Document 1gB97NBB78G2KExEwvBw7GwnZ

tfXS BETZ PROCESS CHEMICALS, INC P.O. BOX 4300 The Woodlands, Texas 77387 (713) 367-2442 MATERIAL SAFETY DATA SHEET 24 HOUR EMERGENCY TELEPHONE (HEALTH OR ACCIDENT) 6 S 7 02 (215) 355-3300 DISTRIBUTED; MAY-25-1990 PRODUCT ; PROCHEM 6A4 (PAGE 1 OF 3) EFFECTIVE DATE 05-18-89 PRINTED; 10-Apr-1990 REVISIONS TO SECTIONS: 3 PRODUCT APPLICATION : AN OIL BASED DEFOAMER. ........... SECTION 1---................... HAZARDOUS INGREDIENTS INFORMATION ON PHYSICAL HAZARDS, HEALTH HAZARDS, PEL'S AND TLV'S FOR SPECIFIC PRODUCT INGREDIENTS AS REQUIRED BY THE OSHA HAZARD COMMUNICATIONS STANDARD ARE LISTED. REFER TO SECTION 4 (PAGE 2) FOR OUR ASSESSMENT OF THE POTENTIAL ACUTE AND CHRONIC HAZARDS OF THIS FORMULATION. TRADE SECRET INGREDIENT(437);EYE IRRITANT;COMBUSTIBLE;MANUFACTURER'S RECOMMENDED EXPOSURE LIMIT:100PPM;PEL:500PPM;TLV:NONE. TSRN 125438 - 5267P --------- SECTION 2...........................TYPICAL PHYSICAL DATA--......................................................... PH: 50% EXTRACT (APPROX.) FL.PT,(DEG.F): 120 P-M(CC) VAPOR PRESSURE (irunHG) : ND VISC cps70F: 130 EVAP.RATE: <1 ETHER-l PHYSICAL STATE: LIQUID 9.9 ODOR: HYDROCARBON SP.GR.(70F)OR DENSITY: 6.8LBS/GAL VAPOR DENSITY(AIR~1): >1 %SOLUBILITY(WATER): 0 APPEARANCE: COLORLESS FREEZE POINT(DEG.F): <-30 --------- SECTION 3-........................ REACTIVITY DATA------------------------------ ----------------------- - STABLE.MAY REACT WITH STRONG OXIDIZERS.DO NOT CONTAMINATE.BETZ TANK CLEAN-OUT CATEGORY 'B' THERMAL DECOMPOSITION (DESTRUCTIVE FIRES) YIELDS ELEMENTAL OXIDES. SAL 000009307 jlXS BETZ PROCESS |Uj CHEMICALS, INC GS702 P.O. BOX 4300 The Woodlands, Texas 77387 (713) 367-2442 MATERIAL SAFETY DATA SHEET (PAGE 2 OF 3) PRODUCT: PROCHEM 6A4 ........... SECTION 4......... .................HEALTH HAZARD EFFECTS........................................................... ACUTE SKIN EFFECTS *** PRIMARY ROUTE OF EXPOSURE MODERATELY IRRITATING TO THE SKIN.MAY CAUSE DERMATITIS. ACUTE EYE EFFECTS *** SEVERE IRRITANT TO THE EYES ACUTE RESPIRATORY EFFECTS *** PRIMARY ROUTE OF EXPOSURE VAPORS,GASES,MISTS OR AEROSOLS MAY CAUSE IRRITATION TO UPPER RESPIRATORY TRACT.PROLONGED EXPOSURE MAY CAUSE DIZZINESS AND HEADACHE. CHRONIC EFFECTS OF OVEREXPOSURE*** PROLONGED OR REPEATED EXPOSURES MAY CAUSE DEFATTING-TYPE DERMATITIS. MEDICAL CONDITIONS AGGRAVATED *** NOT KNOWN SYMPTOMS OF EXPOSURE *** EXCESSIVE DERMAL EXPOSURE CAUSES DEFATTING AND DRYING OF SKIN;EXCESSIVE INHALATION OF VAPORS CAUSES DIZZINESS,HEADACHE AND NAUSEA. SECTION 5.........................................FIRST AID INSTRUCTIONS...................................................... SKIN CONTACT*** REMOVE CONTAMINATED CLOTHING.WASH EXPOSED AREA WITH A LARGE QUANTITY OF SOAP SOLUTION OR WATER FOR 15 MINUTES EYE CONTACT*** IMMEDIATELY FLUSH EYES WITH WATER FOR 15 MINUTES. IMMEDIATELY CONTACT A PHYSICIAN FOR ADDITIONAL TREATMENT INHALATION EXPOSURE*** REMOVE VICTIM FROM CONTAMINATED AREA TO FRESH AIR.APPLY APPROPRIATE FIRST AID TREATMENT AS NECESSARY INGESTION*** DO NOT FEED ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSIVE VICTIM DO NOT INDUCE VOMITING. IMMED. CONTACT PHYSICIAN. DILUTE CONTENTS OF STOMACH USING 3-4 GLASSES MILK OR WATER --------- SECTION 6--......................SPILL,DISPOSAL