Document 44EXp7x4O16JReXeVeRyXV9bR
FILE NAME: Asbestos Cement Pipe and Sheet (ACPS) DATE: 1986 Jan 16 DOC#: ACPS135
DOCUMENT DESCRIPTION: Material Safety Data Sheet - Asbestos-Cement Pipe [Transite Pipe]
U.S. DEPARTM ENT O F LABOR Occupational Safety and Health Administration
MATERIAL SAFETY DATA SHEET
Required under U S D L Safety and Health Regulations for S lip Repairing, Shipbuilding, and Shipbreaking (29 C F R 1915, 1916, 1917)
Form Approved OMB No. 44-R13S7
Prepared By: Dr. E.E. Wang Rev. 1-16-86
M A N U FA CTU RER'S NAME
SECTION
EM ERGEN CY TELEPH O N E NO.
J-M A/C Pipe Corporation___________
a d d r e s s (Number, Street, City, Stele, end ZIP CodeI
1051 Sperry Road. Stockton. CA 95206
CH EM ICAL NAME AND SYNONYMS
Asbestos-Cement Pine
CH EM ICAL FA M ILY
Mineral
[209] 982-1500
T R A D E NAME AN D SYNONYMS
TRANSITE PiDe
FORM ULA
N/A
SECTION II - HAZARDOUS INGREDIENTS
PAINTS. PR ESER V A TIV ES. 8i SOLVENTS
*
TLV
(Uniti)
ALLO YS AND M ETALLIC COATINGS
PIGM ENTS
BASE METAL
CATALYST V EH ICLE SOLVENTS AD D ITIVES
N/A N/A N/A
A LLO YS M ETA LLIC COATINGS FILLER METAL PLUS COATING OR CO R E FLU X OTHERS
N/A
q/A
N/ A
N /A
OTHERS
N/A
HAZARDOUS M IXTURES OF OTHER LIQUIDS, SOLIDS. OR GASES
Asbestos [CAS 8: 1332-21-4], A Carcinogen Determined By IARC Silica [CAS #: 7631-86-9]
Portland Cement
* TLVs Refer To Airborne Concentrations Over 8-Hr TWA.
TLV % (Uniti)
TLV w % (Units)
15 2f/cc 35 5mg/m^ 50 ISmg/m
BO ILING POINT (F.) V A P O R P R E S S U R E (mm Ha.) VAPOR D EN SITY (AIR-1) S O L U B IL IT Y IN W ATER a p p e a r a n c e AND ODOR
SECTION III PHYSICAL DATA
N/A N/A
N/A
SP EC IFIC G R A V IT Y (H jO -1)
PERCENT, V O LA TILE BV VOLUM E ()
EVAPORATION RA TE
1
-1)
N/A
Grayish-White Pipe; Odorless;
SECTION IV - F IR E AND EXPLOSION HAZARD DATA
F L A S H PO IN T (MaUiod u n d )
FLAM M ABLE LIM ITS . . . .
Lai
N /A
EXTIN GUISH IN G M EDIA
, .
N/A
S P EC IA L F IR E FIGH TIN G PROCEDURES
N/A
1.85___ N/A N/A
U8l
U N U SU AL F IR E AND EXPLOSION HAZARDS
None
P A G E (1)
(Continued on reverse aide)
JONES 0003882
Form OSHA-20 R n . May 71
A/C Pipe
SECTION V HEALTH HAZARD DATA
TH RESHOLD LIM IT V A LU E
Shown On First Page; Inhalation Of Excessive Silica Mav Cause Silicosis.______
EFFECTS OF OVEREXPOSURE
Over-Exposure To Excessive Concentrations Of Airborne Asbestos Fibers May Cause
Pulmonary Disease. Smoking Greatly Increases Risk From Asbestos Exposure._____
EM ERGENCY AND FIRST AID PROCEDURES
Inhalation: Move Person To Fresh Air. Eyes: Wash With Water For IS Minutes.
Skin: Clean Area Of Contact. Ingestion: Seek. Medical Attention If Necessary.
SECTION VI - R EA CTIV ITY DATA
S T A B ILIT Y
UNSTABLE
c o n d it io n s t o a v o i d Power Driven Saws With Abrasive Discs Should NOT Be Used For Drv Cutting Or_____
sta ble
i n c o m p a t a b i l i t v (Materiali to avoid)
None
H A Z A RRDDOOU S D ECO M PO SITIO N P R O D U C T S
None
HAZARDOUS POLYM ERIZATION
MAY OCCUR W ILL NOT OCCUR
Beveling Asbestos-Cement Pipe. Always Avoid Creatii ig And Breathing Dust.
CONDITIONS TO AVOID
N/A
SECTION VII - SPILL OR LEA K PROCEDURES
S T EP S T O B E T A K E N IN C A S E M A T E R IA L IS R E L E A S E D O R S P IL L E O
Pipe Fragments And Installation Debris Must Be Handled In A Manner Which Avoids Airborne Dispersion Of Asbestos Dust. Use Wet Or Vacuum Method For Clean-Up.
W ASTE DISPOSAL METHOD
Comply With All Applicable Local. State. And Federal Repulat-ions
SECTION V III SPECIAL PROTECTION INFORMATION
r e s p ir a t o r y PROTECTIO N (Specify type)
Not Required When Recommended Work
VEN TILATION
LO CAL EXHAUST
N/A
M E C H A N IC A L (General) N/A
PRO TECTIVE G LO VES
Not Required
O TH ER P R O T E C T IV E EQUIPMENT
Not Required When Recommended Work
Practices ftTe :n l 1owed
S P E C IA L
N/A O TH ER N/A
E V E PROTECTION
______________ Not Required______________
Practices Are Followed.
SECTION IX SPECIAL PRECAUTIONS
PRECAU TIO N S TO B E T A K E N IN HAN DLIN G AND STORING
____ Follow "Recommended Work Practices For A/C Pipe'* Published Bv A/C Pipe________
____ Producers Association.________ ____ ____________ ____________________________
OTHER PRECAUTIONS
All Tools Which May Release Asbestos Fibers Tn
nf Thp FvpnsiiTP Tim-ii-c choiL-
Be Provided With Local Exhaust Ventilation Systems.
-
' Note: This Information "Is-Given'Without Warranty,' Representation/'Induceraent-Or - - Xe
PAGE 12) License Of Any Kind, Except That It Is Accurate To The Best Of Our Knowledge
opo .s 40 Qr obtained From Sources Believed By Us To Be Accurate, And We Do Not
Assume Any Legal Responsibility For Use Or Reliance Upon Same.
JONES 0003883