Document 6BQymxqg4KVy3BLmQbZgnVQ19

CG 04 CODE K0-736--D PKG 0CT/_2$_I982 T'd a t I") 5084* T2H36 i EST WGT ) < LOT > LOCATN PROCESS APPROVED / B'l < ) K0-786-B <p) FWP 10/04/82 COMTYP JOBNAME: 04K0786DMP TIME: _:0O__H STANDARD HRS* 10.5 ~PQ ZZ J*. MsEEDIm? 1 LBS /BEFORE USING SV, MAKE SURE THAT N--2S-B (HYDRO-!1 !/ CHLORIC ACID) LINE, IF ANY IS BLANKED OFF". |1 60*<990 G) WATER IN V-21 i & ADD ASSUME 50%:i so CAUSTIC SODA SQLN) & SET AGITATOR ON HIGH SPEEDiI a *\ WEIGH IN DRUM AND POUR IN (SODIUM SILICATE) 1 270 3 j DUMP IN AND STIR^ &tN (MOLYBDATE ORANGE) I0^X50 RECORD START_X5^-^ LOT 1 4X\fO FIN ^fJtJOtL 1______ N 1 ACCT CODE f LBS ---1 1 i 7-D J 15 J 32-D I 270 Ye/o 0 iYCior-t i 4(00 ><?0 _______ I 4'| ADJUST TO 75" <1275 G) *NOTE: VOLUMES HIGHER J>PHAN 75" MAY CAUSE DUSTING IN EXHAUST HOOD. 5*T WITH AGITATOR ON LOW SPEED PUMP V-211 THRU | .... HOMOG AT 1800-2200 PSI INTO V-208 (irTWHEN V-211 MT, WASH COLOR THRU HOMOG WITH MIN OT WATER AT 1800-2200 PSI INTO V-208 *r \ JftCtfBi)*. V-208 VOL._______ * & ADJUST TO 50*<184G.) INSPECT HOMOG STRAINER c\ CLEAN IF NECESSARY 9-T RUNE5S' i(771 G ) WATER INTO V-, START | j -XaAgGiItTaAtTcOR & INSTALL TEMP CHART ! 1 dn PtlHF V- 20( 8 THRU HOMOG AiT 4800-5200 PSI INTO SV. ! RECORD: TIME START fjJ&ffoTAL MINUTES Z>M$ 1 IF HOMOG PRESSURE FALLS BELOW 480 PSI, i -WAY VALVE WILL RECIRCULATE SLURRY TO V-208 i WHEN V-208 MT, RUN IN 5*<240 G) WATER & PUMP i THRU HOMOG AT 4800-5200 PSI INTO SV ! NOU 1982 349 & 384 iijS? WHILE HOMOG RUN 6 * (284 G) WATER INTO V-349 i^f^-RUN 1000* WATER INTO V-384 h HEAT TO 11~120F W<J^-WEIG.H INTO V-384 'h PUMP TO V-349 UPlS J RUN 1OO0* WATER INTO V-384 & PUMP TO V-349 ADJ V-349 TO 22* ,<1040 G) h STIR 15 MIN RECORD DENSITY: //M^G/ML ( T* 078-1 < 081 ) i 2400 1 32-D 2400 frSV L-WtfE'N S-1 1 HOMOG JSOMPLETE, ADJ SV TO 66" (34 00 G> J PECORD: PH / A & ADJ TO 10.4-10.8 USING N-7-D i 4 , DILUTED TO 5% "(10 PARTS WATER TO 1 PART N-7-D) ! |' ASSUME 50% ! I SIPHON N--7-D INTO SV U RECORD: PH \ 1 HE.A1 TO 190-194KF IN 55 65 MIN 6 REC.:-H1 Lit.M i J i< RECORD i?,<!.. *''* ' ! '' . 7 QUIP HENT I . COMTYP JOB NAME = 04K0786DMP PAGE 02 PAGE 2 CG 04 K0-786--B lA 2/6 DAT E PR USE I iL: BS' /2l >82 N -- ! ACCT CODE ! LBS WHILE HEATING | ^p-"' v-343 >25 I METER IN (SULFURIC ACID 60%) FROM V-386 35! >2CKSTIR 15 MIN OR LONGER RECORD: DENSITY hMf- G/ML <1 .018-1 ,020) 4EN S 20 HEATING COMPLETE, RECORD: PH A T V-343 ACID PUMP AT 72 SETTING <225 MIN) ET V-349 SILICATE PUMP AT 66 SETTING <180 MIN) IZfr'T MEDIATELY METER IN V-343 6 V-349. MAINTAIN SV i 1 90-1 94MF DURING STRIKE 2-T ! RECORD: START FIN MXI^TES V-343 V-349 wKZo.^, TIME V-343 V-349 NORMAL INCHES MIN^C^ <47> INCHES (2m.2a PH 9.3-10.0)| <43>,,W. Cl <9.3-10.0)| HR 3.1IP < 38) 1 5),,,,<5 UtLf( 9.3-10.0) | hHRr 463$ 87M>'0>.,, < 7>^r_ ( L*l_<9.3-10.0) | J_<9.3-10.0)I FINISH^jJ' < 0>___ TiJ&fC 7.5-8.5) ! NOTE: IF PH DROPS BELOW 9.3 IN FIRST HOUR, STQPI PUMPS 6 SEE SUPV. IF FINAL PH IS ABOVE I 8.5, ADJ TO 7.5-8.5 & RECORD: _PH I ASSUME 77% I ii ______I 27-D |______ ADD 67' <514 G) WATER TO V- 385 $, STIR 2 MXN S' 50 7-D 32 | WHEN V-349 MT, RINSE IN WITH MINIMUM WATER & JET PUMP AT ZERO SETTING WHEN V-343 MT, RINSE IN WITH MINIMUM WATER & I L^-TORN OOFFF PUMP MOTOR ! 3-4-^TdRN OFF STEAM <UN IN LIQUID ALUM USING BADGER METER 600 f115-D LUSH ALUM LINE WITH WATER. RECORD: FHJL6. <3.3-3.7) & IF NECESSARY ADJ <DOWN ONLY) TO 3.3-3.7 it RECORD: PH___,, I NOTE: USE LIQUID ALUM, N-115-A. ADD TO SV VIA I i BADGER METER. STIR 5 MIN AFTER EACH ADDITION. ASSUME 50%i________1115-D 3I.RUN IN N-7-D/ROM S 33 IN 4-6 MIN & STIR 5 MIN | | 1RECORD: PH,,5f'^f4.0-4.2) & IF NECESSARY ADJ TO PM 4.0-4.2. RECORD: PH ___ ASSUME 77%I ! 27-D fLUTE N-7-D 10: TO 1 WITH WATER ASSUME 50% i| 7-D SIPHON N-7-D INTO SV WHEN SCHEDULED ON TOP OF PAGE 1, DUMP IN SUBSTANDARD TO BE BLENDED BACK. RECORD: CODE LOT STOP AGITATOR JTART^ FINISH* OPERATOR -Jteif:. I 75 1 300 t Siip/t- !3f DUP050060094 DUP050060095 DUP050060096