms, Boiler Rooms, Incinerator Booms, Tank and Ptnnp Booms, Shops and other like spaces in Cellars, stencil letters 2 inches high shall he painted designating the name of the room. Abbreviations, even though noted on the Drawings, shall not be used. Toilet Booms shall he lettered "MEN"--"WOMEN" as the ease may be. 9. In addition to painting noted for Eieetrio Service Meter Booms in the previous paragraph, paint the following on all doors to these rooms in letters 2 inches high, in red in a panel: CEE NO WATER FERE DEPARTMENT 10. In addition to painting noted for Paint Shop, paint the following sign on wall of the Paint 8hop, where directed, in red letters, 2 foh* high in a panel: NO VOLATILE OILS ABE TO BE USED TURPENTINE SHALL BE OF HIGH FUSE (100*) lL The following lettering shall he painted on a piece of sheet steel and fastened with screws to the inside of each Stair hnlkbead door leading to the roof: FERE EXIT ONLY TENANTS MUST KEEP OFF ROOFS VIOLATORS OF THIS ORDER WILL BE PROSECUTED This sign shall he approximately 10 inches high by 16 inches wide and shall be painted as directed, in letters of colon as approved. 12. All doors to stairways, including exterior doom, shall have the word "EXIT" painted thereon so aa to be readable in the Direction of egress. Where double glass oamra, the letters shall be painted on the inside surface of the glass. Letters shall be in red, eight indies high and ana inch stroke. 15. Lettering in Style and Design shall be executed as approved by the Director, using No. 4 Paint and finishing with Spar Varnish. Painting of signs on roof doors, service doors and toilet doors throughout cellar and on shaft side of elevator doom may be done by atencOa. 14. AH sign work shall he executed hr experienced, capable mechanics. Sate 12--SAMPLES OF FINISHES L Samples of type of fiuiah on wood and metal, suitable in sice, shall he sub mitted for approval. The entire aide of an interior wood door shall be finished for approval U 0007NHA 000647307 R0155.cit(2137.nycha22jnycha.org) caseyd@nycha22aiycha.org. The Mar 1717:06:27 EST1998 0007-N HA-000647307 Sramuin Sraomussan General Construction CONTRACT 6 Dmaircr JULVjlu. Painting Section 12--SAMPLES OF FINISHES--(Coatined) 2. After selection of materials and colon, the contractor shall paint three (3) complete rooms for approval of the Director before proceeding further with the work. Section 13--SCAFFOLDING 1. 3J Contractor shall provide all scaffolding, ladders and other equipment required for the proper execution of this work, all of winch shall conform to all laws, rales and regulations governing same. Section 14-noncnoN 1. The contractor shall protect Soon and other finish, work from damage doting the execution of the work under tins division. 2. He shall be responsible for any damage done to other work under this Contract and shall, at Us own expense, replace any materials which, in the opinion of the Inspector, have become damaged to such an extent that they cannot he restored to their original condition. 3. ' Extreme ears shall be exercised to protect finished work while applying ***T"**ftT n surfaces. A Work not to be finished nnder this dviaicn shall be protected against spatter, stain or soiling, and each type of finished snrfsee shall he protected against defacement by other or subsequent finish. 5. AH surfaces shall be left dean at the completion of the work under this division. Section 15--RRE EXTINGUISHERS FOB PERMANENT PAINT SHOPS L Provide foam fire extinguishers as required end approved by the Deport ment of Buildings and the Fire Department) with standard wall brackets, of 2% gallon capacity each, labeled by the National Board of Fire Underwriters. 2. These extinguishers shall be substantially hung on the walla of the Paint Shops where directed by the Director. Section 15--SAND PAHS FOB PERMANENT PAINT SHOPS 1. Provide one-galkm galvanised iron sand pails as required by the New Pork City Building Code and New York City Fixe Department regulations. 2. These peils shell be hung on % by 1 inch galvanised strep iron brackets expansion bolted to the wall of the Paint Shop. Section 17--TOUCHING UP L At the oompletian of sll other work specified, all painted work shall be touched up and restored where damaged or defaced and the entire work left free from blemishes. Section It--CLEANING L The Contractor shall dean all paint spots, oil and stain from floors, wood work, glass, hardware, metal work, and all similar items and leave the work in perfect condition upon completion. 12 0007NHA 000647308 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22nycha.org. The Mar 1717:06:27 EST 1998 0007-N HA-000647308 M* Brnnuun Smarnoaxiam General Oanatraotion CONTRACT 6 Dmasm iXVJLu. Painting Section 19--APPROVALS 1. Before wring aay of the materials oovered in tins Division, the Contractor shall receive the approval of the Director in writing. Once formal written approval at the materials has been given by the Authority, no anhstitntion at material by the Contractor will be permitted for the duration of the Contract, except for reasons given in written instructions by the Anhority. 2. This submission for approval shall state: (a) Name of manufacturer and brand or trade name of the paint. (b) Manufacturer's formula for the material, and the maximum amount of thinner which may be added to the delivered packages without in any way impairing the valim of the material Section 20--PENALTIES L From time to time and as he may tee fit, the Inspector will take samples of the paint aa it is being applied on the project and will send same to a tasting laboratory. 2. If sample tested conforms with the specifications, the Authority wifi pay cost of test 3. If sample tested does not conform,with the sporiftatjons, the contractor shall pay cost of test and repaint all snrfaees as ordered hy the Inspector. Section 21--ORTT PRICES 1. The contractor shall consult the "Form of Proposal" and read Unit Prices and assure himself whether or not they will add to, deduct from, or in any way affect the cost of the work under this division of the specifications. 0007NMA 000647309 13 R0155.cit(2137.nycha22.nycha.org) caseyd@nycha22.nycha.org. The Mar 1717:06:27 EST 1998 0007-N HA-000647309