AND FIRE INSTRUCTIONS--................. SPILL INSTRUCTIONS*** VENTILATE AREA,USE SPECIFIED PROTECTIVE EQUIPMENT.CONTAIN AND ABSORB ON ABSORBENT MATERIAL. PLACE IN WASTE DISPOSAL CONTAINER. THE WASTE CHARACTERISTICS OF THE ABSORBED MATERIAL,OR ANY CONTAMINATED SOIL, SHOULD BE DETERMINED IN ACCORDANCE WITH RCRA REGULATIONS. REMOVE IGNITION SOURCES.FLUSH AREA WITH WATER.SPREAD SAND/GRIT. DISPOSAL INSTRUCTIONS*** WATER CONTAMINATED WITH THIS PRODUCT MAY BE SENT TO A SANITARY SEWER TREATMENT FACILITY.IN ACCORDANCE WITH ANY LOCAL AGREEMENT,A PERMITTED WASTE TREATMENT FACILITY OR DISCHARGED UNDER A NPDES PERMIT PRODUCT(AS IS)- INCINERATE OR BURY IN APPROVED LANDFILL FIRE EXTINGUISHING INSTRUCTIONS*** FIREFIGHTERS SHOULD WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS(FULL FACE-PIECE TYPE).PROPER FIRE EXTINGUISHING MEDIA: DRY CHEMICAL,CARBON DIOXIDE,FOAM OR WATER SAL 000009308 tfAS BETZ PROCESS |W| CHEMICALS, INC P.O. BOX 4300 The Woodlands, Texas 77387 (713) 367-2442 MATERIAL SAFETY DATA SHEET (PAGE 3 OF 3) G S 7 02 PRODUCT: PROCHEM 6A4 ........... SECTION 7...........................SPECIAL PROTECTIVE EQUIPMENT.......................................... USE PROTECTIVE EQUIPMENT IN ACCORDANCE WITH 29CFR SECTION 1910.132-134. USE RESPIRATORS WITHIN USE LIMITATIONS OR ELSE USE SUPPLIED AIR RESPIRATORS. VENTILATION PROTECTION*** ADEQUATE VENTILATION TO MAINTAIN AIR CONTAMINANTS BELOW EXPOSURE LIMITS RECOMMENDED RESPIRATORY PROTECTION*** IF VENTILATION IS INADEQUATE OR SIGNIFICANT PRODUCT EXPOSURE IS LIKELY, USE A RESPIRATOR WITH ORGANIC VAPOR CARTRIDGES. RECOMMENDED SKIN PROTECTION*** NEOPRENE GLOVES WASH OFF AFTER EACH USE . REPLACE AS NECESSARY RECOMMENDED EYE PROTECTION*** SPLASH PROOF CHEMICAL GOGGLES ...........SECTION 8......... ................. STORAGE AND HANDLING PRECAUTIONS................................ STORAGE INSTRUCTIONS*** KEEP DRUMS & PAILS CLOSED WHEN NOT IN USE. KEEP AWAY FROM FLAMES OR SPARKS. BOND CONTAINERS DURING FILLING OR DISCHARGE WHEN PERFORMED AT TEMPERATURES AT OR ABOVE THE PRODUCT FLASH POINT. HANDLING INSTRUCTIONS*** COMBUSTIBLE THIS MSDS COMPLIES WITH THE OSHA HAZARD COMMUNICATION STANDARD HAROLD M. HERSH (ENVIRONMENTAL INFORMATION COORDINATOR) APPENDIX: REGULATORY INFORMATION THE CONTENT OF THIS APPENDIX REPRESENTS INFORMATION KNOWN TO BETZ ON THE EFFECTIVE DATE OF THIS MSDS. THIS INFORMATION IS BELIEVED TO BE ACCURATE. VNY CHANGES IN REGULATIONS WILL RESULT IN UPDATED VERSIONS OF'THIS DOCUMENT. . . . TSCA: ALL COMPONENTS OF THIS PRODUCT ARE LISTED IN THE TSCA INVENTORY ...REPORTABLE QUANTITY(RQ) FOR UNDILUTED PRODUCT: TREAT AS OIL SPILL . . . RCRA: IF THIS PRODUCT IS DISCARDED AS A WASTE, THE RCRA HAZARDOUS WASTE IDENTIFICATION NUMBER IS: D001=IGNITABLE ...DOT HAZARD/UN#/ER GUIDE# IS: COMBUSTIBLE LIQUID NAl993/#27 ...THIS PRODUCT CONTAINS THESE CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER OR REPRODUCTIVE TOXICITY: NONE PRESENT IN SIGNIFICANT AMOUNTS ...SARA SECTION 313 CHEMICALS: NONE PRESENT IN SIGNIFICANT AMOUNTS ...SARA SECTION 312 HAZARD CLASS: IMMEDIATE(ACUTE),DELAYED(CHRONIC) AND FIRE ...MICHIGAN CRITICAL MATERIALS: NONE PRESENT IN SIGNIFICANT AMOUNTS NFPA/HMIS : HEALTH - 2 ; FIRE - 2 ; REACTIVITY - 0 ; SPECIAL - NONE ; PE - B MOTT!*-, " m rnMi