Document 49oMDGNLxmgg1ywLVr7GzgMR

tr 'cM CODE YEpZJI-D < DATE ) _L(/ 4448* LBS* 71 < LOT ) p ( EST WT ) PROCESSES < ) YE-721 -D (hi) APPROVED BY: FW'P 11/08/82 COMTYP JOB NAME: 01YE721DMM BLENDED BACK : CO 01, F'Q 98, (CODE) ----- ' (POUNDS) EQUIP | MENT i --------- i PREP ! 1I 351 359 3 NAME: MOLYBDATE RED OBTAIN FOR S-12 3BTAIN FOR S-34 OBTAIN FOR S-3S JTAIN FOR S-40 STAIN FOR S-44 OBTAIN FOR S-47 WEIGH WEIGH IN: OPTR lj&t OPTR m mm M mm mm mm mm IN : 0PTft/*a.., OPTR MK-^l?, T-___ MK T-____ , ______% mm mm-mm m* :mm mm mm .mm mm mm vm+ mm mm mm-mm mm mm "mm mm mm MK M., 1-362,23&-V. MK T-___ 6PCT N-CODE | LBS RUN 10* (500 G) WATER INTO V-358 "J59 INTO V-351 & PUMP IN V-351 TO 55* (2600 G) IN N-108-A FROM S j , 5 MIN 6 RECORD: PH_-/,*>_(9.0y 0) ADJ TO PH 9*8-9*9 & RECORD: PH,,J?L'.? ASSUME 50% ASSUME 66% RUfcUINTO V-351 FROM BADGER MEXER^y- R^S^C---> K%J2.__ _ sJSl&Lz UMP FROM V-351 TO V-358 FLUSH V-351 4, PUMPING LINES WITH lOOOG ! LJWATER INTO V-358 in ADJ TO 74* (3530 G) AT 67-69*F RECORD: VOLXM.* 4, __&l ZJ*F I 1 i STIR 5 MIN.^RECORD: PH.^Lj<7.2-7,4) 6 I G/ML 1.055-1 *058) i NOTE IF G/ML OUT OF LIMITS FILL OUT CHECK LIST & ATTACH* TAKE 1 QT SAMPLE, RUN 20* (996 G) WATER INTO V- ^*21. RECORD N-41-D STORAGE TANK TO PUMPFROM.* IRCLE ONE: 402 410 411 420 42403D CHECK WITH CU SUPV-. *ST0RAGE TANK MUST CONTAIN AT LEAST 1900 GAL: 462-39*. 410=20*. 411=38", 420=20' 424=20' *ST0RAGE TAM MUST HAVE STIRRED AT LEAST 2 MIN SINCE LAST ADDITION OR ADJUSTMENT h STORAGE TANK MUST BE ISOLATED UNTIL ALL HP IMG FOR THIS BATCH IS COMPLETE,. SET METER FOR 300 5 & PUMP TO SV LOT: EQUIP KENT | SV~~I__ COMTYP JOB NAME: 01YE721DMM PAGE 02 AT APPROX 100 G WHILE CONTINUING TO PUMP DATE PRINTED:11/08/S2 USE N- ACCT jLw j CODE LBS 51 CUNT | CHECK PH ic DENSITY. RECORD BELOW. IP NOT IN RANSE, STOP PUMPING & SEE SUPV. I * PH^/L <2.2-3.7) DENSITY: G/ML (1.270-1 .328) IF S-23 OK ^JWHEN S-22 COMPLETE, RECORD DENSITY/aJSsQL G/ML ON TRAPPED SAMPLE L*J5ROH END OF S-22 PUMPING. ^eruUsSIiNG DENSITY FROM S-24, FIND METER SETTING FOR SECOND PUMPING IN TABLE BELOW. NOTE: TABLE ACCOUNTS FOR 300 G ALREADY PUMPED IN S-22. CIRCLE DENSITY & SETTING IN TABLE BELOW. #*** TABLE * * G/ML 1 .270 1 .271 1 .272 1.273 1 .274 1.275 1 .276 1.277 1.278 1.279 1 .280 1.231 1.282 1.283 1.284 1.285 1.286 1 .287 1.288 1 .289 1.290 SETTING 1 G/ML 1259 1 1 .291 1253 1 1.292 1248 1 1 .293 1242 1 1.294 1236 1 1.295 1231 I 1.296 1225 1 1.297 1219 } 1.298 1214 1 1.299 1208 1 1.300 1203 1 1.301 1198 1 1.302 1193 1 1.303 1187 1 1.304 1182 i 1 .305 1177 1 1.306 1171 1 1 .307 1166 1 1 .308 1161 1 1.309 1155 1 1.310 1151 1 1.311 SETTING 1 G/ML SETTING 1 1146 1 1.312 1049 1 1141 1 1.313 1045 1 1136 1 1.314 1040 | 1131 1 1.315 1036 | 1126 1 1.316 1032 | 1121 I 1 .317 1027 | 1116 1 1.318 1023 | 1112 1 1 .319 1019 | 1107 1 1 .320 1015 | 1103 I 1 .321 1010 1 1098 1 1.322 1006 | 1094 1 1 .323 1003 | 1089 1 1.324 999 | 1084 1 1.325 995 1 1080 1 1.326 991 1 1076 H25D 1070 1 1.328 983 | 1066 1 1,329 979 1 1061 1 1 .330 975 | 1057 1 1.331 971 | 1053 1 1.332 967 | 1 1 I 1 1 I 1 1 1 1 I I 1 1 1 1 1 1 1 1 1 1 SET METER 6 PUMP G (RECORD FROM TABLE) FLUSH LINE WITH WATEF INTO SV FOR APPROXIMATELY I SECONDS | ADJ LEAD NITRATE TO 3244 G (68'-242/a*MfliHfer | AT 67-A9*? | I 41-D CORD: _4Su*_*F & ICE CONSUMED (330*/BLOCK> I330X__| 57-A STIR 5 MIN & RECORD PH(2.2-3.7) w# USE TITRIMETER TO ADJUST N-41-D PH #** j j IF NECESSARY ADJ TO PH 3.0-3.1 ASSUME 66Z|________ | 33-D RECORD PH: ASSUME 50Z|________ | 7-D I JxOTE: DILUTE N-7-D 10:1 WITH WATER BEFORE ADDING| 3*1 R1P0RD:V^^_ G/ML (1.128-1.129) IF OUT OF SPEC I I I INFILL OUT CHECK LIST 6 ATTACH, fir] STIR AT 67-6?#F FOR S-33. TAKE 1 QT SAMPLE. I 4094 DUP050059708 L.cr= EQUIP ME'NT I COMTYP JOB NAME: 01YE721DMM PAGE 03 DATE PRINTED:11/08/82 USE N- USE LBS CODE LBS $\T~ 5 CONT OBTAIN i QT SAMPLES OF S-1? & S-31 SOLUTIONS 4. TITRATE TWICE NOTIFY SUPV IF ML N-10-D IS NOT IN RANGE 9,5-9.? OR IF THE TWO TITRATIONS DIFFER BY MORE THAN 0,10 ML N-1D-D (IF YES, FLUSH ALL EQUIPMENT 6 REPEAT TITRATIONS). DO NOT PROCEED IF N-10-D TITRATION IS OUT OF RANGE ADJUST V-358 FOR A TITRATION PH OF FROM FINAL IN-LINE TITRATION, RECORD LOWEST PH & ML N-10-D DL^jJjL c?> 33-D 7-D WHEN S-32 TITRATION OK, STRIKE V-358 THRU BOTH I I UNDERSURFACE DISTRIBUTORS INTO SV IN 4 46 MIN I | RECORD: START TOTAL MIN V I i NOTE: STRIKE TIME UP WHEN 1/2 VAT BOTTtf I L^rBUBBLES APPEAR IN SIGHT GLASSES 13-ri IMMEDIATELY DUMP IN N-4-A FROM S 2 & SET 15 MINUTES 135 LOURING S 34, WASH IN V-358 . |3<T | MfR 2 MIN 4< RECORD PH__!L^__<1.7-1.8) J^PBXS,toJX!!`__<MUST BE + ) YT STIR TOTAL OF 15 MIN' FROM S-34 6 ICORD: TEMP_-.JSr_-.HF <67-?3*F) N-3-A FROM S-3 3 MIN IN N-32-D FROM S-4 IR 2 MIN N IN LIQUID ALUM USING BADGER METER !49 >TIR 3 MIN & FLUSH ALUM LINE WITH WATER 14/rT^ IN N-3 FROM S-5 604 115-D 302 STIR 4 MIN FOR S-49 RUN IN HYDROCHLORIC ACID USING WEIGHT aUfLOW, | ^ CONTROL PANEL MK v___ .30,%*/ MK ______, _______%I,,_____ DURING S-45 SIFT N-711-B FROM S-6 INTO V-390 I WITH AGITATOR ON IN 1-2 MIN I STIR 1-2 MIN TO MILKY SOLUTION | 28-D 28-D n WHEN S-45 COMPLETE, IMMEDIATELY RUN IN N-711-B 1 SOLUTION GRADUALLY OVER 5 MIN PERIOD INTO SV | WATCH FOAM!!! IF FOAMING IS EXCESSIVE, STOP | 1 UNTIL FOAM SUBSIDES: P IN BLANC FIXE N I_ >"575 |>KTWWIHEN SCHEDULED, DUMP IN BLEND BACK LISTED ON ' I I TOP OF PAGE 1 Uig^SSTRIRECO20RDM: INCO/DE _mi__, ^ LOT _TTr.___, 'CORD: PH,,Jtl__(5.8-6.0.) IF iiECESSARY, ADJ TO PH^ 8-6.0 ASSUME 50% & RECORD: PH~_J"L_______ ASSUME 667, FLOOD TO 153' <7298 G> 4. STOP AGITATOR 706#* 3*9 FINIS OPTR 128-A 275 7-D 33-D DUP050059709