Document 3NGJomya0pp15aBvey3G00eYO

C-5 TRADE SALES PROGRESS REPORT JAY 1952 House Paints Endurance House Paint lias been reformulated as Y-I8OO-X-3. 205) of the W-91 has been replaced with W-1?0 so as to give better control of the chalking properties. Titanozinc Y-1350-F has been reformulated to exclude lead driers. Paint v/ill be featured as a "Fume Resistant" White Paint. Previous formula with lead drier would only show slight darkening under most rigid contact with EgS fumes but new formula is better. We caution the testing laboratories to check drying very care fully when manufacturing. We have noted some lead free competitive paints which are slow dry. Pastel Endurance Colors'. While the new color card indicates that customer may ob tain colors shovm by adding oil colors to other established colors in the Endurance Line, we have established formulas for tinting the pastel shades if ordered in large enough quantities. Havrthorne Pinecrest Acacia Adirondack Coronado Rambler Desert Sand Willow Green Saratoga Fiesta Shenandoah Coral Tone Cataline Everglade Pagoda GL-61955 GL-61956 GL-6195? GL-61953 GL-61959 GL-6196O GL-61961 GL-61962 GL-61963 GL-61964 GL-61965 GL-61966 GL-61967 Gl-61968 GL-61969 Flat Wall Paints We have ejranined a number of alkyds on the market which are recommended for flat wall paints, Likewise a number of odorless solvents have come to our atten tion for use in such products. The Alhyd from F. T. Washburn seems to be the most interesting and most versatile in use. Factory Letters Caulking Compound - Gun Grade: Two samples submitted and tested against our present source. Sample submitted by the Overall ?t. c" Varnish Co. had good tack, good adhesion and formed a good bead but the material was too stiff to v?ork well in a gun particularly in cool 'weather. illTha other sample v/ae submitted by I. T. Holmes d Co. Claim was made that it con tained a later, ''aso. The working cualities wore found to be satisfactory. One objection to this sample was that no definite skin was evident even after several GLD007002 1 0-6 days. Another test was to put some of the sample and our present caulking compound on smooth steel and heat the panel up to 110?. The E, T, Holmes sample slipped off the panel in less than 15 minutes v/hlle our present caulking was still in place after one hour. Abbott Laboratories: The following chemical-resistant finishes were developed in Epon-vehicle quality. 56-G-18-A #2 Green Chemical Resistant Enamel 56-G-22-A #4 Park Green Chemical Resistant Enamel These enamels dry in two to three hours. Apply full body. They show good re sistance to oleic acid and severe temperature changes. Chemical Resistant Hetal Primer, GL-62091, has been developed in similar quality to be used under the above finishes. It shows excellent adhesion and good water and dilute chemicals resis tance. . Primer Sealer, GL-61940, was f orr.ulated to be used on new plaster at Charity Hospital over Forolculite plaster. It consists of Y-4516 flatted down with 4 oz. /t. of W-166 per gallQn and then tinted to a yellow slightly lighter than Y-3405. Spred Sealer could not be applied properly on this type of plaster. Dependable Harris Co. Cantonment Green Ext. Paint, GL-61970, was formulated on a bid for Armed Services. It is of general Endurance quality. Raiser Aluminum Co. Red Stencil Paint, GL-61946, was formulated for marking wooden reels. Drying time is 8 minutes. Durability is very limited. GL-61946 was matched to a submitted sample. Y-592 was recommended for painting the wooden reels. . Soya Products Division. Sandstone Plinanel formulated to natch Y-1168 for color on 5 drum order. ---- ------- ---------- E. G. Itock. Gray Green H-t. Trim Paint was formulated in Post-ad quality to match customer's sample. Blue-Gray Plinamel, GL-620591 formulated for brewery maintenance. Order placed. Raw Materials Leaded Zinc. American Chemet has submitted a sample of If--35* v/hich is more easily ground than previous material. iTev; standard sample has been set up and samples sent to the other plants. Sherwin-Williams .submitted ^ sample of 10-14$ Leaded Zinc which we evaluated against the W-35i in both the Y-lOOO and Y-1804 formula tion. The S-W material doesn't give as much body to a paint as W-35 The color iB not as vrhite as W-35* E:cposure tests are being put out. Shingle Stain Oil. Kentuclty Color & Chemical Co. nave submitted a new material for 0-211 Shingle Stain Oil which they claim does contain some creosote base. There is no change in color from previous material, We have tested this new product out in White Cresote Paint, Y-596, and have approved for 0-211. nj 6/17/52 K. G. Hayward CU>00K>'